engine oil AUDI A4 1996 B5 / 1.G AWM Engine Lubrication System Components Workshop Manual

AUDI A4 1996 B5 / 1.G AWM Engine Lubrication System Components Workshop Manual A4 1996 B5 / 1.G AUDI AUDI https://www.carmanualsonline.info/img/6/939/w960_939-0.png AUDI A4 1996 B5 / 1.G AWM Engine Lubrication System Components Workshop Manual

Page 1 of 35

AUDI A4 1996 B5 / 1.G AWM Engine Lubrication System Components Workshop Manual 17-1
 
     
Lubrication system 
components, removing and 
installing 
     
Note:  
     
If large quantities of metal shavings or particles 
are found in the engine oil when repairing the 
engine, a

Page 15 of 35

AUDI A4 1996 B5 / 1.G AWM Engine Lubrication System Components Workshop Manual 17-15
 
    
CAUTION! 
The hooks and locating pins of the lifting tackle must be secured 
with locking pins -arrows in illustration-.  -  Engage lifting tackle 2024 A in front and rear lifting eyes on

Page 25 of 35

AUDI A4 1996 B5 / 1.G AWM Engine Lubrication System Components Workshop Manual 17-25
      
-  Immediately attach oil pan and tighten bolts in 
described sequence: 
    
Note:    -  Tighten bolts -1 to 18- diagonally to 5 Nm.
  -  Tighten bolts securing oil pan to transmission t

Page 26 of 35

AUDI A4 1996 B5 / 1.G AWM Engine Lubrication System Components Workshop Manual 17-26
 
    
 Repair Manual, Suspension, Wheels, Steering, Repair Group 40
   
Vehicles with automatic transmission: 
 Repair Manual, 5 Spd. Automatic Transmission 01V, Repair Group 37
   
All models:

Page 27 of 35

AUDI A4 1996 B5 / 1.G AWM Engine Lubrication System Components Workshop Manual 17-27
      
Tightening torques  
     
Component  
  
Nm  
Oil pan to cylinder block   M7   15  
  
M10   40  
Oil pan to transmission      45  
Limit stop for torque reaction support on oil 
pan

Page 31 of 35

AUDI A4 1996 B5 / 1.G AWM Engine Lubrication System Components Workshop Manual 17-31
      
Test requirements:  
     
Oil level OK. 
     Engine oil temperature approx. 80 C. 
     
Oil pressure warning lamp -K3- must come 
on when ignition is switched on. 
     In vehicles wit

Page 32 of 35

AUDI A4 1996 B5 / 1.G AWM Engine Lubrication System Components Workshop Manual 17-32
      
-  Connect voltage tester VAG 1527 B to oil 
pressure switch and positive side of battery (+) 
using test leads from VAG 1594 A. 
     
Test lamp should not light up. 
     
-  If test la

Page 33 of 35

AUDI A4 1996 B5 / 1.G AWM Engine Lubrication System Components Workshop Manual 17-33
      
Check oil pressure  
     
-  Disconnect wire from oil pressure switch.
    
If specified values are not attained:  -  Remove oil pressure switch and screw in oil pressure tester VAG 1342

Page 34 of 35

AUDI A4 1996 B5 / 1.G AWM Engine Lubrication System Components Workshop Manual 17-34
      
Engine oil
 
      The engine is filled with a high quality multigrade 
oil at the factory. This oil may be used all year 
round, except in extremely cold climates.  
     
Viscosity grad

Page 35 of 35

AUDI A4 1996 B5 / 1.G AWM Engine Lubrication System Components Workshop Manual 17-35
      
Engine oil level, checking
 
     
Test requirements:  
     
Engine oil temperature at least 60 C 
     
Vehicle must be level (horizontal) 
     Wait a few minutes after switching off e