engine oil BUICK REGAL 2003 Owner's Guide

Footnotes
†The U.S. Environmental Protection Agency or the
California Air Resources Board has determined that the
failure to perform this maintenance item will not nullify
the emission warranty or limit recall liability prior to
the completion of the vehicle ’s useful life. We, however,
urge that all recommended maintenance services be
performed at the indicated intervals and the
maintenance be recorded.
@Whenever the tires are rotated, the Tire Ination
Monitor System must be reset.
+A good time to check your brakes is during tire
rotation. See Brake System Inspection on page 6-15.
Engine Oil Scheduled Maintenance
Change engine oil and filter as indicated by the
GM Oil Life System (or every 12 months, whichever
occurs first). Reset the system.
Your vehicle has a computer system that lets you know
when to change the engine oil andfilter. This is
based on engine revolutions and engine temperature,
and not on mileage. Based on driving conditions,
the mileage at which an oil change will be indicated can
vary considerably. For the oil life system to work
properly, you must reset the system every time the oil is
changed.When the system has calculated that oil life has been
diminished, it will indicate that an oil change is
necessary. A CHANGE OIL SOON light will come on.
Change your oil as soon as possible within the next two
times you stop for fuel. It is possible that, if you are
driving under the best conditions, the oil life system may
not indicate that an oil change is necessary for over a
year. However, your engine oil andfilter must be
changed at least once a year and at this time the system
must be reset. Your dealer has GM-trained service
people who will perform this work using genuine GM
parts and reset the system.
It is also important to check your oil regularly and keep
it at the proper level.
If the system is ever reset accidentally, you must
change your oil at 3,000 miles (5 000 km) since your
last oil change. Remember to reset the oil life system
whenever the oil is changed. SeeEngine Oil on
page 5-13for information on resetting the system.
An Emission Control Service.
See the mileage intervals following for additional
services that may be performed with an engine oil
change. After the services are performed, record the
date, odometer reading and who performed the service
on the maintenance record pages in Part E of this
schedule.
6-5
2003 - Regal OM

7,500 Miles (12 500 km)
❑Rotate tires. SeeTire Inspection and Rotation on
page 5-59for proper rotation pattern and additional
information.(See footnote @.) (See footnote +.)
15,000 Miles (25 000 km)
❑Inspect engine air cleanerfilter. If necessary, replace
thefilter. If vehicle is driven in dusty/dirty conditions,
inspectfilter at every engine oil change. See
Engine Air Cleaner/Filter on page 5-18for more
information.An Emission Control Service. (See
footnote†.)
❑Replace passenger compartment airfilter. If you
drive regularly under dusty conditions, thefilter
may require replacement more often.
❑Rotate tires. SeeTire Inspection and Rotation on
page 5-59for proper rotation pattern and additional
information.(See footnote @.) (See footnote +.)
22,500 Miles (37 500 km)
❑Rotate tires. SeeTire Inspection and Rotation on
page 5-59for proper rotation pattern and additional
information.(See footnote @.) (See footnote +.)
30,000 Miles (50 000 km)
❑Replace passenger compartment airfilter. If you
drive regularly under dusty conditions, thefilter
may require replacement more often.
❑Rotate tires. SeeTire Inspection and Rotation on
page 5-59for proper rotation pattern and additional
information.(See footnote @.) (See footnote +.)
❑Replace engine air cleanerfilter. SeeEngine Air
Cleaner/Filter on page 5-18for more information.
An Emission Control Service.
❑For supercharged engines only: Check the
supercharger oil level and add the proper
supercharger oil as needed (or every 36 months,
whichever occursfirst). SeePart D: Recommended
Fluids and Lubricants on page 6-16.An Emission
Control Service. (See footnote†.)
37,500 Miles (62 500 km)
❑Rotate tires. SeeTire Inspection and Rotation on
page 5-59for proper rotation pattern and additional
information.(See footnote @.) (See footnote +.)
6-6
2003 - Regal OM

45,000 Miles (75 000 km)
❑Inspect engine air cleanerfilter. If necessary, replace
thefilter. If vehicle is driven in dusty/dirty conditions,
inspectfilter at every engine oil change. See
Engine Air Cleaner/Filter on page 5-18for more
information.An Emission Control Service. (See
footnote†.)
❑Replace passenger compartment airfilter. If you
drive regularly under dusty conditions, thefilter
may require replacement more often.
❑Rotate tires. SeeTire Inspection and Rotation on
page 5-59for proper rotation pattern and additional
information.(See footnote @.) (See footnote +.)
50,000 Miles (83 000 km)
❑Change automatic transaxlefluid andfilter if the
vehicle is mainly driven under one or more of
these conditions:
In heavy city traffic where the outside
temperature regularly reaches 90°F (32°C) or
higher.
In hilly or mountainous terrain.
When doing frequent trailer towing.
Uses such as found in taxi, police or delivery
service.
If you do not use your vehicle under any of these
conditions, change theuid andlter at 100,000 miles
(166 000 km).
52,500 Miles (87 500 km)
❑Rotate tires. SeeTire Inspection and Rotation on
page 5-59for proper rotation pattern and additional
information.(See footnote @.) (See footnote +.)
60,000 Miles (100 000 km)
❑Replace passenger compartment air lter. If you
drive regularly under dusty conditions, the lter
may require replacement more often.
❑For supercharged engines only: Check the
supercharger oil level and add the proper
supercharger oil as needed (or every 36 months,
whichever occurs rst). SeePart D: Recommended
Fluids and Lubricants on page 6-16.An Emission
Control Service. (See footnote†.)
❑Rotate tires. SeeTire Inspection and Rotation on
page 5-59for proper rotation pattern and additional
information.(See footnote @.) (See footnote +.)
❑Replace engine air cleaner lter. SeeEngine Air
Cleaner/Filter on page 5-18for more information.
An Emission Control Service.
67,500 Miles (112 500 km)
❑Rotate tires. SeeTire Inspection and Rotation on
page 5-59for proper rotation pattern and additional
information.(See footnote @.) (See footnote +.)
6-7
2003 - Regal OM

75,000 Miles (125 000 km)
❑Inspect engine air cleanerlter. If necessary, replace
thelter. If vehicle is driven in dusty/dirty conditions,
inspectlter at every engine oil change. See
Engine Air Cleaner/Filter on page 5-18for more
information.An Emission Control Service. (See
footnote†.)
❑Replace passenger compartment airlter. If you
drive regularly under dusty conditions, thelter
may require replacement more often.
❑Rotate tires. SeeTire Inspection and Rotation on
page 5-59for proper rotation pattern and additional
information.(See footnote @.) (See footnote +.)
82,500 Miles (137 500 km)
❑Rotate tires. SeeTire Inspection and Rotation on
page 5-59for proper rotation pattern and additional
information.(See footnote @.) (See footnote +.)
90,000 Miles (150 000 km)
❑Replace passenger compartment airlter. If you
drive regularly under dusty conditions, thelter
may require replacement more often.
❑Replace engine air cleanerlter. SeeEngine Air
Cleaner/Filter on page 5-18for more information.
An Emission Control Service.
❑For supercharged engines only: Check the
supercharger oil level and add the proper
supercharger oil as needed (or every 36 months,
whichever occursrst). SeePart D: Recommended
Fluids and Lubricants on page 6-16.An Emission
Control Service. (See footnote†.)
❑Rotate tires. SeeTire Inspection and Rotation on
page 5-59for proper rotation pattern and additional
information.(See footnote @.) (See footnote +.)
97,500 Miles (162 500 km)
❑Rotate tires. SeeTire Inspection and Rotation on
page 5-59for proper rotation pattern and additional
information.(See footnote @.) (See footnote +.)
6-8
2003 - Regal OM

Part B: Owner Checks and Services
Listed in this part are owner checks and services
which should be performed at the intervals specied to
help ensure the safety, dependability and emission
control performance of your vehicle.
Be sure any necessary repairs are completed at once.
Whenever anyuids or lubricants are added to your
vehicle, make sure they are the proper ones, as shown
in Part D.
At Each Fuel Fill
It is important for you or a service station attendant to
perform these underhood checks at each fuelll.
Engine Oil Level Check
Check the engine oil level and add the proper oil if
necessary. SeeEngine Oil on page 5-13for further
details.
Engine Coolant Level Check
Check the engine coolant level and add DEX-COOL®
coolant mixture if necessary. SeeEngine Coolant
on page 5-22for further details.
Windshield Washer Fluid Level Check
Check the windshield washeruid level in the windshield
washer tank and add the properuid if necessary.
SeeWindshield Washer Fluid on page 5-38for further
details.
At Least Once a Month
Tire Inflation Check
Make sure tires are inated to the correct pressures.
Don’t forget to check your spare tire. SeeTires on
page 5-56for further details.
Cassette Tape Player Service
Clean cassette tape player. Cleaning should be done
every 50 hours of tape play. SeeAudio System(s)
on page 3-44for further details.
6-10
2003 - Regal OM

Part D: Recommended Fluids and
Lubricants
Fluids and lubricants identied below by name, part
number or specication may be obtained from your
dealer.
Usage Fluid/Lubricant
Engine OilEngine oil with the American
Petroleum Institute Certied for
Gasoline Engines starburst symbol
of the proper viscosity. To determine
the preferred viscosity for your
vehicle’s engine, seeEngine Oil on
page 5-13.
Engine Coolant50/50 mixture of clean, drinkable
water and use only
DEX-COOL
®Coolant. SeeEngine
Coolant on page 5-22.
Hydraulic Brake
SystemDelco Supreme 11 Brake Fluid or
equivalent DOT-3 brakeuid.
Windshield
Washer SolventGM Optikleen
®Washer Solvent or
equivalent.
Usage Fluid/Lubricant
Power Steering
SystemGM Power Steering Fluid (GM Part
No. U.S. 1052884, in Canada
993294, or equivalent).
Automatic
TransaxleDEXRON
®-III Automatic
Transmission Fluid.
Key Lock
CylindersMulti-Purpose Lubricant, Superlube
(GM Part No. U.S. 12346241, in
Canada 10953474, or equivalent).
SuperchargerSupercharger Oil (GM Part No. U.S.
12345982, in Canada 10953513).
SeeSupercharger Oil on page 5-18.
Hood Latch
Assembly,
Secondary
Latch, Pivots,
Spring Anchor
and Release
PawlLubriplate Lubricant Aerosol (GM
Part No. U.S. 12346293, in Canada
992723, or equivalent) or lubricant
meeting requirements of NLGI #2,
Category LB or GC-LB.
Hood and Door
HingesMulti-Purpose Lubricant, Superlube
(GM Part No. U.S. 12346241, in
Canada 10953474, or equivalent).
Weatherstrip
ConditioningDielectric Silicone Grease (GM Part
No. U.S. 12345579, in Canada
10953014, or equivalent).
6-16
2003 - Regal OM

Center High-Mounted Stoplamp (CHMSL)...........5-52
Center Passenger Position, Safety Belts.............1-20
Chains, Tires..................................................5-65
Charging System Light....................................3-31
Check
Engine Light...............................................3-35
Checking Coolant............................................5-23
Checking Engine Oil........................................5-13
Checking Things Under the Hood....................... 5-8
Checking Your Restraint Systems......................1-54
Chemical Paint Spotting...................................5-83
Child Restraints
Child Restraint Systems...............................1-32
Infants and Young Children...........................1-29
Lower Anchorages and Top Tethers for
Children (LATCH System)..........................1-38
Older Children.............................................1-27
Securing a Child Restraint Designed for the
LATCH System........................................1-40
Securing a Child Restraint in a Center Rear
Seat Position...........................................1-42
Securing a Child Restraint in a Rear Outside
Seat Position...........................................1-40
Securing a Child Restraint in the Right Front
Seat Position...........................................1-44
Top Strap...................................................1-36
Top Strap Anchor Location............................1-37
Where to Put the Restraint...........................1-35Cigarette Lighter
.............................................3-17
Cleaning
Inside of Your Vehicle
..................................5-78
Outside of Your Vehicle
................................5-80
Underbody Maintenance
...............................5-83
Weatherstrips
..............................................5-80
Cleaning Exterior Lamps/Lenses
.......................5-81
Climate Control System
Air Filter, Passenger Compartment
.................3-24
Dual
..........................................................3-17
Dual Automatic
............................................3-20
Outlet Adjustment
........................................3-24
Compact Disc Messages
..................................3-54
Compact Spare Tire
........................................5-77
Control Buttons
...............................................3-43
Control of a Vehicle
.......................................... 4-5
Convenience Net
............................................2-36
Coolant
Engine Temperature Gage
............................3-34
Engine Temperature Warning Light
.................3-34
Heater, Engine
............................................2-20
Cooling System
..............................................5-28
Cornering Lamps
............................................3-13
Courtesy Lamps
.............................................3-13
Cruise Control
.................................................. 3-8
Cruise Control Light
........................................3-40
3
2003 - Regal OM

E
Electrical System
Add-On Equipment......................................5-86
Fuses and Circuit Breakers...........................5-87
Headlamp Wiring.........................................5-86
Power Windows and Other Power Options......5-86
Windshield Wiper Fuses...............................5-86
Emergency Trunk Release Handle.....................2-13
Emissions Inspection and Maintenance
Programs...................................................3-37
Engine
Air Cleaner/Filter.........................................5-18
Battery.......................................................5-42
Change Engine Oil Light...............................3-39
Check and Service Engine Soon Light............3-35
Compartment Overview................................5-10
Coolant......................................................5-22
Coolant Heater............................................2-20
Coolant Temperature Gage...........................3-34
Coolant Temperature Warning Light................3-34
Cooling System Inspection............................6-15
Exhaust
.....................................................2-29
Oil
.............................................................5-13
Overheating
................................................5-25
Starting
......................................................2-19
Supercharger Oil
.........................................5-18
Engine Coolant Level Check
.............................6-10Engine Cooling When Trailer Towing..................4-41
Engine Oil Additives........................................5-16
Engine Oil Level Check...................................6-10
Entry Lighting.................................................3-13
Express-Down Window....................................2-15
Extender, Safety Belt.......................................1-26
Exterior Lamps...............................................3-10
F
Fabric/Carpet.................................................5-78
Filter
Engine Air Cleaner......................................5-18
Finding a Station....................................3-46, 3-50
Finish Care....................................................5-81
Finish Damage...............................................5-83
Flash-to-Pass................................................... 3-7
Flat Tire........................................................5-66
Flat Tire, Changing.........................................5-66
Fluid
Automatic Transaxle.....................................5-20
Power Steering...........................................5-36
Windshield Washer......................................5-38
FM ...............................................................3-57
Fog Lamps ....................................................3-13
Folding Rear Seat............................................ 1-6
Following Distance..........................................4-39
Footnotes........................................................ 6-5
5
2003 - Regal OM

How to Add Coolant to the Coolant
Recovery Tank............................................5-30
How to Add Coolant to the Radiator..................5-31
How to Add Fluid............................................5-21
How to Check........................................5-20, 5-57
How to Check and Add Oil...............................5-18
How to Check Power Steering Fluid..................5-37
How to Use This Manual...................................... ii
How to Wear Safety Belts Properly...................1-11
Hydroplaning..................................................4-20
I
If No Steam Is Coming From Your Engine..........5-27
If Steam Is Coming From Your Engine...............5-26
If the Light Is Flashing.....................................3-36
If the Light Is On Steady.................................3-37
If You Are Stuck in Sand, Mud, Ice or Snow
.......4-30
If You Do Decide To Pull A Trailer
.....................4-36
If You’re Caught in a Blizzard
...........................4-28
Ignition Positions
.............................................2-18
Ignition Transaxle Lock Check
..........................6-13
Illumination on Remote Activation
........................ 2-7
Infants and Young Children, Restraints
...............1-29
Inflation -- Tire Pressure
..................................5-57Inspection
Brake System.............................................6-15
Engine Cooling System................................6-15
Exhaust System..........................................6-14
Fuel System...............................................6-15
Part C - Periodic Maintenance.......................6-14
Steering, Suspension and Front Drive Axle
Boot and Seal.........................................6-14
Throttle System...........................................6-15
Instrument Panel
Cluster.......................................................3-27
Overview..................................................... 3-2
Instrument Panel Brightness.............................3-13
Instrument Panel Fuse Block............................5-87
Interior Lamps................................................3-13
Interior Plastic Components..............................5-80
J
Jump Starting.................................................5-43
K
Key Lock Cylinders Service..............................6-11
Keyless Entry System....................................... 2-3
Keys............................................................... 2-2
7
2003 - Regal OM

L
Lamps
Exterior......................................................3-10
Interior.......................................................3-13
Lap Belt........................................................1-20
Lap-Shoulder Belt...................................1-12, 1-22
LATCH System
Child Restraints...........................................1-38
Securing a Child Restraint Designed for
the LATCH System...................................1-40
Leather.........................................................5-79
Leaving Your Vehicle.......................................2-11
Leaving Your Vehicle With the Engine Running......2-26
Light
Air Bag Readiness.......................................3-30
Anti-Lock Brake System Warning...................3-32
Brake System Warning.................................3-31
Change Engine Oil......................................3-39
Charging System.........................................3-31
Cruise Control.............................................3-40
Door/Trunk Ajar Warning...............................3-40
Engine Coolant Temperature Warning.............3-34
Low Fuel Warning.......................................3-42
Low Oil Level.............................................3-39Light (cont.)
Low Traction...............................................3-33
Low Washer Fluid Warning...........................3-40
Malfunction Indicator....................................3-35
Oil Pressure...............................................3-38
Safety Belt Reminder...................................3-29
Security.....................................................3-40
Service Vehicle Soon...................................3-41
TCS Warning Light......................................3-33
Tire Pressure..............................................3-35
Traction Control System (TCS) Warning..........3-33
Lighted Visor Vanity Mirrors..............................2-15
Loading Your Vehicle
.......................................4-33
Lockout Protection
..........................................2-11
Locks
Door
........................................................... 2-9
Leaving Your Vehicle
....................................2-11
Lockout Protection
.......................................2-11
Power Door
................................................2-10
Programmable Automatic Door Locks
.............2-10
Loss of Control
...............................................4-15
Low Fuel Warning Light
...................................3-42
Low Traction Light
..........................................3-33
Low Washer Fluid Warning Light
.......................3-40
8
2003 - Regal OM