Peugeot Expert Dag 2006 Owner's Manual

Practical information96 -
When towing with the en-
gine switched off, there is
no braking or steering as-
sistance.
TOWING YOUR VEHICLE
Without lifting
(4 wheels on the ground)
You must always use a tow bar.
The towing eyes are located at the
front and the rear under the vehicle's
bumpers.
Lifting
(2 wheels only on the ground)
It is preferable to raise the vehicle
with a professional lifting device.
Never use the radiator crossmember.
Special features of the
automatic gearbox
When towing with four wheels on the
ground, the following rules must be
obeyed:
- lever in position N,
- tow the vehicle at less than 30 mph (50 km/h) over a maximum distance
of 30 miles (50 km),
- do not add oil to the gearbox.

97Practical information-
TOWING A TRAILER,
CARAVAN, BOAT, etc.
We recommend the use of original
PEUGEOT towbars that have been
tested and approved from the design
stage of your vehicle and that the fit-
ting of the towbar is entrusted to a
PEUGEOT dealer.
Your vehicle is primarily designed
for transporting people and luggage
but it may also be used for towing a
trailer.
Driving with a trailer subjects the tow-
ing vehicle to more significant stress
and its driver must be particularly
careful.
Air density decreases with altitude,
thus reducing engine performance.
Above 1 000 metres, the maximum
towing load must be reduced by 10 %
and so on for every 1 000 metres of
altitude.
Driving advice
Distribution of loads: Distribute the
load in the trailer so that the heaviest
items are as close as possible to the
axle and the nose weight approach-
es the maximum permitted without
exceeding it.
Cooling: Towing a trailer on a slope
increases the temperature of the
coolant.
As the fan is electrically controlled,
its cooling capacity is not dependent
on the engine speed.
On the contrary, use a high gear to
lower the engine speed and reduce
your speed.
The maximum towing load on a long
slope depends on the gradient and
the outside temperature.
In all cases, pay attention to the
coolant temperature.
If the warning light comes on, stop
the vehicle and switch off the engine
as soon as possible. Tyres:
Check the tyre pressures of
the towing vehicle and of the trailer,
observing the recommended pres-
sures.
Braking: Towing increases the
braking distance.
Lights: Check the electrical signal-
ling on the trailer.
Side wind: Take into acount the
increased sensitivity to side wind.

Practical information98 -
Before installing any elec-
trical accessory on your ve-
hicle, contact a PEUGEOT
dealer.
ACCESSORIES FOR YOUR
EXPERT
For your PEUGEOT only use acces-
sories and original parts approved by
the manufacturer.
These accessories and parts are all
adapted to your PEUGEOT, after be-
ing tested and approved for reliability
and safety, which PEUGEOT cannot
guarantee for other products.
A wide choice of original accessories,
approved by PEUGEOT, is available
through the dealer network. They all
carry the PEUGEOT guarantee.
* According to version.- Communication:
Audio systems,
audio-telephone, speakers, CD
changer...
- Customising: Ladder, mud flaps,
front fog lamps kit*...
- Leisure: Towbar, roof bars, snow
chains...
- Children: Booster seats and child
seats...
- Maintenance products: Screen-
wash, interior and exterior mainte-
nance and cleaning products...
- Safety:
Window protectors, anti-
theft alarm, wheel locks, signalling
triangle, first aid kit, safety jacket...
- Comfort: Rear and side windows,
audio-telephone console, seat
covers compatible with side air
bags, mats, strap-guide...
- Loading: Roof bars, thermoformed
interior protectors, wooden interior
fittings, loading roller...

99Technical data-
Model codesPETROL
BARFNC/IF
BBRFNC/IF - BCRFNC/IF
BDRFNC/IF - BERFNC/IF BARFNE
BBRFNE - BJRFNE
BDRFNE - BERFNE
ENGINES 2 litre 16V
Cubic capacity (cm
3) 1 997
Bore x stroke (mm) 85 x 88
EU standard maximum power (kW) 100
Maximum power engine speed (rpm) 6 000
EU standard maximum torque (Nm) 190
Maximum torque engine speed (rpm) 4 100
Fuel Unleaded
Catalytic converter Yes
Gearbox Manual
(5-speed) Automatic
(4-speed)
Oil capacity (in litres)
Engine (with cartridge replacement) 4.25 -
Gearbox-Final drive --
ENGINES AND GEARBOXES

Technical data100 -
ENGINES AND GEARBOXES
Model codesDIESEL
BAWJYB - BBWJYB
BDWJYB - BEWJYB BARHXB BARHZB
BBRHXB BBRHZB
BCRHXB BCRHZB
BDRHXB BDRHZB
BERHXB BERHZB BARHWB - BBRHWB
BCRHWB - BDRHWB
BERHWB
ENGINES 1.9 litre 2 litre Turbo HDI
(95 bhp/110 bhp) 2 litre Turbo HDI 16V
Cubic capacity (cm
3) 1 868 1 997 1 997
Bore x stroke (mm) 82.2 x 88 85 x 88 85 x 88
EU standard maximum power (kW) 51 69 80 80
Maximum power engine speed (rpm) 4 600 4 000 4 000
EU standard maximum torque (Nm) 125 215 250 270
Maximum torque engine speed (rpm) 2 500 1 750 1 750
Fuel Diesel Diesel Diesel
Catalytic converter Yes Yes Yes
Gearbox Manual
(5-speed) Manual
(5-speed) Manual
(5-speed)
Oil capacity (in litres)
Engine (with cartridge replacement) 4.5 5.5 4.75
Gearbox-Final drive - - -

101Technical data-
CONSUMPTION
In accordance with EC Directive 80/1268 (as amended) mpg (litres/100 km)
Engines Gearbox
Model codes
BA... BB... BC... BD... BE... BJ...Urban driving Inter-urban
driving Mixed driving Emission of
CO2 by weight
(g/km)
2 litre 16V ManualRFNC/IF23.5 (12.0) 38.7 (7.3) 31.1 (9.0) 216
2 litre 16V Automatic RFNE20.9 (13.5) 37.2 (7.6) 29.1 (9.7) 232
1.9 litre Diesel ManualWJYB27.9 (10.1) 42.8 (6.6) 35.8 (7.9) 211
2 litre Turbo
HDI (95 bhp) Manual
RHXB32.4 (8.7) 47.9 (5.9) 40.4 (7.0) 187
2 litre Turbo
HDI (110 ch) Manual
RHZB32.4 (8.7) 50.4 (5.6) 42.2 (6.7) 180
2 litre Turbo HDI 16V Manual
RHWB31.7 (8.9) 47.1 (6.0) 40.4 (7.0) 186
The consumption values presented here correspond to the values communicated at the time of printing. These consumption values
were established in accordance with EC Directive 80 /1268 (as amended). They may vary depending on the style of driving, traffic
conditions, weather conditions, the load in the veh icle, the maintenance of the vehicle and the use of the accessories.

Technical data102 -
WEIGHTS AND TOWED LOADS (IN KG)
(1) 5-seat Combi - (2) 9-seat Combi.
* In the case of a towing vehicle, the speed is limited to 60 mph (100 km/h).
2 litre 16V
VanCombi
5-6-7-8-9 Platform
cab
Gearbox Manual Manual Auto. Manual
• Payload -
1 060 (1) - 1 002 (2) 834 (1) - 776 (2)-
• Kerb weight 1 412
1 520 (1) - 1 578 (2) 1 561 (1) - 1 619 (2)1 263
• Weight without load 1 397
1 445 (1) - 1 503 (2) 1 486 (1) - 1 544 (2)1 188
• Gross vehicle weight (GVW) 2 185 2 505 2 320 2 185
• Gross train weight (GTW)* 3 485 3 595 3 620 3 485
• Unbraked trailer 706 750 750 631
• Braked trailer (within GTW) 1 300 1 300 1 300 1 300
• Recommended nose weight 60 60 60 60

103Technical data-
WEIGHTS AND TOWED LOADS (IN KG)
1.9 litre DieselVanExtended
van Combi
5-6-8-9 Platform
cab Extended
platform cab
• Payload - -
743 (1) - 695 (2)- -
• Kerb weight 1 429 1 469
1 537 (1) - 1 595 (2)1 280 1 310
• Weight without load 1 174 1 394
1 462 (1) - 1 520 (2)1 205 1 235
• Gross vehicle weight (GVW) 2 205 2 205
2 205 (1) - 2 215 (2)2 205 2 205
• Gross train weight (GTW)* 3 305 3 305 3 305 3 305 3 305
• Unbraked trailer 715 735 750 640 655
• Braked trailer (within GTW) 1 100 1 100 1 300 1 100 1 100
• Recommended nose weight 60 60 60 60 60
(1) 5-seat Combi - (2) 9-seat Combi. 2 litre Turbo HDI 95 bhp Van
Extended
van Combi
5-6-8-9 Platform
cab Extended
platform cab
• Payload - -
997 (1) - 939 (2)- -
• Kerb weight 1 476 1 516
1 583 (1) - 1 641 (2)1 327 1 360
• Weight without load 1 401 1 441
1 508 (1) - 1 566 (2)1 252 1 285
• Gross vehicle weight (GVW)
2 250/2 3302 330 2 505 2 330 2 330
• Gross train weight (GTW)*
3 550/3 6303 630 3 640 3 630 3 630
• Unbraked trailer 738 750 750 664 680
• Braked trailer (within GTW) 1 300 1 300 1 300 1 300 1 300
• Recommended nose weight 60 60 60 60 60
* In the case of a towing vehicle, the speed is limited to 60 mph (100 km/h).

Technical data104 -
WEIGHTS AND TOWED LOADS (IN KG)
2 litre Turbo HDI 110 bhp VanExtended
van Combi
5-6-7-8-9 Platform
cab Extended
platform cab
• Payload - -
993 (1) - 935 (2)- -
• Kerb weight 1 480 1 520
1 587 (1) - 1 645 (2)1 331 1 361
• Weight without load 1 405 1 445
1 512 (1) - 1 570 (2)1 256 1 286
• Gross vehicle weight (GVW) 2 330 2 330 2 505 2 330 2 330
• Gross train weight (GTW)* 3 630 3 630 3 640 3 630 3 630
• Unbraked trailer 740 750 750 665 680
• Braked trailer (within GTW) 1 300 1 300 1 300 1 300 1 300
• Recommended nose weight 60 60 60 60 60
(1) 5-seat Combi - (2) 9-seat Combi. 2 litre Turbo HDI 16V Van
Extended
van Combi
5-6-7-8-9 Platform
cab Extended
platform cab
• Payload - - - - -
• Kerb weight 1 491 1 532
1 598 (1) - 1 656 (2)1 342 1 372
• Weight without load 1 416 1 457
1 523 (1) - 1 581 (2)1 267 1 297
• Gross vehicle weight (GVW) 2 250 2 250 2 505 2 250 2 250
• Gross train weight (GTW)* 3 550 3 550 3 640 3 550 3 550
• Unbraked trailer 746 750 750 671 686
• Braked trailer (within GTW) 1 300 1 300 1 300 1 300 1 300
• Recommended nose weight 60 60 60 60 60
* In the case of a towing vehicle, the speed is limited to 60 mph (100 km/h).

105Technical data-
EXTERIOR DIMENSIONS (in mm)
Version Van - Combi Platform cab
Wheelbase Normal Extended Normal Extended A 4 522 4 922 4 503 4 903
B 2 824 3 224 2 824 3 224
C 919 919
D 779 760
E 1 540 1 540
F 1 844 1 844
G 1 919 to 1 994 1 932 to 1 950 (1) 1 907 to 1 935
H 1 540 1 540
I 2 130 2 130
(1) Panel van.