fuel cap ASTON MARTIN DB AR1 Q 2003 Owners Guide

viii
Maintenance and Servicing
Regular maintenance and servicing is the responsibility of the owner.
Regular routine maintenance helps to prevent unnecessary breakdowns
and inconvenience. Each vehicle is given a full Pre-Delivery Inspection to
ensure that all systems function correctly and that the vehicle meets its
specifications. Failure to carry out maintenance at the recommended
intervals could result in deterioration of vehicle performance and possible
infringement of regulations. Such lack of proper maintenance may also
adversely affect your warranty protection.
Your Aston Martin dealer will arrange for appointments on a distance or time
interval basis to ensure that all routine and corrective maintenance work is
undertaken and recorded in the 'Service Schedules and Service Records'
section of this Owner's Guide.
Location of Components
When reading component descriptions or when
following procedures in this Owner's Guide, the
following convention is adopted for locating items
within the vehicle.
All directions are described as viewed from the
driver's seat. Thus the fuel filler cap indicated on this
diagram will be described as "located at the rear left
side of the vehicle".
DB AR1 Owner's Guide

B - Controls
1-B-10
Instruments
Voltmeter (top left)
Shows the battery voltage when the ignition is turned on and shows the
voltage delivered from the alternator when the engine is running.
Fuel Gauge (bottom left)
The DB AR1 fuel capacity is 82 litres (18 Imp gallons / 21.5 US gallons). The
low fuel warning lamp will illumunate when approximately 20 litres (4.4
imp
gallons / 5.0 US gallons) of fuel remain.
Note: Approximately 7 litres of the total fuel capacity specified above is required
to prime the fuel system and is therefore not usable.
Tachometer (centre left)
Indicates the engine speed in revolutions per minute x 1000.
Trip Meter/External Temperature Digital Display
The tachometer also contains the trip meter/external temperature display.
Trip Meter - The trip meter may be used to record the distance travelled on
individual journeys. Whilst the trip reading is displayed, it may be set to zero
by holding the trip button pressed for more than about two seconds.

C - Driving
1-C-2
Checks Before Driving
Inspect the car to make sure that everything is according to the information
and specifications in this Owner's Guide.
Check the wheels, wheel nuts and tyres.
Check that all windows, mirrors and lights are clear and unobstructed.
Check that the boot and bonnet are closed.
Once you are in the car, check that the doors are closed.
Check that the seat, mirrors and steering wheel adjustments are correct.
Check that all gauges and indicators are reading correctly.
Check that the seat backs are in an upright position.
Check that all occupants have fastened their seat belts.
Fuel
DB AR1 uses 95/98 RON Unleaded Fuel only (USA - Premium Unleaded).
For optimum performance and extended high speed driving, the use of 98
RON fuel is recommended.
Caution: Do not use unleaded petrol containing metal based additives, such as those
based on Manganese (often sold as MMT) and Iron (often sold as Ferrocene). The use
of fuel containing such additives could lead to catalyst failure which is not covered by
the vehicle warranties.
The DB AR1 total fuel capacity is 82 litres (18 Imp gallons / 21.5 US gallons).
Note: Approximately 7 litres of the total fuel capacity specified above is required
to prime the fuel system and is therefore not usable.

C - Driving
1-C-3
Fuel Filler Cap
The fuel filler cap is located on the
left side of the car, to the left of the
boot (trunk) lid. The filler flap is
unlocked automatically upon turning
off the alarm or upon operating the
central locking system by unlocking
either door lock with the ignition
key.
Lift the filler flap. Release the filler
cap by rotating a quarter turn
anticlockwise, then lift off the cap.
WARNINGS: Fuel vapour is highly flammable, toxic and explosive. Always switch
off the ignition before refuelling. Do not overfill the fuel tank. Do not inhale fuel
fumes.
Never carry additional fuel in portable containers. They may leak, explode or
cause a fire, whether full or partially empty.
If you handle fuel improperly, it can ignite or explode and cause injury. Do not
smoke or light a flame while refuelling. Do not use mobile phones at filling
stations.
Do not use the car if there is fuel leakage or a persistent smell of fuel.

G - Specifications
1-G-11
Capacities
Europe UK USA
Engine sump (incl. filter) 11 litres (20.0 pints) (11.5 Qts)
Engine sump (excl. filter) 10 litres (18 pints) (10.3 Qts)
Engine cooling system 14.35 litres (25.25 pints) (15.2 Qts)
Screen washer reservoir 2.8 litres (5.0 pints) (3.2 Qts)
Manual gearbox 4.0 litres (7.0 pints) (4.2 Qts)
Automatic gearbox 12.8 litres (22.5 pints) (13.5 Qts)
Final drive 1.6 litres (2.8 pints) (1.7 Qts)
Fuel tank 82 litres (18 galls) (21.5 galls)
Note: Approximately 7 litres of the total fuel capacity specified above is
required to prime the fuel system and is therefore not usable.

Index
5-A-2
C
Care and Maintenance of Seat Belts 1-F-57
Catalytic Converters 1-C-4
Child Safety Seats
Child Seats and Passenger Airbags 1-A-20, 1-A-21
Warnings 1-A-19
Clock 1-B-17
Column Switchgear
Left Hand Stalk 1-B-12
Right Hand Stalk 1-B-14
Console Mounted Controls 1-B-16
D
Door Edge Lights 1-F-52
Door Locks 1-A-5
Door Sealing 1-A-5
Driving in Wet Conditions 1-C-9
E
Electric Window Reset Procedure 1-F-52
Electrics
Battery 1-F-30
Engine Bay 1-F-6
Engine Coolant Temperature Gauge 1-B-11
Engine Immobiliser 1-A-4
F
Fluid Level Checks 1-F-4
Brake Fluid Reservoir 1-F-11
Clutch Hydraulic Fluid Reservoir 1-F-9
Engine Oil Level 1-F-7
Power Steering Reservoir 1-F-10
Footbrake 1-C-19
Front Indicator Lights / Front Parking Lights 1-F-47
Front Interior Lights 1-F-51
Fuel 1-C-2
Fuel Cut-Off Switch 1-C-8
Fuel Filler Cap 1-C-3
Fuel Filling 1-C-3
Fuel Gauge 1-B-10
Fuse Boxes 1-F-38
Fuse Lists - Right Hand Drive 1-F-39