electric VOLVO V60 2012 Owner's Guide

08 Maintenance and service
Lamps
08
320
Pull out the headlamp's locking pins.
Release the headlamp by alternately
tilting and pulling it out.
IMPORTANT
Do not pull the electrical cable, only the con-
nector.
3. (Second illustration)
Detach the headlamp connector by
pressing down the clip with your thumb.
At the same time, guide out the con-
nector with your other hand.
4. Lift out the headlamp and place it on a soft
surface to avoid scratching the lens.
5. Replace the bulb in question.
Securing the headlamp
1. Plug in the connector, a clicking sound
should be heard.
2. Reinstall the headlamp and locking pins.
The short pin is fitted closest to the grille.
Check that they are correctly inserted.
3. Check the lighting.
The headlamp must be mounted and the con-
nector correctly installed before the lighting is
switched on or the remote control key is
inserted into the ignition switch.
Removing the cover
Before starting to replace a bulb, see
page 319.
1. Unscrew the cover's four screws with the
tool (1) in the tool kit, see page 294. They
should not be detached completely.
(3 - 4 turns are sufficient.)
IMPORTANT
Use the tool in the toolkit to remove and
attach this correctly.
2. Slide the cover to one side.
3. Remove the cover.
Reinstall the cover in reverse order.
ProCarManuals.com

08 Maintenance and service
Battery
08
328
Symbols on the battery
Use protective goggles.
Further information in the
owner's manual.
Store the battery out of
the reach of children.
The battery contains cor-
rosive acid.
Avoid sparks and naked
flames.
Risk of explosion.
Must be taken for recy-
cling.
NOTE
An expended battery must be recycled in an
environmentally responsible manner - it
contains lead.
Replacing the main battery
RemovalFirst of all: Take the remote control key from
the ignition switch and wait at least 5 minutes
before any electrical connections are touched
- this is because the car's electrical system
needs to store the necessary information to
control modules.
ProCarManuals.com

08 Maintenance and service
Fuses
08
333 General
All electrical functions and components are
protected by a number of fuses in order to pro-
tect the car's electrical system from damage by
short circuiting or overloading.
If an electrical component or function does not
work, it may be because the component's fuse
was temporarily overloaded and failed. If the
same fuse fails repeatedly then there is a fault
in the circuit. Volvo recommends that you visit
an authorised Volvo workshop for checking.
Changing1. Look in the fuse diagram to locate the fuse.
2. Pull out the fuse and check from the side
to see whether the curved wire has blown.
3. If this is the case, replace it with a new fuse
of the same colour and amperage.
WARNING
Never use a foreign object, or a fuse with an
amperage higher than that specified when
replacing a fuse. This could cause signifi-
cant damage to the electrical system and
possibly lead to fire.
Location, fuse boxes
Central electrical unit locations in a left-hand
drive car. In a right-hand drive car the central
electrical units under the glovebox change
sides.
Engine compartment
, Under the glovebox
Cargo area under the cargo floor
Engine compartment cold zone (only
Start/Stop*)
ProCarManuals.com

08 Maintenance and service
Fuses
08
336* Option/accessory, for more information, see Introduction.
FunctionA
Relay coil, relay, vacuum pump
(5-cyl. petrol)5
Headlamp control5
--
--
--
Internal relay coils5
Auxiliary lamps*20
Horn15
Relay coil, main relay, engine
management system, Engine
control module (5, 6-cyl. petrol)10
Transmission control module15
Compressor A/C (not 5-cyl. die-
sel), Coolant pump (5-cyl. diesel
Start/Stop)15
FunctionA
Relay coil, relay, compressor A/
C (not 5-cyl. diesel), Relay coil,
relay, coolant pump (5-cyl. die-
sel Start/Stop)
Relay coils in central electrical
unit in engine compartment cold
zone Start/Stop5
Actuator solenoid, starter
motorA30
Ignition coils (4-cyl. petrol),
Glow control module (5-cyl. die-
sel)10
Ignition coils (5, 6-cyl. petrol),
Capacitor (6-cyl.)20
Engine control module (petrol)10
Engine control module (diesel)15
FunctionA
Valves (1.6 l petrol), Mass air
flow sensor (1.6 l petrol)
Mass air flow sensor (D4162T),
Control valve, fuel flow
(D4162T)10
Mass air flow sensor (5, 6-cyl.),
Control valves (5-cyl. diesel),
Injectors (5, 6-cyl. petrol),
Engine control module (6-cyl.)15
Compressor A/C (5, 6-cyl.),
Engine valves, Engine control
module (6-cyl.) Solenoids (6-cyl.
without turbo), Actuator motors,
intake manifold (6-cyl. without
turbo), Mass air flow sensor (4-
cyl. 2.0 l petrol), Oil level sensor
(5-cyl. diesel)
Coolant pump (D4162T)10
Lambda-sonds (4-cyl. petrol),
Lambda-sond (diesel), Control
module, radiator roller cover
(manual 5-cyl. 2.0 l diesel)10
EVAP valve (5, 6-cyl. petrol),
Lambda-sonds (5, 6-cyl. petrol)15
ProCarManuals.com

08 Maintenance and service
Fuses
08

* Option/accessory, for more information, see Introduction.341 Cargo area
Positions
FunctionA
Electric parking brake, left30
Electric parking brake, right30
Rear window defroster30
Trailer socket 2*15
FunctionA
--
12 V socket, cargo area15
--
--
FunctionA
--
--
Trailer socket 1*40
--
ProCarManuals.com

08 Maintenance and service
Fuses
08
342* Option/accessory, for more information, see Introduction.
Engine compartment, cold zone - Start/Stop*
Location of fuses for the Start/Stop function.
•Fuses A1 and A2 are of the "MEGA Fuse"
type and must only be replaced by a work-
shop
2.
•Fuses 1-11 are of the "Midi Fuse" type and
must only be replaced by a workshop2.
•Fuse 12 is of the "Mini Fuse" type.
For more information on Start/Stop - see
page 123.
Positions
FunctionA
Main fuse for central electrical
unit in the engine compartment175
FunctionA
Main fuse for central electronic
module (CEM) with fuse box B
under the glovebox, central
electrical unit in passenger
compartment with fuse box A
under the glovebox, central
electrical unit in cargo area175
PTC element, air preheater*100
2An authorised Volvo workshop is recommended.
ProCarManuals.com

350
Type designations................................................................................. 352
Dimensions and weights....................................................................... 354
Engine specifications............................................................................ 358
Engine oil............................................................................................... 359
Fluids and lubricants............................................................................. 361
Fuel....................................................................................................... 363
Wheel and tyres, dimensions and pressure ......................................... 366
Electrical system................................................................................... 369
Type approval....................................................................................... 370
Symbols in the display.......................................................................... 382
ProCarManuals.com

09 Specifications
Electrical system09
* Option/accessory, for more information, see Introduction.369 Electrical system
The car has a voltage-regulated AC alternator.
The electrical system is single-pole and uses
the chassis and engine casing as a conductor.The battery capacity is dependent upon the
equipment level in the vehicle.IMPORTANT
If the battery is replaced, replace it with a
battery of the same cold start capacity and
reserve capacity as the original (see the
decal on the battery).
Battery
EngineVoltage (V)Cold start capacity,
CCA - Cold Cranking Amperes (A)Reserve capacity
(minutes)
Petrol (Ethanol)12520–800100–160
Diesel12700–800135–160
Petrol/Diesel with Start/Stop function12760A135
ABattery type AGM (Absorbed Glass Mat) must be used in cars with the Start/Stop function.
NOTE
•The battery's container size should be
consistent with the original battery's
dimensions.
•The battery's height is different depend-
ing on size.
Eco Start/Stop DRIVe*For information on batteries in cars with
Eco Start/Stop DRIVe, see page 330.
ProCarManuals.com

10 Alphabetical Index
10
387
Battery.............................................327, 369
maintenance....................................... 327
remote control ................................... 250
remote control key/PCC....................... 53
start assistance................................... 116
symbols on the battery....................... 328
warning symbols................................. 328
Bioethanol E85........................................ 275
Blind spot (BLIS)...................................... 211
Blind Spot Information System, BLIS...... 211
Bluetooth
Ÿ
handsfree ........................................... 251
media ................................................. 243
microphone off ..................................253
streaming audio ................................. 243
transfer call to mobile ........................ 253
Bonnet, opening...................................... 312
Brake and clutch fluid..............................317
Brake light.................................................. 90
Brakes...................................................... 131
anti-lock braking system, ABS........... 131
brake light............................................. 90
brake system...................................... 131
electric parking brake......................... 133
Emergency Brake Assistance, EBA ... 131
emergency brake lights........................ 90filling brake fluid.................................. 318
symbols in the combined instrument
panel...................................................132
Bulbs, see Lighting.................................. 319
C
Calls
incoming............................................. 253
operation............................................. 253
Camera sensor................................189, 195
Car care................................................... 344
Car care, leather upholstery.................... 346
Cargo area
cargo cover......................................... 281
lighting.................................................. 92
loading................................................278
mounting points.................................. 279
safety grille.......................................... 281
safety net............................................ 280
Cargo cover............................................. 281
Car upholstery......................................... 346
Car wash.................................................. 344
Catalytic converter................................... 274
recovery..............................................290CD ........................................................... 236
Centre console........................................ 144
Chassis settings......................................170
Checking and topping up the coolant..... 316
Checking the engine oil level................... 313
Children..................................................... 31
child safety locks.................................. 38
child seats and side airbags................. 24
location in the car.................................31
safety.................................................... 31
Child safety locks...................................... 64
Child seat................................................... 31
Child seats................................................. 31
integrated two-stage booster cushion. 36
ISOFIX fixture system for child seats. . . 38
recommended...................................... 33
size classes for child seats with the ISO-
FIX fixture system................................. 38
upper mounting points for child seats. . 42
Cigarette lighter socket............................ 216
City Safety™............................................ 188
Cleaning
automatic car washes......................... 344
car wash............................................. 344
rims..................................................... 345
ProCarManuals.com

10 Alphabetical Index
10
389
Electrical socket......................................217
cargo area........................................... 279
front seat............................................. 217
Electric parking brake.............................. 133
low battery voltage.............................133
releasing automatically....................... 134
releasing manually.............................. 134
Emergency equipment
warning triangle.................................. 302
Emergency puncture repair..................... 305
Emissions of carbon dioxide................... 277
Engine
overheating......................................... 283
starting................................................ 112
Engine block heater................................. 114
fuel-driven........................................... 162
Engine compartment
coolant................................................ 316
oil........................................................ 313
overview.............................................. 313
power steering fluid............................ 318
Engine drag control ................................168
Engine oil.........................................313, 359
adverse driving conditions.................. 359
capacities........................................... 359filter..................................................... 313
oil grade.............................................. 359
Engine specifications............................... 358
Environmental labelling, FSC, owner's
manual.......................................................12
Error messages
Driver Alert Control............................. 201
Lane Departure Warning..................... 203
see Messages and symbols.......135, 183
Error messages in BLIS........................... 213
Error messages in Distance Alert............ 186
Error messages in the Adaptive cruise con-
trol............................................................ 183
ETC, electronic temperature control ....... 156
Expectant mothers, seatbelt...................... 17
External dimensions................................354
F
Fan........................................................... 157
Fault tracing for the camera sensor. 190, 196
First aid equipment.................................. 302
First aid kit .............................................. 302Flexifuel.................................................... 114
adaptation........................................... 115
Fluids, capacities..................................... 361
Fluids and oils.......................................... 361
Fog lamps
rear........................................................ 90
Foot brake............................................... 131
FOUR-C – Active chassis........................170
FSC, environmental labelling..................... 12
Fuel.......................................................... 274
fuel consumption................................ 363
fuel economy...................................... 301
fuel filter.............................................. 276
Fuse box.................................................. 333
glovebox............................................. 338
Fuses.......................................................333
box in cargo area................................ 341
changing............................................. 333
cold zone............................................ 342
general................................................ 333
relay/fuse box in engine compart-
ment.................................................... 334
Start/Stop........................................... 342
Fuse table
fuses in engine compartment............. 335
ProCarManuals.com