BMW 3 SERIES 2006 E90 Service and warranty information

Federal Emissions Performance
Warranty (Valid only in the
U.S.A. and Puerto Rico)
In those states and jurisdictions that have
established periodic vehicle emissions tests
to encourage proper vehicle maintenance and
require the car to pass an emissions test
approved by the U.S. Environmental
Protection Agency and:
1. The car was distributed by BMW of North
America (BMW NA), or sold through the
BMW NA European Delivery Program; and
2. The car has been maintained and
operated in accordance with the instruc-
tions for proper maintenance and use set
forth in the Owner’s Manual supplied with
the car; and
3. The car fails to conform to the applicable
emissions standards of the EPA as judged
by an EPA approved emissions test; and
4. The failure to conform results or will result
in the owner of the car having to bear a
penalty or other sanction (including the
denial of the right to use the car) under
local state or federal law if the non-
conformity is not remedied within a speci-
fied period of time.
Then, in accordance with the provisions of
section 207(b) of the Clean Air Act, BMW NA
warrants that if the car is eligible for coverage
under this warranty, any non-conformities in
the car, which cause it to fail an EPA-
approved emissions test will, without charge
for parts or labor (including diagnosis), be
adjusted, repaired, or replaced, at the option
of BMW NA to proper specifications, in order
to make the car comply with applicable
emissions standards. The decision to adjust,
repair or replace parts is solely the preroga-
tive of BMW NA and must reasonably be
expected to correct the failure of the
warranted part.
This warranty begins on the date of first retail
sale, or the date the vehicle is first placed in
service as a demonstrator or company
vehicle, whichever is earlier. This warranty
continues for a period of 2 years or 24,000
miles, whichever occurs first, except forspecific emissions control components (as
listed on page 38), for which the warranty
period is 8 years or 80,000 miles whichever
occurs first.
This warranty is made subject to the terms
and conditions that apply to the Emission
Control System Warranty and the New
Vehicle Limited Warranty.
No claim under this warranty will be denied
on the basis of use of a properly installed
EPA certified emission part for maintenance
and repair.
A vehicle manufacturer may deny an
emission performance warranty claim on the
basis of an uncertified replacement part used
in the maintenance or repair of a vehicle only
if the vehicle manufacturer presents evidence
that the uncertified replacement part is either
defective in materials or workmanship or not
equivalent from an emission standpoint to the
original equipment part.
Maintenance, replacement, or repair of
emission control devices and systems
may be performed by any automotive
repair establishment or individual using
any certified part.
Immediately after the car has failed an EPA
approved emission short test, your claim can
be made at any authorized BMW center. The
BMW center will honor or deny your claim
within the time period specified by local or
state laws (not to exceed 30 days), to avoid
further penalties or sanctions. lf the claim is
denied, the BMW center will notify you in
writing of the reason(s). The BMW center is
required by law to honor the claim if notice of
denial is not received by the owner within the
specified time period.
You may obtain further information concern-
ing the emission warranties, or report viola-
tions of warranty terms, by contacting the
Director, Field Operations and Support
Division (6406J), Environmental Protection
Agency, 401 “M” Street, SW, Washington,
D.C. 20460.
37
27578 3 Series Text for#72A.qxd 1/31/05 10:30 AM Page 37

The following systems are covered by the
Federal Emission Performance Warranty for a
period of two years or 24,000 miles,
whichever occurs first. The specific systems
may vary according to model, therefore, all of
the systems listed may not be used on your
vehicle. For assistance in determining which
systems and specific components within
these systems apply to your vehicle, please
contact your BMW center.
AIR INDUCTION SYSTEM
FUEL METERING SYSTEM
IGNITION SYSTEM
POSITIVE CRANKCASE VENTILATION
SYSTEM (PCV)
FUEL EVAPORATIVE CONTROL SYSTEM
EXHAUST SYSTEM
ENGINE EMISSION CONTROL SYSTEM
SENSORS/DEVICES
ON BOARD DIAGNOSTIC SYSTEM (OBD)
RELATED PARTS ASSOCIATED WITH THE
ABOVE SYSTEMS
The following components and/or system
are/is covered under the Federal Emission
Warranty for a period of 8 years or 80,000
miles, whichever occurs first.
CATALYTIC CONVERTER
ENGINE CONTROL MODULE (INCLUDING
ON-BOARD DIAGNOSTIC SYSTEM)
For assistance in determining coverage of the
specific components of the on-board diagnos-
tic system, please contact your BMW center.
38
27578 3 Series Text for#72A.qxd 1/31/05 10:30 AM Page 38

California Emission Control
Warranty Statement*
Your Warranty Rights and
Obligations
The California Air Resources Board and
BMW of North America (BMW NA) are
pleased to explain the emission control
system warranty on your 2006 vehicle. In
California, new motor vehicles must be
designed, built and equipped to meet the
State’s stringent anti-smog standards. BMW
NA must warrant the emission control system
on your vehicle for the periods of time listed
below provided there has been no abuse,
neglect or improper maintenance of your
vehicle.
Your emission control system may include
parts such as the fuel injection system, the
ignition system, catalytic converter, and
engine computer. Also included may be
hoses, belts, connectors and other emission-
related assemblies.
Where a warrantable condition exists, BMW
NA will repair your vehicle at no cost to you
including diagnosis, parts and labor.
Manufacturer’s Warranty Coverage:
– For 3 years or 50,000 miles whichever
occurs first:
1. If your vehicle fails a Smog Check inspec-
tion, all necessary repairs and adjustments
will be made by BMW NA to ensure that
your vehicle passes the inspection. This is
your emission control system PERFOR-
MANCE WARRANTY.
2. If any emission-related part on your
vehicle is defective, the part will be
repaired or replaced by BMW NA. This is
your short-term emission control system
DEFECTS WARRANTY.
– For 7 years or 70,000 miles whichever
occurs first:
If an emission-related part specially noted on
page 42 as having coverage for 7 years or
70,000 miles is defective, the part will be
repaired or replaced by BMW NA. This is
your long-term emission control system
DEFECTS WARRANTY.
Owner’s Warranty Responsibilities:
– As the vehicle owner, you are responsible
for the performance of the required
maintenance listed in your Owner’s
Manual. BMW NA recommends that you
retain all receipts covering maintenance on
your vehicle, but BMW NA cannot deny
warranty solely for the lack of receipts or
for your failure to ensure the performance
of all scheduled maintenance.
– You are responsible for presenting your
vehicle to an authorized BMW center as
soon as a problem exists. The warranty
repairs should be completed in a reason-
able amount of time, not to exceed 30
days.
– As the vehicle owner, you should also be
aware that BMW NA may deny your
warranty coverage if your vehicle or part
has failed due to abuse, neglect, improper
maintenance or unapproved modifications.
If you have any questions regarding your
warranty rights and responsibilities, you
should contact:
BMW of North America, LLC
Customer Relations and Services
Department
PO. Box 1227
Westwood, N.J. 07675-1227
Telephone: 1-800-831-1117
Website:
www.bmwusa.com
or the
California Air Resources Board
9528 Telstar Avenue
El Monte, CA 91731
*The California Emissions Control System
Limited Warranty applies to all 2006 U.S.
specification BMW vehicles sold, leased,
and/or registered in California, Maine,
Massachusetts or Vermont.
39
27578 3 Series Text for#72A.qxd 1/31/05 10:30 AM Page 39

California Emission Control
System Limited Warranty*
This warranty applies to California certified
vehicles distributed by BMW of North
America (BMW NA) or sold through the BMW
NA European Delivery Program, registered
and operated primarily in California.
BMW NA warrants to the original purchaser
and each subsequent owner that the vehicle
is:
(a) designed, built and equipped so as to
conform with the applicable California Air
Resources Board emission standards.
(b) free from defects in materials and
workmanship which cause any part that
can affect emissions to fail to conform
with applicable requirements or to fail a
California Smog Check test or EPA
approved short test for a period of 3
years or 50,000 miles, whichever occurs
first.
(c) free from defects in materials and
workmanship in emission related parts,
which are contained in the California
Emission Warranty Parts List on page 42,
for a period of 7 years or 70,000 miles,
whichever occurs first.
This warranty begins on the date of first retail
sale, or the date the vehicle is first placed in
service as a demonstrator or company
vehicle, whichever is earlier.
To obtain service under this warranty, the
vehicle must be brought, upon failure of a
Smog Check test or upon discovery of the
defect, to the workshop of any authorized
BMW center, during normal business hours.
The BMW center will honor or deny your
claim within 30 days. If the claim is denied,
the BMW center will notify you in writing of
the reason(s). The BMW center is required
by law to honor the claim if notice is not given
to the owner within 30 days.
The BMW center will, without charge for parts
or labor (including diagnosis), either adjust,
repair or replace the defective part and other
parts affected by the failure of the warranted
part, if any. If your vehicle failed the California
Smog Check test or an EPA approved shorttest, then BMW NA will repair your vehicle so
that it will pass this test. Items that require
scheduled replacement are warranted up to
the replacement interval specified in the
Service section of this Statement. BMW NA
may repair a part in lieu of replacing it when
performing warranty repairs. Parts for which
replacements are made become the property
of BMW NA. After 3 years or 50,000 miles,
and in accordance with paragraph (c) above,
such repairs are limited to the repair or
replacement of those parts identified in the
California Emissions Warranty List.
If your California registered vehicle is
between 7 and 8 years old and has been
driven less than 80,000 miles, then your
vehicle is eligible for additional warranty
coverage under the Federal Emissions
Warranty.
A repair performed as the result of a smog
check test failure due to a defect in a part,
which is warranted for 7 years/70,000 miles,
is covered.
In all cases, a reasonable time, not to exceed
30 days, must be allowed for a warranty
repair to be completed, after the car is
received by the BMW center.
It is the owner’s responsibility to have all
required maintenance services performed (at
the owner’s expense), as prescribed in the
maintenance schedule for the BMW Emission
Control System. Service intervals are
computed by the service interval indicator
and displayed on the instrument panel.
However, BMW NA will not deny your
warranty repair claims solely because you do
not have maintenance records or you did not
perform the required maintenance unless
BMW NA demonstrates that such lack of
required maintenance is a direct cause of the
emission control system failure. The instruc-
tions for required maintenance and use can
be found in the Owner’s Manual and in the
Service section of this Statement.
*The California Emissions Control System
Limited Warranty applies to all 2006 U.S.
specification BMW vehicles sold, leased,
and/or registered in California, Maine,
Massachusetts or Vermont.
40
27578 3 Series Text for#72A.qxd 1/31/05 10:30 AM Page 40

It is strongly recommended that any replace-
ment parts used for maintenance, repair or
replacement of emission control systems be
genuine BMW Service Parts or BMW
Authorized Remanufactured Parts. Without
invalidating this warranty, the owner may elect
to have maintenance, repair or replacement
of the emission control systems performed by
any automotive repair establishment, or elect
to use parts other than BMW Authorized
Remanufactured or genuine BMW Service
Parts. However, the cost of such service or
parts will not be covered under this warranty,
except in emergency situations. In an
emergency situation, where an authorized
BMW center is not reasonably available or a
warranty replacement part is not available
within 30 days, repairs may be performed at
any available service establishment or by any
individual using any replacement part.
A repair not completed within 30 days consti-
tutes an emergency. BMW NA will reimburse
the owner for such emergency repairs (includ-
ing labor, parts and diagnosis not to exceed
BMW suggested retail price for all warranted
parts replaced and labor charges based on
the manufacturer’s recommended time
allowance for the warranty repair and the
geographically appropriate hourly labor rate)
that are covered under this warranty.
Replaced parts and paid invoices must be
presented to a BMW center as a condition of
reimbursement for emergency repairs not
performed by a BMW center.
The use of replacement parts, which are not
of equivalent quality, may impair the effective-
ness of emission control systems. If other
than genuine BMW Service Parts or
Authorized Remanufactured Parts are used
for maintenance, repair or replacement of
components affecting emission control, the
owner should obtain assurances that such
parts are warranted by their manufacturer to
be equivalent to genuine BMW parts in
performance and durability. BMW NA
assumes no liability under this warranty with
respect to parts other than genuine BMW
parts.
However, the use of non-BMW replacement
parts does not invalidate the warranty on
other components, unless non-BMW partscause damage to warranted parts.
What is not covered
This warranty does not cover malfunctions
caused by any of the following: accident,
flood, misuse, modification, alteration,
tampering, disconnection, improper or inade-
quate maintenance, except if performed by an
authorized BMW center doing warranty repair
work, use of leaded fuel or fuel other than as
specified in the Owner’s Manual.
The replacement of maintenance parts, such
as spark plugs, filters and similar items used
in required maintenance services or the
repair or replacement of maintenance parts
beyond the first replacement interval.
Any car on which the odometer has been
replaced or altered and the true mileage
cannot be determined.
The car, if the vehicle identification number is
altered or cannot be determined, or if the car
has been declared a total loss or sold for
salvage purposes.
General
The warranty gives you specific legal rights,
and you may also have other rights which
vary from state to state.
THE DURATION OF ANY IMPLIED
WARRANTIES, INCLUDING THE IMPLIED
WARRANTY OF MERCHANTABILITY, IS
LIMITED TO THE DURATION OF THE
EXPRESS WARRANTIES HEREIN. BMW
OF NORTH AMERICA HEREBY EXCLUDES
INCIDENTAL AND CONSEQUENTIAL
DAMAGES, INCLUDING LOSS OF TIME,
INCONVENIENCE, OR LOSS OF USE OF
THE VEHICLE, FOR ANY BREACH OF ANY
EXPRESS OR IMPLIED WARRANTY,
INCLUDING THE IMPLIED WARRANTY OF
MERCHANTABILITY, APPLICABLE TO THIS
PRODUCT.
41
27578 3 Series Text for#72A.qxd 1/31/05 10:30 AM Page 41

For assistance in determining which parts are
covered by this warranty, please contact your
authorized BMW center or the BMW NA
Customer Relations Department at 1-800-
831-1117. You may obtain further information
concerning the emissions warranty or report
violations of warranty terms, by contacting Air
Resources Board (ARB), Mobile Source
Operations Division, 9528 Telstar Avenue, El
Monte, CA 91731. Please include the title of
the BMW service department head and
telephone number.
California Emission Warranty
Parts List
The following components are covered for
defects by the California Emission Control
System Limited Warranty for a period of 7
years or 70,000 miles, whichever comes first:
Component 325i/330i
CATALYTIC CONVERTER•
CYLINDER HEAD COVER GASKET•
ENGINE CONTROL MODULE•
EXHAUST MANIFOLD GASKET•
EXHAUST MANIFOLD W/CATALYST•
FUEL PUMP•
FUEL TANK•
INTAKE MANIFOLD•
INTAKE MANIFOLD GASKET•
KNOCK SENSOR•
TRANSMISSION CONTROL MODULE•
VALVETRONIC ACTUATOR•
VALVETRONIC CONTROL UNIT•
VALVETRONIC SENSOR•
VANOS CAMSHAFT POSITIONCONTROLLER•
Notice
The “National Traffic & Motor Vehicle Safety
Act of 1966” requires manufacturers to be in a
position to contact the vehicle owners when a
correction of a product defect becomes
necessary. Please fill in the attached
postcard if you change your address or
purchase a used BMW.
Tire Warranty Statement
Tires are warranted by their respective
manufacturer as detailed in the applicable tire
manufacturer’s warranty statements.
Instructions for proper tire care and mainte-
nance are contained in the Owner’s Manual.
Should you experience difficulty in obtaining
warranty service from a tire manufacturer,
your authorized BMW center will assist you in
resolving the difficulty.
42
27578 3 Series Text for#72A.qxd 1/31/05 10:30 AM Page 42

BMW of North America, LLC
P.O. Box 1227
Westwood, NJ 07675-9868
Attn: Customer Satisfaction
NO POSTAGE
NECESSARY
IF MAILED IN
THE
UNITED STATES
BUSINESS REPLY MAILFIRST CLASS MAIL PERMIT NO. 131 WESTWOOD, NJ
BMW of North America, LLC
P.O. Box 1227
Westwood, NJ 07675-9868
Attn: Customer Satisfaction
NO POSTAGE
NECESSARY
IF MAILED IN
THE
UNITED STATES
BUSINESS REPLY MAILFIRST CLASS MAIL PERMIT NO. 131 WESTWOOD, NJ

Please Check One
❑ADDRESS CHANGE
❑USED CAR PURCHASE
Month Day Year
Date
(the last eight
digits of the VIN)
Model
Chassis Number
Last Name First Name
NumberStreet Apt./Suite
CityStateZip Code
--AM
Telephone--PM
Telephone
--AM
Fax--PM
Fax
Email
Please Check One
❑ADDRESS CHANGE
❑USED CAR PURCHASE
Month Day Year
Date
(the last eight
digits of the VIN)
Model
Chassis Number
Last Name First Name
NumberStreet Apt./Suite
CityStateZip Code
--AM
Telephone--PM
Telephone
--AM
Fax--PM
Fax
Email

©BMW of North America, LLC
Woodcliff Lake, New Jersey 07677
Printed in U.S.A. 02/05
SD 92284
Service and
Warranty
Information
2006
325i, 330i SedansThe Ultimate
Driving Machine®