battery ASTON MARTIN DB AR1 Q 2003 Owners Guide

F - Owner Maintenance
1-F-58
Storing the Car - Recommendations
Note: These recommendations apply to new and pre-owned cars either in
Dealer or customer ownership.
When ever the car is not in use always cover the car with it's fabric cover.
If the vehicle is not to be used for periods up to six months it should be stored
in a dry, well ventilated building.
Drive the car for a sufficient distance to warm the oil in the engine, torque
convertor, transmission and final drive unit; this ensures complete lubrication
of the internal components.
Check the engine coolant level. Top up if necessary with the correct
antifreeze/water solution.
In order to take the weight off the tyres, raise the car with a jack and place
supports under the front and rear suspension.
If the vehicle is not raised from the ground, increase the tyre pressures to 3.4
bar 340 kpa 50 psi. Cover the tyres to exclude any light. Rotate the wheels
1/4 turn every month to avoid tyre flat spots.
The battery should be removed and cleaned. Fully charge the battery on a
trickle charger and recharge once a month.
Once a month
Reconnect the battery and ventilate the storage area. Start and run the
engine until fully warmed up. Check that there are no fluid leaks. Check
and correct the tyre pressures if necessary.
Run the Air Conditioning system to keep the internal parts of the Air
Conditioning system lubricated.

F - Owner Maintenance
1-F-60
Recommissioning After Storage
Provided that the car has been stored in accordance with the recommended
procedure, the following points only should require attention before using
the car on the road.
Check the tyre pressures, inflate if necessary and lower the car to the ground.
Fully charge and refit the battery. Reset the clock and electric windows.
Drain the engine sump and final drive unit, fit a new engine oil filter element,
then refill with the approved oils. Check the coolant level and if necessary
top up with the correct antifreeze/water solution.
Check all fluid levels and top-up as necessary. Fill the fuel tank
Caution: Starting the engine without sufficient lubrication can cause serious engine
damage. Take care to establish engine oil pressure as directed in the following steps
before allowing the engine to start.
Press and hold the accelerator hard to the floor (kickdown switch actuated).
This will temporarily inhibit the fuel injectors during cranking. Turn on the
ignition. Press and hold the starter button to crank the engine until normal
oil pressure is indicated on the oil pressure gauge. Release the starter button
and the accelerator pedal.
Start the engine normally and check that the oil pressure and ignition
warning lights go out as the engine starts indicating correct oil pressure and
battery charging. Raise the bonnet and check for leaks of fuel, oil and
coolant.
Finally, check the operation of all instruments, lights and accessories.

G - Specifications
1-G-2
Body
Two door Roadster with 2+0 seating.
Steel underframe and body panels. Steel front wings, boot lid, sills and front
and rear bumper aprons. Steel doors, bonnet inner, boot inner and rear
quarters. Side impact protection in the doors.
Engine
All alloy, quad overhead cam 48 valve V12. 5935 cc. Compression ratio
10.3:1.
Twin EECV engine management systems with multi-point sequential fuel
injection and 'Coil on Plug' Ignition System.
Fuel 95 RON Unleaded or 98 RON Super Unleaded.
(USA - Premium Unleaded). 2 in-tank fuel pumps.
Emission control 4 Oxygen sensors / three-way catalytic convertors,
Exhaust gas recirculation, Evaporative loss purge
Bore 89.0mm
Stroke 79.5mm
Spark Plugs NGK - PTR6E-13
Spark Plug Gap 1.3 ± 0.1mm
Lubrication system Wet sump pressurised lubrication
Alternator Denso L3BHE 120A
Voltage Regulation 13.8V ±0.5V @ 20°C
Battery Varta 90AH
(Manual) (Automatic)
Max Power 324 kW (435 bhp) 309kW (420 bhp)
@ 6000 rpm @ 6000 rpm
Max Torque 556 Nm (410 lb/ft) 542 Nm (400 lb/ft)

2-A-5
A - Service Schedules
Pre-delivery Inspection (PDI)
Before you receive your DB AR1, it will undergo a comprehensive pre-
delivery inspection at the Dealer's premises to ensure that it meets Aston
Martin's quality standards. The following checks will be made:
Levels and Leaks
Engine oil
Power steering oil
Brake Fluid
Clutch fluid (manual only)
Engine coolant level
Engine coolant specific gravity
Windscreen washer fluid
Fuel system
Gearbox oil/Auto transmission fluid
Rear axle oil - Differential
Battery
Mechanical Functions
Auto transmission
Selection and P & N functions
Manual gear selection
Clutch operation (manual only)
Throttle pedal operation
Parking brake operation
Steering column adjustment and lock
operation
Seat adjuster rails
Bonnet (Hood) release and catch
Door operation and locks
Storage compartments
Rear view mirror
Wheels and Tyres
Road wheel nuts
Tyre pressures
Front wheel tracking
Electrical Checks
Battery condition
Heated windscreen
Windscreen washers
Windscreen wipers
Air-conditioning controls
Gauges and warning lights
Radio/Cassette/CD player
Navigation (where fitted)
All speakers
Electric aerial
Inertia switch
Window mechanisms
Side and headlights (main and dip)
Front fog lights
Rear fog lights (where fitted)
Hazard warning lights
Instrument illumination and dimmer
Air conditioning panel illumination
Auto Trans. PRNDL illumination
Horns
Interior/map lights
Cigar lighter
Seat adjustment - all functions
Door mirror adjustments
Reset clock (if necessary)
Door / boot courtesy lights
Central locking system
Filler flap lock operation
Seat belt operation
Seat belt warning system
Security system / Remote control
Clutch pedal start inhibit
Interrogate DTC codes (not N.
America)
Record battery open-circuit voltage

A - Service Schedules
2-A-8
Mechanical Function Checks
1000mls 7500mls 15000mls
1500km 12000km 24000km
3 months 6 months 12 months
- x x Lubricate all door locks and hinges
- x x Grease all points excluding hubs
x x x Check / adjust all drive belt tensions,
renew if necessary
x x x Lubricate handbrake links and cables
x x x Check handbrake security
- - 30,000 Check condition of handbrake shoes
- x x Inspect brake pad wear and condition of discs
- x x Check and renew wiper blade inserts
if necessary
- - 30000 Renew wiper blades
- - 30000 Clean out engine and A/C radiators
x x x Check condition and operation of all seat belts
x x x Check security of exhaust system mountings
x x x Check brake hoses, pipes and unions
x x x Check power steering pipes and unions for
corrosion and mechanical defects
- - x Check security and condition of fuel hoses
x x x Check cooling system hoses security
and condition
x - - Check air conditioning hoses security
and condition
x x x Check condition and security of steering unit
joints and gaiters
x x x Check security and condition of
suspension fixings
- - x Check tightness of propshaft and driveshaft bolts
x x x Check interior rear view mirror for security and
function
- - x Check the condition of underbody protection
Electrical Function Checks
1000mls 7500mls 15000mls
1500km 12000km 24000km
3 months 6 months 12 months
- - 45,000 ml Renew spark plugs
- - x Check / top-up battery electrolyte
x x x Clean and grease the battery connections

Index
5-A-1
Index
A
ABS Warning Light 1-C-22
Adjustments Before Driving 1-A-7
Air Conditioning System 1-D-2
Defrost 1-D-6
Door Mounted Vents 1-D-4
Face Level Vents 1-D-3
Fan Speed Control 1-D-5
Heating/Cooling 1-D-2
Internal Air Flow 1-D-3
Mode Switch 1-D-6
Temperature Control 1-D-5
Temperature Differential Control 1-D-9
Ventilation 1-D-3
Airbags
Child Seats - Passenger Airbags 1-A-20
Alarm
Key Fob 1-A-3
Locking the DB AR1 1-A-4
The Security System 1-A-3
Turning off the Alarm 1-A-4
Turning on the Alarm 1-A-4
Unlocking the DB AR1 1-A-4
Anti-Lock Braking System (ABS) 1-C-21
Ashtray 1-B-22
Automatic Locking Retractors 1-A-15
B
Battery
Battery Conditioner 1-F-33
Battery Disconnect Switch 1-F-32
Electrical Start from Another Vehicle 1-F-36
Quiescent Battery Drain 1-F-31
The Battery Reconnect Switch 1-F-35
Boot (Trunk) Lock Control 1-E-6
Brake System Warning Light 1-C-22
Brake Warning Indications During Driving 1-C-21
Braking Systems 1-C-19
Bulb and Fuse Replacement 1-F-42

Index
5-A-2
C
Care and Maintenance of Seat Belts 1-F-57
Catalytic Converters 1-C-4
Child Safety Seats
Child Seats and Passenger Airbags 1-A-20, 1-A-21
Warnings 1-A-19
Clock 1-B-17
Column Switchgear
Left Hand Stalk 1-B-12
Right Hand Stalk 1-B-14
Console Mounted Controls 1-B-16
D
Door Edge Lights 1-F-52
Door Locks 1-A-5
Door Sealing 1-A-5
Driving in Wet Conditions 1-C-9
E
Electric Window Reset Procedure 1-F-52
Electrics
Battery 1-F-30
Engine Bay 1-F-6
Engine Coolant Temperature Gauge 1-B-11
Engine Immobiliser 1-A-4
F
Fluid Level Checks 1-F-4
Brake Fluid Reservoir 1-F-11
Clutch Hydraulic Fluid Reservoir 1-F-9
Engine Oil Level 1-F-7
Power Steering Reservoir 1-F-10
Footbrake 1-C-19
Front Indicator Lights / Front Parking Lights 1-F-47
Front Interior Lights 1-F-51
Fuel 1-C-2
Fuel Cut-Off Switch 1-C-8
Fuel Filler Cap 1-C-3
Fuel Filling 1-C-3
Fuel Gauge 1-B-10
Fuse Boxes 1-F-38
Fuse Lists - Right Hand Drive 1-F-39