Peugeot Partner VU 2007 Owner's Manual

Practical information96 -
Removing and fitting a fuse
Before changing a fuse, the cause
of the fault must be found and reme-
died. The fuse numbers are indicated
on the fuse box.
Use the pliers B.CHANGING A FUSE
The fuse boxes are located under
the fascia and in the engine compart-
ment.
Fascia fuse box
Unclip the cover to gain access to the
fuses.
The spare fuses and the pliers B are
secured on the inside of the cov-
er A. Correct Incorrect
Pliers B Always replace a faulty fuse with
a fuse of the same rating (two fuse
types according to manufacturer -
see images).

97Practical information-
Fuse RatingFunctions
1 15 A Rear wiper (hinged doors) - Rear 12 V sockets.
4 20 A Multi-function display - Instrument panel - Audio equipment - Ste ering wheel controls.
5 15 A Alarm siren.
6 10 A Diagnostic socket.
7 15 A Alarm - Rain and brightness sensor.
9 30 A Heated seats.
10 40 A Rear screen and mirrors demisting.
11 15 A Rear windscreen wiper (tailgate).
12 30 A Front electric windows.
14 10 A Engine fuse box - Steering wheel controls.
15 15 A Instrument panel - Multi-function display - Audio equipment - Parki ng assistance.
16 30 A Locking/unlocking controls for doors, bonnet and boot.
20 10 A Right-hand brake light.
21 15 A Left-hand brake light.
22 20 A Front courtesy light - Map reading light - Lighter - Front 12 V socket - Electric mirror.

Practical information100 -
ECONOMY MODE FUNCTION
After the engine has stopped, certain
functions (windscreen wiper, elec-
tric windows, courtesy lights, audio
equipment, etc.) can only be used for
a combined duration of approximate-
ly thirty minutes, to prevent discharg-
ing the battery.
Once the thirty minutes are over, a
switching to economy mode mes-
sage appears on the multi-function
display and the active functions are
put on standby.
These functions are reactivated au-
tomatically next time the vehicle is
driven.
In order to resume the use of these
functions immediately, the engine
must be started and left to run for a
few minutes.
The time available to you will then be
double the duration for which the en-
gine is left running. However, this pe-
riod will always be between five and
thirty minutes.
BATTERY
To charge the battery using a
battery charger:
- Disconnect the battery,
- Follow the instructions for use giv- en by the battery charger manufac-
turer,
- Reconnect starting with the nega- tive (-) terminal,
- Check that the terminals and con- nectors are clean. If they are cov-
ered with sulphate (white or greenish
deposit), disconnect them and clean
them.
It is advisable to disconnect the
battery if the vehicle is not to be
used for a period of more than
one month.
Never disconnect a terminal
when the engine is running.
Never charge a battery with-
out first disconnecting the
terminals.
After every reconnection of
the battery, switch on the ignition
and wait 1 minute before starting to
allow the electronic systems to be
initialised. If slight difficulties are ex-
perienced after this, please contact a
PEUGEOT dealer. A flat battery prevents the
engine from starting.
To start the vehicle from
another battery:
- Connect the red cable to the positive
(+) terminals of the two batteries,
- Connect one end of the green or black cable to the negative (-) ter-
minal of the slave battery,
- Connect the other end of the green or black cable to an earth point on
the broken down vehicle as far as
possible from the battery.
Operate the starter, let the engine
run.
Wait for the engine to return to idle,
then disconnect the cables.

101Practical information-
Making the connections
A1: -
A2: - Digital control (manufacturer).
A3: - Digital control (manufacturer).
A4: - Audio equipment multiplexing (manufacturer).
A5: -
A6: (+ve) Accessories
A7: (+ve) Permanent
A8: (-ve) Earth
B1: (+) -
B2: (-) -
B3: (+) Front right speaker and tweeter
B4: (-) Front right speaker and tweeter
B5: (+) Front left speaker and tweeter
B6: (-) Front left speaker and tweeter
B7: (+) -
B8: (-) -
FITTING SPEAKERS
The factory-fitted equipment allows
the fitting of:
- 35 mm diameter tweeters in the fascia,
- 165 mm diameter speakers in the front doors.
FITTING AUDIO EQUIPMENT
Your vehicle is equipped with certain
factory-fitted audio equipment:
- roof aerial,
- coaxial aerial cable,
- basic interference suppression,
- supply to front speakers and tweet-ers,
- two 8-way connectors.
Contact a PEUGEOT dealer
before fitting audio equip-
ment or speakers in your ve-
hicle.

Practical information102 -
SNOW SCREEN*
The snow screen is installed on the
lower part of the front bumper to pre-
vent the accumulation of snow at the
radiator cooling fan.
When the snow has cleared (tem-
perature above 10 °C), remove the
snow screen.
* According to country.
FITTING

Offer up the snow screen facing
the front bumper.
 Put it in place positioning the low-
er clips A in the bumper.
 Press the snow screen at each
upper clip B.
REMOVAL
 Press the two upper clips B and
pull the snow screen.

103Practical information-
Without lifting (four wheels on the
ground)
You must always use a towbar.Never use the radiator cross-
member.
When towing another vehicle,
it must freewheel (gearbox in
neutral).
By lifting (two wheels only on the
ground)
It is preferable to lift the vehicle by
the wheels.
TOWING YOUR VEHICLE
From the front or the rear
Attach the towbar to the towing eye.

Practical information104 -
TOWING A TRAILER,
CARAVAN, BOAT, etc.
We recommend the use of original
PEUGEOT towbars that have been
tested and approved from the design
stage of your vehicle and that the fit-
ting of the towbar is entrusted to a
PEUGEOT dealer.
Your vehicle is primarily designed
for transporting people and luggage
but it may also be used for towing a
trailer.
Driving with a trailer subjects the tow-
ing vehicle to more significant stress
and its driver must be particularly
careful.
Air density decreases with altitude,
thus reducing engine performance.
Above 1 000 metres, the maximum
towing load must be reduced by 10 %
and so on for every 1 000 metres of
altitude.
Driving advice
Distribution of loads: Distribute the
load in the trailer so that the heaviest
items are as close as possible to the
axle and the nose weight approach-
es the maximum permitted without
exceeding it.
Cooling: Towing a trailer on a slope
increases the temperature of the
coolant.
As the fan is electrically controlled,
its cooling capacity is not dependent
on the engine speed.
On the contrary, use a high gear to
lower the engine speed and reduce
your speed.
The maximum towing load on a long
slope depends on the gradient and
the outside temperature.
In all cases, pay attention to the cool-
ant temperature.
If the warning light comes on, stop
the vehicle and switch off the engine
as soon as possible. Tyres:
Check the tyre pressures of
the towing vehicle and of the trailer,
observing the recommended pres-
sures.
Braking: Towing increases the brak-
ing distance.
Lights: Check the electrical signal-
ling on the trailer.
Side wind: Take into acount the in-
creased sensitivity to side wind.

105Practical information-
ACCESSORIES FOR YOUR
PARTNER
A wide choice of accessories recom-
mended by PEUGEOT and original parts
is available through the dealer network.
These accessories and parts, after
being tested and approved for reli-
ability and safety, are all adapted to
your PEUGEOT vehicle.
This product range offered by PEUGEOT Ac-
cessories is structured around 5 categories:
- PROTECTION
- TOURING
- IN-CAR TECHNOLOGY
- STYLING
- UNIVERSAL,
it is dedicated to:Depending on the country in
which the vehicle is sold, it is
compulsory to have a safety
jacket, a signalling triangle
and a set of spare bulbs
available in the vehicle.
The fitting of electrical equipment or
accessories which are not recom-
mended by PEUGEOT may result in
a failure of your vehicle’s electronic
system.
Please note this specific warning.
You are advised to contact a repre-
sentative of the Marque to be shown
the range of recommended equip-
ment and accessories.

"Universal" : Screenwash,
interior and exterior main-
tenance and cleaning prod-
ucts...
"Protection" : Separation
grille, window protectors,
anti-theft alarm, wheel locks,
parking assistance, signal-
ling triangle, first aid kit, fog
lamps, safety jacket...
"In-Car Technology": Audio
systems, audio- telephone,
speakers, CD changer, navi-
gation system, telephone
console...
"Touring"
: Rear and side
windows, audio-telephone
console, seat covers com-
patible with side air bags,
mats, rubber boot carpet,
thermoformed side protec-
tors, low partition interior
grille, luggage net, door deflectors,
roof rack, thermoformed interior pro-
tectors, wooden interior fittings, load-
ing roller, towbar, roof bars (load on
longitudinal bars: 75 kg max: har-
mony: 100 kg max), snow chains,
tailgate bicycle carrier, booster seats
and child seats...
Note
To prevent the mat from becoming
caught under the pedals:
- ensure that the mat is positioned and secured correctly,
- never fit one mat on top of another. "Styling"
: Alloy wheels,
door sills, mud flaps...

Technical data106 -
PETROL ENGINES AND GEARBOXES
(1) Draining by gravity - (2) Draining by suctionModel codes
GBKFWC
GCKFWC
ENGINES 1.4 litre
Cubic capacity (cm
3) 1 360
Bore x stroke (mm) 75 x 77
EU standard maximum power (kW) 55
Maximum power at engine speed (rpm) 5 500
EU standard maximum torque (Nm) 120
Maximum torque at engine speed (rpm) 3 400
Fuel Ron 95 - Ron 98
Catalytic converter Yes
Gearbox Manual
(5 speed)
Oil capacity (in litres)
Engine (with cartridge replacement) 3 (1) - 3.25 (2)
Gearbox-Final drive 2

107Technical data-
DIESEL ENGINES AND GEARBOXES
Model codesGB9HWC
GC9HWCGB9HXC
GC9HXC
GBWJYB
GCWJYB
GBRHYB
GCRHYB
ENGINES
1.6 litre Turbo HDI1.6 litre Turbo HDI1.9 litre2 litre Turbo HDI
Cubic capacity (cm
3) 1 560 1 560 1 867 1 997
Bore x stroke (mm) 75 x 88.3 75 x 88.3 82.2 x 88 85 x 88
EU standard maximum power (kW) 55 66 51 66
Maximum power at engine speed (rpm) 4 000 4 000 4 600 4 000
EU standard maximum torque (Nm) 170 215 125 205
Maximum torque at engine speed (rpm) 1 750 1 750 2 500 1 900
Fuel Diesel Diesel Diesel Diesel
Catalytic converter Yes Yes Yes Yes
Gearbox Manual
(5 speed) Manual
(5 speed) Manual
(5 speed) Manual
(5 speed)
Oil capacity (in litres)
Engine (with cartridge replacement) 3,8 3,8 4,8 4,5
Gearbox-Final drive 1,9 1,9 1,9 1,9