ignition Seat Mii 2015 Repair Manual

Advice
● Pr e
s
s on the rear area of the flap and open
it.
Refuelling
Problem: If the ambient temperature is very
high, the natural gas pump protection
against overheating disconnects this auto-
matically.
● Remove the plug from the gas filler mouth
›››
Fig. 166 1 .
● Connect the pump filling nozzle to the gas
fi l
l

er mouth.
● The fuel tank will be full when the p
ump
compressor automatically cuts the supply.
● If you wish to finish refuelling in advance,
pres
s the button on the pump to stop the
flow.
Closing the fuel tank cap
● Check that the gas filler mouth retainer 2is not trapped with the filler nozzle. If neces-
s
ar
y

, place it in the filler mouth again.
● Insert the plug in the filler mouth.
● Close the tank flap. Make sure you hear it
click
into place. WARNING
Natural gas is a highly explosive, easily flam-
mab l

e substance. Incorrect handling of the
natural gas can cause accidents serious
burns and other injuries. ●
Bef or

e refuelling with natural gas, the fill-
ing mouth must be correctly engaged. If you
can smell gas, stop refuelling immediately. WARNING
The vehicle is not prepared to use liquefied
n at ur

al gas (LNG) and this fuel must not be
added under any circumstances. Liquefied
natural gas can cause the natural gas tank to
explode, resulting in serious injury. Note
● The fil lin

g nozzles of natural gas pumps
can differ in the way they are operated. If you
are unacquainted with the pump, it is advisa-
ble that a member of staff of the service sta-
tion performs the refuelling operation.
● Noises heard when refuelling are normal
and do not indicat
e the presence of a fault in
the system.
● The vehicle natural gas system is prepared
both for ref
uelling with a small compressor
(slow refuel) and a large compressor (fast re-
fuel) in natural gas service stations. Bonnet
W ork in

g in the engine compartment Read the additional information carefully
› ›
›

 page 10 Before working in the engine compartment,
make s

ure that the vehicle is parked on hori-
zontal and firm ground.
The engine compartment of the vehicle is a
hazardous area. Never work on the engine or
in the engine compartment if you are not fa-
miliar with the operations to be carried out,
the applicable safety standards and especial-
ly if you do not have the necessary instru-
ments, liquids and tools ››› ! If required,
h av
e an

y work carried out by a specialised
workshop. Negligent work can cause serious
injury. WARNING
If the vehicle moves unexpectedly, this could
cau se seriou

s injury.
● Never work under the vehicle if it has not
been immobi
lized. If you must work under-
neath the vehicle with the wheels in contact
with the ground then it should be parked on
flat ground, the wheels should be prevented
from moving and the key should be removed
from the ignition.
● If you have to work underneath the vehicle,
you mus
t use suitable stands additionally to
support the vehicle, there is a risk of acci-
dent!. The jack is not intended for this kind of
work and its failure could lead to severe inju-
ries.
● Disconnect the Start-Stop system. 184

Checking and refilling levels
WARNING
The engine compartment is a dangerous area
cap ab
le of causing serious injury.
● For all type of work, always take the utmost
precaution
s, work carefully and note the gen-
eral safety standards in force. Never take per-
sonal risks.
● Never work on the engine or in the engine
compar
tment if you are not familiar with the
necessary operations. If you are not sure
about procedures then visit a specialised
workshop to carry out the necessary work.
Working incorrectly can cause serious inju-
ries.
● Never open the bonnet if you see steam or
cool
ant escaping from the engine compart-
ment. This may cause serious burns. Always
wait until you cannot see or hear the sound of
steam or coolant coming from the engine
compartment.
● Always allow the engine to cool down be-
fore openin
g the bonnet.
● Contact with hot elements of the engine
and the exhau
st system can cause burns.
● Once the engine has cooled, follow the in-
structions
below before opening the bonnet:
– Engage the handbrake and place the gear
selector lever in N or the gear stick in
neutral.
– Remove the key from the ignition.
– Keep children away from the engine com-
partment and never leave them unsuper-
vised. ●
When the engine i s

warm or hot, the cool-
ing system is pressurised. Do not unscrew
the cap on the expansion tank when the en-
gine is hot. Otherwise, coolant may spray out
under pressure causing burns and serious in-
jury.
–After cooling, carefully and slowly un-
screw the cap anticlockwise, gently
pressing down on it.
– Always protect your face, hands and arms
from hot coolant and steam using a large,
thick cloth.
● When refilling liquids, avoid spilling them
on part
s of the engine and the exhaust sys-
tem. Spilled liquids could cause a fire. WARNING
The high voltages of the electrical system can
give el ectric

shocks as well as causing burns
and serious injury and possibly even death!
● Never cause short circuits in the electrical
syst
em. The battery could explode.
● To minimise the risk of electric shock and
serious c
onsequences while the engine is
running or starting the engine, note the fol-
lowing:
– Never touch the electrical wiring of the
ignition system. WARNING
In the engine compartment, there are rotat-
ing p ar

ts that could cause serious injury. ●
Never p l

ace your hands directly on or near
the radiator fan. Touching the rotor blades
could seriously harm you. The ventilator
works according to the engine temperature
and could start suddenly even when the igni-
tion is turned off and the key is removed.
● If any work has to be performed when the
engine is
started or with the engine running,
there is an additional, potentially fatal, safety
risk from rotating parts, such as the drive
belts, alternator, radiator fan, etc., as well as
from the high-voltage ignition system. Al-
ways work with the utmost caution.
– Always make sure that no parts of your
body, jewellery, ties, loose clothing and
long hair can be trapped by the rotating
parts of the engine. Before any work, re-
move ties and jewellery (necklaces, etc),
tie long hair back and tie all items of
loose clothing to your body to make sure
that they cannot be trapped by engine
components.
– Take extreme caution when operating the
accelerator and remain attentive. The ve-
hicle could move, even if the handbrake
is applied.
● Always make sure you have not left any ob-
jects, s
uch as cleaning cloths and tools, in
the engine compartment. If any object is left
in the engine compartment, this could cause
malfunctions, engine faults and even a fire. » 185
Technical data
Advice
Operation
Emergencies
Safety

Checking and refilling levels
WARNING
Only change the engine oil yourself if you
hav e the s
pecialist knowledge required!
● Before opening the bonnet, read and ob-
serve the w
arnings ››› page 184.
● Wait for the engine to cool down. Hot oil
may
cause burn injuries.
● Wear eye protection to avoid injuries, such
as ac
id burns, caused by splashes of oil.
● When removing the oil drain plug with your
finger
s, keep your arm horizontal to help pre-
vent oil from running down your arm.
● Wash your skin thoroughly if it comes into
contact
with engine oil.
● Engine oil is poisonous! Used oil must be
stor
ed in a safe place out of the reach of chil-
dren. CAUTION
No additives should be used with engine oil.
This c

ould result in engine damage. Any dam-
age caused by the use of such additives
would not be covered by the factory warranty. For the sake of the environment
Before changing the engine oil, find a suita-
bl e loc

ation or service for proper disposal. For the sake of the environment
Always dispose of engine oil with the utmost
re s

pect for the environment. Never dispose of used engine oil in places such as a garden,
wood
s, dr

ains, roads, paths, rivers and drain-
age systems. Engine coolant
Introduction WARNING
Engine coolant is toxic!
● Only keep engine coolant in its original
c ont ainer

, tightly shut and in a safe place.
● Never store engine coolant in empty food
container
s or bottles as other people may ac-
cidentally drink it.
● Always keep engine coolant out of reach of
chil
dren.
● Ensure that the proportion of engine cool-
ant ad
ditive corresponds to the lowest out-
side temperature to which the vehicle will be
exposed.
● If the outside temperature is extremely low,
the engine coo
lant could freeze causing the
vehicle to stop. As this would also cause the
heating to stop working, vehicle occupants
without warm clothing could freeze. For the sake of the environment
Coolants and additives can contaminate the
env ir

onment. If any fluids are spilled, they should be collected and correctly disposed
of, w
ith r

espect to the environment. Coolant warning lamp
Several warning and indication lamps light
up for a f
ew sec

onds when the ignition is
switched on, signalling that the function is
being verified. They will switch off after a few
seconds. 
It lights up
Excessive engine
coolant tempera-
ture.
 Stop the vehicle!
Stop the vehicle safely as soon as
possible. Switch off the engine and
let it cool.
Insufficient en-
gine coolant lev-
el.  Stop the vehicle!
Check the engine coolant when the
engine has cooled and, if it is low,
refill with engine coolant
››› page 190.
Engine coolant
system faulty.  Do not drive any further.
Obtain professional assistance. 
Flashes
Engine coolant
system faulty.Seek specialist assistance.
WARNING
Observe the safety warnings ›››
in On the
ins trument
panel on page 27. » 189
Technical data
Advice
Operation
Emergencies
Safety

AdviceSymbolMeaning

A highly explosive mixture of gases is re-
leased when the battery is under charge.

Keep children away from acid and batter-
ies!
WARNING
Working on the vehicle battery and the elec-
trica l

system can cause corrosion, fire and
electric shocks. Always read and take into ac-
count the following warnings and safety
standards before carrying out any work:
● Before working on the battery, switch off
the engine, the ignition and al
l electrical de-
vices then disconnect the negative connec-
tion on the battery.
● Keep children away from acid and the bat-
tery
itself!
● Wear eye protection.
● Battery acid is very corrosive and caustic. It
can burn sk
in and cause blindness. When
handling the battery, protect yourself from
splashes of acids, above all your hands, arms
and face.
● Do not smoke and never work close to pla-
ces
exposed to flames or sparks.
● Avoid sparks and electrostatic discharges
when workin
g with cables and electrical devi-
ces.
● Never short the battery terminals. ●
Never u se a d

amaged battery. It can ex-
plode. Replace a damaged battery immedi-
ately.
● Replaced damaged or frozen batteries as
soon as po
ssible. A flat battery can also
freeze at temperatures close to 0 °C (+32 °F). CAUTION
● Nev er di s

connect the battery if the ignition
is switched on or if the engine is running.
This could damage the electrical system or
electronic components.
● Do not expose the battery to direct sunlight
over a lon
g period of time, as the intense ul-
traviolet radiation can damage the battery
housing.
● If the car is left standing for long periods,
protect
the battery from extreme cold temper-
ature so that it does not “freeze up” and be-
come damaged. Warning lamp

It lights up
Faulty generator.
Contact a specialised workshop.
Have the electrical system checked.
Disconnect any unnecessary elec-
trical devices. The generator does
not charge the battery while the ve-
hicle is in motion. Several warning and indication lamps light
up f
or a f
ew sec

onds when the ignition is
switched on, signalling that the function is
being verified. They will switch off after a few
seconds. WARNING
Observe the safety warnings ›››
in On the
ins trument
panel on page 27. Checking the electrolyte level of the
vehic
l

e battery Fig. 171
In the engine compartment: Remove
the c o
v

er from the vehicle's battery. The battery's electrolyte level should be
c
hec
k

ed regularly in high-mileage vehicles,
in hot countries and in older batteries. Other
batteries do not require maintenance.
Vehicles fitted with the Start-Stop system are
equipped with special batteries. For technical
194

Checking and refilling levels
reasons, the electrolyte level cannot be
c hec
k
ed in these batteries.
Preparations
● Prepare the vehicle for work in the engine
compar
tment ››› page 184
● Open the bonnet  ›››
page 184.
● Press on the tabs ›››
Fig. 171 (arrows) in the
direction of the arrows and lift the battery
cover up.
Checking the battery electrolyte level
● Make sure there is sufficient lighting to
cle
arly recognise the colours. Never use
flames or shiny objects as a light source.
● Depending on the level of acid, the Magic
eye on the top of
the battery will change col-
our.
Colour in-
dicatorNecessary operations
Light yellow
or colourlessThe electrolyte level of the vehicle's bat-
tery is too low. Have the battery checked
and, where applicable, replaced by a
specialised workshop.
BlackThe electrolyte level of the vehicle's bat-
tery is correct. WARNING
Working with the vehicle battery involves a
risk of

corrosion, explosions and electric
shock.
● Never tilt the vehicle battery. Battery acid
coul
d spill out of the openings for the release
of gases and cause corrosion damage.
● Never open the vehicle battery.
● If battery acid splashes on you, immediate-
ly rinse
your eyes and skin abundantly with
water for several minutes. Then seek medical
care immediately.
● If acid is swallowed by mistake, consult a
doctor immediat
ely. Charging, replacing and connecting or
di
s
c

onnecting the battery Charging the battery
The
v
ehic

le battery should be charged by a
specialised workshop only, as batteries us-
ing special technology have been installed
and they must be charged in a controlled en-
vironment ››› . SEAT recommends taking
y our c
ar in f

or technical service.
Replacing a vehicle battery
The battery has been developed to suit the
conditions of its location and has special
safety features. If the battery must be re-
placed, consult a technical service for infor- mation on electromagnetic compatibility, the
size and m

aintenance, performance and
safety requirements of the new battery in
your vehicle before you purchase one. SEAT
recommends you have the battery replaced
by a technical service.
Use only maintenance-free genuine batteries
conforming to TL 825 06 and VW 7 50 73
Standards. These standards must be dated
April 2008 or later.
Vehicles fitted with the Start-Stop system are
equipped with a special battery. Therefore,
this battery must only be replaced by another
with the same specifications.
Disconnecting the vehicle's battery
If you must disconnect the battery from the
electrical system, please note the following:
● Switch off the ignition and all electrical
equipment.
● The v

ehicle must be unlocked before dis-
connecting the b
attery, otherwise the alarm
will be triggered.
● First disconnect the negative cable and
then the positiv
e ››› .
C onnectin
g the
vehicle's battery
● Before reconnecting the battery, switch off
the engine and all
electrical devices.
● First reconnect the positive cable and then
the negativ
e ››› .
»
195
Technical data
Advice
Operation
Emergencies
Safety

Advice
Different control lamps may light up after
c onnectin
g the b
attery and switching the ig-
nition on. They will be turned off after a short
trip at a speed of between 15-20 km/h
(10-12 mph). If the warning indicators remain
lit, please visit a specialised workshop to
have the vehicle checked.
If the battery has been disconnected for a
long time, it is possible that the next service
date is not displayed or calculated correctly
››› page 86. Respect the maximum service in-
tervals permitted ››› Booklet Maintenance
Programme.
Automatic device disconnection
The intelligent vehicle electrical system auto-
matically implements a range of measures to
prevent the battery from discharging when
high demands are made on it:
● The idling speed is increased so that the al-
ternat
or provides more electricity.
● Where necessary, the power to the most
power
ful devices is reduced or even com-
pletely disconnected.
● On starting the engine, the power supply
from the 12-v
olt power sockets and the ciga-
rette lighter may be interrupted for a short
time.
The on-board management program cannot
always prevent the battery from running flat.
For example, if the ignition is left on for a long period with the engine off or if the side
lights or park

ing lights are left on while the
vehicle is stationary.
Why the battery runs flat:
● When stationary for a long time without
star
ting the engine, particularly if the ignition
is switched on.
● Use of electrical devices with the engine
switc
hed off. WARNING
Incorrectly securing the battery or using the
wron g b

attery can cause short-circuits, fire
and serious injuries.
● Always use only maintenance-free batter-
ies, prot
ected to prevent a leak, and whose
properties, specifications and size corre-
spond to the standard battery. WARNING
A highly explosive mixture of gases is re-
le a

sed when the battery is under charge.
● The batteries should be charged in a well-
ventil
ated room only.
● Never charge a frozen or recently thawed
batter
y. A flat battery can also freeze at tem-
peratures close to 0 °C (+32 °F).
● Always replace a battery which has frozen.
● Battery cables not correctly connected may
cause a shor
t circuit. Reconnect first the posi-
tive cable and then the negative cable. CAUTION
● Never di s

connect the battery if the ignition
is switched on or if the engine is running.
This could damage the electrical system or
electronic components.
● Never plug accessories that supply current,
such a
s solar panels or a battery charger, to
the 12-volt power socket or the cigarette
lighter. This could damage the vehicle's elec-
trical system. For the sake of the environment
Dispose of the battery in an environment-
friendly m anner

. Batteries contain toxic sub-
stances such as sulphuric acid and lead. For the sake of the environment
Battery acid can contaminate the environ-
ment. C o

llect any spilt service fluids and dis-
pose of them correctly. 196

Wheels and tyres
tyres wear too quickly, have the wheel align-
ment c
hec
ked at a specialised workshop. WARNING
If you notice unusual vibration or the car pulls
to one s ide whi

le driving, this may indicate
that one of the tyres is damaged.
● Reduce speed immediately and stop, while
obser
ving the highway code.
● Check the wheels and tyres for damage.
● Never carry on driving on worn tyres or
wheels. Reque
st qualified assistance immedi-
ately.
● If there is no visible exterior damage, drive
slowly
and carefully to the nearest special-
ised workshop and have the vehicle checked. Tyre monitor system* 
Fig. 175
Centre console: tyre monitor system
b utt
on The tyre control lamp compares wheel revolu-
tion
s
and w

ith it, the wheel diameter of each
wheel using the ESC. If the diameter of a
wheel changes, the tyre control lamp 
lights up. The wheel diameter changes when:
● Tyre pressure is insufficient.
● The tyre structure is damaged.
● The vehicle is unbalanced because of a
load.
● The wheel

s of one axle are under more
pres
sure (for example, driving with a trailer or
on steep slopes).
● The vehicle is fitted with snow chains.
● The temporary spare wheel is fitted.
● The wheel on one axle is changed.
Tyr
e pressure adjustment
On adjusting tyre pressure or changing one
or more wheels, the ››› Fig. 175 button must
be kept pressed down, with the ignition on,
until an acoustic signal is heard.
If the wheels are under excessive load (for ex-
ample, driving with a trailer or heavy load),
the tyre pressure must be increased to the
recommended value for a full load (see the
sticker on the inside of the fuel flap). If the
tyre monitor system button is pressed down,
the new tyre pressures are confirmed. The tyre pressure control lamp
 lights up
If
the tyre pressure of a wheel is much lower
than the value set by the driver, then the tyre
pressure control lamp ››› will light up.
WARNING
● When the tyr e pr

essure control lamp lights
up, reduce speed immediately and avoid any
sudden turning or braking manoeuvre. Stop
when possible, and check the tyre pressure
and status.
● The driver is responsible for maintaining
correct
tyre pressures. For this reason, tyre
pressure must be regularly checked.
● Under certain circumstances (e.g. when
driving in a s
porty manner, in winter condi-
tions or on a dirt track) the tyre control lamp
may light up belatedly or may function incor-
rectly. Note
If the battery is disconnected, the yellow
warnin g l

amp  lights up after turning the
ignition on. This should turn off after a brief
journey. 203
Technical data
Advice
Operation
Emergencies
Safety

Index
Index
A
Abr o
a
d
extended stay abroad with your vehicle . . . . . 176
sale of vehicle . . . . . . . . . . . . . . . . . . . . . . . . . . 176
ABS see Anti-lock brake system . . . . . . . . . . . . . . . 147
Accessories . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 159
Acoustic alarm seatbelt unfastened . . . . . . . . . . . . . . . . . . . . . . 53
Adjusting front seat . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 108
lights . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 104
rear head restraints . . . . . . . . . . . . . . . . . . . . . 108
Rear head restraints . . . . . . . . . . . . . . . . . . . . . . 50
seats . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 47
Adjusting the head restraints rear head restraints . . . . . . . . . . . . . . . . . . . . . 108
Advice for driving spare wheel or temporary spare wheel . . . . . . 204
Airbag covers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14
Airbags . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 58
Airbag system . . . . . . . . . . . . . . . . . . . . . . . . . . 14, 58 activation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 60
cleaning dash panel . . . . . . . . . . . . . . . . . . . . . 174
control lamp . . . . . . . . . . . . . . . . . . . . . . . . . . . . 62
description . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 59
front airbags . . . . . . . . . . . . . . . . . . . . . . . . . 14, 61
functioning . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 60
locking the vehicle after deployment . . . . . . . . 93
repairs . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 161
Side airbags . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16
use of child seats . . . . . . . . . . . . . . . . . . . . . . . . 15
vehicle care . . . . . . . . . . . . . . . . . . . . . . . . . . . . 174 Air conditioning . . . . . . . . . . . . . . . . . . . . . . . . . . 124
climatr onic . . . . . . . . . . . . . . . . . . . . . . . . 28, 124
controls . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28
special features . . . . . . . . . . . . . . . . . . . . . . . . 127
user instructions . . . . . . . . . . . . . . . . . . . . . . . . 126
Air outlets . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 127
Air recirculation . . . . . . . . . . . . . . . . . . . . . . . . . . 128
Antenna . . . . . . . . . . . . . . . . . . . . . . . . . . . 161, 176
Anti-freeze . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 31
Anti-lock brake system . . . . . . . . . . . . . . . . . . . . . 147
Anti-lock system . . . . . . . . . . . . . . . . . . . . . . . . . . 147
Anti-puncture kit . . . . . . . . . . . . . . . . . . . . . . . . 34, 71 Check after 10 minutes . . . . . . . . . . . . . . . . . . . 73
Anti-theft security system . . . . . . . . . . . . . . . . . . . 95
Ashtray . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 116
Aspects to take into account before starting the vehicle . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46
ASR see Traction control system . . . . . . . . . . . . . . . 147
Assistance systems brake assist system (BAS) . . . . . . . . . . . . . . . . 147
cruise control . . . . . . . . . . . . . . . . . . . . . . . . . . 151
electronic differential lock (EDS) . . . . . . . . . . . 148
optical parking system (OPS) . . . . . . . . . . . . . 150
parking aid . . . . . . . . . . . . . . . . . . . . . . . . . . . . 149
parking distance warning system . . . . . . . . . . 149
safety Assist . . . . . . . . . . . . . . . . . . . . . . . . . . . 152
Assisted starting . . . . . . . . . . . . . . . . . . . . . . . . . . 42
Assist systems traction control (ASR) . . . . . . . . . . . . . . . . . . . . 148
traction control (TC) . . . . . . . . . . . . . . . . . . . . . 148
Audible warnings Control and warning lamps . . . . . . . . . . . . . . . . 25
lights . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 102
speed . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24
Automatic belt retractor . . . . . . . . . . . . . . . . . . . . . 57
Automatic device disconnection battery . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 196 Automatic gearbox
driving tip s . . . . . . . . . . . . . . . . . . . . . . . . . . . . 140
ignition key removal lock . . . . . . . . . . . . . . . . . 131
kick-down . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 140
malfunction . . . . . . . . . . . . . . . . . . . . . . . . . . . . 141
starting on a slope . . . . . . . . . . . . . . . . . . . . . . 140
stopping on a slope . . . . . . . . . . . . . . . . . . . . . 140
Automatic gear change . . . . . . . . . . . . . . . . . . . . 139
Axle loads . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 210
B Bag support . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 114
BAS see Brake assist systems . . . . . . . . . . . . . . . . . 147
Battery changing in the vehicle key . . . . . . . . . . . . . . . . 91
Battery acid . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 195
Before starting the vehicle . . . . . . . . . . . . . . . . . . 46
Belt tension device service and disposal . . . . . . . . . . . . . . . . . . . . . 57
Belt tensioner . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 57
Belt tension limiter . . . . . . . . . . . . . . . . . . . . . . . . . 57
Belt tightening . . . . . . . . . . . . . . . . . . . . . . . . . . . . 57
Bonnet . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10, 184
Boot hatch emergency locking and unlocking . . . . . . . . . . . 10
Brake assist system . . . . . . . . . . . . . . . . . . . . . . . 147
Brake fluid . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32 specification . . . . . . . . . . . . . . . . . . . . . . . . . . . 192
Brakes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 132 brake assist systems . . . . . . . . . . . . . . . . . . . . 147
brake fluid . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 191
brake fluid level . . . . . . . . . . . . . . . . . . . . . . . . 192
brake pads . . . . . . . . . . . . . . . . . . . . . . . . . . . . 135
brake servo . . . . . . . . . . . . . . . . . . . . . . . . . . . . 136
changing the brake fluid . . . . . . . . . . . . . . . . . 192
217

Index
vehicle tool kit . . . . . . . . . . . . . . . . . . . . . . . . . . 69
w arnin
g tri
angle . . . . . . . . . . . . . . . . . . . . . . . . . 69
Emergency closing or opening driver door . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
passenger door . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Emergency locking and unlocking . . . . . . . . . . . . 76
Emergency unlocking boot hatch . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
Emission control system control and warning lamps . . . . . . . . . . . . . . . 145
Emissions data . . . . . . . . . . . . . . . . . . . . . . . . . . . 209
Engine assisted starting . . . . . . . . . . . . . . . . . . . . . . . . . 42
noises . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 131
Running in . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 141
Start-Stop system . . . . . . . . . . . . . . . . . . . . . . . 156
Engine and ignition . . . . . . . . . . . . . . . . . . . . . . . 130 12 Volt sockets . . . . . . . . . . . . . . . . . . . . . . . . . 118
ignition lock . . . . . . . . . . . . . . . . . . . . . . . . . . . 130
Immobiliser . . . . . . . . . . . . . . . . . . . . . . . . . . . . 132
starting the engine . . . . . . . . . . . . . . . . . . . . . . 130
stopping the engine . . . . . . . . . . . . . . . . . . . . . 131
unauthorised vehicle key . . . . . . . . . . . . . . . . . 130
Engine compartment . . . . . . . . . . . . . . . . . . 10, 184 battery . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32, 193
brake fluid . . . . . . . . . . . . . . . . . . . . . . . . . 32, 191
coolant . . . . . . . . . . . . . . . . . . . . . . . . . . . 31, 189
engine oil . . . . . . . . . . . . . . . . . . . . . . . . . 30, 188
windscreen washer reservoir . . . . . . . . . . . . . . 193
Windscreen washer reservoir . . . . . . . . . . . . . . . 32
Engine coolant . . . . . . . . . . . . . . . . . . . . . . . . . . . . 31 checking the level . . . . . . . . . . . . . . . . . . . . . . . 189
G12 plus-plus . . . . . . . . . . . . . . . . . . . . . . . . . . . 31
G13 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 31
specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . 31
temperature display . . . . . . . . . . . . . . . . . . . . . 189
Engine data . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 212 Engine management . . . . . . . . . . . . . . . . . . . . . . 145
contro l lamps . . . . . . . . . . . . . . . . . . . . . . . . . . 145
Engine oil . . . . . . . . . . . . . . . . . . . . . . . . . . . 30, 186 changing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 186
checking oil level . . . . . . . . . . . . . . . . . . . . . . . 187
consumption . . . . . . . . . . . . . . . . . . . . . . 187, 188
dipstick . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 187
oil properties . . . . . . . . . . . . . . . . . . . . . . . . . . . 31
specifications . . . . . . . . . . . . . . . . . . . . . . . . . . 187
topping up . . . . . . . . . . . . . . . . . . . . . . . . . . . . 188
warning and indication lamps . . . . . . . . . . . . . 187
Environment Environmental compatibility . . . . . . . . . . . . . . 142
Environmental ecological driving . . . . . . . . . . . . . . . . . . . . . . . 143
Environmental tips refuelling . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 183
Equipment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 159 safety . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 59
ESC electronic stability control . . . . . . . . . . . . . . . . 147
Event Data Recorder . . . . . . . . . . . . . . . . . . . . . . . 162
Exhaust gas purification system . . . . . . . . . . . . . 145
Exterior mirrors adjusting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13
vehicle care . . . . . . . . . . . . . . . . . . . . . . . . . . . . 169
Exterior rear view mirrors control of the function . . . . . . . . . . . . . . . . . . . 108
electric exterior mirrors . . . . . . . . . . . . . . . . . . 108
exterior . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 107
Exterior view . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5, 6
F Fabrics: cleaning . . . . . . . . . . . . . . . . . . . . . . . . . 173
Fastening rings . . . . . . . . . . . . . . . . . . . . . . . . . . . 121
Fault parking distance warning system . . . . . . . . . . 150 Fault memory
connector . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 163
reading . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 163
Filling the tank . . . . . . . . . . . . . . . . . . . . . . 180, 183
Fire extinguisher . . . . . . . . . . . . . . . . . . . . . . . . . . . 69
First-aid kit storage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 69
Floor mats . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 51
Fog light . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21
Front airbags . . . . . . . . . . . . . . . . . . . . . . . . . . 14, 61
Front passenger front airbag control lamp . . . . . . . . . . . . . . . . . . . . . . . . . . . . 62
disabling . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15
disconnection . . . . . . . . . . . . . . . . . . . . . . . . . . . 62
Front seat manual adjustment . . . . . . . . . . . . . . . . . . . . . 108
manually adjusting . . . . . . . . . . . . . . . . . . . . . . . 12
Front wiper blades change . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 45
cleaning . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 45
Fuel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 30, 178 consumption . . . . . . . . . . . . . . . . . . . . . . . . . . . 210
natural gas . . . . . . . . . . . . . . . . . . . . . . . . . . . . 179
petrol . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 178
savings . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 143
type of fuel . . . . . . . . . . . . . . . . . . . . . . . . . . . . 178
Fuel gauge control lamp . . . . . . . . . . . . . . . . . . . . . . . . . . . 181
petrol . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 181
Fuel tank cap opening and closing . . . . . . . . . . . . . . . . . . . . . 30
Fuel tank flap opening and closing . . . . . . . . . . . . . . . . . . . . . 30
Fuses . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 33, 77 fuse box . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 78
identifying blown fuses . . . . . . . . . . . . . . . . . . . 33
Identifying by colours . . . . . . . . . . . . . . . . . . . . . 33
220

Index
Preparation before replacing . . . . . . . . . . . . . . . 33
r ep
l
acing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 33
G Gearbox lever . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 27
Gear change . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 27 automatic gearbox . . . . . . . . . . . . . . . . . . . . . . . 27
changing gears manually . . . . . . . . . . . . . . . . . 138
gear recommendation . . . . . . . . . . . . . . . . . . . 141
Manual gear change . . . . . . . . . . . . . . . . . . . . . . 27
putting the vehicle in gear (manual gearbox) 138
Gear engaged . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 27
General instrument panel Instrument panel . . . . . . . . . . . . . . . . . . . . . . . . 85
General view control and warning lamps . . . . . . . . . . . . . . . . 25
Generator . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 194
Glove compartment . . . . . . . . . . . . . . . . . . 113, 114
H
Handbrake . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 134
Hazard warning lights . . . . . . . . . . . . . . . . . 22, 103
Head-on collisions and the laws of physics . . . . . 54
Headlight range control . . . . . . . . . . . . . . . . . . . . 104
Headlights driving abroad . . . . . . . . . . . . . . . . . . . . . . . . . 104
Head rest adjustment . . . . . . . . . . . . . . . . . . . . . . . . . . . . 108
Head restraints Adjusting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 108
Rear head restraints . . . . . . . . . . . . . . . . . . . . . . 50
Heated rear window . . . . . . . . . . . . . . . . . . . . . . . . 29
Heating and ventilation system . . . . . . . . . . . . . 124 controls . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28
instructions . . . . . . . . . . . . . . . . . . . . . . . . . . . . 126
Hill driving assistant . . . . . . . . . . . . . . . . . . . . . . 156 Hill hold
contro l and warning lamps . . . . . . . . . . . . . . . 156
Start-Stop system . . . . . . . . . . . . . . . . . . . . . . . 157
Horn . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 85
How to jump start . . . . . . . . . . . . . . . . . . . . . . . . . . 42 description . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 43
Hubcaps . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 36
I
Identifying letters on engine . . . . . . . . . . . . . . . . 209
Ignition . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20 see "Engine and ignition" . . . . . . . . . . . . . . . . 130
Ignition lock . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20 removal lock . . . . . . . . . . . . . . . . . . . . . . . . . . . 131
unauthorised vehicle key . . . . . . . . . . . . . . . . . 130
In case of emergency . . . . . . . . . . . . . . . . . . . . . . . 69
Indications on the display . . . . . . . . . . . . . . . . . . . 87 odometer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 87
recommended gear . . . . . . . . . . . . . . . . . . . . . . 88
reminder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 89
seat belt status . . . . . . . . . . . . . . . . . . . . . . . . . . 88
selector lever positions . . . . . . . . . . . . . . . . . . . 88
Start-Stop . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 88
temperature . . . . . . . . . . . . . . . . . . . . . . . . . . . . 88
Instrument panel . . . . . . . . . . . . . . . . . . . . . . . . . . 86 control and warning lamps . . . . . . . . . . . . . . . . 25
display . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 86, 87
general instrument panel . . . . . . . . . . . . . . . . . . 85
instruments . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 86
menus . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23
service intervals . . . . . . . . . . . . . . . . . . . . . . . . . 88
symbols . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25
Instrument panel lighting . . . . . . . . . . . . . . . . . . 104
Interior lights . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22
Interior rear vision mirror anti-dazzle . . . . . . . . . . . . . . . . . . . . . . . . . . . . 107 Interior view
left . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
ISOFIX system . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19
J Jack . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 35, 69, 71 mounting points . . . . . . . . . . . . . . . . . . . . . . . . . 38
Jump leads . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 42
K Keys control lamp . . . . . . . . . . . . . . . . . . . . . . . . . . . . 91
duplicates . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 91
mechanical key . . . . . . . . . . . . . . . . . . . . . . . . . . 91
remote control . . . . . . . . . . . . . . . . . . . . . . . . . . 90
replacing the battery . . . . . . . . . . . . . . . . . . . . . 91
spare key . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 90
Synchronising . . . . . . . . . . . . . . . . . . . . . . . . . . . 92
unlocking and locking . . . . . . . . . . . . . . 8, 93, 95
vehicle key . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 90
Kick-down . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 140
L Labels and plates . . . . . . . . . . . . . . . . . . . . . . . . . 176
Level control . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 30
Lift platform . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 166
Lights . . . . . . . . . . . . . . . . . . . . . . . . . . 21, 101, 102 audible warnings . . . . . . . . . . . . . . . . . . . . . . . 102
control and warning lamps . . . . . . . . . . . . . . . 101
control lighting . . . . . . . . . . . . . . . . . . . . . . . . . 104
daytime running lights . . . . . . . . . . . . . . . . . . . 102
dipped beam headlights . . . . . . . . . . . . . . . . . 102
driving abroad . . . . . . . . . . . . . . . . . . . . . . . . . 104
fog lights . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21
functions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 102
Hazard warning lights . . . . . . . . . . . . . . . . . . . . 22
headlight range control . . . . . . . . . . . . . . . . . . 104
221