ECU TOYOTA RAV4 1999 Owners Manual

'99 Rav4.U13
CAUTION
Keep the back door (hardtop) or
tailgate (soft- top) closed while driv-
ing. This not only keeps the lug-
gage from being thrown out but
also prevents exhaust gases from
entering the vehicle.
If the open back door (hardtop) or
tailgate (soft- top) hides the rear
stop and tail lights or rear turn sig-
nal lights while you are parked, oth-
er road users must be warned of
the presence of your vehicle by a
warning triangle or other device.
Hood
To open the hood:
1. Pull the hood lock release lever. The hood will spring up slightly.
CAUTION
Before driving, be sure that the hood
is closed and securely locked. Other-
wise, the hood may open unexpected-
ly while driving and an accident may
occur.
2. In front of the vehicle, pull up the auxiliary catch l ever and lift the
hood.

'99 Rav4.U
14
3. Hold the hood open by inserting the support rod into the slot.
Before closing the hood, check that you
have not forgotten any tools, rags, etc.
and return the support rod to its clipÐthis
prevents rattles. Then lower the hood until
it is about 20 cm (8 in.) above the engine
compartment and release it. If the hood is
still not fully closed, lift and release the
hood again. After closing the hood, make
sure it is securely locked.
If you notice while driving that the hood
is not securely locked, stop the vehicle at
once and close the hood.
CAUTION
Right after driving the support rod
may be hot, so only touch the part
coated with nylon.
After inserting the rod
into the
slot, make sure the rod supports
the hood securely from falling down
on to your head or body.
When closing the hood, be careful
not to get your hands caught be-
tween the hood and the vehicle
body.
NOTICE
Do not press on the hood, or you
may deform the hood.
Fuel tank cap
1. To open the fuel filler door, pull the lever up.
When refueling, turn off the engine.
CAUTION
Do not smoke, cause sparks or al-
low open flames when refueling.
The fumes are flammable.
When opening the cap, do not re-
move the cap quickly. In hot weath-
er, fuel under pressure could cause
injury by spraying out of the filler
neck if the cap is suddenly re-
moved.

'99 Rav4.U15
2. To remove the fuel tank cap, turnthe cap slowly counterclockwise,
then pause slightly before removing
it. After removing the cap, hang it
on the cap hanger.
It is not unusual to hear a slight swoosh
when the cap is opened. When insta lling,
turn the cap clockwise till you hear aclick.
If the cap is not tightened securely, the
malfunction indicator lamp comes on.
Make sure the cap is tightened securely.
The indicator lamp goes off after driving
several times. If the indicator lamp does
not go off, contact your Toyota dealer as
soon as possible.
CAUTION
Make sure the cap is tightened se-
curely to prevent fuel sp illage in
case of an accident.
Use only a genuine Toyota fuel tank
cap for replacement. It has a built-
in check valve to reduce fuel tank
vacuum.
Electric moon roof
Sliding operation
Tilting operation

'99 Rav4.U
16
To operate the moon roof, use the
switches beside the personal light.
The key must be in the ºONº position.
Sun shade operationÐ
The sun shade can be opened or closed
by hand.
Sliding operationÐ
To open: Push the switch on the ºSLIDEº
side.
The sun shade will be opened together
with the roof.
To close: Push the switch on the opposite
side of the ºSLIDEº side.
As a precaution when closing, the roof
stops at the three- quarters closed position
before fully closing. Therefore, release the
switch and then push it again to close it
completely.
Tilting operationÐ
To tilt up: Push the switch on the ºUPº
side.
To lower: Push the switch on the opposite
side of the ºUPº side.
You may stop the moon roof at any de-
sired position. The roof will move while
the switch is being pushed and stop when
released.
CAUTION
To avoid serious personal injury, you
must do the following.
While the vehicle is moving, always
keep the head, hands and other
parts of the body of all occupants
away from the roof opening. Other-
wise, you could be seriously injured
if the vehicle stops suddenly or if
the vehicle is involved in an acci-
dent.
Always make sure nobody places
his/her head, hands and other parts
of the body in the roof opening be-
fore you close the roof. If some-
one's neck, head or hands gets
caught in the closing roof, it could
result in a serious injury. When
anyone close the roof, first make
sure it is safe to do so.
Never leave small children alone in
the vehicle, especially with the igni-
tion key still inserted. They could
use the moon roof switches and get
trapped in the roof opening. Unat-
tended children can become in-
volved in serious accidents.
Never sit on top of the vehicle
around the roof opening.
CAUTION
To avoid serious personal injury, you
must do the following. While the vehicle is moving, always
keep the head, hands and other
parts of the body of all occupants
away from the roof opening. Other-
wise, you could be seriously injured
if the vehicle stops suddenly or if
the vehicle is involved in an acci-
dent.
Never sit on top of the vehicle
around the roof opening.
Never attempt to remove the sun
roof panel while driving. Otherwise,
the panel may become a hazard by
falling into or flying off the vehicle.
After installing the sun roof panel,
make sure they are firmly secured
by pushing up on the underside of
each panel.
Never put your hands between the
sun roof panel and the surrounding
roof.
Detachable sun roofÐ
ÐSun roof precautions

'99 Rav4.U17
ÐTilting up and closing
To tilt up the sun roof, first pull down
on the handle while pushing in one of
the lock buttons. Then push up the sun
roof until it locks.
After tilting up the sun roof, make sure
the handle is securely in place.
When closing the sun roof, slowly pull
down the handle while supporting the roof
with your hand. Close and lock the sun
roof by pushing the handle until it cli
cks.
Be sure to use your palm to push the
handle. After closing the sun roof, make
sure it is securely locked. ÐRemoving1. Pull the handle down while pushing
in one of the lock buttons.2. Push in the retaining spring arms asshown and push up the sun roof.

'99 Rav4.U19
2. Set the front edge of the sun roofpanel into the holders.3. Place the removed holder over thesun roof handle.4. Secure the holder by turning thebolts clockwise.
NOTICE
Do not drive the vehicle without
checking that the roof panel is se-curely attached to the tailgate.

'99 Rav4.U21
Do not drive the vehicle only with
the rear window removed because
serious injury or death can result.
The removed rear window may let
the exhaust gases enter the vehicle.
If you must drive with the rear win-
dow removed, broken or not fully
sealed, you should immediately re-
move the quarter windows also to
avoid exhaust gas filled up and as
necessary have the window fixed
immediately.
Make sure no object overhangs the
vehicle. The overhanging objects
may cause an accident.NOTICE
Make sure there are no items or
packages between the rear seatbackand the soft- top storage area whenraising or lowering the soft- top.
Even small items may interfere withsoft- top operation and can causedamage.
Do not sit or place excessiveweight on the soft- top; when thetop is up or down, damage may
result.
Do not raise or lower the soft- topwhen the temperature is below 0
5C
(32
5F), or damage may result to the
top material, rear window or quarter
windows. If necessary to do so,warm the vehicle in a heated garage
prior to operating the soft- top
mechanism.
Do not lower the soft- top if the top
is damp or wet. Interior water dam-age, water stains or mildew of the
top material may result.
Do not bend the removed quarter and rear windows or hit them on ahard object. It may damage the re-
moved windows.
ÐLowering the soft- top
Before lowering the soft- top, make sure
the soft- top is securely closed.
REMOVING THE QUARTER WINDOWS
1. Remove the Velcros on the top of the quarter window from the inside
of the vehicle.

'99 Rav4.U25
4. Take the latch handle cover out ofthe glove box, put it over the latch
handle and fasten it securely with
Ve l c r o s . ÐRaising the soft- topRAISING THE SOFT- TOP
1. Remove the latch handle cover.
Store the removed cover in the glove
box.2. Raise the soft- top.
CAUTION
When raising the soft- top, keep
hands clear from any parts of the top
linkage.

'99 Rav4.U
26
3. Separate the latch handle and hook while pressing the lock release but-
ton.4. Set the hook, push up the latch han-dle to securely lock it.
CAUTION
Try pushing and pulling the latch
handle to make sure it is securely
locked.
Try pushing the soft- top forward
and rearward to make sure it is se-
curely locked.
INSTALLING THE REAR WINDOW
1. Open the tailgate and engage the zipper approximately 25 mm (1.0 in.).
CAUTION
The rear window must be securely
sealed to prevent exhaust gases from
coming into the occupant compart-
ment and causing serious personal
injury or death.

'99 Rav4.U27
2. Align the retainer on the bottom ofthe window with the groove.
CAUTION
Make sure the retainer on the rear
window is securely inserted into the
groove.
3. Fasten the zippers securely andalign the Velcros to secure the rear
window.INSTALLING THE QUARTER WINDOWS
1. Engage the zipper approximately 25
mm (1.0 in.).