tires SATURN ASTRA 2009 Service Manual

When InSP appears, certain
services, checks, and inspections
are required. Required services
are described in the following
for “MaintenanceI” and
“Maintenance II.” Generally, it is
recommended that the rst service
be Maintenance I, the second
service be Maintenance II, and then
alternate Maintenance Iand Maintenance
IIthereafter. However,
in some cases, Maintenance II
might be required more often.
Maintenance I—Use
Maintenance Iif InSP displays
within 10 months since the vehicle
was purchased or Maintenance II
was performed. Maintenance
II—Use
Maintenance IIif the previous
service performed was
Maintenance I. Always use
Maintenance IIwhenever the letters
InSP display 10 months or more
since the last service or if InSP has
not come on at all for one year.
Scheduled Maintenance
Service MaintenanceIMaintenance II
Change engine oil and lter. See Engine Oil on page 9-7. Reset oil life system.
See Engine Oil Life System on page 9-9 .An Emission Control Service. ••
Visually check for any leaks or damage. See footnote (a). ••
Inspect engine air cleaner lter. If necessary, replace lter. See Engine Air
Cleaner/Filter on page 9-11 .See footnote (b). •
Rotate tires and check ination pressures and wear. See Tire Inspection and
Rotation on page 9-52 and “Tire Wear Inspection” in At Least Once a Month
on page 11-10. ••
11-4 Service and Maintenance
ProCarManuals.com

At Least Once a Month
Tire Ination Check
Inspect the vehicle’s tires and make
sure they are inated to the correct
pressures. Do not forget to check
the spare tire. SeeInflation - Tire
Pressure on page 9-47. Check to
make sure the spare tire is stored
securely. SeeChanging a Flat Tire
on page 9-61.
Tire Wear Inspection
Tire rotation may be required for
high mileage highway drivers prior to
the Engine Oil Life System service
notication. Check the tires for
wear and, if necessary, rotate the
tires. SeeTire Inspection and
Rotation on page 9-52.
At Least Once a Year
Starter Switch Check
{CAUTION
When you are doing this
inspection, the vehicle could move
suddenly. If the vehicle moves,
you or others could be injured.
1. Before starting this check, be
sure there is enough room
around the vehicle.
2. Firmly apply both the parking
brake and the regular brake.
SeeParking Brake on page 8-10.
Do not use the accelerator
pedal, and be ready to turn off
the engine immediately if it starts.
3. Try to start the engine in
each gear. The vehicle should
start only in P (Park) or
N (Neutral). If the vehicle starts
in any other position, contact
your dealer/retailer for service.
Automatic Transmission Shift
Lock Control System Check
{CAUTION
When you are doing this
inspection, the vehicle could move
suddenly. If the vehicle moves,
you or others could be injured.
1. Before starting this check, be
sure there is enough room
around the vehicle. It should be
parked on a level surface.
2. Firmly apply the parking brake.
SeeParking Brake on page 8-10.
Be ready to apply the regular
brake immediately if the vehicle
begins to move.
3. With the engine off, turn the
ignition to ON/RUN, but do not
start the engine. Without applying
the regular brake, try to move the
shift lever out of P (Park) with
normal effort. If the shift lever
moves out of P (Park), contact
your dealer/retailer for service.
11-10 Service and Maintenance
ProCarManuals.com

Services Provided

Emergency Fuel Delivery:
Delivery of enough fuel
for the vehicle to get to the
nearest service station.
Lock-Out Service:Service is
provided to unlock the vehicle
if you are locked out. A remote
unlock may be available if you
have OnStar
®. For security
reasons, the driver must present
identication before this service
is given.
Emergency Tow From a Public
Road or Highway:Tow to the
nearest Saturn retailer for
warranty service, or if the vehicle
was in a crash and cannot be
driven. Assistance is also
given when the vehicle is stuck
in sand, mud, or snow.
Flat Tire Change:Service is
provided to change a at tire
with the spare tire. The spare tire,
if equipped, must be in good
condition and properly inated.
It is the owner’s responsibility for
the repair or replacement of
the tire if it is not covered by the
warranty.
Battery Jump Start:Service is
provided to jump start a dead
battery.
Trip Interruption Benets and
Assistance:If your trip is
interrupted due to a warranty
failure, incidental expenses may
be reimbursed during the 5 years/
100,000 miles (160 000 km)
Powertrain warranty period.
Items considered are hotel,
meals, and rental car.
Services Not Included in
Roadside Assistance

Impound towing caused by
violation of any laws.
Legal nes.
Mounting, dismounting or
changing of snow tires, chains,
or other traction devices.
Towing or services for vehicles
driven on a non-public road or
highway.
Customer Information 12-7
ProCarManuals.com

Bulb Replacement (cont.)
Halogen Bulbs..................9-28
Headlamp Aiming..............9-26
Headlamps......................9-28
License Plate Lamps.........9-33
Replacement Bulbs...........9-34
Taillamps.................9-30, 9-32
Buying New Tires.................9-54
C
California Fuel.....................8-34
California Perchlorate
Materials Requirements....... 9-3
California Proposition 65
Warning............................ 9-3
Canadian Owners..................... ii
Capacities and
Specications...................10-2
Carbon Monoxide.........8-14, 8-27
Care, Safety Belts................1-23
Cargo Cover......................... 3-2
Cargo Tie Downs................... 3-2
Cautions and Notices............... iii
Center High-Mounted
Stoplamp (CHMSL)...........9-29Chains, Tire........................9-60
Charging System Light..........4-16
Check
Engine Lamp...................4-18
Chemical Paint Spotting........9-80
Child Restraints
Child Restraint Systems.....1-43
Infants and Young
Children.......................1-40
Lower Anchors and
Tethers for Children.......1-46
Older Children..................1-38
Securing..................1-51, 1-53
Where to Put the
Restraint......................1-44
Cleaning
Exterior...........................9-76
Interior............................9-73
Underbody Maintenance....9-80
Climate Control System.......... 7-1
Outlet Adjustment............... 7-4
Clutch, Hydraulic..................9-12
Collision Damage Repair.....12-10
Compact Spare Tire.............9-68
Content Theft-Deterrent.......... 2-9
Control of a Vehicle..............8-17Coolant
Engine............................9-16
Engine Temperature
Warning Light...............
4-18
Cooling System...................9-12
Courtesy
Transportation..........12-5, 12-9
Cruise Control....................... 4-5
Cruise Control Light..............4-23
Cupholders........................... 3-1
Customer Information
Courtesy
Transportation.......12-5, 12-9
Customer Assistance
Offices.........................12-5
Customer Satisfaction
Procedure....................12-1
GM Mobility
Reimbursement
Program.......................12-6
Online Owner Center.........12-4
Reporting Safety Defects
to Saturn....................12-14
Reporting Safety Defects
to the Canadian
Government................12-14
i-2 INDEX
ProCarManuals.com

F
Filter
Engine Air Cleaner............9-11
Final Drive
End Play Measurement....... 5-4
Finish Damage....................9-79
Fixed Mast Antenna.............6-24
Flashers, Hazard Warning....... 4-4
Flash-to-Pass........................ 4-8
Flat Tire..............................9-60
Flat Tire, Changing...............9-61
Flat Tire, Storing..................9-66
Fluid
Automatic Transmission.....9-12
Power Steering.................9-20
Windshield Washer...........9-20
Fog Lamp
Fog .................................. 5-2
Fog Lamp Light...................4-22
Fuel...................................8-34
Additives.........................8-34
California Fuel..................8-34
Driving for Better
Economy......................8-15
Filling a Portable Fuel
Container.....................8-37Fuel (cont.)
Filling the Tank.................8-36
Fuels in Foreign
Countries.....................8-35
Gage ..............................4-24
Gasoline Octane...............8-34
Gasoline Specications......8-34
Low Warning Light............4-24
Fuses.................................9-35
Engine Compartment
Fuse Block...................9-35
Rear Compartment
Fuse Block...................9-37
G
Gage
Fuel................................4-24
Speedometer...................4-13
Tachometer......................4-13
Gasoline
Octane............................8-34
Specications...................8-34
Glove Box............................ 3-1
GM Mobility Reimbursement
Program..........................12-6
H
Hazard Warning Flashers........ 4-4
Head Restraints..................... 1-5
Headlamp
Aiming ............................9-26
Headlamp Wiring.................9-34
Headlamps
Bulb Replacement.............9-28
Daytime Running Lamp....... 5-2
Delayed............................ 5-2
Exterior Lamps................... 5-1
Flash-to-Pass..................... 4-8
Front Turn Signal
Lamps .........................9-28
Halogen Bulbs..................9-28
High/Low Beam Changer..... 4-8
Heater................................. 7-1
Engine.............................. 8-5
Height Adjuster, Seat.............. 1-2
Highbeam On Light..............4-23
High-Speed Operation,
Tires...............................9-48
Highway Hypnosis................8-25
Hill and Mountain Roads.......8-26
Hood
Release............................ 9-5
i-4 INDEX
ProCarManuals.com

T
Tachometer.........................4-13
Taillamps....................9-30, 9-32
Theft-Deterrent, Radio...........6-23
Theft-Deterrent Systems......... 2-8
Content Theft-Deterrent....... 2-9
Immobilizer........................ 2-8
Immobilizer Operation......... 2-8
Tilt Wheel............................. 4-4
Tire
Pressure Light..................4-18
Tires..................................9-40
Buying New Tires.............9-54
Chains............................9-60
Changing a Flat Tire.........9-61
Compact Spare Tire..........9-68
Different Size...................9-56
High-Speed Operation.......9-48
If a Tire Goes Flat............9-60
Ination - Tire Pressure.....9-47
Inspection and Rotation.....9-52
Installing the Spare Tire.....9-63
Pressure Monitor
Operation.....................9-51
Pressure Monitor
System........................9-49
Removing the Flat Tire......9-63Tires (cont.)
Removing the Spare Tire
and Tools.....................9-62
Storing a Flat or Spare
Tire and Tools...............9-66
Tire Sidewall Labeling.......9-42
Tire Terminology and
Denitions....................9-44
Uniform Tire Quality
Grading.......................9-57
Wheel Alignment and
Tire Balance.................9-58
Wheel Replacement..........9-59
When It Is Time for
New Tires....................9-54
Winter Tires.....................9-41
Towing
Recreational Vehicle..........9-73
Towing a Trailer................9-73
Your Vehicle.....................9-73
Traction
StabiliTrak
®System..........8-19
Transmission
Fluid, Automatic................9-12
Fluid, Manual...................9-12
Transmission Operation,
Automatic.......................... 8-6
Transmission Operation,
Manual............................. 8-9Trip Odometers....................4-13
Turn and Lane-Change
Signals............................. 4-8
Turn Signal/Multifunction
Lever................................ 4-4
U
Uniform Tire Quality
Grading...........................9-57
V
Vehicle
Control............................8-17
Loading...........................8-30
Parking Your....................8-13
Running While Parked.......8-14
Service Soon Light...........4-23
Symbols.............................. iii
Vehicle Data Recording and
Privacy..........................12-16
Vehicle Identication
Number (VIN)...................10-1
Service Parts Identication
Label...........................10-1
Ventilation Adjustment............. 7-4
Visors.................................2-11
INDEX i-9
ProCarManuals.com

W
Warning Lights, Gages and
Indicators........................4-11
Warnings
DIC Warnings and
Messages....................4-36
Hazard Warning Flashers.... 4-4
Wheels
Alignment and Tire
Balance.......................9-58
Different Size...................9-56
Replacement....................9-59
Where to Put the Restraint....1-44
Windows.............................2-10
Power .............................2-10Windshield
Washer............................. 4-9
Washer Fluid....................9-20
Wiper Blade
Replacement................9-21
Wipers.............................. 4-8
Windshield, Rear Washer/
Wiper............................... 4-9
Winter Driving......................8-27
Winter Driving Mode Light.....4-22
Winter Tires........................9-41
Y
Your Vehicle and the
Environment.....................11-2
i-10 INDEX
ProCarManuals.com