check engine AUDI TT 1999 8N / 1.G AEB ATW Engines Lubrication System Components Workshop Manual

AUDI TT 1999 8N / 1.G AEB ATW Engines Lubrication System Components Workshop Manual TT 1999 8N / 1.G AUDI AUDI https://www.carmanualsonline.info/img/6/953/w960_953-0.png AUDI TT 1999 8N / 1.G AEB ATW Engines Lubrication System Components Workshop Manual

Page 8 of 33

AUDI TT 1999 8N / 1.G AEB ATW Engines Lubrication System Components Workshop Manual 17-5
 
  
CAUTION! 
Part numbers are listed here for reference only. 
Always check with your Parts department for 
the latest information.  24 - 
Gasket 
Always replace
25 - 
Bolt 10 Nm (7 ft lb)
26 -

Page 18 of 33

AUDI TT 1999 8N / 1.G AEB ATW Engines Lubrication System Components Workshop Manual 17-14
      
-  Using 10-222A engine support bridge spindle, lift 
up engine as far as possible. 
     
Note:  
     Lift engine only as far as possible without over-
stretching or damaging any pipes

Page 24 of 33

AUDI TT 1999 8N / 1.G AEB ATW Engines Lubrication System Components Workshop Manual 17-19
      
-  Install subframe   Repair Manual, Suspension, 
Wheels, Steering,Repair Group 40.      
-  Place torque support on rubber buffer for torque 
support and tighten bolts to 25 Nm (18 ft lb

Page 27 of 33

AUDI TT 1999 8N / 1.G AEB ATW Engines Lubrication System Components Workshop Manual 17-22
      
Oil pressure and oil pressure switch, 
checking
 
     
Function of dynamic oil pressure warning 
system  
     
Warning lamp, checking 
      With engine switched off and ignition on (te

Page 29 of 33

AUDI TT 1999 8N / 1.G AEB ATW Engines Lubrication System Components Workshop Manual 17-23
      
Special tools and equipment  
     
VAG1342 oil pressure tester
     VAG1527B voltage tester
     VAG1594A measuring appliance adapter
     
Test conditions 
     Oil level OK 
     Oil p

Page 30 of 33

AUDI TT 1999 8N / 1.G AEB ATW Engines Lubrication System Components Workshop Manual 17-24
      
Oil pressure switch, checking  
     
-  Disconnect line from oil pressure switch.
    
Note:  
While starting engine, watch pressure tester and LED as oil pressure 
switch may open durin

Page 31 of 33

AUDI TT 1999 8N / 1.G AEB ATW Engines Lubrication System Components Workshop Manual 17-25
      
Oil pressure, checking  
     
-  Disconnect line from oil pressure switch.
    
If specified values are not obtained, the pressure relief valve or the oil 
pump is faulty.  -  Remove oil

Page 33 of 33

AUDI TT 1999 8N / 1.G AEB ATW Engines Lubrication System Components Workshop Manual 17-27
      
Oil level, checking
 
     
Test conditions 
     
Minimum engine oil temperature: 60 C 
(140 F) 
     
Vehicle on level ground 
     After stopping engine, wait a few minutes to 
allow o