coolant CHEVROLET ASTRO 1997 2.G Owner's Manual

Downloaded from www.Manualslib.com manuals search engine Adding Coolant
If you need more coolant, add the proper DEX-COOL@
coolant mixture at the coolant recovery tank.
I
I:
A
Add coolant mix at the recovery tank, but be careful not
to spill it.
'hrning the radiator pressure cap when the
engine and radiator are hot can allow steam and
scalding liquids to blow out and burn you badly.
With the coolant recovery tank,
you will almost
never have to add coolant
at the radiator.
Never turn the radiator pressure cap
-- even a
little -- when the engine and radiator are hot.
I A CAUTION:
You can be burned if you spill coolant on hot
engine parts. Coolant contains ethylene glycol,
and it will burn if the engine parts
are hot
enough. Don't spill coolant on
a hot engine.
6-28

Downloaded from www.Manualslib.com manuals search engine Radiator Pressure Cap
I NOTICE:
~~
Your radiator cap is a 15 psi (105 kPa)
pressure-type cap and must be tightly installed
to prevent coolant loss and possible engine
damage from overheating. Be sure the arrows
on
the cap line up with the overflow tube on the
radiator filler neck.
When you replace your radiator pressure cap, a GM cap
is recommended.
6-29

Downloaded from www.Manualslib.com manuals search engine Thermostat
Engine coolant temperature is controlled by a thermostat
in the engine coolant system. The thermostat stops the
flow
of coolant through the radiator until the coolant
reaches
a preset temperature.
Power Steering Fluid
When to Check Power Steering Fluid
It is not necessary to regularly check power steering
fluid unless you suspect there is
a leak in the system or
you hear an unusual noise. A fluid loss in this system
could indicate a problem. Have the system inspected
and repaired.
How To Check Power Steering Fluid
When the engine compartment is cool, unscrew the cap
and wipe the dipstick
with a clean rag. Replace the cap
and completely tighten it. Then remove the cap again
and look at the fluid level on the dipstick.
The level should be at the
FULL COLD mark. If
necessary, add only enough fluid to bring the level up
to the mark.
What to Use
To determine what kind of fluid to use, see
“Recommended Fluids and Lubricants”
in the Index.
Always use the proper fluid. Failure to use the proper
fluid can cause leaks and damage
hoses and seals.
6-30

Downloaded from www.Manualslib.com manuals search engine I Short Trip/City Maintenance Schedule I
100,000 Miles (166 000 km)
CI Inspect spark plug wires.
An Emission Control Service.
Replace spark plugs.
0 Inspect Positive Crankcase Ventilation
(Pcv) valve.
An Emission Control Service.
An Emission Control Service.
DATE
SERVICED BY: ACTUAL MILEAGE
150,000 Miles (240 000 km)
CI Drain, flush and refill cooling system
(or
every 60 months since last service,
whichever occurs first). See “Engine
Coolant” in the Index for what to use.
Inspect hoses. Clean radiator, condenser,
pressure cap and neck. Pressure test cooling
system and pressure cap.
An Emission Control Service.
DATE ACTUAL MILEAGE
I I
SERVICED BY: I
I
7-29

Downloaded from www.Manualslib.com manuals search engine 100,000 Miles (I66 000 km)
0 Inspect spark plug wires.
0 Replace spark plugs.
0 Inspect. Positive Crankcase Ventilation
(Pcv) valve. An Emission Control Sewice.
An Emission Control Service.
An Emission
Control Service.
.
DATE ACTUAL MILEAGE SERVICED BY:
-
150,000 Miles (240 000 km)
0 Drain, flush and refill cooling system
(or every
60 months since last service,
whichever occurs first). See “Engine
Coolant” in the Index for what
to use.
Inspect hoses. Clean radiator, condenser,
pressure cap and neck. Pressure test the
cooling system and pressure cap.
An Emission Control Service.
DATE
I
ACTUAL MILEAGE SERVICED BY

Downloaded from www.Manualslib.com manuals search engine Part B: Owner Checks and Services
Listed below are owner checks and services which should be performed at the intervals specified to help
ensure the safety, dependability and emission control
performance of your vehicle.
Be sure any necessary repairs are completed at once.
Whenever any fluids or lubricants are added to your
vehicle, make sure they are the proper ones,
as shown
in
Part D.
At Each Fuel Fill
It is important for you or a service station attendant to
per&orm these underhood checks at each fuel
fill.
Engine Oil Level Check
Check the engine oil level and add the proper oil if
necessary. See “Engine Oil” in the Index for
further details.
Engine Coolant Level Check
Check the engine coolant level and add DEX-COOL@
coolant mix if necessary. See “Engine Coolant” in the
Index for further details.
Windshield Washer Fluid Level Check
Check the windshield washer fluid level in the
windshield washer tank and add the proper fluid if
necessary. See “Windshield Washer Fluid” in the Index
for further details.
At Least Once a Month
Tire Inflation Check
Make sure tires are inflated to the correct pressures. See
“Tires” in the Index for further details.
Cassette Deck Service
Clean cassette deck. Cleaning should be done every
50 hours of tape play. See “Audio Systems’’ in the Index
for further details.
7-43

Downloaded from www.Manualslib.com manuals search engine !‘ Part D: Recommended Fluids
and Lubricants
NOTE: Fluids and lubricants identified below by name, part number or specification may be obtained from your
GM dealer.
I USAGE
Engine Coolant
Coolant Supplement
Sealer
FLUIDLUBRICANT
Engine oil with the American
Petroleum Institute Certified For
Gasoline Engines “Starburst”
symbol of the proper viscosity.
To
determine the preferred viscosity
for your vehicle’s engine, see
“Engine Oil” in the Index.
50/50 mixture of clean water
(preferably distilled) and GM
Goodwrench@ DEX-COOL
or
Havoline@ DEX-COOL TM
(silicate-free) antifreeze. See
“Engine Coolant’’ in the Index.
GM Part No. 3634621 or
equivalent with a complete flush
and refill.
-_
USAGE
Delco Supreme 11 @ Brake Fluid Hydraulic Brake
FLUIDLUBRICANT
(GM Part No. 12377967 or System equivalent DOT-3 brake fluid).
Parking Brake Chassis lubricant (GM
Part
Cable Guides No. 1052497 or equivalent) or
lubricant meeting requirements
of NLGI
# 2, Category LB
or GC-LB.
Power Steering
GM Power Steering Fluid
System (GM
Part No. 1052884 - 1 pint,
Automatic DEXRON@-I11 Automatic
Transmission Transmission Fluid.
Key
Lock Multi-Purpose lubricant, Superlube@
Cylinders
(GM Part No. 12346241
or equivalent).
1050017
- 1 quart, or equivalent).
Chassis Chassis lubricant
(GM Part
Lubrication No. 1052497 or equivalent)
or
lubricant meeting requirements
of NLGI # 2, Category LB
or GC-LB.
7-49

Downloaded from www.Manualslib.com manuals search engine Brakes. Anti-Lock ............................... 4-7
Braking
........................................ 4-6
Braking in Emergencies
........................... 4-9
Break.In. New Vehicle
.......................... 2- 15
BTSICheck
................................... 7-45
Bulb Replacement
.............................. 6-36
Built-in Child Restraint
.......................... 1-44
Canadian Roadside Assistance
.................... 8-7
Capacities and Specifications
...................... 6-67
Carbon Monoxide
..... 2.27.2.28.2.30.4.27.4.34. 4.35
Care
of Your Cassette Tape Player .................. 3-29
Cassette Deck Service
........................... 7-43
Cassette Tape Player
....................... 3- 11. 3. 13
Cassette Tape Player Care
........................ 3-29
Center Passenger Position
........................ 1-39
Certificatioflire Label
.......................... 4-28
Chains. Safety
................................. 4-34
Chains. Tire
................................... 6-50
Changing a Flat Tire ............................. 5-23
Charging System Light
.......................... 2-6 1
Check Gages Light
.............................. 2-68
Checking Your Restraint Systems
.................. 1-65
Chemical Paint Spotting
.......................... 6-58
Child Restraints
................. 1.41. 1.42. 1.43. 1-53
Cleaning
.................................... 6-54
Care
....................................... 6-54
Securing in a Rear Outside Seat Position
........... 1-55
Securing in the Center Seat Position .............. 1-57
Securing in the Right Front Seat Position .......... 1-59 Top
Strap
................................... 1-54
Where to Put
........................... 1-53. 1-54
Cigarette Lighter
............................... 2-50
Circuit Breakers and Fuses ....................... 6-61
Cleaner. Air Filter
.............................. 6-19
Cleaning Aluminum Wheels
............................ 6-57
Built-in Child Restraint
........................ 6-54
Exterior LampsLenses
........................ 6-55
Fabric
...................................... 6-52
Glass Surfaces
............................... 6-54
Inside
of Your Vehicle ......................... 6-51
Instrumentpanel
............................. 6-54
Leather
..................................... 6-53
Outside of Your Vehicle
........................ 6-55
Special Problems
............................. 6-52
Stains
...................................... 6-52
Tires
....................................... 6-57
Vinyl
....................................... 6-53
Wheels
..................................... 6-57
Windshield and Wiper Blades
................... 6-55
Clock, Setting the
................................ 3-9
Comfort Controls
................................ 3-2
Compact Disc Care
............................. 3-30
Compact Disc Player
....................... 3-19, 3-24
Compact Spare Tire
............................. 5-35
Control of a Vehicle .............................. 4-6
Convenience Net
............................... 2-49
Convex Outside Mirror
.......................... 2-42
Coolant
....................................... 6-25
Heater, Engine
............................... 2-18
Recovery Tank ............................... 5-16
9-2

Downloaded from www.Manualslib.com manuals search engine Cooling System ................................ 5- I5
Courtesy Lamps ................................ 2-39
Courtesy Transportation
........................... 8-8
Cruise Control
................................. 2-34
Customer Assistance Information
................... 8- 1
Customer Satisfaction Procedure .................... 8-2
Customer Assistance for Text Telephone Users
......... 8-4
Damage. Finish
............................... 6-58
Damage. Sheet Metal
............................ 6-57
Daytime Running Lamps
......................... 2-38
Daytime Running Lamps Indicator Light
............ 2-68
Dead Battery
................................... 5-3
Defects. Reporting Safety
................... 8- IO. 8- 11
Defensive Driving ............................... 4-2
Defogger. Rear Window
.......................... 3-8
Defrosting
..................................... 3-6
Dimensions. Vehicle
............................ 6-68
Dome Lamps
.................................. 2-39
Door Locks
....................................... 2-6
Sliding ..................................... 2-10
Drive Position
................................. 2-21
Driver Position
................................. 1 - 18
Driving
City
........................................ 4-18
Defensive
.................................... 4-2
Drunken
..................................... 4-3
Freeway
.................................... 4-19
TnaBlizzard
................................. 4-26
In Foreign Countries ........................... 6-4
IntheRain
.................................. 4-16
Night
...................................... 4-14
OnCurves
................................... 4-9
On Grades While Towing
a Trailer ............... 4-37
On
Hill and Mountain Roads .................... 4-22
OnSnowandIce
............................. 4-24
Throughwater
............................... 4-18
WetRoads
.................................. 4-16
Winter
...................................... 4-24
With a Trailer ................................ 4-35
DrunkenDriving
................................ 4-3
Electrical Equipment. Adding
.......... 2- 18. 3-28. 6-60
Electrical System
............................... 6-60
Engine
........................................ 6-9
Coolant
..................................... 6-25
Coolant Heater
............................... 2-18
Coolant Level Check
.......................... 7-43
Cooling System Capacity
....................... 6-66
Cover
...................................... 6-15
Exhaust ..................................... 2-27
FuseBlock
.................................. 6-64
Identification
................................ 6-60
OilLevelCheck
.............................. 7-43
Overheating
................................. 5-13
Running While Parked
......................... 2-28
Specifications
................................ 6-66
Starting
..................................... 2-17
Temperature Gage
............................ 2-64
9-3

Downloaded from www.Manualslib.com manuals search engine Engineoil .................................... 6-11
Adding ..................................... 6-12
Additives
................................... 6- 14
Checking
................................... 6-11
Pressure Gage ................................ 2-68
Used
....................................... 6-14
Whentochange
.............................. 6-14
Exhaust, Engine
....... 2-27,2-28,2-30,4-27,4-34, 4-35
Express-Down Window
.......................... 2-29
Fabric Cleaning
............................... 6-52
FillingYourTank
6-5
Fi 1 ter
.
................................
Air Cleaner Replacement ....................... 6-68
Engine Oil Replacement
....................... 6-68
Finish Care
.................................... 6-56
Finish Damage
................................. 6-58
FirstGear ..................................... 2-22
Flashers, Hazard Warning
......................... 5-2
Flat Tire. Changing
............................. 5-23
Fluid Capacities
........................... 6.66. 6.67
Foreign Countries. Fuel
........................... 6-4
Fluids and Lubricants ............................ 7-49
French Language Manual
11
Front
Axle
....................................... 6-24
Towing
................................. 5-9. 5.10
Turn Signal Lamp Bulb Replacement ............. 6-40
.. ...........................
Storage Area ................................. 2-42
Fuel .......................................... 6-3
Filling Your Tank
.............................. 6-5
Gage
....................................... 2-69
In Foreign Countries ........................... 6-4
Regulator
................................... 2-18
Fuses and Circuit Breakers
....................... 6-61
Gages Engine Coolant Temperature
.................... 2-64
Fuel ....................................... 2-69
Engine Oil Pressure
........................... 2-67
Garage Door Opener
............................ 2-45
GAWR
....................................... 4-28
Gear Positions. Automatic Transmission
............. 2-19
GloveBox
.................................... 2-42
Gross Axle Weight Rating
........................ 4-28
Gross Vehicle Weight Rating
...................... 4-28
Guide en Franpis 11
GVWR ....................................... 4-28
.. .................................
Halogen Bulbs ................................ 6-36
Hatch Release
.................................. 2-12
Hazard Warning Flashers
.......................... 5-2
Head Restraints
................................. 1-5
Headlamps .................................... 2-38
Bulb Replacement
............................ 6-37
High/Low Beam Changer ...................... 2-32
Wiring
..................................... 6-61
OnReminder ................................ 2-38
9-4