engine PONTIAC G6 2005 Owners Manual

Parking Brake and Automatic Transaxle
Park (P) Mechanism Check
{CAUTION:
When you are doing this check, your vehicle
could begin to move. You or others could be
injured and property could be damaged. Make
sure there is room in front of your vehicle in
case it begins to roll. Be ready to apply the
regular brake at once should the vehicle begin
to move.Park on a fairly steep hill, with the vehicle facing
downhill. Keeping your foot on the regular brake, set the
parking brake.
To check the parking brake’s holding ability: With
the engine running and transaxle in NEUTRAL (N),
slowly remove foot pressure from the regular
brake pedal. Do this until the vehicle is held by the
parking brake only.
To check the PARK (P) mechanism’s holding ability:
With the engine running, shift to PARK (P). Then
release the parking brake followed by the regular
brake.
Contact your GM Goodwrench
®dealer if service is
required.
Underbody Flushing Service
At least every spring, use plain water to ush any
corrosive materials from the underbody. Take care to
clean thoroughly any areas where mud and other debris
can collect.
6-11

Recommended Fluids and
Lubricants
Fluids and lubricants identied below by name,
part number or specication may be obtained from
your dealer.
Usage Fluid/Lubricant
Engine OilEngine oil which meets GM
Standard GM6094M and displays
the American Petroleum Institute
Certied for Gasoline Engines
starburst symbol. GM
Goodwrench
®oil meets all the
requirements for your vehicle. To
determine the proper viscosity for
your vehicle’s engine, seeEngine
Oil on page 5-13.
Engine Coolant50/50 mixture of clean, drinkable
water and use only DEX-COOL
®
Coolant. SeeEngine Coolant on
page 5-19.
Hydraulic Brake
SystemDelco Supreme 11 Brake Fluid or
equivalent DOT-3 brake uid.
Usage Fluid/Lubricant
Windshield
Washer SolventGM Optikleen
®Washer Solvent.
Automatic
TransaxleDEXRON
®-III Automatic
Transmission Fluid. Look for
“Approved for the H-Specication”
on the label.
Key Lock
CylindersMulti-Purpose Lubricant, Superlube
(GM Part No. U.S. 12346241, in
Canada 10953474).
Hood Latch
Assembly,
Secondary
Latch, Pivots,
Spring Anchor
and Release
PawlLubriplate Lubricant Aerosol
(GM Part No. U.S. 12346293, in
Canada 992723) or lubricant
meeting requirements of NLGI #2,
Category LB or GC-LB.
Hood and Door
HingesMulti-Purpose Lubricant, Superlube
(GM Part No. U.S. 12346241, in
Canada 109435474).
Weatherstrip
ConditioningDielectric Silicone Grease
(GM Part No. U.S. 12345579, in
Canada 992887).
6-12

Normal Maintenance Replacement Parts
Replacement parts identied below by name, part number, or specication can be obtained from your GM dealer.
Part GM Part NumbersACDelco®Part
Numbers
Engine Air Cleaner/Filter 10366901 A1615C
Engine Oil Filter 25010792 PF47
Spark Plugs 12568387 41-101
Windshield Wiper Blades
Driver’s Side — 24.0 inches (60.0 cm)
Passenger’s Side — 21.2 inches (53.0 cm)22711051
22711050—
—
6-13

Additional Program Information
Courtesy Transportation is available during the
Bumper-to-Bumper warranty coverage period, but it is
not part of the New Vehicle Limited Warranty. A
separate booklet entitledWarranty and Owner
Assistance Informationfurnished with each new vehicle
provides detailed warranty coverage information.
Courtesy Transportation is available only at participating
dealers and all program options, such as shuttle
service, may not be available at every dealer. Please
contact your dealer for specic information about
availability. All Courtesy Transportation arrangements
will be administered by appropriate dealer personnel.
Canadian Vehicles:For warranty repairs during
the Complete Vehicle Coverage period of the General
Motors of Canada New Vehicle Limited Warranty,
alternative transportation may be available under the
Courtesy Transportation Program. Please consult
your dealer for details.
General Motors reserves the right to unilaterally modify,
change or discontinue Courtesy Transportation at
any time and to resolve all questions of claim eligibility
pursuant to terms and conditions described herein
at its sole discretion.
Vehicle Data Collection and Event
Data Recorders
Your vehicle, like other modern motor vehicles, has a
number of sophisticated computer systems that monitor
and control several aspects of the vehicle’s performance.
Your vehicle uses on-board vehicle computers to monitor
emission control components to optimize fuel economy,
to monitor conditions for airbag deployment and, if so
equipped, to provide anti-lock braking and to help the
driver control the vehicle in difficult driving situations.
Some information may be stored during regular
operations to facilitate repair of detected malfunctions;
other information is stored only in a crash event by
computer systems, such as those commonly called event
data recorders (EDR).
In a crash event, computer systems, such as the Airbag
Sensing and Diagnostic Module (SDM) in your vehicle
may record information about the condition of the vehicle
and how it was operated, such as data related to
engine speed, brake application, throttle position, vehicle
speed, safety belt usage, airbag readiness, airbag
performance, and the severity of a collision. This
information has been used to improve vehicle crash
performance and may be used to improve crash
performance of future vehicles and driving safety.
7-9

To contact NHTSA, you may either call the Auto Safety
Hotline toll-free at 1-800-424-9393 (or 366-0123 in
the Washington, D.C. area) or write to:
NHTSA, U.S. Department of Transportation
Washington, D.C. 20590
You can also obtain other information about motor
vehicle safety from the hotline.
Reporting Safety Defects to the
Canadian Government
If you live in Canada, and you believe that your vehicle
has a safety defect, you should immediately notify
Transport Canada, in addition to notifying General
Motors of Canada Limited. You may write to:
Transport Canada
330 Sparks Street
Tower C
Ottawa, Ontario K1A 0N5
Reporting Safety Defects to
General Motors
In addition to notifying NHTSA (or Transport Canada) in
a situation like this, we certainly hope you’ll notify us.
Please call us at 1-800-762-2737, or write:
Pontiac Customer Assistance Center
P.O. Box 33172
Detroit, MI 48232-5172
In Canada, please call us at 1-800-263-3777 (English)
or 1-800-263-7854 (French). Or, write:
General Motors of Canada Limited
Customer Communication Centre, 163-005
1908 Colonel Sam Drive
Oshawa, Ontario L1H 8P7
Service Publications Ordering
Information
Service Manuals
Service Manuals have the diagnosis and repair
information on engines, transmission, axle suspension,
brakes, electrical, steering, body, etc.
7-11

A
Accessory Power Outlets.................................3-18
Additives, Fuel................................................. 5-6
Add-On Electrical Equipment............................5-75
Adjustable Throttle and Brake Pedal..................2-22
Air Cleaner/Filter, Engine.................................5-17
Air Conditioning..............................................3-19
Airbag
Readiness Light..........................................3-27
Airbag Sensing and Diagnostic Module (SDM)...... 7-9
Airbag System................................................1-47
How Does an Airbag Restrain?......................1-55
Servicing Your Airbag-Equipped Vehicle..........1-57
What Makes an Airbag Inate?......................1-55
What Will You See After an Airbag Inates?....1-56
When Should an Airbag Inate?....................1-54
Where Are the Airbags?...............................1-50
Antenna, Backglass.........................................3-78
Antenna, XM™ Satellite Radio
Antenna System..........................................3-78
Anti-Lock Brake System (ABS)........................... 4-6
Anti-Lock Brake, System Warning Light..............3-29
Appearance Care............................................5-66
Aluminum Wheels........................................5-71
Care of Safety Belts....................................5-69
Chemical Paint Spotting...............................5-72
Cleaning Exterior Lamps/Lenses....................5-69
Fabric/Carpet..............................................5-66
Finish Care.................................................5-70Appearance Care (cont.)
Finish Damage............................................5-72
Glass Surfaces............................................5-68
Instrument Panel.........................................5-68
Interior Plastic Components...........................5-68
Leather......................................................5-68
Sheet Metal Damage...................................5-72
Tires..........................................................5-71
Underbody Maintenance...............................5-72
Vehicle Care/Appearance Materials................5-73
Vinyl..........................................................5-68
Washing Your Vehicle...................................5-69
Weatherstrips..............................................5-69
Windshield and Wiper Blades........................5-70
Audio System(s).............................................3-44
Audio Steering Wheel Controls......................3-76
Backglass Antenna......................................3-78
Care of Your CD and DVD Player..................3-78
Care of Your CDs and DVDs........................3-78
Radio with CD....................................3-46, 3-51
Radio with Six-Disc CD................................3-62
Setting the Time for Radios with Radio
Data Systems (RDS)................................3-45
Setting the Time for Radios without
Radio Data Systems (RDS).......................3-45
Theft-Deterrent Feature................................3-76
Understanding Radio Reception.....................3-77
XM™ Satellite Radio Antenna System............3-78
Automatic Headlamp System............................3-15
1

Automatic Transaxle
Fluid..........................................................5-19
Operation...................................................2-24
B
Backglass Antenna..........................................3-78
Battery..........................................................5-33
Run-Down Protection...................................3-17
Before Leaving on a Long Trip.........................4-22
Bench Seat, Split (60/40)................................... 1-7
Brake
Anti-Lock Brake System (ABS)........................ 4-6
Emergencies................................................ 4-8
Parking......................................................2-28
System Warning Light..................................3-28
Brake Pedal, Throttle.......................................2-22
Brakes..........................................................5-30
Braking........................................................... 4-5
Braking in Emergencies..................................... 4-8
Break-In, New Vehicle.....................................2-20
Bulb Replacement...........................................5-38
Center High-Mounted Stoplamp (CHMSL)........5-39
Halogen Bulbs............................................5-38
Headlamps, Front Turn Signal, Sidemarker,
and Parking Lamps..................................5-38
Replacement Bulbs......................................5-40Bulb Replacement (cont.)
Taillamps, Turn Signal, Sidemarker, Stoplamps,
and Back-Up Lamps.................................5-40
Buying New Tires...........................................5-51C
California Fuel.................................................. 5-6
Canadian Owners................................................ ii
Capacities and Specications............................5-82
Carbon Monoxide...................2-12, 2-31, 4-25, 4-38
Care of
Safety Belts................................................5-69
Your CD and DVD Player.............................3-78
Your CDs and DVDs....................................3-78
Center Console Storage Area...........................2-42
Center High-Mounted Stoplamp (CHMSL)...........5-39
Chains, Tire...................................................5-54
Charging System Light....................................3-28
Check
Engine Light...............................................3-31
Checking Things Under the Hood......................5-10
Chemical Paint Spotting...................................5-72
Child Restraints
Child Restraint Systems...............................1-34
Infants and Young Children...........................1-31
2

Child Restraints (cont.)
Lower Anchorages and Top Tethers for
Children (LATCH System)..........................1-39
Older Children.............................................1-28
Securing a Child Restraint Designed for
the LATCH System...................................1-41
Securing a Child Restraint in a Rear
Seat Position...........................................1-42
Securing a Child Restraint in the Right
Front Seat Position...................................1-45
Top Strap...................................................1-37
Top Strap Anchor Location............................1-39
Where to Put the Restraint...........................1-37
Cleaning
Aluminum Wheels........................................5-71
Exterior Lamps/Lenses.................................5-69
Fabric/Carpet..............................................5-66
Finish Care.................................................5-70
Glass Surfaces............................................5-68
Instrument Panel.........................................5-68
Interior Plastic Components...........................5-68
Leather......................................................5-68
Tires..........................................................5-71
Underbody Maintenance...............................5-72
Vinyl..........................................................5-68
Washing Your Vehicle...................................5-69
Weatherstrips..............................................5-69
Windshield and Wiper Blades........................5-70Climate Control System...................................3-19
Outlet Adjustment........................................3-23
Comfort Guides, Rear Safety Belt.....................1-25
Compact Spare Tire........................................5-65
Content Theft-Deterrent....................................2-16
Control of a Vehicle.......................................... 4-5
Convenience Net............................................2-42
Coolant
Engine Temperature Gage............................3-30
Heater, Engine............................................2-23
Surge Tank Pressure Cap.............................5-22
Cooling System..............................................5-24
Cruise Control Lever.......................................3-10
Cruise Control Light........................................3-35
Cupholder(s)..................................................2-41
Customer Assistance Information
Courtesy Transportation.................................. 7-7
Customer Assistance for Text
Telephone (TTY) Users............................... 7-4
Customer Assistance Offices........................... 7-4
Customer Satisfaction Procedure..................... 7-2
GM Mobility Reimbursement Program............... 7-5
Reporting Safety Defects to General Motors....7-11
Reporting Safety Defects to the Canadian
Government............................................7-11
Reporting Safety Defects to the United
States Government...................................7-10
Roadside Assistance Program......................... 7-5
Service Publications Ordering Information........7-11
3

D
Daytime Running Lamps..................................3-14
Defensive Driving............................................. 4-2
Delayed Headlamps........................................3-14
Delayed Locking.............................................2-10
Doing Your Own Service Work........................... 5-4
Dome Lamp...................................................3-16
Door
Delayed Locking..........................................2-10
Door Ajar Reminder.....................................2-10
Locks.......................................................... 2-9
Power Door Locks.......................................2-10
Driver
Position, Safety Belt.....................................1-13
Driver Information Center (DIC).........................3-36
DIC Operation and Displays..........................3-37
DIC Vehicle Personalization..........................3-42
DIC Warnings and Messages........................3-40
Driving
At Night.....................................................4-16
City...........................................................4-20
Defensive..................................................... 4-2
Drunken....................................................... 4-2
Freeway.....................................................4-21
Hill and Mountain Roads..............................4-24
In Rain and on Wet Roads...........................4-18
Rocking Your Vehicle to Get it Out.................4-30
Winter........................................................4-25
E
Electrical System
Add-On Equipment......................................5-75
Engine Compartment Fuse Block...................5-78
Fuses and Circuit Breakers...........................5-75
Instrument Panel Fuse Block.........................5-76
Power Windows and Other Power Options......5-75
Rear Compartment Fuse Block......................5-79
Windshield Wiper Fuses...............................5-75
Engine
Air Cleaner/Filter.........................................5-17
Battery.......................................................5-33
Check and Service Engine Soon Light............3-31
Coolant......................................................5-19
Coolant Heater............................................2-23
Coolant Temperature Gage...........................3-30
Engine Compartment Overview......................5-12
Exhaust.....................................................2-31
Oil .............................................................5-13
Overheating................................................5-22
Starting......................................................2-21
Enhanced Traction System (ETS)......................4-10
Entry/Exit Lighting...........................................3-17
Event Data Recorders (EDR)............................. 7-9
Extender, Safety Belt.......................................1-27
4

F
Filter
Engine Air Cleaner......................................5-17
Finish Damage...............................................5-72
Flash-to-Pass................................................... 3-8
Flat Tire........................................................5-55
Flat Tire, Changing.........................................5-56
Flat Tire, Storing.............................................5-64
Fluid
Automatic Transaxle.....................................5-19
Windshield Washer......................................5-29
Fog Lamps....................................................3-16
Fuel............................................................... 5-5
Additives...................................................... 5-6
California Fuel.............................................. 5-6
Filling a Portable Fuel Container....................5-10
Filling Your Tank........................................... 5-8
Fuels in Foreign Countries.............................. 5-7
Gage.........................................................3-36
Gasoline Octane........................................... 5-5
Gasoline Specications.................................. 5-5
Low Warning Light.......................................3-36
Fuses
Engine Compartment Fuse Block...................5-78
Fuses and Circuit Breakers...........................5-75
Instrument Panel Fuse Block.........................5-76
Rear Compartment Fuse Block......................5-79
Windshield Wiper.........................................5-75
G
Gage
Engine Coolant Temperature.........................3-30
Fuel..........................................................3-36
Speedometer..............................................3-26
Tachometer.................................................3-26
Garage Door Opener.......................................2-37
Gasoline
Octane........................................................ 5-5
Specications............................................... 5-5
Glove Box.....................................................2-41
GM Mobility Reimbursement Program.................. 7-5
H
Hazard Warning Flashers................................... 3-6
Head Restraints............................................... 1-6
Headlamps....................................................3-13
Automatic Headlamp System.........................3-15
Bulb Replacement.......................................5-38
Daytime Running Lamps...............................3-14
Delayed.....................................................3-14
Flash-to-Pass............................................... 3-8
Halogen Bulbs............................................5-38
Headlamps, Front Turn Signal, Sidemarker,
and Parking Lamps..................................5-38
High/Low Beam Changer................................ 3-8
On Reminder..............................................3-13
Headlamps Off in Park (P)...............................3-14
5