fuel AUDI Q5 2016 Service Manual

,....,
N
co
er::
co
,...., Gross Axle Weight Rating
The G ross Axle We igh t Rating is the max imum
l oad that can be applied at each axle of the vehi ­
cle ~.& .
Vehicle capacity weight
The vehicle capac ity we ight (max. load) is listed
on the drive r's side 8-p illar.
_& WARNING
- T he ac tual Gross Ax le Weight Ra ting a t the
front and rear axles sho uld not exceed the
permissible weights, and their combination
must not exceed the Gross Ve hicle We ight
Rating.
Dimensions
Leng th i
n (mm)
Width in (mm)
Width (a cross mirro rs) in (mm)
He ight (un loaded)al in (mm)
Technical data
- Exceeding permissible weight ratings can
res ult in vehicle damage, accidents and per­
sonal injury.
(D Note
- The vehi cle capacity weig ht figures apply
when the load is d istributed evenly in the
vehicle (passengers and luggage) . When
transport ing a heavy load in the luggage
compartment, carry the load as near to the
rear axle as possib le so that the veh icle's
hand ling is not impaired .
- Do not exceed the maximum perm iss ible
ax le loads or the maximum gross vehicle
we igh t. Always remember that the veh icle's
han dling will be affe cted by the extra load.
Th erefore, adjust your spee d accordingly.
- Always observe local regulations.
QS /QS hybrid SQS
18 2.6 (4639) 183 .0 (464 7)
74.7 (1898) 75.2 (1911)
8 2.2 ( 2089) 82 .2 (2089)
65.2 (1655) 65 .3 (1658)
a ) T he heig h t of t he ve hicl e de pe nds on th e tir es and the suspen sio n.
When driving up steep ramps, on rough roads,
over curbs, etc . it is important to remember that
some pa rts of your vehicle, such as spo ile rs or ex- haust system components, may be close to the
ground. Be carefu
l not to damage them.
Capacities
QS /SQS QS hybrid
Fuel tank: tota l capacity gal (liters) approx. 19.8 (75) approx . 19 .0 (72)
Windsh ield and h eadlight* quarts (liters) approx . 4 .9 (4 .6) approx . 4 .9 (4 .6)
washer fluid container
277

Tech nical data
Gasoline engines
QS 2.0, 4 cylinder
Maximum output SAE net hp@ rpm 220 @ 4450 -6000
Max imum torq ue SAE net lb-ft@ rpm 259@ 1500 - 4300
Displacement CID (cm
3
) 121.1 (1984)
Engine oil with filter change
1>
Fuel Premium unl ead ed (9 1 A KI) c;, page 212, Fuel
or Bio-ethanol (E85 ) ¢ page 213, Ethanol fuel (Bio-etha-
no[) .
QS 2.0 hybrid, 4 cylinder
Maximum output SAE net hp@ rpm 211 @4300 -6000
Maximum torque SAE net lb-ft@ rpm 258 @ 1500 - 4200
Displacement C
ID (cm
3
) 1 21.1 (1984)
Engine oil with filter change
1
)
Fuel Premium unleaded (91 AKI) , ¢ page 212, Fuel
Electr ic output (short-term)
hp 54
El ectr ic to rque (short-te rm) lb-ft
155
Total output (short-term) hp 245
T otal torq ue (short-term)
lb-ft 354
Battery type Lithium-ion
Battery energy conten t kWh 1.3
QS 3.0, 6 cylinder
Max imum ou tput SA E net hp@ rpm 2
72@ 4780 -6500
Maximum torque SAE net lb-ft@ rpm 295 @2150 -4780
Displacement C
ID (cm
3
) 1 82 .8 (2995)
Engine oil with filter change
1l
Fuel Premium unleaded
(91 AKI) ,
c;, page 212, Fuel
SQS 3.0, 6 cylinder
Maximum ou tpu t SA E ne t hp@ rpm 354@ 6000
-6500
Max imum torq ue SA E net lb-ft@ rpm 347 @4000 -4500
Displacement C
ID (cm
3
) 1 82.8 (2995)
E ngine o il w ith f ilter change
1l
Fuel Premium unleaded
(91 AKI) ,
c;, page 212, Fuel
278

,....,
N
co
er::
co
,...., Diesel engine
QS 3.0 TOI, 6 cylinder
Maximum output SAE net hp@rpnn
Maximum torque SAE net lb-ft@ rpm
Displacement CID (cm
3
)
Engine oil with filter change1>
Fuel U LS D No . 2, c::> page 214, Diesel fuel
ll For specific engine oil capacities, please see
the most current information for the USA at
http:/ /www.audiusa.com/help/maintenance or
for Canada at http:/ /www.audi.ca/ca/brand/ en/
your _aud i/ aud i_services_a nd/Care_and_M a i nte­
n a nce/ schedu le.html or call 800-822-2834.
Techn ical dat a
240@ 3750 -4000
428@ 1750 -2250
181.1 (2967)
279

Consumer information
Consumer information
Warranty coverages
Your Audi is covered by the following warran­
ties:
- New Vehicle Limited Warranty
- Limited Warranty Against Corrosion Perfora-
tion
- Emissions Control System Warranty
- Emissions Performance Warranty
- California Emissions Control Warranty (USA
vehicles only)
- California Emissions Performance Warranty
(USA vehicles only)
Detailed information regarding your warranties
can be found in your
Warranty & Maintenance
booklet .
Operating your vehicle
outside the U.S.A. or
Canada
Government regulati ons in the United States and
Canada require that automobi les meet specific
emission regulations and safety standards.
Therefore, vehicles built for the U.S.A. and Cana ­
da differ from vehicles sold in other countries.
If you plan to take your vehicle outside the conti­
nenta l limits of the United States or Canada,
there is the poss ibility that:
- un leaded fue ls for vehicles with catalytic con­
verter may not be available;
- fuel may have a considerably lower octane rat­
ing . Improper fuel may cause engine damage;
- service may be inadequate due to lack of proper
service facilities, tools or testing equipment;
- r eplacement parts may not be readily available.
- Nav igation systems for veh icles built for the
U.S .A . and Canada will not necessarily work in
Europe, and may not work in other countries
outside of North America.
280
(D Note
Audi cannot be responsib le for mechanical
damage that could result from inadequate
fuel, service or parts ava ilability.
Audi Service Repair
Manuals and Literature
Audi Official Factory Service Manuals and Litera ­
ture are published as soon as poss ible after mod­
el introduction . Service Manuals and literature
are available to order from the Audi Technical Lit ­
erature Ordering Center at :
www.audi.techliterature .com
Maintenance
General '
Your vehicle has been designed to help keep
maintenance requirements to a minimum. How­
ever, a certain amount of regular maintenance is
still necessary to assure your vehicle's safety,
economy and reliability . For detailed vehicle
maintenance consult your Warranty & Mainte­
nance booklet .
Under difficult operating conditions, for exam ­
ple at extremely low outside temperatures, in
very dusty regions, when towing a trailer very fre­
quently, etc., some service work should be per­
formed between the intervals specified. This ap­
plies particularly to:
- oil changes, and
- cleaning or replac ing the a ir filter .
'
@) For the sake of the environment
By regularly maintain ing your vehicle, you
help make sure that em iss ion standards are
maintained, thus minimizing adverse effects
on the environment .
Important considerations for you and your
vehicle
The increasing use of electronics, sophisticated
fuel injection and emission control systems, and
the generally increas ing technica l complexity of ..,_

Consumer inf orm ation
@ For the sake of the env ironment
- Changing the engine settings wi ll adversely
affect emission levels. Th is is detrimental to
the environment and increases fuel con­
sumption.
- A lways observe environmental regu lations
when disposing of old engine o il, used brake
fl ui d, d irty engine coolant, spent batteries
or worn out tires.
- Undeployed airbag modules and pretension­
ers mig ht be classified as Perchlorate Mate­
rial -special handl ing may apply, see
www.dtsc .ca.gov/hazardouswaste/perchlo­
r ate. When the vehicle or parts of the re­
straint system including airbag modu les
safety be lts wi th pretensioners are scrap­
ped, all applicab le laws and regulations
must be observed. Your authorized Audi
dealer is familiar with these requirements
and we recommend that you have your deal­ er perform this service for you.
Accessories and technical changes
Additional accessories and parts replacement
Always consult an authorized Audi dealer before
purchasing accessories.
Your vehicle incorporates the latest safety design
features ensuring a high standard of active and passive safety.
This safety could be comp romised by non-ap­
proved changes to the vehicle . For this reason, if
parts have to be replaced, please observe the fo l­
lowing points when insta lling addit ional accesso­
ries:
Approved Audi accessories and genuine Audi parts are available from author ized Audi dealers.
These dealers also have the necessary facilities,
too ls and trained specialists to install the parts
and accessories properly.
282
A WARNING
-
Using the wrong spare parts or using non-ap-
proved accessories can cause damage to the
vehicle and serious personal injury.
- Use only accessories expressly approved by
Aud i and genuine Audi spare parts
- These parts and accessor ies have been spe­
cially designed to be used on your vehicle.
- Never install accessor ies such as telephone
cradles or beverage holders on airbag covers
or w ith in the airbag deployment zones. Do­
ing so will increase the risk of injury if a ir­
bags are triggered in an accident!
- Before you check anything in the eng ine
compartment, always read and heed all
WARN INGS
Qpage 220.
(D Note
-If items other than genu ine Audi spare
parts, add-on equipment and accessory
items are used or if repair wor k is not per­
formed a ccording to specified methods, this
c an resul t in severe damage to you r vehi­
cle's eng ine and body (such as corrosion)
and adve rsely af fect your vehicle's war ranty.
- I f emergency repai rs must be performed
elsewhere, have the vehicle exam ined by an
authorized A udi dealer as soon as possib le .
- T he manuf acture r ca nnot be held liable for
damage which occurs d ue to failure to com ­
ply with these stipulations.
Technical Modifications '
Our guidelines must be complied with when tech ­
nical modifications are made .
Always consult an a uthorized Audi de aler bef ore
sta rt ing work on any modifica tions.
This will help ensure that vehicle fu nction, per­
fo rmance and safety are not impaired
Q ,& .
Attempting to work on electronic components
and the software used with them can cause mal­
funct io ns. Because of the way elect ronic compo­
nen ts a re interconnected with each othe r, such
malfunc tions c an also have an adverse affect on
othe r systems that are not d irectl y involved. This ..,.

,....,
N
co
er::
co
,...., Automatic driving light control . . . . . . . . . . . 52
Automatic Shift Lock (ASL) . . . . . . . . . . . . . 123
Automatic transmission . . . . . . . . . . . . . . . . 122
Automatic Shift Lock (ASL) . . . . . . . . . . . . 123
Driving .. ... ................... ... . 124
Emergency mode . . . . . . . . . . . . . . . . . . . . 126
Emergency release . . . . . . . . . . . . . . . . . . . 127
Hill descent control . . . . . . . . . . . . . . . . . . 125
Kick-down . . . . . . . . . . . . . . . . . . . . . . . . . . 126
Manual shift program . . . . . . . . . . . . . . . . 126
Removal lock (ignition key) . . . . . . . . . . . . . 84
Selector lever . . . . . . . . . . . . . . . . . . . . . . . 122
Shift padd les . . . . . . . . . . . . . . . . . . . . . . . 126
Automatic wipe/wash system . . . . . . . . . . . . 57
Auto Safety Hotline . . . . . . . . . . . . . . . . . . . 141
AUTO (climate control) . . . . . . . . . . . . . . . . . . 81
Average speed . . . . . . . . . . . . . . . . . . . . . . . . 22
Avoid damaging the vehicle . . . . . . . . . . . . . 198
B
Bass box . . . . . . . . . . . . . . . . . . . . . . . . . . . . 255
Battery . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 229
Battery location inside the luggage compart-
ment .. .. .. .. .. ........... .. .. .. .. . 230
Charge level . . . . . . . . . . . . . . . . . . . . . . . . 195
Charging ... .. .................. 104,231
Ene rgy management . . . . . . . . . . . . . . . . . 195
Important warnings when working on the
battery . . . . . . . . . . . . . . . . . . . . . . . . . . . . 230
Jump starting . . . . . . . . . . . . . . . . . . . . . . . 270
Replacing the battery . . . . . . . . . . . . . . . . 232
Voltage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 33
W inter operation . . . . . . . . . . . . . . . . . . . . 229
Work ing on the battery . . . . . . . . . . . . . . . 230
Before driving . . . . . . . . . . . . . . . . . . . . . . . . 134
Belt tensioners . . . . . . . . . . . . . . . . . . . . . . . 149
Bio-ethanol (Fuel) .............. .. .. .. . 213
Blended gasoline . . . . . . . . . . . . . . . . . . . . . 212
Blow er (climate control) . . . . . . . . . . . . . . . . 81
Boo ster seats . . . . . . . . . . . . . . . . . . . . . . . . 179
Brake fluid
Changing the brake fluid . . . . . . . . . . . . . . 229
Checking the brake flu id level . . . . . . . . . . 228
B rake system
Anti-lock brake system . . . . . . . . . . . . . . . . 17
Brake booster . . . . . . . . . . . . . . . . . . . . . . . 192
Index
Brake fluid . . . . . . . . . . . . . . . . . . . . . . . . . 228
Brake fluid specifications for refill and re­
placement . . . . . . . . . . . . . . . . . . . . . . . . . 229
Brake light defective . . . . . . . . . . . . . . . . . . 32
Brakes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 192
E le ctromechanical parking brake . . . . . . . . 89
Fluid reservoir . . . . . . . . . . . . . . . . . . . . . . 228
Malfunction . . . . . . . . . . . . . . . . . . . . . . . . . 28
Warning/indicator lights . . . . . . . . . . . . . . . 18
Worn brake pads symbol . . . . . . . . . . . . . . . 32
Braking Brake assist . . . . . . . . . . . . . . . . . . . . . . . . 190
Braking guard ... .. .. ............. 106, 112
Messages . . . . . . . . . . . . . . . . . . . . . . . . . . 113
Settings . . . . . . . . . . . . . . . . . . . . . . . . . . . 113
Switching on and
off . . . . . . . . . . . . . . . . . 113
Break-in period Brake pads . . . . . . . . . . . . . . . . . . . . . . . . . 192
Tires . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 197
Brea king in . . . . . . . . . . . . . . . . . . . . . . . . . . 197
New tires . . . . . . . . . . . . . . . . . . . . . . . . . . 241
Breakover angle ... .. .... ...... ... .. .. 201
Bu lbs . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 268
C
California Proposition 65 Warning . . . . . . . 221
Battery specific . . . . . . . . . . . . . . . . . . . . . 231
Capacities . . . . . . . . . . . . . . . . . . . . . . . . . . . 277
AdBlue ............................ 217
Eng ine oil . . . . . . . . . . . . . . . . . . . . . . . . . . 222
Care . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 207
Cargo area
refer to Loading the luggage compart-
ment..... .... .. .. ............... .. 139
Cargo floor . . . . . . . . . . . . . . . . . . . . . . . . . . . 71
Catalytic converter . . . . . . . . . . . . . . . . . . . . 197
Center armrest Adjusting . . . . . . . . . . . . . . . . . . . . . . . . . . . 68
Storage compartment . . . . . . . . . . . . . . . . . 68
C en tral locking . . . . . . . . . . . . . . . . . . . . . . . . 38
Certification . . . . . . . . . . . . . . . . . . . . . . . . . 283
Changing Engine oil . . . . . . . . . . . . . . . . . . . . . . . . . . 225
Ch ecking
Engine coolant level . . . . . . . . . . . . . . . . . . 226
285

,....,
N
co
er::
co
,...., (upholders . . . . . . . . . . . . . . . . . . . . . . . . 74, 76
Heated and cooled . . . . . . . . . . . . . . . . . . . . 7 5
D
Data recorder
Date display 189
12
Daytim e running lights . . . . . . . . . . . . . . . . . 53
Declaration of compliance
Adapt ive cruise control . . . . . . . . . . . . . . . 283
Audi side assist . . . . . . . . . . . . . . . . . . . . . 283
Cell phone package . . . . . . . . . . . . . . . . . . 283
Convenience key . . . . . . . . . . . . . . . . . . . . . 283
E lectronic immobilizer . . . . . . . . . . . . . . . . 283
Homelink unive rsal remote control . . . . . 283
Remote control key . . . . . . . . . . . . . . . . . . 283
Defective light bulb warning . . . . . . . . . . . . . 32
Defrosting (windows) . . . . . . . . . . . . . . . . . . . 82
Determining correct load limit . . . . . . . . . . 248
Diesel fuel . . . . . . . . . . . . . . . . . . . . . . . . . . . 214
Diesel particulate filter . . . . . . . . . . . . . 34, 198
Digital clock . . . . . . . . . . . . . . . . . . . . . . . . . . 12
Digital compass . . . . . . . . . . . . . . . . . . . . . . . 61
Digital speedometer............ .. .. .. .. 21
Dimensions . . . . . . . . . . . . . . . . . . . . . . . . . . 277
Dimming the rearview mirror . . . . . . . . . . . . 60
Doors Child sa fety locks . . . . . . . . . . . . . . . . . . . . . 45
Emergen cy locking . . . . . . . . . . . . . . . . . . . . 42
Driver information system . . . . . . . . . . . . . . . 20
Defective light bulb warning . . . . . . . . . . . . 32
Digita l speedometer . . . . . . . . . . . . . . . . . . 21
Driver information messages . . . . . . . . . . . 27
Indicator lights . . . . . . . . . . . . . . . . . . . . . . 99
Messages . . . . . . . . . . . . . . . . . . . . . . . . . . . 99
Open door or rear lid warning . . . . . . . . . . . 21
Outside temperature display.. .. .. .. .. .. 21
Sound system display . . . . . . . . . . . . . . . . . 20
Driver sea t
refer to Seating position . . . . . . . . . . . . . . 135
Driv er's seat memory
Activating remote control key . . . . . . . . . . . 66
Drive select . . . . . . . . . . . . . . . . . . . . . . . . . . 119
Adapt ive dampers . . . . . . . . . . . . . . . . . . . 119
Dynamic steering . . . . . . . . . . . . . . . . . . . . 119
Setting the driving mode . . . . . . . . . . . . . . 120
Driving economically 198
Index
Driving lights . . . . . . . . . . . . . . . . . . . . . . . . . 52
Driving messages . . . . . . . . . . . . . . . . . . . . . . 27
Driving offroad Driving through water . . . . . . . . . . . . . . . . 202
Driving tips . . . . . . . . . . . . . . . . . . . . . . . . . 201
Rules of behav ior . . . . . . . . . . . . . . . . . . . . 201
Sand and mud 202
Snow-covered ground . . . . . . . . . . . . . . . . 202
Unpaved roads ... .. ............... .. 202
Driving sa fely . . . . . . . . . . . . . . . . . . . . . . . . 134
Driving through water . . . . . . . . . . . . . . . . . 202
Driving time
Duplicate key
Dust filter .
. .. .. .. .................. 22
36
refer to Pollutant filter (climate control) . . 80
Dynamic steering .. .. ............. 119, 190
Indicator light . . . . . . . . . . . . . . . . . . . . . . 194
E
E85 (Fuel) 213
Effici ency program . . . . . . . . . . . . . . . . . . . . . 25
Fuel economy messages . . . . . . . . . . . . . . . 25
Memory levels . . . . . . . . . . . . . . . . . . . . . . . 23
Other equipment . . . . . . . . . . . . . . . . . . . . . 25
E lectrica l accessories
ref er to Socket . . . . . . . . . . . . . . . . . . . . . . . 77
Electrical seat adjustment
refer to Seat adjustment . . . . . . . . . . . . . . . 64
Electromechanical parking brake Emergency braking . . . . . . . . . . . . . . . . . . . 91
Malfunction . . . . . . . . . . . . . . . . . . . . . . . . . 91
Operation . . . . . . . . . . . . . . . . . . . . . . . . . . . 89
Parking . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 90
Releasing and closing . . . . . . . . . . . . . . . . . 89
Starting assist . . . . . . . . . . . . . . . . . . . . . . . 90
Starting from rest . . . . . . . . . . . . . . . . . . . . 90
Starting off with a trai ler............ .. . 90
Warning/indicator lights . . . . . . . . . . . . . . . 18
Electromechanical power assist . . . . . . . . . . 194
Indicator light . . . . . . . . . . . . . . . . . . . . . . 194
Electronic Differential Lock . . . . . . . . . . . . . 190
Electronic differentia l lock (EDL)
Warning/indicator lights . . . . . . . . . . . . 15, 17
Electronic immobilizer . . . . . . . . . . . . . . . . . . 38
Electronic power control
(EPC) warning/indicator light . . . . . . . . . . . 15
287