oil pressure BMW MOTORRAD K 1200 GT 2002 Rider's Manual (in English)

8
General information and controls
1
Telltale and warning lights
1Warning light, coolant tem-
perature
j red (b 40, 67)
2 Warning light, battery
charge current red
r
(b 67)
3 Telltale light, high-beam
headlight blue
q
4 Warning light, engine oil
pressure red
p (b 29, 66) 5
Warning light, fuel level/
when approx. 4 litres
(0.9 gal) left in tank yellow
m
(b 31, 66)
( ) Number in parentheses
bpage number for description
34512
10k41bkg2.book Seite 8 Donnerstag, 24. Juli 2003 9:17 09

22
27
Safety check
2
For this reason, check the
details in the following sections
before you start the journey:
– Fuel level
– Positions of the handlebar levers
–Brakes
–Brake fluid level
– Clutch fluid level
– Coolant level
– Shock-absorber setting and spring preload
– Wheel rim and tyre condition, tread depth and tyre
pressures
– Load, gross weight
–Lights
– Warning lights and indicator lights with ignition switched
on – Check regularly (every time
you stop for fuel), on the basis
of the following section:
– Engine oil level (every sec- ond/third stop for fuel):
– Brake pads
If you encounter any problems
or difficulties, it is always best to
contact your authorised BMW
motorcycle dealer.
He will provide the necessary
advice and assistance.
Checklist
10k41bkg2.book Seite 27 Donnerstag, 24. Juli 2003 9:17 09

22
29
Safety check
2
 Check the oil level at the sight glass:
MAX Top edge
of marking ring
MIN Bottom edge
of marking ring
– The difference between the two marks is approx. 0.5 litre
(0.88 pint)
 If necessary, remove oil filler
plug 3 and top up the engine
oil through oil filler neck 1 ,
using funnel 2
 Reinstall oil filler plug 3
e Attention:
The red warning light
p (b 8)
for engine oil pressure indicates
no (or very little) oil pressure in the
lube-oil system; this light must not
be regarded as an oil level check.
Oil pressure builds up after 1-2
seconds and the warning light
goes out – the red engine oil
pressure warning light
p should
remain off while the engine is
running.
Engine oil
1
BMW recommends Castrol
MAX
MIN
3
2
10k41bkg2.book Seite 29 Donnerstag, 24. Juli 2003 9:17 09

66
Starting – Riding – Parking
3
ABS warning lightThe ABS warning light 1 lights up
if the BMW Integral ABS develops
a fault (
b 79).
Warning light, general General warning light 2 lights up if
the BMW Integral ABS develops a
fault (
b 79), or if the tail light or
brake light is defective.
Low fuel levelWhen warning light 3 comes on,
there are still approximately
4 litres (0.9 gal) of fuel in the tank.
Engine oil pressureWarning light 4 goes out above
idle speed.
*n depending on national-market
specification
e Attention:
If warning light 4 comes on dur-
ing the journey, take the follow-
ing action as soon as traffic
conditions permit:
Declutch
 Operate the kill switch
 Bring the motorcycle safely to
a halt
 Check engine oil level
(
b 28)
Top up with fresh oil if the oil
level is low. If the warning light
for engine oil pressure lights up
even though the oil level is cor-
rect, it is absolutely essential to
consult a specialist workshop,
preferably an authorised BMW
motorcycle dealer.
Warning lights
1*2
43
10k41bkg2.book Seite 66 Donnerstag, 24. Juli 2003 9:17 09

89
Index
i
EEmergency off (kill) switch for ignition, 13
Engine oil, 29
Oil filler neck, 29
Engine oil pressure
telltale light, 66
Engine speed, 68
FFront brake Brake fluid level, 38
Handbrake lever, 33
Fuel Octane number, 31
Fuel filler cap, 4, 30
Fuel gauge, 6
Fuel tank capacity, 66
Fuse box, 4
GGear indicator, 7
Gearshift lever, 19
Gearshifts, 68, 69
General view, Left side, 4
Right side, 5
HHandlebar fitting
Left, 12
Right, 13
Handlebar lever
Handbrake lever, 33 Hazard warning flashers, 9
Headlight basic setting, 53
Headlight switch, 12
Heated handlebar grips, 13
High-beam/low-beam headlight
switch, 12
Horn, 12
Horn push, 12
IIgnition switch and steering lock, 6, 10
Function, 11
Installing system case, 25
Integral brake function, 74
KKeys, 10
LLHD traffic Headlight setting, 51
Lifting handle, 4
Light switch, 13
Lights, 50, 52, 53 Beam throw, 40, 51
Notes, 40
Loading, 47
MMain (centre) stand, 60, 61
Motorcycle accessories, 85
E - M
10k41bkg2.book Seite 89 Donnerstag, 24. Juli 2003 9:17 09

90
Index
i
NNeutral (gearbox), 64
Notes on safetyGeneral, 56
OOctane number, fuel, 31
Odometer, 6
Oil filler neck, 5, 29
Oil levelCheck, 29
Engine oil pressure, 8, 66
Sight glass, 5
Overheating, 57, 65
PPartially integral brakes, 74
Permitted gross weight, 49
Power socket, 4
RRefuelling, 30
Removing system case, 24
RESIDUAL BRAKING FUNCTION, 37, 75
Revolution counter, 6
RHD traffic Headlight setting, 51
Rider’s equipment, 84
Riding, 68
Right flashing turn indicator switch, 13 Rims, 45
Running-in speeds, 62
SSafety check, 26, 27
Safety instructions
Catalytic converter, 57
Safety margin, 73
Seat Adjusting, 20
Installing, 21
Removing, 20
Seat lock, 4
Self-cancelling turn indicators, 12,
13
Self-diagnosis with pull-away test,
76
Sensitive electronic control, 72
Service, 81
Service worldwide, 82
Side stand, 58, 59, 64
Speedometer, 6
Spring preload
Front wheel, 43
Starter button, 13
Starter switch, 13
Starting, 65
Switch on the ignition, 64
System case, 23, 25
N - S
10k41bkg2.book Seite 90 Donnerstag, 24. Juli 2003 9:17 09

91
Index
i
TTank cap, 4
Telltale and warning lightsABS, 7, 66
Battery charge current, 8
Battery charge light, 67
Coolant temperature, 8, 67
Cruise control, 7
Engine oil pressure, 8, 66
High-beam headlight, 8
Low fuel level, 8, 66
Neutral, 7
Turn indicator, right, 7
Telltale lights Turn indicator, left, 7
Toolkit, 4
Tools, 4, 20
Tread depth, tyres, 45, 46
Troubleshooting ABS, 79
Troubleshooting chart, 79
Turn indicator switch, left, 12
Turn-indicator cancel switch, 13
Tyres
Inflation pressure, 46
Running in, 63WWarning lightLow fuel level, 66
Warning lights
ABS, 66
Battery charge light, 67
Coolant temperature, 67
Engine oil pressure, 66
General, 66
Warnings
Braking, 70
T - Z
10k41bkg2.book Seite 91 Donnerstag, 24. Juli 2003 9:17 09