check engine light SATURN ION 2005 User Guide

You can run the engine to keep warm, but be careful.
{CAUTION:
Snow can trap exhaust gases under your
vehicle. This can cause deadly CO (carbon
monoxide) gas to get inside. CO could
overcome you and kill you. You cannot see it
or smell it, so you might not know it is in your
vehicle. Clear away snow from around the
base of your vehicle, especially any that is
blocking your exhaust pipe. And check around
again from time to time to be sure snow does
not collect there.
Open a window just a little on the side of the
vehicle that is away from the wind. This will
help keep CO out.
Run your engine only as long as you must. This saves
fuel. When you run the engine, make it go a little
faster than just idle. That is, push the accelerator
slightly. This uses less fuel for the heat that you get and
it keeps the battery charged. You will need a
well-charged battery to restart the vehicle, and possibly
for signaling later on with your headlamps. Let the
heater run for a while.
4-27
ProCarManuals.com

Adding Equipment to the Outside of
Your Vehicle
Things you might add to the outside of your vehicle
can affect the airow around it. This may cause
wind noise and affect windshield washer performance.
Check with your retailer before adding equipment to
the outside of your vehicle.
Fuel
Use of the recommended fuel is an important part of the
proper maintenance of your vehicle.
Gasoline Octane
If your vehicle has the 2.2L L4 engine, use regular
unleaded gasoline with a posted octane of 87 or higher.
If the octane is less than 87, you may get a heavy
knocking noise when you drive. If this occurs, use a
gasoline rated at 87 octane or higher as soon as
possible. Otherwise, you might damage your engine. A
little pinging noise when you accelerate or drive
uphill is considered normal. This does not indicate a
problem exists or that a higher-octane fuel is necessary.
If you are using 87 octane or higher-octane fuel and
hear heavy knocking, your engine needs service.
If your vehicle has the 2.0L Supercharged engine, use
premium unleaded gasoline with a posted octane of
91 or higher for best performance. You may also
use middle grade or regular unleaded gasoline rated at
87 octane or higher, but your vehicle’s acceleration
may be slightly reduced. If the octane is less than 87,
you may get a heavy knocking noise when you drive. If
this occurs, use a gasoline rated at 87 octane or
higher as soon as possible. Otherwise, you might
damage your engine.
5-5
ProCarManuals.com

A 50/50 mixture of clean, drinkable water and
DEX-COOL®coolant will:
Give freezing protection down to−34°F (−37°C).
Give boiling protection up to 265°F (129°C).
Protect against rust and corrosion.
Help keep the proper engine temperature.
Let the warning lights and gages work as they
should.
Notice:Using coolant other than DEX-COOL
®may
cause premature engine, heater core or radiator
corrosion. In addition, the engine coolant may
require changing sooner, at 30,000 miles (50 000 km)
or 24 months, whichever occurs rst. Any repairs
would not be covered by your warranty. Always use
DEX-COOL
®(silicate-free) coolant in your vehicle.
What to Use
Use a mixture of one-half clean, drinkable water and
one-half DEX-COOL®coolant which will not damage
aluminum parts. If you use this coolant mixture, you do
not need to add anything else.
{CAUTION:
Adding only plain water to your cooling
system can be dangerous. Plain water, or
some other liquid such as alcohol, can boil
before the proper coolant mixture will. Your
vehicle’s coolant warning system is set for the
proper coolant mixture. With plain water or the
wrong mixture, your engine could get too hot
but you would not get the overheat warning.
Your engine could catch re and you or others
could be burned. Use a 50/50 mixture of clean,
drinkable water and DEX-COOL
®coolant.
Notice:If you use an improper coolant mixture,
your engine could overheat and be badly damaged.
The repair cost would not be covered by your
warranty. Too much water in the mixture can freeze
and crack the engine, radiator, heater core and
other parts.
If you have to add coolant more than four times a year,
have your retailer check your cooling system.
Notice:If you use the proper coolant, you do not
have to add extra inhibitors or additives which claim
to improve the system. These can be harmful.
5-25
ProCarManuals.com

Brakes
Brake Fluid
The hydraulic clutch and
brake master cylinder use
the same reservoir.
The reservoir is lled with
DOT-3 brake uid. See
Engine Compartment
Overview on page 5-12for
the location of the
reservoir.
There are only two reasons why the brake uid level in
the reservoir might go down. The rst is that the
brake uid goes down to an acceptable level during
normal brake lining wear. When new linings are put in,
the uid level goes back up. The other reason is
that uid is leaking out of the brake system or hydraulic
clutch system if you have a manual transaxle. If it is,
you should have both systems checked and the
necessary repairs made, since a leak means that sooner
or later your brakes and/or clutch will not work well, or
will not work at all.So, it is not a good idea to top off your brake uid.
Adding brake uid will not correct a leak. If you add uid
when your linings are worn, then you will have too
much uid when you get new brake linings. You should
add or remove brake uid, as necessary, only when
work is done on the brake and/or clutch hydraulic
system.
{CAUTION:
If you have too much brake uid, it can spill on
the engine. The uid will burn if the engine is
hot enough. You or others could be burned,
and your vehicle could be damaged. Add brake
uid only when work is done on the brake
and/or clutch hydraulic system.
When your brake uid falls to a low level, your brake
warning light will come on. SeeBrake System Warning
Light on page 3-30.
5-38
ProCarManuals.com

Change Engine Oil Message............................3-41
Check
Engine Light...............................................3-33
Check Gage Message.....................................3-42
Check Gas Cap Message................................3-43
Checking Things Under the Hood......................5-10
Chemical Paint Spotting...................................5-90
Child Restraints
Child Restraint Systems...............................1-36
Infants and Young Children...........................1-32
Lower Anchorages and Top Tethers for
Children (LATCH System)..........................1-42
Older Children.............................................1-30
Securing a Child Restraint Designed for
the LATCH System...................................1-43
Securing a Child Restraint in a Rear
Seat Position...........................................1-44
Securing a Child Restraint in the Right
Front Seat Position...................................1-46
Top Strap...................................................1-39
Top Strap Anchor Location............................1-41
Where to Put the Restraint...........................1-39
Cigarette Lighter.............................................3-17
Cleaning
Aluminum Wheels........................................5-88
Exterior Lamps/Lenses.................................5-87
Fabric/Carpet..............................................5-85Cleaning (cont.)
Finish Care.................................................5-87
Inside of Your Vehicle..................................5-84
Instrument Panel, Vinyl, and Other Plastic
Surfaces.................................................5-86
Tires..........................................................5-89
Underbody Maintenance...............................5-90
Washing Your Vehicle...................................5-87
Weatherstrips..............................................5-86
Windshield and Wiper Blades........................5-88
Climate Control System...........................3-18, 3-20
Air Filter, Passenger Compartment.................3-23
Outlet Adjustment........................................3-23
Clutch, Hydraulic.............................................5-24
Comfort Guides, Rear Safety Belt.....................1-26
Compact Spare Tire........................................5-83
Control of a Vehicle.......................................... 4-5
Convenience Net............................................2-40
Coolant
Engine Temperature Gage............................3-33
Low Level Warning Message.........................3-41
Surge Tank Pressure Cap.............................5-27
Cooling System..............................................5-30
Cruise Control................................................3-10
Cruise Control Message...................................3-40
Cupholder(s)..................................................2-39
3
ProCarManuals.com

Engine
Air Cleaner/Filter.........................................5-22
Battery.......................................................5-41
Change Oil Message...................................3-41
Check and Service Engine Soon Light............3-33
Coolant......................................................5-24
Coolant Temperature Gage...........................3-33
Engine Compartment Overview......................5-12
Exhaust.....................................................2-30
Oil .............................................................5-15
Oil Life System...........................................5-20
Overheating................................................5-28
Reduced Power Light...................................3-37
Starting......................................................2-19
Enhanced Traction System (ETS)........................ 4-8
Entry Lighting.................................................3-16
Error Message................................................3-43
Event Data Recorders (EDR)............................. 7-7
Extender, Safety Belt.......................................1-29
F
Filter
Engine Air Cleaner......................................5-22
Finish Damage...............................................5-89
Fixed Mast Antenna........................................3-68Flash-to-Pass................................................... 3-8
Flat Tire........................................................5-72
Flat Tire, Changing.........................................5-73
Flat Tire, Storing.............................................5-81
Fluid
Automatic Transaxle.....................................5-24
Manual Transaxle........................................5-24
Windshield Washer......................................5-37
Fog Lamps............................................3-15, 5-52
Folding Rear Seat............................................ 1-9
Folding Seatback, Passenger............................. 1-6
Fuel............................................................... 5-5
Additives...................................................... 5-6
California Fuel.............................................. 5-6
Filling a Portable Fuel Container....................5-10
Filling Your Tank........................................... 5-8
Fuels in Foreign Countries.............................. 5-7
Gage.........................................................3-38
Gasoline Octane........................................... 5-5
Gasoline Specications.................................. 5-6
Low Warning Message.................................3-43
Fuses
Engine Compartment Fuse Block...................5-96
Fuses and Circuit Breakers...........................5-93
Instrument Panel Fuse Block.........................5-94
Windshield Wiper.........................................5-93
5
ProCarManuals.com

G
Gage
Boost.........................................................3-39
Engine Coolant Temperature.........................3-33
Fuel..........................................................3-38
Speedometer..............................................3-27
Tachometer.................................................3-27
Gas, Check Cap Message...............................3-43
Gasoline
Octane........................................................ 5-5
Specications............................................... 5-6
Glove Box.....................................................2-39
GM Mobility Reimbursement Program.................. 7-5
H
Hazard Warning Flashers................................... 3-5
Head Restraints............................................... 1-5
Headlamp
Aiming.......................................................5-46
Headlamps....................................3-13, 5-47, 5-48
Automatic Headlamp System.........................3-14
Bulb Replacement.......................................5-47
Daytime Running Lamps...............................3-14
Flash-to-Pass............................................... 3-8
Front Turn Signal and Parking Lamps.............5-51Headlamps (cont.)
Front Turn Signal Lamps..............................5-50
Halogen Bulbs............................................5-47
High/Low Beam Changer................................ 3-8
Sidemarker Lamps.......................................5-52
Heater...................................................3-18, 3-20
Height Adjuster, Driver Seat............................... 1-3
Highbeam On Light.........................................3-37
Highway Hypnosis...........................................4-22
Hill and Mountain Roads..................................4-22
Hood
Checking Things Under................................5-10
Release.....................................................5-11
Horn............................................................... 3-6
How to Use This Manual...................................... ii
How to Wear Safety Belts Properly...................1-16
Hydraulic Clutch.............................................5-24
I
Ignition Positions.............................................2-17
Infants and Young Children, Restraints...............1-32
Ination -- Tire Pressure..................................5-63
Instrument Panel
Overview..................................................... 3-4
Instrument Panel (I/P)
Brightness..................................................3-15
Cluster.......................................................3-26
6
ProCarManuals.com

Maintenance Schedule (cont.)
At Least Once a Year..................................6-11
Introduction.................................................. 6-2
Maintenance Footnotes.................................. 6-8
Maintenance Record....................................6-17
Maintenance Requirements............................. 6-2
Normal Maintenance Replacement Parts.........6-16
Owner Checks and Services........................... 6-9
Recommended Fluids and Lubricants.............6-14
Scheduled Maintenance................................. 6-4
Using.......................................................... 6-2
Your Vehicle and the Environment................... 6-2
Malfunction Indicator Light................................3-33
Manual Lumbar Controls.................................... 1-3
Manual Seats................................................... 1-2
Manual Transaxle
Fluid..........................................................5-24
Operation...................................................2-24
Manual Windows............................................2-13
Map Lamps....................................................3-16
Message
Center.......................................................3-39
Change Engine Oil......................................3-41
Check Gage...............................................3-42
Check Gas Cap..........................................3-43
Cruise Control.............................................3-40
Error..........................................................3-43Message (cont.)
Low Coolant Level Warning..........................3-41
Low Fuel Warning.......................................3-43
Low Traction...............................................3-40
Power Steering...........................................3-42
Service Vehicle...........................................3-43
Traction Off................................................3-40
Transaxle Fluid Cold....................................3-41
Transaxle Fluid Hot......................................3-41
Trunk Ajar Warning......................................3-42
Mirrors
Automatic Dimming Rearview with Compass
and Temperature Display...........................2-34
Automatic Dimming Rearview with OnStar
®,
Compass and Temperature Display.............2-32
Manual Rearview Mirror................................2-31
Manual Rearview Mirror with OnStar
®.............2-31
Outside Convex Mirror.................................2-37
Outside Power Mirrors..................................2-37
Outside Remote Control Mirror......................2-36
MyGMLink.com................................................ 7-4
N
New Vehicle Break-In......................................2-16
Normal Maintenance Replacement Parts............6-16
8
ProCarManuals.com

O
Odometer......................................................3-27
Odometer, Trip...............................................3-27
Off-Road Recovery..........................................4-12
Oil
Engine.......................................................5-15
Pressure Light.............................................3-36
Oil, Engine Oil Life System..............................5-20
Older Children, Restraints................................1-30
Online Owner Center........................................ 7-4
OnStar
®System, see OnStar®Manual...............2-38
Other Warning Devices...................................... 3-6
Outlet Adjustment............................................3-23
Outside
Convex Mirror.............................................2-37
Power Mirrors.............................................2-37
Remote Control Mirror..................................2-36
Owner Checks and Services.............................. 6-9
Owners, Canadian............................................... ii
P
Park (P)
Shifting Into................................................2-27
Shifting Out of............................................2-28Parking
Brake........................................................2-26
Over Things That Burn.................................2-29
Parking Your Vehicle.......................................2-29
Passenger Compartment Air Filter.....................3-23
Passing.........................................................4-12
Passlock
®......................................................2-16
Power
Accessory Outlet(s)......................................3-16
Door Locks.................................................. 2-8
Electrical System.........................................5-93
Reduced Engine Light..................................3-37
Retained Accessory (RAP)............................2-19
Steering Message........................................3-42
Windows....................................................2-14
Pretensioners, Safety Belt................................1-29
Programmable Automatic Door Locks.................. 2-8
Q
Questions and Answers About Safety Belts.........1-15
9
ProCarManuals.com

R
Radios..........................................................3-44
AM-FM Radio.............................................3-45
Care of Your CD Player...............................3-68
Care of Your CDs........................................3-68
Radio with CD....................................3-47, 3-52
Setting the Time for Radios with Radio
Data Systems (RDS)................................3-44
Setting the Time for Radios without
Radio Data Systems (RDS).......................3-44
Theft-Deterrent............................................3-65
Understanding Reception..............................3-67
Rear Door Security Locks.................................. 2-9
Rear Doors....................................................2-10
Rear Safety Belt Comfort Guides......................1-26
Rear Seat Passengers, Safety Belts..................1-23
Rearview Mirror, Automatic Dimming with
Compass and Temperature Display................2-34
Rearview Mirror, Automatic Dimming with OnStar
®,
Compass and Temperature Display..................2-32
Rearview Mirror with OnStar
®...........................2-31
Rearview Mirrors.............................................2-31
Reclining Seatbacks.......................................... 1-4Recommended Fluids and Lubricants.................6-14
Recreational Vehicle Towing.............................4-34
Reduced Engine Power Light............................3-37
Remote Keyless Entry System............................ 2-3
Remote Keyless Entry System, Operation............ 2-4
Removing the Flat Tire and Installing the
Spare Tire..................................................5-77
Removing the Spare Tire and Tools...................5-74
Replacement Bulbs.........................................5-55
Reporting Safety Defects
Canadian Government................................... 7-8
Saturn......................................................... 7-8
United States Government.............................. 7-8
Restraint System Check
Checking the Restraint Systems....................1-59
Replacing Restraint System Parts
After a Crash..........................................1-60
Retained Accessory Power (RAP)......................2-19
Right Front Passenger Position, Safety Belts......1-23
Roadside
Assistance Program....................................... 7-5
Rocking Your Vehicle to Get it Out....................4-29
Roof Rack System..........................................2-40
Running the Engine While Parked.....................2-30
10
ProCarManuals.com