battery AUDI A4 1998 B5 / 1.G Quattro Fuel Syst

20-98


Note:
Ensure that fuel hoses fit tightly.
Radio operating instructions - Tighten union nut with 3217 wrench.
60 Nm
- Connect wiring and harness connector.
- Connect Battery Ground strap with ignition switched OFF.
- After connecting Battery, input radio anti-theft code
- Run door windows up to stop using electric window lifters.
- Operate all window lifters again for at least 1 second in "closed"
position to activate automatic up/down.
- Set the clock.
Pa
ge 47 of 55 Fuel su
pp
ly system, servicin
g (vehicles with all wheel drive and 1.8 ltr. turbo or 2.8 ltr. en
gine
)
11/18/2002 htt
p://127.0.0.1:8080/audi/servlet/Dis
play?action=Goto&t
yp
e=re
pair&id=AUDI.B5.GE04.20.3

20-101

Sender for fuel gauge -G, removing and
installing


Vehicles with all wheel drive and 1.8 ltr. turbo
or 2.8 ltr. engine
Observe Safety measures Page 20
-1 .
Observe Rules of cleanliness Page 20
-4 .

Removing

CAUTION!

Obtain the radio Anti-theft code from the
customer before disconnecting the Battery
Ground strap.

Note:
Fuel tank must not be filled higher than
1/3 maximum. - Disconnect Battery Ground strap with ignition switched OFF.
- Open fuel tank cover briefly and close again.
- If necessary, drain fuel tank using fuel cart Page 20
-66
.
Fuel supply unit, removing Page 20
-91
.
Pa
ge 50 of 55 Fuel su
pp
ly system, servicin
g (vehicles with all wheel drive and 1.8 ltr. turbo or 2.8 ltr. en
gine
)
11/18/2002 htt
p://127.0.0.1:8080/audi/servlet/Dis
play?action=Goto&t
yp
e=re
pair&id=AUDI.B5.GE04.20.3

20-103

Installing
Installation is performed in reverse order, when
performing, note the following:

- Install sender for fuel gauge in guide on surge
housing outer section and press down until it
engages Page 20
-97
.

- Connect battery Ground strap with ignition
switched OFF.

- After connecting battery, input radio anti-theft
code

Radio operating instructions
- Operate door windows up to the stop using
window switches.

- Operate all window lifters again for at least 1
second in the "closed" position to activate the
automatic up/down.

- Set the clock.
Pa
ge 52 of 55 Fuel su
pp
ly system, servicin
g (vehicles with all wheel drive and 1.8 ltr. turbo or 2.8 ltr. en
gine
)
11/18/2002 htt
p://127.0.0.1:8080/audi/servlet/Dis
play?action=Goto&t
yp
e=re
pair&id=AUDI.B5.GE04.20.3