Seat Ibiza 2020 Workshop Manual

Self-help
Check the condition of the wiper blades reg-
ul arly.
If the wipers scrape across the
glass, they should be changed if they are
damaged, or cleaned if they are dirty ››› .
If this does not pr oduce the desir

ed results,
the setting angle of the windscreen wiper
arms might be incorrect. They should be
checked by a specialised workshop and cor-
rected if necessary.
Damaged windscreen wiper blades should
be replaced immediately. These are availa-
ble from qualified workshops.
Raising and lowering windscreen wiper
arms

Emergencies
If the engine fails to start because of a dis-
char ged batt
ery, the battery can be connec-
ted to the battery of another vehicle to start
the engine.
Jump leads must comply with standard DIN
72553 (see cable manufacturer's instruc-
tions). The wire cross section must be at least
25 mm 2
for petrol engines and at least
35 mm 2
for diesel engines. Note

Self-help
Make sure the battery clamps have sufficient
met al
-to-metal contact with the battery ter-
minals.
If the engine fails to start after about 10 sec-
onds, switch off the starter and try again after
about 1 minute. WARNING

Emergencies
WARNING
Vehicle handling and braking capacity
change consider ably during t
owing. Please
observe the following instructions to mini-
mise the risk of serious accidents and in-
jury:

Self-help
Notes for the driver of the towed vehicle

Emergencies
must be started using jump leads to deacti-
v
at
e the steering column electronic gear-
box lock. Front towline anchorage
Fig. 45
Right side of the front bumper: remove
the co v

er. Fig. 46
Right side of the front bumper: towline
anchor age in position. The housing of the removable towline an-
chor
age is on the right side of the fr

ont bump-
er underneath a cover ››› Fig. 45
.
The towing eye should always be kept in the
vehicle.
Bear in mind the instructions for towing
››› page 52.
Fitting the towline anchorage

Fuses and bulbs
The housing of the screw towing eye is on the
right side of the r ear bumper behind a lid
›
›› Fig. 47.
Bear in mind the instructions for towing
››› page 52.
Fitting the rear towline anchorage

Emergencies
Fuses inside the vehicle Fig. 49
On the driver

Fuses and bulbs
Replace a blown fuse Fig. 51
Image of a blown fuse. Preparations

Emergencies
No. Consumer/Amps
40 Light switch, diagnosis input, head-
l
amp r
ange regulator, LSS steering
column: lamps, halogen lamps,
switch, reverse gear, electrochromic
mirror, RKA without radio. 7.5
41 Regulation of unfolded exterior mir-
r
ors, 7.5
4

2 Clutch pedal, ignition relays, CNG
r
el

ay coil, AC pressure sensor 7.5
43 DWP relay coil, rear window wiper motor 15
44

Airbag 7.5
45 Left full LED headlight 7.5
46 Right full LED headlight 7.5
48 Steering column lock, Kessy Control
Unit 7.5
49 SCR relay 7.5
53 Automatic gearbox lever, ZSS 7.5
58 Windscreen washer pump 7.5
59 Heated rear view mirrors 10
60 Tow hook 30
61 Tow hook 30 Fuse arrangement in engine compartment
No. Consumer/Amps
1 MPI Engine Injection Module
10
TSI Engine Injection Module 15
Diesel Engine Injection Module 30
2 Fuel metering valve (TJ4/T6P/TJ7),
L
o

w temperature coolant pump
(TJ4/T6P/TJ7); Oil pressure regulat-
ing valve (TJ1), AGR coolant valve
(TJ1), High and low pressure water
pumps (TJ1), SCR relay coil, cylin-
der head water valve 7.5
3 Lambda probes 15
4 Engine petrol pump relay (MPI),
Gauge contr
ol unit (T

SI and diesel)15
5 Electric fan (EC), LDR valve, canni-
ster and v

ariable distribution valve,
oil pressure regulating valve, cylin-
der disconnection valves, WIV sen-
sor and CNG pressure regulator 10
6 Spark plugs (MPI and TSI)
20
Glow plug relay, Suction hose resis-
t or (diesel) 7.5
7

Vacuum pump (TSI, CNG) 15
8 Injectors and EKP relay coil (MPI),
Fuel metering v

alve (diesel) 10
9 Servo sensor 7.5 No. Consumer/Amps
10 Vref Battery: Gateway, BDM and
BCM 7.5
12 Detachable compressor 10
14 ESC, Relay 87 coil and engine con-
tr
oll

er of engines (+ TJ1 / TJ4 / TH4 /
T5I / T6P / TJ7 / TC5 / T5Y). 7.5
15 Automatic gearbox DQ200 and
AQ160 30
17 50 Diag 7.5
18 BDM starter motor 30
20 ESC (Pump)
60
ABS (Pump) 40
21 ESC/ABS (Valves) 25
24 TH4 Electric fan without A/C for
moder
at

e climate countries 30
25 TH4 fan with A/C or T5I for moder-
ate climat

e countries 20
PTC1 40
26 TJ1/TJ4/TJ7/T6P or TH4/T5I Electric
fan f

or warm climate countries 50
27 TH4 fan with A/C or T5I for moder-
ate climat

e countries 30
PTC2 40
28 PTC3 4058