RENAULT CLIO 1997 X57 / 1.G Petrol Engines Repair Manual

Engine fitted with a CAMSHAFT SPROCKET WITH
MARKS
Set the engine to TDC with ignition in cylinder
No.1.
Turn the crankshaft clockwise
(seen from the
timing side)
as far as the first mark.
SET:exhaust 1
exhaust 3
move on to the second mark:
SET:inlet 1
inlet 3
third mark:
SET:exhaust 2
exhaust 4
fourth mark:
SET:inlet 2
inlet 4
ENGINE AND PERIPHERALS
En
gine repair10
10072S
10-49
Page 1 of 1 E_Series_51
04.08.2003 http://jester.com.ua/renault/motors/e/E_Series/css/E_Series_51.htm

ENGINE AND PERIPHERALS
En
gine repair10
Refit:
- the cylinder head cover fitted with a new gas-
ket,
- the coolant pipe and the dipstick guide tube
with new seals,
- the timing cover,
- the crankshaft pulley tightening the bolt to
2 daN.m, then angle tighten to
68°
±6°,
- the inlet and exhaust manifolds, tightening the
nuts to
2.5 daN.m,
- the accessories belt or belts.
Tensionin
g process
Engine cold (ambient temperature).
Fit the new belt.
Position the sensor of the
Mot. 1273.
Turn the knurled wheel of the sensor until it re-
leases (three "clicks").
Tension the belt until the fitting value recommen-
ded on the next page is shown on the display of
the
Mot. 1273.
Lock the tension wheel, carry out a check and ad-
just the value.
Rotate the crankshaft
three turns.
Check that the tension value is within the fitting
tension tolerance, and if not readjust it.
NOTE : Never refit a belt which has been remo-
ved.
10-50
Page 1 of 1 E_Series_52
04.08.2003 http://jester.com.ua/renault/motors/e/E_Series/css/E_Series_52.htm

ENGINE AND PERIPHERALS
En
gine repair10
12310R
Tension(US = SEEM
Units)
Alternator
belt
Vee
F1
Grooved
3 teeth
F2Power assisted
steerin
g
belt
Grooved 3 teeth
F3
(E7J 764)F3 F4Air
conditionin
g
belt
Vee
F5Grooved 4 teeth
F6 F7Air conditionin
g and
power assisted
steerin
g
belt
Grooved 4
teeth
F8 F9Grooved 5
teeth
F8
Fitting
83 ± 7 84 ± 684 ± 684 ±5 84 ±490
102 ±6 103 ±4 106 110 ± 7110
Minimum
operating70 52 52 46 47 72 55 77 59 75 59
A Crankshaf
t
B Alternator
C Air conditioning compressor
D Power assisted steering pump
E Pulley
T Tension wheel
→ Tension checking poin
t
Alternator Power assisted steering
12311R
10-51
Page 1 of 1 E_Series_53
04.08.2003 http://jester.com.ua/renault/motors/e/E_Series/css/E_Series_53.htm

ENGINE AND PERIPHERALS
En
gine repair10
94103R1
Power assisted steering
92672R
Air conditioning
12308R1
Air conditioning
12309R1
Air conditioning
10-52
Page 1 of 1 E_Series_54
04.08.2003 http://jester.com.ua/renault/motors/e/E_Series/css/E_Series_54.htm

ENGINE AND PERIPHERALS
En
gine repair10
98707R1
Air conditioning and Power assisted steering
98707R2
Power assisted steering and Air conditioning
10-53
Page 1 of 1 E_Series_55
04.08.2003 http://jester.com.ua/renault/motors/e/E_Series/css/E_Series_55.htm