warning RAM CHASSIS CAB 2007 Owners Manual

WARNING!Worn brake hoses can burst and cause brake failure.
You could have an accident. If you see any signs of
cracking, scuffing, or worn spots, have the brake
hoses replaced immediately.
Brake Master Cylinder – Brake Fluid Level Check
The fluid level of the master cylinder should be checked
when performing under the hood service, or immedi-
ately if the brake system warning lamp indicates system
failure.
The brake master cylinder has a translucent plastic
reservoir. On the outboard side of the reservoir, there is a
“FULL” dot and an “ADD” dot. The fluid level must be
kept within these two dots. Do not add fluid above the
full mark because leakage may occur at the cap. With disc brakes the fluid level can be expected to fall as
the brake linings wear. However, an unexpected drop in
fluid level may be caused by a leak and a system check
should be conducted.
Refer to Fluids, Lubricants and Genuine Parts for the
correct Fluid type.
WARNING!Use of a brake fluid that may have a lower initial
boiling point, or unidentified as to specification,
may result in sudden brake failure during hard
prolonged braking. You could have an accident. MAINTAINING YOUR VEHICLE 435
7

WARNING!Overfilling the brake fluid reservoir can result in
spilling brake fluid on hot engine parts and the
brake fluid catching fire.
Use only brake fluid that has been in a tightly closed
container to avoid contamination from foreign matter or
moisture.
CAUTION!Do not allow a petroleum-base fluid to contaminate
the brake fluid. Seal damage and loss of brake
performance may result. Clutch Hydraulic System
The clutch hydraulic system is a sealed maintenance-free
system. In the event of leakage or other malfunction, the
system must be replaced.
Clutch Linkage
If the clutch pedal linkage begins to squeak or grunt, the
clutch pedal pivot bushings should be lubricated. Refer
to Fluids, Lubricants and Genuine Parts for the correct
lubricant type. Multipurpose Grease, NLGI Grade 2 E.P.
Rear Axle And 4x4 Front Driving Axle Fluid Level
For Model 9.25 Front Axles and 11.5” Rear Axles refer to
Fluids, Lubricants and Genuine Parts for the correct
lubricant type. For normal service, periodic fluid level
checks are not required. When the vehicle is serviced for
other reasons, the exterior surfaces of the axle assembly
should be inspected.436 MAINTAINING YOUR VEHICLE

Interior Care
Use Mopar  Total Clean to clean fabric upholstery and
carpeting.
Use Mopar  Total Clean to clean vinyl upholstery.
Mopar  Total Clean is specifically recommended for
leather upholstery.
Your leather upholstery can be best preserved by regular
cleaning with a damp soft cloth. Small particles of dirt
can act as an abrasive and damage the leather upholstery
and should be removed promptly with a damp cloth.
Stubborn soils can be removed easily with a soft cloth
and Mopar  Total Clean. Care should be taken to avoid
soaking your leather upholstery with any liquid. Please
do not use polishes, oils, cleaning fluids, solvents, deter-
gents, or ammonia based cleaners to clean your leather
upholstery. Application of a leather conditioner is not
required to maintain the original condition. WARNING!Do not use volatile solvents for cleaning purposes.
Many are potentially flammable, and if used in
closed areas they may cause respiratory harm.
Cleaning Headlights
Your vehicle has plastic headlights that are lighter and
less susceptible to stone breakage than glass headlights.
Plastic is not as scratch resistant as glass and therefore
different lens cleaning procedures must be followed.
To minimize the possibility of scratching the lenses and
reducing light output, avoid wiping with a dry cloth. To
remove road dirt, wash with a mild soap solution fol-
lowed by rinsing.
Do not use abrasive cleaning components, solvents, steel
wool or other aggressive material to clean the lenses. MAINTAINING YOUR VEHICLE 455
7

WARNING!You can be badly injured working on or around a
motor vehicle. Do only that service work for which
you have the knowledge and the right equipment. If
you have any doubt about your ability to perform a
service job, take your vehicle to a competent me-
chanic.
MAINTENANCE SCHEDULES – GAS ENGINES
There are two maintenance schedules that show the
required service for your vehicle.
First is Schedule “B” . It is for vehicles that are operated
under one or more of the following conditions that are
listed below and at the beginning of the schedule.
• Day or night temperatures are below 32° F (0° C).
• Stop and go driving. • Extensive engine idling.
• Driving in dusty conditions.
• Short trips of less than 10 miles (16 km).
• More than 50% of your driving is at sustained high
speeds during hot weather, above 90° F (32°C).
• Trailer towing.
• Snowplowing.
• Heavy Loading.
• Taxi, police, or delivery service (commercial service).
• Off-road or desert operation.
• If equipped for and operating with E-85 (ethanol)
fuel.
NOTE: If ANY of these apply to you then change your
engine oil every 3,000 miles (5 000 km) or 3 months,484 MAINTENANCE SCHEDULES
8 M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

* This maintenance is not required if the belt was
previously replaced.
Inspection and service should also be performed anytime
a malfunction is observed or suspected. Retain all re-
ceipts. WARNING!You can be badly injured working on or around a
motor vehicle. Do only that service work for which
you have the knowledge and the right equipment. If
you have any doubt about your ability to perform a
service job, take your vehicle to a competent me-
chanic.502 SCHEDULE “A”
8 M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

may depart significantly from the norm due to variations
in driving habits, service practices and differences in road
characteristics and climate.
Traction Grades
The traction grades, from highest to lowest, are AA, A, B,
and C. Those grades represent the tire’s ability to stop on
wet pavement as measured under controlled conditions
on specified government test surfaces of asphalt and
concrete. A tire marked C may have poor traction perfor-
mance.
WARNING!The traction grade assigned to this tire is based on
straight-ahead braking traction tests, and does not
include acceleration, cornering, hydroplaning, or
peak traction characteristics. Temperature Grades
The temperature grades are A (the highest), B, and C,
representing the tire’s resistance to the generation of heat
and its ability to dissipate heat when tested under
controlled conditions on a specified indoor laboratory
test wheel. Sustained high temperature can cause the
material of the tire to degenerate and reduce tire life, and
excessive temperature can lead to sudden tire failure. The
grade C corresponds to a level of performance which all
passenger car tires must meet under the Federal Motor
Vehicle Safety Standard No. 109. Grades B and A repre-
sent higher levels of performance on the laboratory test
wheel than the minimum required by law.510 IF YOU NEED CONSUMER ASSISTANCE

WARNING!The temperature grade for this tire is established for
a tire that is properly inflated and not overloaded.
Excessive speed, under inflation, or excessive load-
ing, either separately or in combination, can cause
heat buildup and possible tire failure. IF YOU NEED CONSUMER ASSISTANCE 511
9

Adding Fuel ........................ 333,335
Adjustable Pedals ....................... 130
Air Cleaner, Engine (Engine Air Cleaner
Filter) .......................... 406,407,446
Air Conditioner Maintenance ............... 420
Air Conditioning Refrigerant ............. 420,421
Air Conditioning System ................ 233,420
Air Conditioning System, Zone Control ........ 236
AirFilter .............................. 407
Air Pressure, Tires .................... 315,323
Airbag .............................. 48,53
Airbag Light ......................... 76,173
Airbag On/Off Switch ..................... 53
Alarm, Panic ............................ 22
Alarm (Security Alarm) ................. 18,175
Alarm System (Security Alarm) ............... 18
Alignment and Balance ................... 322
Alterations/Modifications, Vehicle ............. 8
Antenna, Satellite Radio ................... 226 Antifreeze (Engine Coolant) .............. 428,429
Capacities ........................... 468
Anti-Lock Warning Light ............... 177,304
Anti-Theft Security Alarm (Theft Alarm) ........ 18
Anti-Theft System ..................... 18,175
Appearance Care ........................ 452
Ashtray ............................... 151
Auto Unlock, Doors ...................... 145
AutomaticDimmingMirror ................. 84
Automatic Door Locks .................... 145
Automatic Transaxle ...................... 12
Interlock System ........................ 15
Automatic Transmission ........... 267,273,438,441
Fluid and Filter Changes .............. 440,443
Fluid Level Check ................ 439,441,442
FluidType ..................... 438,441,471
Shift Indicator ........................ 175
Special Additives ................... 441,444
Automatic Transmission (Diesel Engine Only) .... 438514 INDEX

Automatic Transmission (Gas Engine Only) ..... 441
AxleFluid .......................... 437,471
Axle Lubrication (Axle Fluid) ............... 437
BallJoints ............................. 422
Battery ............................ 418,419
Blanket .......................... 260,420
Emergency Starting ..................... 382
Keyless Transmitter Replacement (RKE) ....... 24
Saving Feature (Protection) ............... 123
Bearings .............................. 444
Belts,Drive ............................ 406
Belts, Seat .............................. 35
Body Mechanism Lubrication ............... 423
B-Pillar Location ........................ 310
Brake Fluid ............................ 471
Brake System ........................ 301,434
Anti-Lock (ABS) ....................... 302
Disc Brakes .......................... 434 Fluid Check .......................... 435
Hoses .............................. 434
Master Cylinder ....................... 435
Parking ............................. 299
Warning Light ........................ 177
Bulb Replacement ....................... 462
Bulbs,Light ............................ 461
Cab Top Clearance Lights .................. 466
Calibration, Compass .................. 138,148
Capacities, Antifreeze (Engine Coolant) ........ 468
Capacities, Fluid ........................ 468
Caps, Filler
Oil (Engine) ....................... 401,403
Power Steering ........................ 421
Radiator (Coolant Pressure) ............... 429
Car Washes ............................ 452
Carbon Monoxide Warning ............... 75,330
Cassette Tape and Player Maintenance ......... 228 INDEX 515
10

Emergency, In Case of
Freeing Vehicle When Stuck ............... 385
Hazard Warning Flasher ................. 370
Jacking ............................. 372
Jump Starting ......................... 382
Tow Hooks .......................... 386
Towing ............................. 387
Emission Control System Maintenance ......... 474
Emission Related Components .............. 418
Engine ............................ 392,393
Air Cleaner ........................ 406,407
Block Heater .................... 252,259,265
Break-In Recommendations ................ 72
Compartment ......................... 392
Compartment Identification ............... 393
Coolant (Antifreeze) .................... 469
Cooling ............................. 426
Data Plate ........................... 395
Exhaust Gas Caution .................... 330 Flooded, Starting ...................... 249
Identification ......................... 392
Idling .............................. 261
Jump Starting ......................... 382
Oil .............................. 398,469
Oil Filler Cap ...................... 401,403
Oil Selection .......................... 401
Oil Synthetic ....................... 260,403
Runaway ............................ 327
Temperature Gauge ..................... 174
Event Data Recorder ...................... 57
Exhaust Brake .......................... 265
Exhaust Gas Caution ................ 75, 330,425
Exhaust System .................... 75, 425,446
ExteriorLighting ........................ 124
Fabric Care ............................ 454
Fan .................................. 432518 INDEX