AUDI A4 1995 B5 / 1.G Suspension Mount ABS User Guide

AUDI A4 1995 B5 / 1.G Suspension Mount ABS User Guide A4 1995 B5 / 1.G AUDI AUDI https://www.carmanualsonline.info/img/6/1154/w960_1154-0.png AUDI A4 1995 B5 / 1.G Suspension Mount ABS User Guide
Trending: ignition, sensor, boot

Page 11 of 20

AUDI A4 1995 B5 / 1.G Suspension Mount ABS User Guide 45-32
      
Installing 
     
- Replace clamping sleeve   page 45
-30
 item - 2 
-. 
     
-  Grease ABS wheel speed sensor all around with 
assembly paste before inserting. Then, press in 
by hand u

Page 12 of 20

AUDI A4 1995 B5 / 1.G Suspension Mount ABS User Guide 45-33
      
ABS wheel speed sensor rotor on FWD rear 
axle, examining   
     
- Raise vehicle.
     
- Remove wheel.
     
-  Pull ABS wheel speed sensor out of wheel 
bearing housing. 
     
-  Exa

Page 13 of 20

AUDI A4 1995 B5 / 1.G Suspension Mount ABS User Guide in order to relieve the stress on the brake 
hose. 
     Do not allow caliper to hang by brake hose.
    
-  Apply light blows with hammer to jaw of special tool in order to slightly 
knock grease cap

Page 14 of 20

AUDI A4 1995 B5 / 1.G Suspension Mount ABS User Guide 45-34
 
    
Installing  -  Press grease cap off hub. 
-  Remove cotter pin   page 45
-30
 , item -11-.
-  Remove castellated lock   page 45
-30
 , item -9-.
-  Remove hex nut   page 45
-30
 , item -8

Page 15 of 20

AUDI A4 1995 B5 / 1.G Suspension Mount ABS User Guide 45-35
 
    
Note:  
Wheel bearing play is correctly set if it is just possible to move the thrust 
washer with a screwdriver by applying finger pressure (without any 
prying).  -  Adjust wheel bearin

Page 16 of 20

AUDI A4 1995 B5 / 1.G Suspension Mount ABS User Guide 45-36
 
  
Rear suspension ABS components for 
AWD models, removing and installing 
 
WARNING! 
 
Do not re-use any fasteners that are worn or 
deformed in normal use. 
 Some fasteners are designed to

Page 17 of 20

AUDI A4 1995 B5 / 1.G Suspension Mount ABS User Guide 45-37
 
  
1 - 
Drive axle with ABS wheel speed sensor 
rotor 
Examine rotor for signs of dirt and damage 
 page 45
-40
 
If the rotor is damaged, replace outer CV 
joint along with rotor   Repair Man

Page 18 of 20

AUDI A4 1995 B5 / 1.G Suspension Mount ABS User Guide 45-38
 
  
WARNING! 
Do not loosen and tighten hex bolt - 6 - unless 
car is standing on its wheels-risk of accident.  5 - 
Wheel bearing housing 
6 - 
Hex bolt 
M14 thread: tighten to 115 Nm (85 ft l

Page 19 of 20

AUDI A4 1995 B5 / 1.G Suspension Mount ABS User Guide 45-39
      
ABS wheel speed sensor on AWD rear axle, 
removing and installing  
     
Removing 
     
-  Switch ignition off.
     
-  Lift rear seat out of its brackets.
    
-  Detach cable holder

Page 20 of 20

AUDI A4 1995 B5 / 1.G Suspension Mount ABS User Guide 45-40
 
    
Installing 
ABS wheel speed sensor rotor on AWD rear axle, examining  
Note: 
 Repair Manual, "Suspension, Wheels, Steering", Repair Group 42
    -  Release ABS wheel speed sensor harness
Page:   < prev 1-10 11-20
Trending: sensor, boot, ignition