BMW Z4 ROADSTER&COUPE 2005 Service Manual

37
California Emission Control
System Limited Warranty*
This warranty applies to California certified
vehicles distributed by BMW of North America
(BMW NA) or sold through the BMW NA
European Delivery Program, registered and
operated primarily in California.
BMW NA warrants to the original purchaser
and each subsequent owner that the vehicle
is:
(a) designed, built and equipped so as to
conform with the applicable California Air
Resources Board emission standards.
(b) free from defects in materials and workman-
ship which cause any part that can affect
emissions to fail to conform with applicable
requirements or to fail a California Smog
Check test or EPA approved short test for a
period of 3 years or 50,000 miles, which-
ever occurs first.
(c) free from defects in materials and workman-
ship in emission related parts, which are
contained in the California Emission
Warranty Parts List on page 40, for a period
of 7 years or 70,000 miles, whichever
occurs first.
This warranty begins on the date of first retail
sale, or the date the vehicle is first placed in
service as a demonstrator or company vehicle,
whichever is earlier.
To obtain service under this warranty, the
vehicle must be brought, upon failure of a
Smog Check test or upon discovery of the
defect, to the workshop of any authorized
BMW center, during normal business hours.
The BMW center will honor or deny your claim
within 30 days. If the claim is denied, the BMW
center will notify you in writing of the reason(s).
The BMW center is required by law to honor
the claim if notice is not given to the owner
within 30 days.
The BMW center will, without charge for parts
or labor (including diagnosis), either adjust,repair or replace the defective part and other
parts affected by the failure of the warranted
part, if any. If your vehicle failed the California
Smog Check test or an EPA approved short
test, then BMW NA will repair your vehicle so
that it will pass this test. Items that require
scheduled replacement are warranted up to
the replacement interval specified in the
Service section of this Statement. BMW NA
may repair a part in lieu of replacing it when
performing warranty repairs. Parts for which
replacements are made become the property
of BMW NA. After 3 years or 50,000 miles, and
in accordance with paragraph (c) above, such
repairs are limited to the repair or replacement
of those parts identified in the California
Emissions Warranty List.
If your California registered vehicle is between
7 and 8 years old and has been driven less
than 80,000 miles, then your vehicle is eligible
for additional warranty coverage under the
Federal Emissions Warranty.
A repair performed as the result of a smog
check test failure due to a defect in a part,
which is warranted for 7 years/70,000 miles, is
covered.
In all cases, a reasonable time, not to exceed
30 days, must be allowed for a warranty repair
to be completed, after the car is received by
the BMW center.
It is the owner’s responsibility to have all
required maintenance services performed (at
the owner’s expense), as prescribed in the
maintenance schedule for the BMW Emission
Control System. Service intervals are com-
puted by the service interval indicator and
displayed on the instrument panel.
*The California Emissions Control System
Limited Warranty applies to all 2005 U.S.
specification BMW vehicles sold, leased,
and/or registered in California, Maine,
Massachusetts or Vermont.
However, BMW NA will not deny your warranty
repair claims solely because you do not have
maintenance records or you did not perform
the required maintenance unless BMW NA

38 demonstrates that such lack of required
maintenance is a direct cause of the emission
control system failure. The instructions for
required maintenance and use can be found in
the Owner’s Manual and in the Service section
of this Statement.
It is strongly recommended that any replace-
ment parts used for maintenance, repair or
replacement of emission control systems be
genuine BMW Service Parts or BMW
Authorized Remanufactured Parts. Without
invalidating this warranty, the owner may
elect to have maintenance, repair or replace-
ment of the emission control systems
performed by any automotive repair estab-
lishment, or elect to use parts other than
BMW Authorized Remanufactured or
genuine BMW Service Parts. However, the
cost of such service or parts will not be
covered under this warranty, except in
emergency situations. In an emergency
situation, where an authorized BMW center
is not reasonably available or a warranty
replacement part is not available within 30
days, repairs may be performed at any
available service establishment or by any
individual using any replacement part.
A repair not completed within 30 days consti-
tutes an emergency. BMW NA will reimburse
the owner for such emergency repairs
(including labor, parts and diagnosis not to
exceed BMW suggested retail price for all
warranted parts replaced and labor charges
based on the manufacturer’s recommended
time allowance for the warranty repair and the
geographically appropriate hourly labor rate)
that are covered under this warranty. Re-
placed parts and paid invoices must be
presented to a BMW center as a condition of
reimbursement for emergency repairs not
performed by a BMW center.
The use of replacement parts, which are not of
equivalent quality, may impair the effective-
ness of emission control systems. If other than
genuine BMW Service Parts or Authorized
Remanufactured Parts are used for mainte-
nance, repair or replacement of components
affecting emission control, the owner should
obtain assurances that such parts are war-ranted by their manufacturer to be equivalent
to genuine BMW parts in performance and
durability. BMW NA assumes no liability under
this warranty with respect to parts other than
genuine BMW parts.
However, the use of non-BMW replacement
parts does not invalidate the warranty on other
components, unless non-BMW parts cause
damage to warranted parts.
What is not covered
This warranty does not cover malfunctions
caused by any of the following: accident, flood,
misuse, modification, alteration, tampering,
disconnection, improper or inadequate
maintenance, except if performed by an
authorized BMW center doing warranty repair
work, use of leaded fuel or fuel other than as
specified in the Owner’s Manual.
The replacement of maintenance parts, such
as spark plugs, filters and similar items used in
required maintenance services or the repair or
replacement of maintenance parts beyond the
first replacement interval.
Any car on which the odometer has been
replaced or altered and the true mileage
cannot be determined.
The car, if the vehicle identification number is
altered or cannot be determined, or if the car
has been declared a total loss or sold for
salvage purposes.
General
The warranty gives you specific legal rights,
and you may also have other rights which vary
from state to state.
THE DURATION OF ANY IMPLIED WARRAN-
TIES, INCLUDING THE IMPLIED WARRANTY
OF MERCHANTABILITY, IS LIMITED TO THE
DURATION OF THE EXPRESS WARRANTIES
HEREIN. BMW OF NORTH AMERICA
HEREBY EXCLUDES INCIDENTAL AND
CONSEQUENTIAL DAMAGES, INCLUDING
LOSS OF TIME, INCONVENIENCE, OR LOSS
OF USE OF THE VEHICLE, FOR ANY

39 BREACH OF ANY EXPRESS OR IMPLIED
WARRANTY, INCLUDING THE IMPLIED
WARRANTY OF MERCHANTABILITY,
APPLICABLE TO THIS PRODUCT.
For assistance in determining which parts are
covered by this warranty, please contact your
authorized BMW center or the BMW NA
Customer Relations Department at
1-800-831-1117 or through our website:
www.bmwusa.com. You may obtain further
information concerning the emissions warranty
or report violations of warranty terms, by
contacting Air Resources Board (ARB), Mobile
Source Division, 9528 Telstar Avenue, El
Monte, CA 91731. Please include the title of
the BMW service department head and
telephone number.
California Emission Warranty
Parts List
The following components are covered for
defects by the California Emission Control
System Limited Warranty for a period of 7
years or 70,000 miles, whichever comes
first.
COMPONENT Z4
INTAKE AIR COLLECTOR (PLENUM) •
INTAKE MANIFOLD •
THROTTLE BODY AND GASKET •
VANOS CAMSHAFT POSITION CONTROLLER •
ENGINE CONTROL MODULE •
FUEL TANK •
EXHAUST MANIFOLD •
EXHAUST MANIFOLD WITH CATALYST •
THREE WAY CATALYTIC CONVERTER •
TRANSMISSION CONTROL MODULE •
EXHAUST MANIFOLD GASKET •
FUEL PUMP •
TORQUE CONVERTER •

40
Notice
The “National Traffic & Motor Vehicle Safety
Act of 1966” requires manufacturers to be in
a position to contact the vehicle owners
when a correction of a product defect
becomes necessary. Please fill in the
attached postcard if you change your
address or purchase a used BMW.
Tire Warranty Statement
Tires are warranted by their respective
manufacturer as detailed in the applicable tire
manufacturer’s warranty statements.
Instructions for proper tire care and
maintenance are contained in the Owner’s
Manual. Should you experience difficulty in
obtaining warranty service from a tire
manufacturer, your authorized BMW center
will assist you in resolving the difficulty.

Notes

Notes

Notes

Notes

Notes

Notes