TOYOTA SUPRA 1995 Service Repair Manual

Page 1471 of 2543

JOINT ANGLE INSPECTION AND
ADJUSTMENT
NOTICE: When doing operations which involve the re-
moval and installation of the propeller shaft, always
check the joint. Make adjustments if necessary.
1. STABILIZE PROPELLER SHAFT AND DIFFERENTIAL
(a) Turn the propeller shaft several times by hand to stabilize the
center support bearing and flexible couplings.
(b) Using a jack, raise and lower the differential to stabilize the
differential mounting cushion.
2. CHECK JOINT ANGLE OF NO.2 JOINT AND NO.3 JOINT
(a) Using SST, measure the installation angle of the intermediate
shaft and propeller shaft.
SST 09370±50010
HINT: The SST should be directly underneath the tube.
(b) Using SST, measure the installation angle of the differential.
SST 09370±50010
HINT: Measure the installation angle by placing the SST in
the position, as shown in the illustration.
± PROPELLER SHAFTPROPELLER SHAFTPR±17

Page 1472 of 2543

(c) Calculate the No.2 joint angle.
No.2 joint angle:
A ± B = ±1° 09' + 36'
A: Intermediate shaft installation angle
B: Propeller shaft installation angle
(d) Calculate the No.3 joint angle.
No.3 joint angle:
B ± C = 44' + 36'
B: Propeller shaft installation angle
C: Differential installation angle
If the measured angle is not within the specification, adjust
it with the center support bearing adjusting washer, differen-
tial mount upper stopper and adjusting shim. PR±18
± PROPELLER SHAFTPROPELLER SHAFT

Page 1473 of 2543

 
 
 
 
 
 
Thickness
mm (in.) 
 Remarks
 
 Center supportAdjusting
2.0 (0.079)
4.0 (0.157)  Left and right washers should be the same
thickness.
 
 
Center su ort
bearing
Adjusting
washer
4.0 (0.157)
6.0 (0.236)
8.5 (0.335)
thickness.
 2 washers should not be assembled together.
 Some vehicles are not assembled with washers.
 
DifferentialAdjusting
1.0 (0.039)
1 6 (0 063)
 Left and right washers should be the same thickness
This slim is installed on topof the mount upper stopper 
 
DifferentialAdjusting1.6 (0.063)
2.0 (0.079)
 This slim is installed on top of the mount upper stopper.
and is used for adjustment.
ADJUSTMENT CHART
HOW TO READ THIS CHART
Take measurements, then calculate the No.2 and No 3 joint
angle.
Mark the calculated values on the chart and read the coordi-
nates.
Replace the adjusting washer, shim and mount upper stop-
per in accordance with the coordinates read and adjust the
joint angles.
Example
Measurements (Installation angle):
Intermediate shaft 1° 50'
Propeller shaft 2° 14'
Differential 2° 15'
Joint angle:
NO.2 1° 50' ± 2° 14' = ±24'
NO.3 2° 14' ± 2° 15' = ±1'
Adjustment:
Center support bearing
Standard parts 4 mm ± 2 mm = 2 mm
Use adjusting washers which are 2 mm (0.079 in.)
thicker.
Differential
Use adjusting shims which are 1.6 mm (0.063 in.)
thicker.
± PROPELLER SHAFTPROPELLER SHAFTPR±19

Page 1474 of 2543

HINT:
wMaintain the same thickness for the adjusting washers
and adjusting shims on both the left and right sides.
wIf a washer, stopper and shim of the exact thickness are
not available, use the parts which are nearest in
thickness.
NOTICE: Check the joint angle once again after making
the adjustment. PR±20
± PROPELLER SHAFTPROPELLER SHAFT

Page 1475 of 2543

± PROPELLER SHAFTPROPELLER SHAFTPR±21

Page 1476 of 2543

SERVICE SPECIFICATIONS
SERVICE DATA
 Shaft runout Limit 0.8 mm (0.031 in.)
 Joint angle No.2 joint ±1° 09' + 36' 


No.3 joint
 
 44' +36'
TORQUE SPECIFICATIONS
 Part tightened NVm kgfVcm ftVlbf
 Propeller shaft x Differential 79 805 58
 Propeller shaft x Intermediate shaft (2JZ±GE) 74 750 54 
 Propeller shaft x Transmission (2JZ±GTE)
 
 56
 
 570
 
 41
 Intermediate shaft x Center bearing x Universal joint flange (2JZ±GE)   
 1st 181 1,850 134
 Loosen nut   
 
 2nd
 
 69
 
 700
 
 51
 Center support bearing x Body 49 500 36
 Oxygen sensor x Exhaust front pipe 44 450 34
 Exhaust pipe x Exhaust manifold 58 590 43 Crossmember x Body 13 130 8 
 Heat insulator x Body
 
 5.4
 
 55
 
 48 in.Vlbf
 Adjusting Nut (2JZ±GTE) 50 (69) 515 (700) 37 (51)
 Exhaust pipe support bracket X Transmission 37 380 27
( ): For use without SST PR±22
± PROPELLER SHAFTSERVICE SPECIFICATIONS

Page 1477 of 2543

09205±76030Cylinder Head Setting Bolt
Tightening Adaptor
09268±41045Injection Measuring Tool Set
(09268±41070)No.4 Union
(09268±41090)No.7 Union
(90405±09015)No.1 Union
09268±45012 EFI Fuel Pressure Gauge
ECT sensor
09612±24014 Steering Gear Housing Overhaul
Tool Set
(09617±24011) Steering Rack Wrench
09631±22020 Power Steering Hose Nut
14 x 17 mm Wrench Set
09808±14010Fuel Sender Gauge Tool Assy
09816±30010 Oil Pressure Switch Socket
09842±30070 Wiring ªFº EFI InspectionInjector
Knock sensor
Fuel line flare nut
Fuel pressure pulsation damper
SFI SYSTEM (2JZ±GE)
PREPARATION
SST (SPECIAL SERVICE TOOLS)
± ENGINESFI SYSTEM (2JZ±GE)EG±187

Page 1478 of 2543

09843±18020 Diagnostic Check Wire
09990±01000Engine Control Computer Check
Harness ªAº
RECOMMENDED TOOLS
09082±00050 TOYOTA Electrical Tester Set
09200±00010Engine Adjust Kit
09258±00030 Hose Plug SetPlug for vacuum hose, fuel
hose etc.
EQUIPMENT
 Carburetor cleaner 
 
 Graduated cylinder 
 Injector
 Soft brush 
 Sound scope Injector
 Tachometer 
 Torque wrench 
 
 Vacuum gauge
 
 
COOLANT 
 Item
 
 Capacity
 
 Classification
 
 
Engine coolant (w/ Heater) M/T
A/T 
 
7.3 liters (7.7 US qts, 6.4 lmp. qts)
8.3 liters (8.8 US qts, 7.3 lmp. qts) 
 
Ethylene±glycol base
EG±188± ENGINESFI SYSTEMS (2JZ±GE)

Page 1479 of 2543

PRECAUTION
1. Before working on the fuel system, disconnect the
negative (±) terminal cable from the battery.
HINT: Any diagnostic trouble code retained by the computer
will be erased when the negative (±) terminal cable is discon-
nected.
Therefore, if necessary, read the diagnosis before discon-
necting the negative (±) terminal cable from the battery.
2. Do not smoke or work near an open flame when working
on the fuel system.
3. Keep gasoline away from rubber or leather parts.
MAINTENANCE PRECAUTIONS
1. PRECAUTION WHEN CONNECTING GAUGE
(a) Use ba tte ry as th e po we r so u rce fo r th e timin g lig h t,
tachometer, etc.
(b) Connect the tester probe of a tachometer to the terminal IG
of the DLC1.
2. IN EVENT OF ENGINE MISFIRE, FOLLOWING
PRECAUTIONS SHOULD BE TAKEN
(a) Check proper connection of battery terminals, etc.
(b) Handle high±tension cords carefully.
(c) After repair work, check that the ignition coil terminals and all
other ignition system lines are reconnected securely.
(d) When cleaning the engine compartment, be especially
careful to protect the electrical system from water.
3. PRECAUTIONS WHEN HANDLING OXYGEN SENSOR
(a) Do not allow oxygen sensor to drop or hit against an object.
(b) Do not allow the sensor to come into contact with water.
± ENGINESFI SYSTEM (2JZ±GE)EG±189

Page 1480 of 2543

IF VEHICLE IS EQUIPPED WITH MOBIL
RADIO SYSTEM (HAM, CB, ETC.)
If the vehicle is equipped with a mobile communication sys-
tem, refer to the precaution in the IN section.
AIR INDUCTION SYSTEM
1. Separation of the engine oil dipstick, oil filler cap, PCV hose,
etc. may cause the engine to run out of tune.
2. Disconnection, looseness or cracks in the parts of the air
induction system between the throttle body and cylinder
head will cause air suction and cause the engine to run out
of tune.
ELECTRONIC CONTROL SYSTEM
1. Before removing SFI wiring connectors, terminals, etc., first
disconnect the power by either turning the ignition switch
OFF or disconnecting the negative (±) terminal cable from the
battery.
HINT: Always check the diagnostic trouble code before dis-
connecting the negative (±) terminal cable from the battery.
2. When installing the battery, be especially careful not to
incorrectly connect the positive (+) and negative (±) cables.
3. Do not permit parts to receive a severe impact during removal
or installation. Handle all SFI parts carefully, especially the
ECM.
4. Do not be careless during troubleshooting as there are
numerous transistor circuits and even slight terminal contact
can cause further troubles.
5. Do not open the ECM cover.
6. When inspecting during rainy weather, take care to prevent
entry of water. Also, when washing the engine compartment,
prevent water from getting on the SFI parts and wiring
connectors.
7. Parts should be replaced as an assembly.
8. Care is required when pulling out and inserting wiring
connectors.
(a) Release the lock and pull out the connector, pulling on the
connectors.
(b) Fully insert the connector and check that it is locked. EG±190
± ENGINESFI SYSTEMS (2JZ±GE)

Page:   < prev 1-10 ... 1431-1440 1441-1450 1451-1460 1461-1470 1471-1480 1481-1490 1491-1500 1501-1510 1511-1520 ... 2550 next >