chain BMW MOTORRAD F 650 GS DAKAR 2003 Rider's Manual (in English)

2
Introduction
12
i
General information and
controls
General view, left side ........... 4
General view, right side ......... 5
Cockpit ................................. 6
Telltale and warning lights ..... 7
Ignition switch and
steering lock ...................... 8-9
Odometer/clock .................. 10
Hazard warning flashers ...... 11
Handlebar fitting ............ 12-13
Seat .................................... 14
Topcase .........................15-16
System case .................. 17-21 Safety check
Checklist ........................ 22-23
Engine oil ....................... 24-25
Fuel ................................ 26-27
Handlebar levers ............ 28-29
Brakes ........................... 30-34
Shock-absorbers ................ 35
Spring preload .................... 36
Drive chain ......................... 37
Loads............................. 38-39
Wheels ........................... 40-42
Coolant .............................. 43
Lights ............................. 44-45
Contents
10R13bkg4.book Seite 2 Montag, 22. September 2003 4:26 16

1
23
Safety check
2
Checklist
For this reason, check the
details in the following sections
before you start the journey:
– Fuel level
– Clutch-lever play
–Brake pressure
– Brake fluid levels (front and rear)
– Operation of the ABS warning
light
–Drive chain
– Shock-absorber setting and
spring preload
– Wheel rim and tyre condition,
spokes, tread depth and tyre
pressures
–Loading
– Coolant level
–Lights – Check regularly (every time
you stop for fuel), on the basis
of the following section:
– Engine oil level
(every second stop for fuel)
– Brake pads
If you encounter any problems
or difficulties, please contact
your BMW motorcycle dealer.
He will provide the necessary
advice and assistance.
10R13bkg4.book Seite 23 Montag, 22. September 2003 4:26 16

1
37
Safety check
2
Drive chain
Checking the chain
e Attention:
Chain tension has an effect on
the rate of wear of the drive
chain and the chain sprocket,
and it also affects travel of the
rear suspension.
Lubricate the chain regularly.
Before riding off, always check
the chain tension and check the
drive chain for damage and
wear.
Always make sure that there is
no load on the motorcycle when
you check the chain.  Place the motorcycle on its
main stand [Dakar: side stand]
– Make sure the ground is level and firm.
 Chain stretch is not uniform, so turn the rear wheel until
you find the point at which the
chain is at its tightest
 When the chain is at its tight-
e s t , p u sh it f u l ly u p a t po s it i o n 1
 Check chain slack: specifica-
tion
A 35...45 mm
(1.38...1.77 inch)
[Dakar: 40...50 mm
(1.57...1.97 inch)],
adjust the drive chain as
necessary (b Maintenance
Instructions)
A
1
10R13bkg4.book Seite 37 Montag, 22. September 2003 4:26 16

ii
78
Indice alfabetico
AABS shutdown button, 6
Adjusting headlight beam throw, 44
Anti-lock brake system (ABS) Check, 65
Notes, 64
Self-diagnosis, 65
Troubleshooting, 65
Anti-lock braking system (ABS) Deactivation, 68
BBrake fluid levelChecking, 32
front brake, 33
Brake system, checking, 30
Brake-fluid level Checking
rear brake, 34
CCatalytic converter, 49Safety instructions, 49
Chain, 37
Checking brake pads, 31, 34
Clock, 6, 10
Clutch lever, 28
Clutch lever play, adjusting, 28
Cockpit, 6
Coolant, 43
Coolant level Check, 43
DDrive chain
Check, 37
EEmergency off (kill) switch for ignition, 13
Engine oil, 25
Engine oil pressure Telltale light, 59
Environmental protection, 73
FFront brake Brake fluid level, 33
Handbrake lever, 29
Fuel Octane number, 27
Fuel filler cap, 26
Fuel level Checking, 26
Fuel tank Capacity, 27
Fuel tank capacity, 59
Fuse box, 5
GGearbox in neutral Telltale light, 7
Gearshifts, 60, 61
General view Left side, 4
Right side, 5
A - G
10R13bkg4.book Seite 78 Montag, 22. September 2003 4:26 16