gearbox VOLVO V60 2013 Owner's Guide

07 During your journey
Towing and recovery
07
304
Towing
Find out the statutory maximum speed limit for
towing before towing begins.
1. Unlock the steering lock by inserting the
remote control key in the ignition switch
and giving a long press on the START/
STOP ENGINE button - key position II is
activated, see page 78 for more informa-
tion on key positions.
2. The remote control key must remain in the
ignition switch while the car is being towed.
3. Keep the towline taut when the towing
vehicle reduces speed by holding your foot
gently pressed on the brake pedal -
thereby avoiding unnecessary jerking.
4. Be prepared to brake to stop.
WARNING
•Check that the steering lock is unlocked
before towing.
•The remote control key must be in key
position II - in position I all airbags are
deactivated.
•Never remove the remote control key
from the ignition switch when the car is
being towed.
WARNING
The brake servo and power steering do not
work when the engine is switched off - the
brake pedal needs to be depressed
about 5 times more heavily and the steering
is considerably heavier than normal.
Manual gearboxPrior to towing:
–Move gear lever into neutral and release
the parking brake.
Automatic gearbox Geartronic
IMPORTANT
Note that the car must always be towed with
the wheels rolling forward.
•Cars with automatic gearbox must not
be towed at speeds above 80 km/h or
further than 80 km.
Prior to towing:
–
Move the gear selector to position N and
release the parking brake.
Automatic gearbox PowershiftThe model with Powershift transmission
should not be towed as it is dependent on the
engine running in order to receive sufficientlubrication. If towing still has to take place, the
route must be as short as possible and then
with very low speed.
In the event of uncertainty as to whether or not
the car is equipped with Powershift transmis-
sion, this can be verified by checking the des-
ignation on the transmission's label under the
bonnet - see page 370. The designa-
tion ”MPS6” means that it is Powershift – trans-
mission otherwise it is Geartronic automatic
transmission.
IMPORTANT
Avoid towing.
•However, the car can be towed for a
short distance at low speed to move it
from a dangerous position - not further
than 10 km and not faster than
10 km/h. Note that the car must always
be towed with the wheels rolling for-
ward.
•In the event of moving a longer distance
than 10 km, the car must be transported
with the drive wheels raised from the
road - professional recovery is recom-
mended.
Prior to towing:
–
Move the gear selector to position N and
release the parking brake.
ProCarManuals.com

08 Wheels and tyres
Changing wheels
08
* Option/accessory, for more information, see Introduction.315 Removing
Set up the warning triangle, see page 318 if a
wheel must be replaced at a busy location. The
car and jack* must be on a firm horizontal sur-
face.
1. Apply the parking brake and engage
reverse gear, or position P if the car has an
automatic gearbox.
WARNING
Check that the jack is not damaged, that the
threads are thoroughly lubricated and that it
is free from dirt.
NOTE
Volvo recommends only using the jack* that
belongs to the car model in question, which
is indicated on the jack's label.
The label also indicates the jack's maximum
lift capacity at a specified minimum lifting
height.
2. Take out the jack*, wheel wrench* and
removal tool for wheel covers* located
under the cargo floor in the cargo area. If
another jack is selected, see page 328.
3. Place chocks in front of and behind the
wheels which will remain on the ground.Use heavy wooden blocks or large stones
for example.
4. Cars with steel rims have removable wheel
covers. Use the removal tool to hook in and
pull off any full-wheel wheel covers. Alter-
natively, the wheel covers can be pulled
away by hand.
5. Screw together the towing eye with the
wheel wrench* until the stop position as
illustrated below.
IMPORTANT
The towing eye must be screwed into all
threads in the wheel bolt wrench.
6. Loosen the wheel bolts ½-1 turn anticlock-
wise with the wheel wrench.
WARNING
Never position anything between the
ground and the jack, nor between the jack
and the car's jacking point.
7. There are two jacking points on each side
of the car. There is a recess in the plastic
cover at each point. Crank the foot of the
ProCarManuals.com

09 Maintenance and service
Battery 09
348
NOTE
•The higher the current take-off in the car
(extra cooling/heating, etc.) the more
the batteries must be charged =
increased fuel consumption.
•When the capacity of the battery has
fallen below the lowest permissible level
then the Start/Stop function is disen-
gaged.
Temporarily reduced Start/Stop function due
to high current take-off means:
•The engine starts automatically2 without
the driver depressing the clutch pedal
(manual gearbox).
•The engine starts automatically without the
driver lifting his/her foot off the foot brake
pedal (automatic gearbox).
Location of the batteries
A: Left-hand drive car. B: Right-hand drive car. 1.
Battery for starting3 2. Support battery.
The support battery normally requires no more
service than the normal battery that is used for
starting. A workshop should be contacted in
the event of questions or problems - an author-
ised Volvo workshop is recommended.
IMPORTANT
If the following instruction is not observed
then the Start/Stop function may temporar-
ily cease to work after the connection of an
external battery or battery charger:
•The negative battery terminal on the
car's main battery must never be used
for connecting an external battery or
battery charger - only the car chassis
may be used as the grounding point.
See the section "Start assistance" - for a
description of how the cable clamps must
be attached.
2Automatic starting can only take place if the gear lever is in neutral position.3The battery for starting is described in detail on page 345.
ProCarManuals.com

09 Maintenance and service
Fuses 09
354
FunctionA
Coolant pump (1.6 l petrol Start/
Stop, 5-cyl. petrol Start/Stop);
Crankcase ventilation heater (5-
cyl. Petrol); Oil pump automatic
gearbox (5-cyl. petrol Start/
Stop)10
Diesel filter heater20
Control module, radiator roller
cover (5-cyl. petrol)5
Crankcase ventilation heater (5-
cyl. diesel); Oil pump automatic
gearbox (5-cyl. diesel Start/
Stop)10
Glow plugs (diesel)70
Cooling fan (4-cyl., 5-cyl. petrol)60
Cooling fan (6-cyl., 5-cyl. diesel)80
Electro-hydraulic power steer-
ing100
AFor cars with the Start/Stop function this fuse location is
empty - see instead page 359.
ProCarManuals.com

10 Specifications
Type designations
10
371
Knowing the car's type designation, vehicle
identification and engine numbers can facili-
tate all contact with an authorised Volvo dealer
regarding the car and when ordering spare
parts and accessories.
Type designation, vehicle identification
number, maximum permissible weights,
codes for colour and upholstery and type
approval number. The label is visible when
the right rear door is opened.
Label for parking heater.
Engine code and engine serial number.
6-cyl.
4-cyl / 5-cyl
Label for engine oil.
Gearbox type designation and serial num-
ber.
Manual gearbox
Automatic gearbox
Car's identification number. (VIN Vehicle
Identification Number)
Further information on the car is presented in
the registration document.
NOTE
The labels shown in the owner's manual are
not provided as exact reproductions of
those in the car. The purpose is to show
their approximate appearance and location
in the car. The information that applies to
your car in particular is available on the label
in question in your car.
ProCarManuals.com

10 Specifications
Dimensions and weights
10
374
Towing capacity and towball load
EngineEngine codeAGearboxMax. weight braked trailer (kg)Max. towball load (kg)
T3B4164T3Manual, MMT6160075
T3B4164T3Automatic, MPS6160075
T4BB4164TManual, MMT6160075
T4BB4164TAutomatic, MPS6160075
T4CB5204T8Automatic, TF-80SD180090
T4FB4164T2Manual, MMT6160075
T4FB4164T2Automatic, MPS6160075
T5B4204T7Manual, MMT6180090
T5B4204T7Automatic, MPS6180090
T5CB5204T9Automatic, TF-80SC180090
T5CB5254T12Automatic, TF-80SC180090
T6 AWDB6304T4Automatic, TF-80SC180090
D2D4162TManual, MMT6130075
D2D4162TAutomatic, MPS6130075
D3D5204T7Manual, M66160075
D3D5204T7Automatic, TF-80SDE160075
ProCarManuals.com

10 Specifications
Dimensions and weights
10
375
EngineEngine codeAGearboxMax. weight braked trailer (kg)Max. towball load (kg)
D4D5204T3Manual, M66160075
D4D5204T3Automatic, TF-80SCD160075
D4D5204T3Automatic, TF-80SDE160075
D4 AWDD5244T17Automatic, TF-80SC180090
D5D5244T11Manual, M66160075
D5D5244T15Automatic, TF-80SC180090
D5 AWDD5244T15Automatic, TF-80SC180090
AEngine code, component and serial number can be read on the engine, see page 370.BDRIVe for certain markets.COnly certain markets.DWithout Start/Stop.EWith Start/Stop.
Max. weight unbraked trailer (kg)Max. towball load (kg)
75050
ProCarManuals.com

10 Specifications
Engine specifications
10
377
EngineEngine
codeAOutput
(kW/rpm)Output
(hp/rpm)Torque (Nm/
rpm)No. of
cylin-
dersBore
(mm)Stroke
(mm)Swept
volume
(litres)Com-
pression
ratio
D5D5244T11D158/4000215/4000420/1500–3250581.093.152.40016.5:1
D5D5244T15E158/4000215/4000440/1500-3000581.093.152.40016.5:1
AEngine code, component and serial number can be read on the engine, see page 370.BDRIVe for certain markets.COnly certain markets.DManual gearboxEAutomatic gearbox
ProCarManuals.com

10 Specifications
Engine oil
10
380
EngineEngine codeARecommended oil gradeVolume, incl. oil filter
(litres)
T4EB5204T8Oil grade: ACEA A5/B5
Viscosity: SAE 0W–30approx 5.5
T5EB5204T9approx 5.5
T5EB5254T12approx 5.5
AEngine code, component and serial number can be read on the engine, see page 370.BManual gearboxCAutomatic gearboxDDRIVe for certain markets.EOnly certain markets.
For filling engine oil, see page 329.
ProCarManuals.com

10 Specifications
Fluids and lubricants
10

381 Coolant
Prescribed grade: Coolant recommended by
Volvo mixed with 50% water1, see the pack-
aging.
EngineAVolume
(litres)
T5B4204T710.5
D2D4162TD
D2D4162TE11.1
T4BB5204T88.9
T5BB5204T9
T5BB5254T12
T6B6304T4
D4D5204T3
D4 AWDD5244T17
D3D5204T7
D5D5244T15
D5D5244T11
EngineAVolume
(litres)
T3B4164T3D9.2
T4CB4164TD
T4FB4164T2D
T3B4164T3E9.8
T4CB4164TE
T4FB4164T2E
AEngine code, component and serial number can be read on
the engine, see page 370.
BOnly certain markets.CDRIVe for certain markets.DManual gearboxEAutomatic gearbox
1Water quality must fulfil the standard STD 1285.1.
ProCarManuals.com