tires SATURN RELAY 2007 Service Manual

If a Tire Goes Flat
It is unusual for a tire to blowout while you are
driving, especially if you maintain your vehicle’s
tires properly. If air goes out of a tire, it is
much more likely to leak out slowly. But if you
should ever have a blowout, here are a few tips
about what to expect and what to do:
If a front tire fails, the at tire will create a drag
that pulls the vehicle toward that side. Take
your foot off the accelerator pedal and grip the
steering wheel rmly. Steer to maintain lane
position, and then gently brake to a stop well
out of the traffic lane.
A rear blowout, particularly on a curve, acts much
like a skid and may require the same correction
you would use in a skid. In any rear blowout
remove your foot from the accelerator pedal.
Get the vehicle under control by steering the
way you want the vehicle to go. It may be very
bumpy and noisy, but you can still steer. Gently
brake to a stop, well off the road if possible.{CAUTION:
Lifting a vehicle and getting under it to
do maintenance or repairs is dangerous
without the appropriate safety equipment
and training. The jack provided with your
vehicle is designed only for changing a
at tire. If it is used for anything else, you
or others could be badly injured or killed
if the vehicle slips off the jack. Use the
jack provided with your vehicle only for
changing a at tire.
If a tire goes at, the next part shows how to
use the jacking equipment to change a at
tire safely.
483
ProCarManuals.com

To replace the cover, line up the tabs on the right
of the cover with the slots in the cover opening.
Push the cover in place and push down the tab
so that it rests in the groove. This secures
the cover in place.
Store the center cap or the plastic bolt-on wheel
covers until a full size tire is put back on the
vehicle. When you replace the compact spare with
a full-size tire, reinstall the bolt-on wheel covers
or the center cap. Hand-tighten them over
the wheel nuts, using the folding wrench.
Compact Spare Tire
Although the compact spare tire was fully inated
when the vehicle was new, it can lose air after
a time. Check the ination pressure regularly.
It should be 60 psi (420 kPa).
After installing the compact spare on the vehicle,
stop as soon as possible and make sure the spare
tire is correctly inated. The compact spare is made
to perform well at speeds up to 65 mph (105 km/h)
for distances up to 3,000 miles (5 000 km), so
you can nish your trip and have the full-size tire
repaired or replaced at your convenience.Of course, it is best to replace the spare with a
full-size tire as soon as possible. The spare tire will
last longer and be in good shape in case it is
needed again.
Notice:When the compact spare is installed,
do not take your vehicle through an automatic
car wash with guide rails. The compact
spare can get caught on the rails. That can
damage the tire and wheel, and maybe
other parts of your vehicle.
Do not use the compact spare on other vehicles.
And do not mix the compact spare tire or
wheel with other wheels or tires. They will not t.
Keep the spare tire and its wheel together.
Notice:Tire chains will not t your compact
spare. Using them can damage your vehicle
and can damage the chains too. Do not use tire
chains on your compact spare.
500
ProCarManuals.com

Aluminum Wheels
Notice:If you use strong soaps, chemicals,
abrasive polishes, cleaners, brushes, or
cleaners that contain acid on aluminum or
chrome-plated wheels, you could damage the
surface of the wheel(s). The repairs would
not be covered by your warranty. Use
only Saturn-approved cleaners on aluminum
or chrome-plated wheels.
Keep the wheels clean using a soft clean cloth
with mild soap and water. Rinse with clean water.
After rinsing thoroughly, dry with a soft clean
towel. A wax may then be applied.
Notice:Using chrome polish on aluminum
wheels could damage the wheels. The repairs
would not be covered by your warranty.
Use chrome polish on chrome wheels only.
The surface of these wheels is similar to the
painted surface of the vehicle. Do not use strong
soaps, chemicals, abrasive polishes, abrasive
cleaners, cleaners with acid, or abrasive cleaning
brushes on them because the surface could
be damaged. Do not use chrome polish on
aluminum wheels.Notice:If you drive your vehicle through an
automatic car wash that has silicone carbide
tire cleaning brushes, you could damage
the aluminum or chrome-plated wheels.
The repairs would not be covered by your
warranty. Never drive a vehicle equipped with
aluminum or chrome-plated wheels through
an automatic car wash that uses silicone
carbide tire cleaning brushes.
Do not take the vehicle through an automatic car
wash that has silicone carbide tire cleaning
brushes. These brushes can also damage the
surface of these wheels.
Tires
To clean the tires, use a stiff brush with tire
cleaner.
Notice:Using petroleum-based tire dressing
products on your vehicle may damage the
paint nish and/or tires. When applying a tire
dressing, always wipe off any overspray
from all painted surfaces on your vehicle.
507
ProCarManuals.com

Scheduled Maintenance
Service MaintenanceIMaintenanceII
Change engine oil and lter. SeeEngine Oil on page 423. Reset oil life system.
SeeEngine Oil Life System on page 426.An Emission Control Service.••
Lubricate chassis components.See footnote #.••
Visually check for any leaks or damage.See footnote (k).••
Inspect engine air cleaner lter. If necessary, replace lter. SeeEngine Air
Cleaner/Filter on page 428.See footnote (g).•
Rotate tires and check ination pressures and wear. SeeTire Inspection and
Rotation on page 472and “Tire Wear Inspection” inAt Least Once a Month on
page 527.••
Inspect brake system.See footnote (a).••
Check engine coolant and windshield washer uid levels and add uid as
needed.••
Perform any needed additional services. See “Additional Required Services”
in this section.••
Inspect suspension and steering components.See footnote (b).•
Inspect engine cooling system.See footnote (c).•
Inspect wiper blades.See footnote (d).•
Inspect restraint system components.See footnote (e).•
Lubricate body components.See footnote (f).•
Check transaxle uid level and add uid as needed.•
Replace passenger compartment air lter.See footnote (l).•
Inspect throttle system.See footnote (j).•
523
ProCarManuals.com

At Each Fuel Fill
It is important to perform these underhood checks
at each fuel ll.
Engine Oil Level Check
Check the engine oil level and add the proper oil
if necessary. SeeEngine Oil on page 423for
further details.
Notice:It is important to check your oil
regularly and keep it at the proper level. Failure
to keep your engine oil at the proper level
can cause damage to your engine not covered
by your warranty.
Engine Coolant Level Check
Check the engine coolant level and add
DEX-COOL®coolant mixture if necessary. See
Engine Coolant on page 432for further details.
Windshield Washer Fluid Level Check
Check the windshield washer uid level in
the windshield washer uid reservoir and add
the proper uid if necessary.
At Least Once a Month
Tire Ination Check
Visually inspect your vehicle’s tires and make
sure they are inated to the correct pressures.
Do not forget to check the spare tire. See
Ination - Tire Pressure on page 469. Check to
make sure the spare tire is stored securely.
SeeChanging a Flat Tire on page 484.
Tire Wear Inspection
Tire rotation may be required for high mileage
highway drivers prior to the Engine Oil Life System
service notication. Check the tires for wear
and, if necessary, rotate the tires. SeeTire
Inspection and Rotation on page 472.
527
ProCarManuals.com

For prompt and efficient assistance when calling,
please provide the following to the Roadside
Assistance Representatives:
Your name, home address, and home
telephone number
Telephone number of your location
Location of the vehicle
Model, year, color, and license plate number
Odometer reading, Vehicle Identication
Number and delivery date of the vehicle
Description of the problem
While we hope you never have the occasion to
use our service, it is added security while traveling
for you and your family. Remember we are only
a phone call away. Saturn Roadside Assistance:
1-800-553-6000; text telephone (TTY) users,
call1-800-833-6000. Canadian customers
call1-800-268-6800.Saturn and General Motors of Canada Limited
reserve the right to limit services or reimbursement
to an owner or driver when, in their sole
discretion, the claims become excessive in
frequency or type of occurrence.
Roadside Assistance is not part of or included in
the coverage provided by the New Vehicle Limited
Warranty. Saturn and General Motors of Canada
Limited reserve the right to make any changes
or discontinue the Roadside Assistance program
at any time without notication.Towing and Road Service Exclusions
Specically excluded from Roadside Assistance
coverage are towing or services for vehicles
operated on a non-public roadway or highway,
nes, impound towing caused by a violation
of local, Municipal, State, Provincial or Federal
law, and mounting, dismounting or changing
of snow tires, chains or other traction devices.
546
ProCarManuals.com

A
Accessories and Modications..................... 412
Accessory Inator........................................ 480
Accessory Power Outlet(s).......................... 203
Adding Equipment to Your Airbag-Equipped
Vehicle..................................................... 100
Additives, Fuel............................................ 415
Add-On Electrical Equipment....................... 511
Air Cleaner/Filter, Engine............................. 428
Air Conditioning..................................205, 209
Airbag
Passenger Status Indicator....................... 224
Readiness Light....................................... 223
Airbag Sensing and Diagnostic
Module (SDM).......................................... 547
Airbag System............................................... 83
Adding Equipment to Your
Airbag-Equipped Vehicle....................... 100
How Does an Airbag Restrain?.................. 91
Passenger Sensing System....................... 93
Servicing Your Airbag-Equipped Vehicle..... 99
What Makes an Airbag Inate?.................. 91
What Will You See After an Airbag
Inates?................................................. 92Airbag System (cont.)
When Should an Airbag Inate?................. 89
Where Are the Airbags?............................. 86
Antenna, Fixed Mast................................... 355
Antenna, XM™ Satellite Radio Antenna
System.................................................... 356
Anti-Lock Brake System (ABS).................... 363
Anti-Lock Brake, System Warning Light....... 227
Appearance Care
Aluminum Wheels.................................... 507
Care of Safety Belts................................ 504
Chemical Paint Spotting........................... 508
Cleaning Exterior Lamps/Lenses.............. 505
Cleaning the Inside of Your Vehicle.......... 501
Fabric/Carpet........................................... 502
Finish Care.............................................. 505
Finish Damage......................................... 508
Instrument Panel, Vinyl, and Other
Plastic Surfaces.................................... 504
Leather.................................................... 503
Sheet Metal Damage............................... 508
Tires........................................................ 507
Underbody Maintenance........................... 508
Vehicle Care/Appearance Materials.......... 509
555
ProCarManuals.com

Appearance Care (cont.)
Washing Your Vehicle.............................. 505
Weatherstrips........................................... 504
Windshield, Backglass, and
Wiper Blades........................................ 506
Audio System(s).......................................... 270
Audio Steering Wheel Controls................. 353
Care of Your CD and DVD Player............ 355
Care of Your CDs and DVDs................... 355
Chime Level Adjustment........................... 356
Fixed Mast Antenna................................. 355
Mobile Digital Media System.................... 330
Navigation/Radio System, see
Navigation Manual................................ 294
Radio with CD......................................... 272
Rear Seat Audio (RSA)...................325, 328
Setting the Time...................................... 272
Theft-Deterrent Feature............................ 352
Understanding Radio Reception............... 354
XM™ Satellite Radio Antenna System...... 356
Automatic Door Lock................................... 117
Automatic Transaxle
Fluid........................................................ 430
Operation................................................. 143B
Battery........................................................ 449
Electric Power Management..................... 198
Run-Down Protection............................... 199
Before Leaving on a Long Trip.................... 382
Brake
Anti-Lock Brake System (ABS)................. 363
Emergencies............................................ 365
Parking.................................................... 147
System Warning Light.............................. 226
Brakes........................................................ 445
Braking....................................................... 362
Braking in Emergencies............................... 365
Break-In, New Vehicle................................. 138
Bucket Seats, Rear....................................... 14
Bulb Replacement....................................... 455
Front Turn Signal, Parking and Daytime
Running Lamps.................................... 457
Halogen Bulbs......................................... 455
License Plate Lamps................................ 459
Replacement Bulbs.................................. 460
Taillamps, Turn Signal, Stoplamps and
Back-up Lamps..................................... 458
Buying New Tires........................................ 474
556
ProCarManuals.com

C
Calibration................................................... 240
California Fuel............................................. 415
California Proposition 65 Warning................ 413
Canadian Owners........................................... 3
Capacities and Specications...................... 518
Captain Chairs, Rear..................................... 22
Carbon Monoxide..............128, 151, 386, 398
Care of
Safety Belts............................................. 504
Your CD and DVD Player........................ 355
Your CDs and DVDs................................ 355
Cargo Lamp................................................ 198
CD, MP3 ..................................................... 287
Chains, Tire................................................. 480
Charging System Light................................ 226
Check
Engine Light............................................ 229
Checking Things Under the Hood................ 420
Chemical Paint Spotting.............................. 508
Child Restraints
Child Restraint Systems............................. 63
Infants and Young Children........................ 59
Lower Anchors and Tethers for Children..... 69Child Restraints (cont.)
Older Children........................................... 56
Securing a Child Restraint in a Rear
Seat Position.......................................... 77
Securing a Child Restraint in the Right
Front Seat Position................................. 79
Where to Put the Restraint........................ 67
Chime Level Adjustment .............................. 356
Cigarette Lighter.......................................... 205
Cleaning
Aluminum Wheels.................................... 507
Exterior Lamps/Lenses............................. 505
Fabric/Carpet........................................... 502
Finish Care.............................................. 505
Inside of Your Vehicle .............................. 501
Instrument Panel, Vinyl, and Other
Plastic Surfaces.................................... 504
Leather.................................................... 503
Tires........................................................ 507
Underbody Maintenance........................... 508
Washing Your Vehicle .............................. 505
Weatherstrips........................................... 504
Windshield, Backglass, and
Wiper Blades........................................ 506
557
ProCarManuals.com

G
Gage
Engine Coolant Temperature.................... 228
Fuel......................................................... 233
Speedometer........................................... 221
Tachometer.............................................. 221
Garage Door Opener..........................156, 157
Gasoline
Octane..................................................... 414
Specications........................................... 414
Glove Box................................................... 167
GM Mobility Reimbursement Program.......... 543
H
Hazard Warning Flashers............................ 182
Head Restraints............................................ 13
Headlamp Wiring......................................... 511
Headlamps
Bulb Replacement.................................... 455
Daytime Running Lamps/Automatic
Headlamp System................................ 193Headlamps (cont.)
Flash-to-Pass........................................... 185
Halogen Bulbs......................................... 455
Headlamps and Sidemarker Lamps.......... 456
High/Low Beam Changer......................... 185
On Reminder........................................... 193
Wiper Activated........................................ 193
Headlamps and Sidemarker Lamps............. 456
Heated Seats................................................ 10
Heater................................................205, 209
Hideaway Rear Storage Bins....................... 174
Highbeam On Light..................................... 233
High-Speed Operation, Tires........................ 471
Highway Hypnosis....................................... 383
Hill and Mountain Roads............................. 384
Hood
Checking Things Under............................ 420
Release................................................... 421
Horn............................................................ 182
How to Use This Manual ................................ 4
How to Wear Safety Belts Properly............... 38
561
ProCarManuals.com