radio CHEVROLET ASTRO 1996 Owner's Manual

1. Check the other vehicle. It must have a 12-volt
battery with
a negative ground system.
NOTICE:
If the other system isn’t a 12-volt system with a
negative ground, both vehicles can be damaged.
2. Get the vehicles close enough so the jumper cables
can reach, but be sure the vehicles aren’t touching
each other.
If they are, it could cause a ground
connection you don’t want.
You wouldn’t be able to
start your vehicle, and the bad grounding could
damage the electrical systems.
You could be injured
if the vehicles roll. Set the
parking brake firmly on each vehicle. Put an
automatic transmission
in PARK (P) or a manual
transmission in NEUTRAL (N). If you have a
four-wheel-drive vehicle
with a manual transfer case
shift lever, be sure the transfer case
is not in
NEUTRAL (N).
3. Turn off the ignition on both vehicles. Unplug
unnecessary accessories plugged into
the cigarette
lighter or accessory power outlets. Turn off all lamps
that aren’t needed
as well as radios. This will avoid
sparks and help save both batteries.
In addition, it
could save your radio!
I NOTICE:
If you leave your radio on, it could be badly
damaged. The repairs wouldn’t be covered by
your warranty.
4. Open the hoods and locate the batteries. Find the
positive
(+) and negative (-) terminals on
each battery.
5-3

Fuses and Circuit Breakers
The wiring circuits in your vehicle are protected from
short circuits by a combination
of fuses, circuit breakers
and fusible thermal links. This greatly reduces the
chance of fires caused by electrical problems.
Look at the silver-colored band inside the fuse. If the
band is broken or melted, replace the fuse. Be sure you
replace a bad fuse with a new one
of the identical size
and rating.
If you ever have a problem
on the road and don’t have a
spare fuse,
you can borrow one that has the same
amperage. Just pick some feature of your vehicle that
you can get along without -- like the radio or cigarette
lighter
-- and use its fuse, if it is the correct amperage.
Replace it
as soon as you can.
There are two fuse blocks in your vehicle: one
is inside
the vehicle and one
is in the engine compartment.
Instrument Panel Fuse Block
The fuse block is on the lower portion of the instrument
panel on the driver’s side.
You can remove fuses with a fuse extractor.
To remove fuses if you don’t have a fuse extractor, hold
the end of the fuse between your thumb and index finger
and pull straight out.
6-61

15
16
', 17
18
19
Fuse/Circuit Usage Breaker
14 Cluster HVAC Controls, Chime
Module, Radio Illumination, Rear Heat
Switch Illumination, Rear
WiperNasher Switch Illumination,
Rear Liftgate Switch Illumination, Remote Cassette Illumination,
OH Console
DRL Lamps
Front Turn Signals, Rear Turn Signals,
Trailer Turn Signals, Back-up Lamps,
BTSI Solenoid
Radio: ATC (Standby), 2000 Series
(Main Feed), Rear Seat Audio Controls
VCM-Ign 3, VCM- Brake, 4WAL,
Cruise Stepper Motor
Radio: ATC (Main Feed),
2000 Series (Standby)
A
B
Fuse/Circuit Usage
Breaker
20 PRNDLI Odometer, TCC Enable and
PWM Solenoids, Shift
A and Shift B
Solenoids, 3-2 Downshift Solenoids
Not Used
Not Used Rear Wiper, Rear Washer Pump
Not Used
(Circuit Breaker) Power Door Lock,
6-way Power Seat, Keyless Entry
Module, Dutch Door Module, Dutch
Door Release
(Circuit Breaker) Power Windows
21
22
23
24
6-63

Fuse
UPFIT-BATT .......
UPFIT-IGN . .
Spare .....
Fuse Puller*
Spare
.............
Spare .............
ECM-B ............
..
..
HORN ......
A/C COMP ...
RR DEFOG .......
ENG-I ......
IGN-E
..
..
Usage
Upfitter Battery
Power Stud, Trailer Wiring
Harness Upfitter Ignition Relay
Not Used
Not Used Not Used
Fuel Pump Relay,
VCM, Oil Pressure
Switch/Sender
Horn Relay
A/C Enable Relay
Heater-A/C Control Selector Switch
Oxygen Sensors 1-4,
Camshaft Position Sensor,
Mass Air Flow Sensor,
Evaporative Emission
Canister Purge Solenoid
Valve, Linear EGR Valve
Solenoid, VCM
A/C Enable Relay
Fuse
ECM-I ..... .....
LIGHTING .....
BATT I/P .......
IGN A .............
IGN B .............
ABS ..............
AIC ...............
RR HTR/AC ........
Spare .............
Usage
Fuel Injectors 1-6,
Crankshaft Position Sensor,
VCM, Distributor Ignition
Control Module Park Lamps Fuse,
DRL Fuse, Headlamp and
Panel Dimmer Switch
Fuse Block Fuses,
Power Seat CB,
Stop/Hazard Fuse,
Auxiliary Power Fuse,
Cigarette Lighter Fuse,
Radio, Battery Fuse
Starter Relay, Ignition Switch
Ignition Switch
Brake Pressure Module Valve Blower Motor Resistor,
Blower Relay
Auxiliary Heater A/C Relay
Not Used
* A fuse puller is included in the underhood electrical
center. You
will also find spare fuses.
6-65

. .. I. .
Section 9 Index
Accessory'power Outlet ......................... 2-49
Add-on Equipment
............................. 4-28
AirBag
....................................... 1-24
Adding Equipment
............................ 1-30
How Does it Restrain
.......................... 1-28
How it Works
................................ 1-26
Location
.................................... 1-26
Readiness Light
......................... 1.25. 2.54
What Makes it Inflate
.......................... 1-27
What Will
You See After it Inflates .... : .......... 1-28
When Should it Inflate
......................... 1-27
Aircleaner
.................................... 6-19
Air Conditioning
................................ 3-5
Air Conditioning Refrigerants
..................... 6-68
Alignment and Balance. Tire
...................... 6-47
All-Wheel Drive
.......................... 2.21. 6.23
Aluminum Wheels. Cleaning
....................... 6-55
Antenna. Fixed
................................. 3-28
Antifreeze
...................................... 6-25
Anti-Lock
Brake System Warning Light
................ 2-57. 4-6
Brakes
...................................... 4-6
knti-Theft. Radio
.............................. 3-23
Appearance Care
............................... 6-49
Appearance Care Materials
....................... 6-58
Arbitration Program
.............................. 8-7
Servicing
................................... 1-29
Ashtrays
...................................... 2-48
Audio Equipment. Adding
. : ...................... 3-2t
Automatic Audio Systems
.................................. 3-8
Transmission Check
........................... 7-42
Transmission Operation
........................ 2-18
Axle Front
....................................... 6-24
LockingRear
................................ 2-21
Rear
....................................... 6-25
Battery
...................................... 6-35
Jump Starting
................................. 5-2
Replacement. Remote Keyless Entry ............... 2-8
Warnings
...................................... 5-2
BBB Auto Line ................................. 8-7
Better Business Bureau Mediation
................... 8-5
Brake
Adjustment
...................... ........... 6-35
Fluid
..................................... ;.6-32
Master Cylinder
.............................. 6-32
Parking
..................................... 2-21
PedalTravel .................................. 6-32
Replacing System Parts
........................ 6-32
Trailer
...................................... 4-3:
Transmission Shift Interlock Check
............... 7-42
Wear
............................. : ......... 6-3'
9-1

Maintenance When Trailer Towing ............... 4-36
Malfunction Indicator Lamp
...................... 2-58
ManualFrontSeat
............................... 1-1
Manual Lumbar Support .......................... 1-2
Methanol
...................................... 6-4
Mirrors
....................................... 2-38
Convex Outside
.............................. 2-39
Inside Day/Night Rearview
..................... 2-38
Outside
..................................... 2-39
Visor Vanity ................................. 2-49
MMT
......................................... 6-3
ModelReference
................................. vi
Mountain Roads ........ ................ 4-20
Net. Convenience
.............................. 2-46
Neutral
....................................... 2-19
New Vehicle Break-In
........................... 2- I3
Nightvision
................................... 4-13
Odometer
.................................... 2-53
Odometer. Trip
................................. 2-53
Off-Road Recovery
............................. 4- IO
Oil. Engine .................................... 6-11
Opener. Garage Door ............................ 2-43
Outside Mirror
................................. 2-39
Overhead Console
.............................. 2-42
Overheating Engine
............................. 5- I3
Owner Checks and Services
....................... 7-41
Owner Publications. Ordering ...................... 8-9
Paint Spotting. Chemical ........................ 6-57
Park
......................................... 2-18
Shifting Into
................................. 2-22
Shifting Out
of ............................... 2-25
AtNight
.................................... 2-13
Brake ...................................... 2-21
Brake Mechanism Check
....................... 7-44
Lots
....................................... 2-13
Over Things That Burn
......................... 2-25
With
a Trailer ................................ 4-36
Passing
....................................... 4-10
Payload
....................................... 4-28
Periodic Maintenance Inspections
.................. 7-45
Power Accessory Outlet
............................. 2-49
DoorLocks
................................... 2-5
Option Fuses
................................ 6-60
Seat ......................................... 1-3
Steering ..................................... 4-8
Steering Fluid
................................ 6-30
Windows
.................................... 2-27
Pregnancy, Use of Safety Belts
.................... 1-30
Problems on the Road
............................ 5-1
Publications, Service and Owner .................... 8-9
Parking
Radiator
..................................... 5-19
Radiator Pressure Cap ........................... 6-29
Radio Reception
................................ 3-26
Radios
........................................ 3-8
Rain. Driving In ................................ 4-14
Reading
Lamps ................................ 2-38
9-6