warning SATURN ION 2004 Service Manual

Appearance Care
Remember, cleaning products can be hazardous. Some
are toxic. Others can burst into ames if you strike a
match or get them on a hot part of the vehicle. Some are
dangerous if you breathe their fumes in a closed
space. When you use anything from a container to clean
your vehicle, be sure to follow the manufacturer’s
warnings and instructions. And always open your doors
or windows when you are cleaning the inside.
Never use these to clean your vehicle:
Gasoline
Benzene
Naphtha
Carbon Tetrachloride
Acetone
Paint Thinner
Turpentine
Lacquer Thinner
Nail Polish Remover
They can all be hazardous — some more than
others — and they can all damage your vehicle, too.Do not use any of these unless this manual says you
can. In many uses, these will damage your vehicle:
Alcohol
Laundry Soap
Bleach
Reducing Agents
Cleaning the Inside of Your Vehicle
Use a vacuum cleaner often to get rid of dust and
loose dirt. Wipe vinyl, leather, plastic and painted
surfaces with a clean, damp cloth.
Cleaning Fabric/Carpet
Your dealer has cleaners for the cleaning of fabric and
carpet. They will clean normal spots and stains very well.
You can get GM-approved cleaning products from your
dealer. SeeVehicle Care/Appearance Materials on
page 5-93.
5-87
ProCarManuals.com

A
Accessory Power Outlets.................................3-18
Activating the Theft-Deterrent Feature................3-68
Adding Windshield Washer Fluid.......................5-37
Additives, Fuel................................................. 5-6
Add-On Electrical Equipment............................5-95
Adjusting the Speakers
(Balance/Fade)............................3-49, 3-52, 3-58
Air Bag
Readiness Light..........................................3-30
Air Bag Systems.............................................1-50
Adding Equipment to Your
Air Bag-Equipped Vehicle..........................1-58
How Does an Air Bag Restrain?....................1-56
Servicing Your Air Bag-Equipped Vehicle.........1-58
What Makes an Air Bag Inate?....................1-56
What Will You See After an
Air Bag Inates?......................................1-56
When Should an Air Bag Inate?...................1-55
Where Are the Air Bags?..............................1-52
Air Cleaner/Filter, Engine.................................5-22
Airbag Sensing and Diagnostic Module (SDM)......... 7-7
AM ...............................................................3-70
AM-FM Radio.................................................3-47
Antenna, Fixed Mast.......................................3-71
Antenna, XM™ Satellite Radio
Antenna System..........................................3-71Anti-lock Brake System (ABS)............................ 4-6
Anti-Lock Brake, System Warning Light..............3-34
Appearance Care............................................5-87
Care of Safety Belts....................................5-89
Chemical Paint Spotting...............................5-92
Cleaning the Inside of Your Vehicle................5-87
Cleaning the Outside of Your Vehicle..............5-90
Finish Damage............................................5-92
Sheet Metal Damage...................................5-92
Underbody Maintenance...............................5-92
Vehicle Care/Appearance Materials................5-93
Weatherstrips..............................................5-90
Ashtrays........................................................3-19
Audio System(s).............................................3-46
AM-FM Radio.............................................3-47
Care of Your CD Player...............................3-71
Care of Your CDs........................................3-71
Fixed Mast Antenna.....................................3-71
Radio with CD....................................3-50, 3-54
Setting the Time for Radios with
Radio Data Systems (RDS).......................3-47
Setting the Time for Radios without
Radio Data Systems (RDS).......................3-46
Theft-Deterrent Feature................................3-68
Understanding Radio Reception.....................3-70
XM™ Satellite Radio Antenna System............3-71
Automatic Dimming Mirror Operation..........2-38, 2-40
1
ProCarManuals.com

Automatic Headlamp System............................3-16
Automatic Transaxle........................................2-20
Fluid..........................................................5-24
Operation...................................................2-23
B
Backing Up....................................................4-43
Battery..........................................................5-41
Battery Replacement......................................... 2-8
Battery Run-Down Protection............................3-18
Battery Warning Light......................................3-31
Before Leaving on a Long Trip.........................4-22
Brake
Parking......................................................2-30
System Warning Light..................................3-32
Brake Adjustment............................................5-40
Brake Fluid....................................................5-38
Brake Pedal Travel.........................................5-40
Brake Wear...................................................5-40
Brakes..........................................................5-38
Braking........................................................... 4-6
Braking in Emergencies..................................... 4-8
Break-In, New Vehicle.....................................2-18
Bulb Replacement...........................................5-48
Center High-Mounted Stoplamp (CHMSL)........5-55
Fog Lamps.................................................5-53Bulb Replacement (cont.)
Front Turn Signal and Parking Lamps.............5-53
Front Turn Signal Lamps..............................5-51
Halogen Bulbs............................................5-48
Headlamp Aiming........................................5-47
Headlamps.........................................5-48, 5-50
Replacement Bulbs......................................5-56
Sidemarker Lamps.......................................5-54
Taillamps, Stoplamps and Back-Up Lamps........5-55
Buying New Tires...........................................5-70
C
California Fuel.................................................. 5-6
Canadian Owners................................................ ii
Canadian Roadside Assistance........................... 7-7
Capacities and Specications..........................5-102
Carbon Monoxide...................4-26, 4-39, 2-12, 2-34
Care of
Safety Belts................................................5-89
Your CD Player...........................................3-71
Your CDs ...................................................3-71
Cassette Tape Player Service...........................6-10
CD Messages........................................3-54, 3-67
Center Console Storage Area...........................2-44
Center High-Mounted Stoplamp (CHMSL)...........5-55
Chains, Tires..................................................5-74
2
ProCarManuals.com

Convenience Net............................................2-45
Coolant
Engine Temperature Gage............................3-35
Heater, Engine............................................2-22
Low Level Warning Message.........................3-43
Surge Tank Pressure Cap.............................5-29
Cooling System..............................................5-32
Cruise Control................................................3-12
Cruise Control Message...................................3-42
Cupholder(s)..................................................2-44
Customer Assistance Information
Customer Assistance for Text
Telephone (TTY) Users............................... 7-4
Customer Satisfaction Procedure..................... 7-2
GM Mobility Program for Persons with
Disabilities................................................ 7-5
Reporting Safety Defects to Saturn.................. 7-9
Reporting Safety Defects to the
Canadian Government................................ 7-9
Reporting Safety Defects to the
United States Government.......................... 7-9
Roadside Assistance Program......................... 7-5
Service Publications Ordering Information........7-10D
Daytime Running Lamps..................................3-15
Defensive Driving............................................. 4-2
Defogging and Defrosting.........................3-21, 3-23
Delayed Locking.............................................2-10
Dinghy Towing (Five-Speed Automatic
Transaxle and VTi Variable Transaxle)............4-31
Dinghy Towing (Manual Transaxle)....................4-32
Disabling the Theft-Deterrent Feature.................3-70
Doing Your Own Service Work........................... 5-4
Dolly Towing (All Transaxles)............................4-33
Dome Lamp...................................................3-18
Door
Delayed Locking..........................................2-10
Locks.......................................................... 2-9
Power Door Locks.......................................2-10
Programmable Automatic Door Locks.............2-10
Rear Door Security Locks.............................2-11
Rear Doors.................................................2-12
Driver
Position, Safety Belt.....................................1-14
Seat Height Adjuster...................................... 1-3
Driving
At Night.....................................................4-15
City...........................................................4-20
Defensive..................................................... 4-2
4
ProCarManuals.com

F
Filter
Engine Air Cleaner......................................5-22
Finding a Category (CAT) Station......................3-58
Finding a Station............................3-48, 3-50, 3-56
Finish Care....................................................5-90
Finish Damage...............................................5-92
Five-Speed....................................................2-28
Five-Speed Automatic and VTi Variable..............2-23
Fixed Mast Antenna........................................3-71
Flash-to-Pass................................................... 3-9
Flat Tire........................................................5-75
Flat Tire, Changing.........................................5-76
Fluid
Automatic Transaxle.....................................5-24
Manual Transaxle........................................5-25
Windshield Washer......................................5-37
FM Stereo.....................................................3-70
Fog Lamps....................................................3-17
Folding Rear Seat............................................ 1-7
Folding Seatback, Passenger............................. 1-6
Following Distance..........................................4-43
Fuel............................................................... 5-5
Additives...................................................... 5-6
California Fuel.............................................. 5-6Fuel (cont.)
Filling a Portable Fuel Container..................... 5-9
Filling Your Tank........................................... 5-8
Fuels in Foreign Countries.............................. 5-7
Gage.........................................................3-40
Gasoline Octane........................................... 5-5
Gasoline Specications.................................. 5-5
Low Warning Message.................................3-45
Fuses
Fuses and Circuit Breakers...........................5-95
Windshield Wiper.........................................5-95
G
Gage
Engine Coolant Temperature.........................3-35
Fuel..........................................................3-40
Speedometer..............................................3-29
Tachometer.................................................3-29
Gasoline
Octane........................................................ 5-5
Specications............................................... 5-5
Glove Box.....................................................2-44
GM Mobility Program for Persons with
Disabilities.................................................... 7-5
6
ProCarManuals.com

H
Hazard Warning Flashers................................... 3-6
Head Restraints............................................... 1-5
Headlamp
Aiming.......................................................5-47
Headlamp High/Low-Beam Changer..................... 3-9
Headlamps............................3-10, 3-15, 5-48, 5-50
Bulb Replacement.......................................5-48
Front Turn Signal and Parking Lamps.............5-53
Front Turn Signal Lamps..............................5-51
Halogen Bulbs............................................5-48
Sidemarker Lamps.......................................5-54
Height Adjuster, Driver Seat............................... 1-3
High Speed Operation (Redline)........................5-67
Highway Hypnosis...........................................4-23
Hill and Mountain Roads..................................4-24
Hitches..........................................................4-42
Hood
Checking Things Under................................5-10
Release.....................................................5-10
Horn............................................................... 3-7
How to Add Coolant to the Coolant
Surge Tank.................................................5-34
How to Inspect the Engine Air Cleaner/Filter.......5-23How to Use This Manual...................................... ii
How to Wear Safety Belts Properly...................1-14
Hydraulic Clutch.............................................5-25
Hydroplaning..................................................4-19
I
If No Steam Is Coming From Your Engine..........5-31
If Steam Is Coming From Your Engine...............5-30
If the Light Is Flashing.....................................3-37
If the Light Is On Steady.................................3-37
If You Are Caught in a Blizzard.........................4-28
If You Are Stuck in Sand, Mud, Ice or Snow..........4-30
If You Do Decide to Pull a Trailer......................4-40
Ignition Positions.............................................2-18
Infants and Young Children, Restraints...............1-32
Ination - Tire Pressure...................................5-66
Instrument Panel
Cluster.......................................................3-28
Overview..................................................... 3-4
Instrument Panel Brightness.............................3-17
Instrument Panel Fuse Block............................5-96
Interior Lamps................................................3-17
7
ProCarManuals.com

J
Jump Starting.................................................5-42
K
Keyless Entry System....................................... 2-4
Keys............................................................... 2-3
L
Lamps
Exterior......................................................3-15
Fog Lamps.................................................5-53
Interior.......................................................3-17
Lap-Shoulder Belt...................................1-14, 1-23
LATCH System
Child Restraints...........................................1-42
Securing a Child Restraint Designed for
the LATCH System...................................1-44
Leaving Your Vehicle.......................................2-11
Leaving Your Vehicle With the
Engine Running..........................................2-32Light
Air Bag Readiness.......................................3-30
Anti-Lock Brake System Warning...................3-34
Battery Warning..........................................3-31
Brake System Warning.................................3-32
Malfunction Indicator....................................3-36
Oil Pressure...............................................3-39
Passlock
®Warning.......................................3-40
Safety Belt Reminder...................................3-30
Up-Shift.....................................................3-32
Loading Your Vehicle.......................................4-33
Lockout Protection..........................................2-11
Locks
Delayed Locking..........................................2-10
Door........................................................... 2-9
Leaving Your Vehicle....................................2-11
Lockout Protection.......................................2-11
Power Door................................................2-10
Programmable Automatic Door Locks.............2-10
Rear Door Security Locks.............................2-11
Loss of Control...............................................4-14
Low Coolant Level Warning Message................3-43
Low Fuel Warning Message.............................3-45
Low-Prole Performance Tire (Redline)...............5-59
8
ProCarManuals.com

M
Maintenance Schedule
Additional Required Services........................... 6-6
At Each Fuel Fill.........................................6-10
At Least Once a Month................................6-10
At Least Once a Year..................................6-11
Introduction.................................................. 6-2
Maintenance Footnotes.................................. 6-8
Maintenance Record....................................6-18
Maintenance Requirements............................. 6-2
Normal Maintenance Replacement Parts.........6-16
Owner Checks and Services........................... 6-9
Recommended Fluids and Lubricants.............6-14
Scheduled Maintenance................................. 6-4
Using Your................................................... 6-2
Your Vehicle and the Environment................... 6-2
Maintenance When Trailer Towing.....................4-46
Making Turns.................................................4-43
Malfunction Indicator Light................................3-36
Manual Seats................................................... 1-2
Manual Transaxle............................................2-20
Fluid..........................................................5-25
Operation...................................................2-28
Manual Windows............................................2-15
Map Lamps....................................................3-18
Matching Transmitter(s) to Your Vehicle............... 2-7Message
Center.......................................................3-41
Change Engine Oil......................................3-43
Check Gage...............................................3-44
Cruise Control.............................................3-42
Error..........................................................3-45
Low Coolant Level Warning..........................3-43
Low Fuel Warning.......................................3-45
Low Traction...............................................3-42
Power Steering...........................................3-44
Service Vehicle...........................................3-45
Traction Off................................................3-42
Transaxle Fluid Cold....................................3-43
Transaxle Fluid Hot......................................3-42
Trunk Ajar Warning......................................3-44
Mirrors
Automatic Dimming Rearview with
Compass and Temperature Display.............2-40
Automatic Dimming Rearview with OnStar
®,
Compass and Temperature Display.............2-37
Manual Rearview Mirror................................2-36
Manual Rearview Mirror with OnStar
®.............2-36
Outside Convex Mirror.................................2-42
Outside Power Mirrors..................................2-42
Outside Remote Control Mirror......................2-42
MyGMLink.com................................................ 7-4
9
ProCarManuals.com

N
New Vehicle Break-In......................................2-18
Normal Maintenance Replacement Parts............6-16
O
Odometer......................................................3-29
Off-Road Recovery..........................................4-12
Oil
Engine.......................................................5-15
Pressure Light.............................................3-39
Older Children, Restraints................................1-29
Online Owner Center........................................ 7-4
OnStar
®Personal Calling.................................2-44
OnStar®Services............................................2-43
OnStar®System.............................................2-43
OnStar®Virtual Advisor....................................2-44
Operation..............................................3-20, 3-22
Other Warning Devices...................................... 3-7
Outlet Adjustment............................................3-24
Outside
Convex Mirror.............................................2-42
Power Mirrors.............................................2-42
Remote Control Mirror..................................2-42Owner Checks and Services.............................. 6-9
Owner Publications.........................................7-10
Owners, Canadian............................................... ii
P
Park (P)
Shifting Into................................................2-31
Shifting Out of............................................2-33
Parking
Brake........................................................2-30
Over Things That Burn.................................2-34
Parking on Hills..............................................4-45
Parking Your Vehicle.......................................2-33
Passenger Compartment Air Filter.....................3-25
Passenger Visor Webbing Clip (Coupe)..............2-16
Passing.................................................4-12, 4-43
Passlock
®......................................................2-17
Playing a CD.................................................3-52
Playing the Radio...........................3-47, 3-50, 3-55
Playing the Single CD Player...........................3-60
Playing the Six-Disc CD Player.........................3-62
Power
Accessory Outlets........................................3-18
Door Locks.................................................2-10
Electrical System.........................................5-95
10
ProCarManuals.com

Reporting Safety Defects
Canadian Government................................... 7-9
Saturn......................................................... 7-9
United States Government.............................. 7-9
Restraint System Check
Checking Your Restraint Systems...................1-59
Replacing Restraint System Parts
After a Crash..........................................1-59
Restraint Systems
Checking....................................................1-59
Replacing Parts...........................................1-59
Retained Accessory Power (RAP)......................2-19
Right Front Passenger Position, Safety Belts........1-22
Roadside
Assistance Program....................................... 7-5
Roof Rack System..........................................2-45
Routing, Engine Drive Belt...............................6-17
Running Your Engine While You Are Parked.......2-35
S
Safety Belt
Pretensioners..............................................1-28
Reminder Light............................................3-30
Safety Belts
Care of......................................................5-89
Driver Position............................................1-14Safety Belts (cont.)
How to Wear Safety Belts Properly................1-14
Questions and Answers About Safety Belts........1-13
Rear Safety Belt Comfort Guides for
Children and Small Adults.........................1-26
Rear Seat Passengers.................................1-22
Right Front Passenger Position......................1-22
Safety Belt Extender....................................1-28
Safety Belt Use During Pregnancy.................1-21
Safety Belts Are for Everyone......................... 1-8
Safety Chains.................................................4-42
Safety Warnings and Symbols.............................. iii
Scheduled Maintenance..................................... 6-4
Seatback, Folding Passenger............................. 1-6
Seats
Driver Seat Height Adjuster............................. 1-3
Head Restraints............................................ 1-5
Manual........................................................ 1-2
Passenger Folding Seatback........................... 1-6
Reclining Seatbacks...................................... 1-3
Split Folding Rear Seat.................................. 1-7
Securing a Child Restraint
Designed for the LATCH System...................1-44
Rear Seat Position......................................1-44
Right Front Seat Position..............................1-47
Security While You Travel.................................. 7-5
12
ProCarManuals.com