brake sensor SSANGYONG KORANDO 1997 Service Owner's Manual

SSANGYONG MY2002
4F-94 ABS AND TCS
ABS / ABD (AUTOMATIC BRAKE DIFFERENTIAL LOCK):
DIESEL - STOPLAMP SWITCH, ACCELERATION SENSOR, WHEEL SPEED SENSOR DIAGNOSIS
KAA4F290

TRANSFER CASE 5D1-3
SSANGYONG MY2002
A1
A2
A3
A4
A5
A6
A7
A8
A9
A10
A11
A12
B1
B2
B3
B4
B5
B6
B7
B8
B9
B10
B11
B12
B13
B14
B15
B16
B17
B18Shift motor output (- High to low: Battery voltage/ - Low to high or motor brake : Ground)
Shift motor output (- Low to high: Battery voltage/ - High to Low or motor brake : Ground)
TOD output: Electromagnetic clutch control
B (+) : Fuse F17
Ignition Voltage: Fuse F23
Shift motor output (- High to low: Battery voltage/ - Low to high or motor brake : Ground)
Shift motor output (- Low to high: Battery voltage/ - High to Low or motor brake : Ground)
Reference voltage (5V) supply to Throttle Position (TP) sensor and speed sensor
Ground
Ground
B (+) : Fuse F17
Diagnosis (K-line)
Position encoder ground
Illuminate 4WD CHECK lamp
Not in used
Mode (4H/4L) input
Position encoder 2 input
Front propeller shaft speed sensor input
Not in used
Speed sensor ground. Throttle position (TP) sensor return
Illuminate 4WD LOW indicator
CAN bus high line
CAN bus low line
Neutral position sensor signal input (A/T only)
ABS operation signal (ON/OFF)
Brake switch signal input
Position encoder 1 input
Position encoder 3 input
Rear propeller shaft speed sensor signal input
Position encoder 4 input
PIN DESCRIPTION
Pin No.Description

TRANSFER CASE 5D1-5
SSANGYONG MY2002
The motor reaches its destination.
The motor is on for 5 seconds without reaching its
destination. The shift has failed and the TCCU will
respond as default mode.
A fault occurs with either the motor or position
encoder. Refer to the diagnosis requirement.
When the motor is energized, the Ignition, 4H/4L
switch, propeller shaft speeds, and transmission
neutral inputs are ignored.
Indicator Function
Once a range change has been initiated the 4WD LOW
indicator will begin to blink at a rate of 0.3 seconds
on, 0.3 seconds off until the shift is completed or
canceled. If a successful shift has been completed,
the 4WD LOW indicator will be illuminated if the motor
is in low range and it will be turned off if the motor is in
high range.
4WD LOW indicator illuminates as below figure.
KAA5D000
TODTM System Operation
The TODTM System is responsible for distributing torque
between the front and rear axles. The TCCU monitors
the propeller shaft speeds, operating range (high/low),
and ABS activity and then applies a calculated amount
of torque to the front axle by pulse width modulating
(PWM) the current applied to the electromagnetic clutch
(EMC).
Touch-off Torque
The minimum EMC duty cycle is based on the vehicle
speed and throttle position. The TCCU receives the
throttle position (TP) sensor signal from the engine con
trol module (ECM) through CAN bus line.
Wheel Slip Detection and Control
The TCCU continuously monitors the front and rear pro-
peller shaft speeds to detect wheel slip.
When wheel slip is detected the TCCU controls the
EMC duty cycles as necessary until the wheel slip is
reduced below the allowable limit. The EMC duty cycle
will then be reduced to the touch-off value.Brake/ABS Strategy
When the ABS System is active, the EMC duty cycle
is set to a fixed duty cycle (30%) to aid in braking
without counteracting the ABS System.
4L Strategy
When the system is operating in 4WD low range, the
TCCU continues TOD
TM operation provided that the pro
peller shaft speed is below 175 rpm (5220 pulses/min-
ute). When the speed increases above 175 rpm, the
EMC duty cycle is set to the maximum value (88 %)
which applies the maximum available torque to the front
axle.
Position Encoder
The position encoder is used by the TCCU to determine
the position of the shift motor. Each motor position is
identified by a position code as shown.
Motor Position
Left Stop
Left of High
High
Right of High
Zone 1
Neutral
Zone 2
Low
Right Stop Position code 1/2/3/4
1111
1010
0010
0000
1110
1001
0001
0101
0100
Notice:
All other position codes are invalid
Position input : open circuit (> 4.5V) = 1
Position input : Shorted to speed/position return
(< 0.5V) = 0
Position Sensor Interpretation
1. When the module powers up, it will read the position
sensor and the 4H/4L switch input and respond to
the possible codes as following tables.
2. A command to shift will only be acted upon if the
TCCU is reading a valid code at the time the com-
mand to shift is made.
3. After a shift has started, the TCCU will power the
shift motor until the code for the requested position
is read. If an invalid code is read, the TCCU will go
into a default mode.
4. During a shift attempt, the shift motor will be ener-
gized for a maximum of 5 second

BODY WIRING SYSTEM 9A-13
SSANGYONG MY2002
1 C351
2 S201
3 G201
4 G202
5 Auto down unit
6 HLLD switch
7 OSRV switch
8 Rear wiper & washer switch
9 C201
10 Clutch switch “A”
11 Clutch switch “B” (Gasoline E/G)
12 Stop lamp switch
13 Dimmer & passing switch
14 Turn signal,FRT fog lamp & Light switch
15 Wiper switch
16 J201
17 C202
18 Immobilizer antenna
19 Ignition switch
20 Cruise control switch
21 Key reminder switch
22 C203
23 Acceleration pedal sensor
24 Kick down switch
25 REKES
26 ADD’ (LH)
27 Diagnosis connector
28 Brake fluid switch
29 Locking hud solenoid (TCCU)
30 C116
31 Cluster “D”
32 Cluster “C”
33 Cluster “B”
34 Cluster “A”
35 J202
36 J202
37 J203
38 S203
39 4WD switch
40 Hazard switch
41 Defroster switch
42 ECS switch
43 Antenna feeder cable
44 S204
45 Audio
46 DRL unit
47 SDM
48 G204
49 C204
50 Chime Bell
51 Buzzer
52 Acceleration sensor
53 G203
54 Cigar lighter55 Central door lock relay
56 BTSI solenoid
57 A/Tsocket
58 BTSI “P” position sw
59 Mode switch
60 Shift motor
61 Speed sensor & clutch coil
62 VSS
63 C301
64 C302
65 C303
66 C304
67 TCM
68 TOD Resistor (Gasoline E/G)
69 G301
70 TOD or TCCU
71 FRT LH seat belt sw
72 Parking brake sw
73 W/D Burglar connector
74 Seat heater switch
75 STICS
76 G303
77 ECS
78 OVPR (Gasoline E/G)
79 C305
80 Seat belt sw (FRT RH)
81 EBCM (ADD)
82 G303
83 C205
84 Thermo amp
85 Passenger inflator
86 Vertical sensor
87 Lateral sensor
88 Front wiper motor
89 Siren
90 O2 sensor 1 / (Gasoline E/G)
91 EBCM (ABS) & Modulator (ABD)
92 J105
93 C113
94 C112
95 EGR solenoid (Diesel E/G)
96 C114 (Gasoline E/G)
97 C115 (Gasoline E/G)
98 J204 (Gasoline E/G)
99 S205
100 J205 (Gasoline E/G)
101 Antenna feeder cable
102 Auto antenna
103 C206
104 ECM (GSL) or Immobilizer unit (DSL)
105 EGR control unit (Diesel E/G)
106 G205
107 C361
108 O2 sensor 2 (Gasoline E/G)

ELECTRICAL WIRING DIAGRAMS ELECTRICAL WIRING DIAGRAMSELECTRICAL WIRING DIAGRAMS ELECTRICAL WIRING DIAGRAMS
ELECTRICAL WIRING DIAGRAMS
2-7 2-7 2-7 2-7
2-7
2) 2)2) 2)
2)
W/H MAIN W/H MAINW/H MAIN W/H MAIN
W/H MAIN• W/H MAIN
1. C351
2. S201
3. G201
4. G202
5. Auto down unit
6. HLLD switch
7. OSRV switch
8. Rear wiper & washer switch
8-1. DLC9. C201
10. Clutch switch "A"
11. Clutch switch "B" (Gasoline E/G)
12. Stop lamp switch
13. Dimmer & passing switch
14. Turn signal,FRT fog lamp & Light switch
15. Wiper switch
16. J201
17. C20218. Immobilizer antenna
19. Ignition switch
20. Cruise control switch
21. Key reminder switch
22. C203
23. Acceleration pedal sensor
24. Kick down switch
25. REKES
26. ADD' (LH)
27. Diagnosis connector
28. Brake fluid switch
29. Locking hud solenoid (TCCU)
30. C116
31. Cluster "D"
32. Cluster "C"
33. Cluster "B"
34. Cluster "A"
35. J202
36. J202
37. J203
38. S203
39. 4WD switch
40. Hazard switch
41. Defroster switch
42. -
43. Antenna feeder cable
44. S204
45. Audio
46. -
47. SDM
48. G204
49. C204
50. Chime Bell
51. Buzzer
52. Acceleration sensor
53. G203
54. Cigar lighter
55. Central door lock relay
56. BTSI solenoid
57. A/Tsocket
58. BTSI "P" position sw
59. Mode switch
60. Shift motor
61. Speed sensor & clutch coil
62. VSS
63. C301
64. C302
65. C30366. C304
67. TCM
68. TOD Resistor (Gasoline E/G)
69. G301
70. TOD or TCCU
71. FRT LH seat belt sw
72. Parking brake sw
73. W/D Burglar connector
74. Seat heater switch
75. STICS
76. G303
77. -
78. OVPR (Gasoline E/G)
79. C305
80. Seat belt sw (FRT RH)
81. EBCM (ADD)
82. G303
83. C205
84. Thermo amp
85. Passenger inflator
86. -
87. -
88. Front wiper motor
89. Siren
90. O2 sensor 1 / (Gasoline E/G)
91. EBCM (ABS) & Modulator (ABD)
92. J105
93. C113
94. C112
95. EGR solenoid (Diesel E/G)
96. C114 (Gasoline E/G)
97. C115 (Gasoline E/G)
98. J204 (Gasoline E/G)
99. S205
100.J205 (Gasoline E/G)
101.Antenna feeder cable
102.Auto antenna
103.C206
104.ECM (GSL) or Immobilizer unit (DSL)
105.EGR control unit (Diesel E/G)
106. G205
107.C361
108. O2 sensor 2 (Gasoline E/G)
FUSE
BOX
RELAY
BOX
FUSE &
RELAY BOX
A
1011
12131415171618192021222829
30
26
27
31323334
35
3637
38
394041
43
83888990
91
93
9495
9296
979899102
101100
106107
104105
103
108
84
85
44
8-1
4748
49
50
51
52
53
45
55
54565758
60616263
6465
66
67
68
71
72
73
74
7576
78
7980
8182
69
70
59
232425
13
4259678

9. 9. 9. 9.
9.
ABS (ANTI-LOCK BRAKE SYSTEM) ABS (ANTI-LOCK BRAKE SYSTEM)ABS (ANTI-LOCK BRAKE SYSTEM) ABS (ANTI-LOCK BRAKE SYSTEM)
ABS (ANTI-LOCK BRAKE SYSTEM)
....................................................................................... .............................................................................................................................................................................. .......................................................................................
.......................................................................................
5-62 5-62 5-62 5-62
5-62
10. 10.10. 10.
10.
ABS/ABD (A ABS/ABD (AABS/ABD (A ABS/ABD (A
ABS/ABD (A
UT UTUT UT
UT
OMA OMAOMA OMA
OMA
TIC BRAKE DIFFERENTIAL LOCK): TIC BRAKE DIFFERENTIAL LOCK):TIC BRAKE DIFFERENTIAL LOCK): TIC BRAKE DIFFERENTIAL LOCK):
TIC BRAKE DIFFERENTIAL LOCK):
DIESEL DIESEL DIESEL DIESEL
DIESEL
...................................... ............................................................................ ......................................
......................................
5-64 5-64 5-64 5-64
5-64
1) INDICATOR, RELAY (ABD, MOTOR, VALVE), HYDRAULIC MODULATOR.................................................... 5-64
2) STOP LAMP SWITCH, ACCELERATION SENSOR, WHEEL SPEED SENSOR, DIAGNOSIS..................... 5-66
11. 11.11. 11.
11.
ABS/ABD (A ABS/ABD (AABS/ABD (A ABS/ABD (A
ABS/ABD (A
UT UTUT UT
UT
OMA OMAOMA OMA
OMA
TIC BRAKE DIFFERENTIAL LOCK): TIC BRAKE DIFFERENTIAL LOCK):TIC BRAKE DIFFERENTIAL LOCK): TIC BRAKE DIFFERENTIAL LOCK):
TIC BRAKE DIFFERENTIAL LOCK):
GASOLINE GASOLINE GASOLINE GASOLINE
GASOLINE
................................ ................................................................ ................................
................................
5-68 5-68 5-68 5-68
5-68
1) INDICATOR, RELAY (ABD, MOTOR, VALVE), HYDRAULIC MODULATOR.................................................... 5-68
2) STOP LAMP SWITCH, ACCELERATION SENSOR, WHEEL SPEED SENSOR, DIAGNOSIS..................... 5-70
12. 12.12. 12.
12.
ABS/ABD (A ABS/ABD (AABS/ABD (A ABS/ABD (A
ABS/ABD (A
UT UTUT UT
UT
OMA OMAOMA OMA
OMA
TIC BRAKE DIFFERENTIAL LOCK): TIC BRAKE DIFFERENTIAL LOCK):TIC BRAKE DIFFERENTIAL LOCK): TIC BRAKE DIFFERENTIAL LOCK):
TIC BRAKE DIFFERENTIAL LOCK):
EUR EUR EUR EUR
EUR
O III O IIIO III O III
O III
.................................... ........................................................................ ....................................
....................................
5-72 5-72 5-72 5-72
5-72
-ATTACHED EBCM-................................................................................................................................................... 5-72
13. 13.13. 13.
13.
TCCU TCCUTCCU TCCU
TCCU
........................................................................................................................................... ........................................................................................................................................... ........................................................................................................................................... ...........................................................................................................................................
...........................................................................................................................................
5-74 5-74 5-74 5-74
5-74
1) INDICATOR, DIAGNOSIS..................................................................................................................................... 5-74
2) 4WD SWITCH, SPEED SENSOR & CLUTCH COIL, SHIFT MOTOR, LOCKING HUB SOLENOID ............ 5-76
14. 14.14. 14.
14.
TOD (TORQUE ON DEMAND) TOD (TORQUE ON DEMAND)TOD (TORQUE ON DEMAND) TOD (TORQUE ON DEMAND)
TOD (TORQUE ON DEMAND)
................................................................................................. .................................................................................................................................................................................................. .................................................................................................
.................................................................................................
5-78 5-78 5-78 5-78
5-78
1) 4WD SWITCH, INDICATOR, DIAGNOSIS, SHIFT MOTOR.............................................................................. 5-78
2) SPEED SENSOR & CLUTCH (COIL, CLUTCH SW(M/T) & NEUTRAL RELAY (A/T)) .................................... 5-80
15. 15.15. 15.
15.
MANUAL AIR CONDITIONING SYSTEM : DIESEL MANUAL AIR CONDITIONING SYSTEM : DIESELMANUAL AIR CONDITIONING SYSTEM : DIESEL MANUAL AIR CONDITIONING SYSTEM : DIESEL
MANUAL AIR CONDITIONING SYSTEM : DIESEL
................................................................. .................................................................................................................................. .................................................................
.................................................................
5-82 5-82 5-82 5-82
5-82
1) CONDNSER FAN MOTOR, THERMO SWITCH, COMPRESOR, THERMO AMP ............................................ 5-82MANUAL AIR CONDITIONING SYSTEM : GASOLINE MANUAL AIR CONDITIONING SYSTEM : GASOLINEMANUAL AIR CONDITIONING SYSTEM : GASOLINE MANUAL AIR CONDITIONING SYSTEM : GASOLINE
MANUAL AIR CONDITIONING SYSTEM : GASOLINE
........................................................... ...................................................................................................................... ...........................................................
...........................................................
5-84 5-84 5-84 5-84
5-841) CONDNSER FAN MOTOR(LH/RH), COMPRESOR, THERMO AMP ................................................................. 5-84
2) BLOWER MOTOR CIRCUIT................................................................................................................................. 5-86
3) CONTROL PANEL, INTAKE ACTUATOR, MODE ACTUATOR......................................................................... 5-88
16. 16.16. 16.
16.
AIR BAG (SDM : SENSING & DIAGNOSIS MODULE) AIR BAG (SDM : SENSING & DIAGNOSIS MODULE)AIR BAG (SDM : SENSING & DIAGNOSIS MODULE) AIR BAG (SDM : SENSING & DIAGNOSIS MODULE)
AIR BAG (SDM : SENSING & DIAGNOSIS MODULE)
........................................................... ...................................................................................................................... ...........................................................
...........................................................
5-90 5-90 5-90 5-90
5-90
17. 17.17. 17.
17.
SEA SEASEA SEA
SEA
T BEL T BELT BEL T BEL
T BEL
T & T & T & T &
T &
TENSION REDUCER TENSION REDUCERTENSION REDUCER TENSION REDUCER
TENSION REDUCER
........................................................................................ ................................................................................................................................................................................ ........................................................................................
........................................................................................
5-92 5-92 5-92 5-92
5-92
18. 18.18. 18.
18.
CLUSTER CLUSTERCLUSTER CLUSTER
CLUSTER
.................................................................................................................................... .................................................................................................................................... .................................................................................................................................... ....................................................................................................................................
....................................................................................................................................
5-94 5-94 5-94 5-94
5-94
1) VSS(VEHICLE SPEED SENSOR), METER(SPEEDO, TACHO) & GAUGE(FUEL, TEMPERATURE)
- DIESEL................................................................................................................................................................. 5-94

1) VSS(VEHICLE SPEED SENSOR), METER(SPEEDO, TACHO) & GAUGE(FUEL, TEMPERATURE)
- GASOLINE ........................................................................................................................................................... 5-96
(1) W/O EURO III .................................................................................................................................................................................... 5-96
(2) W/ EURO III ....................................................................................................................................................................................... 5-98
2) WARNING LAMP(ENGINE CHECK, AIR BAG, EBD, ABS), TCS INDICATOR............................................. 5-100
3) INDICATOR(DEFROSTER, WINTER MODE, POWR MODE, 4WD LOW, 4WD HIGH, 4WD CHECK)..... 5-102
4) WARNING LAMP (SEAT BELT, DOOR OPEN, PARKING BRAKE), INDICATOR (BATTERY CHARGING,
GLOW).................................................................................................................................................................. 5-104
5) FRONT FOG LAMP, TURN SIGNAL, HAZARD, HIGH BEAM ......................................................................... 5-106
6) DIGITAL CLOCK,WARNING (OIL PRESSURE, LOW FUEL LEVEL) CLUSTER ILLUMINATION............... 5-108
7) SELECTOR LEVER POSITION LAMP (P,R,N,D,3,2,1).................................................................................... 5-110
19. 19.19. 19.
19.
STICS(SUPER STICS(SUPER STICS(SUPER STICS(SUPER
STICS(SUPER
TIME & ALARM INTEGRA TIME & ALARM INTEGRATIME & ALARM INTEGRA TIME & ALARM INTEGRA
TIME & ALARM INTEGRA
TED CONTR TED CONTRTED CONTR TED CONTR
TED CONTR
OL SYSTEM) OL SYSTEM)OL SYSTEM) OL SYSTEM)
OL SYSTEM)
................................ ................................................................ ................................
................................
5-112 5-112 5-112 5-112
5-112
1) STICS UNIT .......................................................................................................................................................... 5-112
2) FRONT WIPER CIRCUIT.................................................................................................................................... 5-114
3) CENTRAL DOOR LOCK SYSTEM ..................................................................................................................... 5-116
4) KEYLESS, KEY REMINDER SWITCH, SIREN, CHIME BELL BUZZER ........................................................ 5-118
5) DEFROSTER........................................................................................................................................................ 5-120
6) LAMP(ROOM, DOOR COURTESY LH/RH, LUGGAGE), DOOR CONTACT SWITCH .................................. 5-122
20. 20.20. 20.
20.
SEA SEASEA SEA
SEA
T HEA T HEAT HEA T HEA
T HEA
TER TERTER TER
TER
.......................................................................................................................... .................................................................................................................................................................................................................................................... ..........................................................................................................................
..........................................................................................................................
5-124 5-124 5-124 5-124
5-124
21. 21.21. 21.
21.
ST STST ST
ST
OP LAMP OP LAMPOP LAMP OP LAMP
OP LAMP
, ,, ,
,
BTSI (BRAKE BTSI (BRAKE BTSI (BRAKE BTSI (BRAKE
BTSI (BRAKE
TRANSMISSION SHIFT INTERLOCK) TRANSMISSION SHIFT INTERLOCK)TRANSMISSION SHIFT INTERLOCK) TRANSMISSION SHIFT INTERLOCK)
TRANSMISSION SHIFT INTERLOCK)
................................... ...................................................................... ...................................
...................................
5-126 5-126 5-126 5-126
5-126
1) METAL TOP .......................................................................................................................................................... 5-126
2) SOFT TOP............................................................................................................................................................ 5-128
22. 22.22. 22.
22.
POWER WINDOW POWER WINDOWPOWER WINDOW POWER WINDOW
POWER WINDOW
..................................................................................................................... .......................................................................................................................................................................................................................................... .....................................................................................................................
.....................................................................................................................
5-130 5-130 5-130 5-130
5-130
23. 23.23. 23.
23.
ELECTRIC OSRV (OUTSIDE REAR VIEW) MIRROR ELECTRIC OSRV (OUTSIDE REAR VIEW) MIRRORELECTRIC OSRV (OUTSIDE REAR VIEW) MIRROR ELECTRIC OSRV (OUTSIDE REAR VIEW) MIRROR
ELECTRIC OSRV (OUTSIDE REAR VIEW) MIRROR
........................................................... ...................................................................................................................... ...........................................................
...........................................................
5-132 5-132 5-132 5-132
5-132
24. 24.24. 24.
24.
REAR REAR REAR REAR
REAR
WIPER & WIPER & WIPER & WIPER &
WIPER &
W WW W
W
ASHER ASHERASHER ASHER
ASHER
...................................................................................................... ............................................................................................................................................................................................................ ......................................................................................................
......................................................................................................
5-134 5-134 5-134 5-134
5-134
25. 25.25. 25.
25.
CIGARETTE LIGHTER, HORN CIGARETTE LIGHTER, HORNCIGARETTE LIGHTER, HORN CIGARETTE LIGHTER, HORN
CIGARETTE LIGHTER, HORN
................................................................................................ ................................................................................................................................................................................................ ................................................................................................
................................................................................................
5-136 5-136 5-136 5-136
5-136
26.HEAD LAMP 26.HEAD LAMP26.HEAD LAMP 26.HEAD LAMP
26.HEAD LAMP
.............................................................................................................................. ............................................................................................................................................................................................................................................................ ..............................................................................................................................
..............................................................................................................................
5-138 5-138 5-138 5-138
5-138
27. 27.27. 27.
27.
HEAD LAMP LEVELING DEVICE (HLLD) HEAD LAMP LEVELING DEVICE (HLLD)HEAD LAMP LEVELING DEVICE (HLLD) HEAD LAMP LEVELING DEVICE (HLLD)
HEAD LAMP LEVELING DEVICE (HLLD)
.............................................................................. ............................................................................................................................................................ ..............................................................................
..............................................................................
5-140 5-140 5-140 5-140
5-140

5-62 5-62 5-62 5-62
5-62
ELECTRICAL WIRING DIAGRAMS ELECTRICAL WIRING DIAGRAMSELECTRICAL WIRING DIAGRAMS ELECTRICAL WIRING DIAGRAMS
ELECTRICAL WIRING DIAGRAMS9. 9.9. 9.
9.
ABS (ANTI-LOCK BRAKE SYSTEM) ABS (ANTI-LOCK BRAKE SYSTEM)ABS (ANTI-LOCK BRAKE SYSTEM) ABS (ANTI-LOCK BRAKE SYSTEM)
ABS (ANTI-LOCK BRAKE SYSTEM)
a. a.a. a.
a.
CONNECTOR INFORMATION CONNECTOR INFORMATIONCONNECTOR INFORMATION CONNECTOR INFORMATION
CONNECTOR INFORMATION
b. b.b. b.
b.
CONNECTOR IDENTIFICATION SYMBOL & PIN NUMBER POSITION CONNECTOR IDENTIFICATION SYMBOL & PIN NUMBER POSITIONCONNECTOR IDENTIFICATION SYMBOL & PIN NUMBER POSITION CONNECTOR IDENTIFICATION SYMBOL & PIN NUMBER POSITION
CONNECTOR IDENTIFICATION SYMBOL & PIN NUMBER POSITION
ACCELERATION
SENSOR
EBCM STOP LAMP "A"
ECM
STOP LAMP "B"
CLUSTER "A"CLUSTER "D"
S202 (BLACK)DIAGNOSIS
CONNECTOR
WHEEL SPEED
SENSOR
C113 (BLACK)
C102 (4Pin, Colorless)
C104 (8Pin, Colorless)
C113 (12Pin, Black)
S202 (20Pin, Black)
J101
J102
J103
J104
J105
J301
J302
J303
J304
G205CONNECTOR(NUMBER) CONNECTOR(NUMBER)CONNECTOR(NUMBER) CONNECTOR(NUMBER)
CONNECTOR(NUMBER)
CONNECTING. WIRING HARNESS CONNECTING. WIRING HARNESSCONNECTING. WIRING HARNESS CONNECTING. WIRING HARNESS
CONNECTING. WIRING HARNESS
CONNECTOR POSITION CONNECTOR POSITIONCONNECTOR POSITION CONNECTOR POSITION
CONNECTOR POSITION
Engine Room Fuse Box - W/H Main
Engine Room Fuse Box - W/H Main
W/H Engine Room - W/H Main
W/H Main
W/H Engine Room
W/H Engine Room
W/H Engine Room
W/H Engine Room
W/H Main
W/H Main
W/H Main
W/H Main
W/H Main
W/H MainEngine Room Fuse Box
Engine Room Fuse Box
Next to Hydraulic Unit
Behind Cluster
Behind Battery
Behind Battery
Below Air Cleaner
Below Air Cleaner
Next to Yellew Label
Below Rear Left Seat
Below Rear Left Seat
Below Rear Right Seat
Below Rear Right Seat
Center "A" Pillar Front Right
DLC(EURO III)

5-72 5-72 5-72 5-72
5-72
ELECTRICAL WIRING DIAGRAMS ELECTRICAL WIRING DIAGRAMSELECTRICAL WIRING DIAGRAMS ELECTRICAL WIRING DIAGRAMS
ELECTRICAL WIRING DIAGRAMS12. 12.12. 12.
12.
ABS/ABD (AUT ABS/ABD (AUTABS/ABD (AUT ABS/ABD (AUT
ABS/ABD (AUT
OMA OMAOMA OMA
OMA
TIC BRAKE DIFFERETIAL LOCK) : TIC BRAKE DIFFERETIAL LOCK) :TIC BRAKE DIFFERETIAL LOCK) : TIC BRAKE DIFFERETIAL LOCK) :
TIC BRAKE DIFFERETIAL LOCK) :
EUR EUR EUR EUR
EUR
O III O IIIO III O III
O III
-ATTACHED EBCM- -ATTACHED EBCM--ATTACHED EBCM- -ATTACHED EBCM-
-ATTACHED EBCM-
a. a.a. a.
a.
CONNECTOR INFORMATION CONNECTOR INFORMATIONCONNECTOR INFORMATION CONNECTOR INFORMATION
CONNECTOR INFORMATION
b. b.b. b.
b.
CONNECTOR IDENTIFICATION SYMBOL & PIN NUMBER POSITION CONNECTOR IDENTIFICATION SYMBOL & PIN NUMBER POSITIONCONNECTOR IDENTIFICATION SYMBOL & PIN NUMBER POSITION CONNECTOR IDENTIFICATION SYMBOL & PIN NUMBER POSITION
CONNECTOR IDENTIFICATION SYMBOL & PIN NUMBER POSITION
ACCELERATION
SENSOREBCM
ECM
STOP LAMP "B"
CLUSTER "A"CLUSTER "D"
S202 (BLACK)
DLC(EURO III)
WHEEL SPEED
SENSOR
C113 (BLACK)
C102 (4Pin, Colorless)
C104 (8Pin, Colorless)
C113 (12Pin, Black)
S202 (20Pin, Black)
J101
J102
J103
J104
J105
J301
J302
J303
J304
G205CONNECTOR(NUMBER) CONNECTOR(NUMBER)CONNECTOR(NUMBER) CONNECTOR(NUMBER)
CONNECTOR(NUMBER)
CONNECTING. WIRING HARNESS CONNECTING. WIRING HARNESSCONNECTING. WIRING HARNESS CONNECTING. WIRING HARNESS
CONNECTING. WIRING HARNESS
CONNECTOR POSITION CONNECTOR POSITIONCONNECTOR POSITION CONNECTOR POSITION
CONNECTOR POSITION
Engine Room Fuse Box - W/H Main
Engine Room Fuse Box - W/H Main
W/H Engine Room - W/H Main
W/H Main
W/H Engine Room
W/H Engine Room
W/H Engine Room
W/H Engine Room
W/H Main
W/H Main
W/H Main
W/H Main
W/H Main
W/H MainEngine Room Fuse Box
Engine Room Fuse Box
Next to Hydraulic Unit
Behind Cluster
Behind Battery
Behind Battery
Below Air Cleaner
Below Air Cleaner
Next to Yellew Label
Below Rear Left Seat
Below Rear Left Seat
Below Rear Right Seat
Below Rear Right Seat
Center "A" Pillar Front Right