ECU CHEVROLET ASTRO 2003 Service Manual

Removing the Spare Tire and Tools
The jacking equipment you’ll need is stored by your
vehicle’s rear doors, along the passenger’s side wall.
1. Remove the jack cover by pulling it away from
the side wall and down to release the tabs
securing the top of the cover.
2. Remove the wheel blocks by turning the top nut
counterclockwise. Remove the nut and washer,
then pull the wheel blocks
off the bolt.
3. Push down on the bolt and remove the hooked end
from the slot. Slide the jack toward the front of the
vehicle and lift it from the mounting. Remove
the extension and the ratchet from the pouch.
5-72

Stori J a Flat or Spare Tire and Tools
Storing a jack, a tire, or other equipment in the
passenger compartment
of the vehicle could
cause injury. In
a sudden stop or collision,
loose equipment could strike someone.
Store all these in the proper place.
1. Put the flat tire on the ground at the rear of the
vehicle with the valve stem pointed down.
2. Tilt the retainer plate downward and through the
wheel opening. Make sure
it is fully seated across
the underside of the wheel. Attach the ratchet,
with the UP side facing you, to the extension.
3. Put the flat end of the extension on an angle
through the hole in the rear door frame, above
the bumper.
The compact spare is for temporary use only.
Replace the compact spare tire with a full-size tire
as soon as you can. See Compact Spare Tire
on page 5-82. See the storage instructions label to
restore your compact spare properly.
vehicle by turning the ratchevwheel wrench until
you hear two clicks or feel it skip twice. The spare
tire hoist cannot be overtightened.
4. Raise the tire fully against the underside of the
5. Make sure the tire is stored securely. Push, pull,
and then try to rotate or turn the tire. If the tire
moves, use the ratchet/wheel wrench
to tighten
the cable.
Return the jacking equipment to its proper location.
5-81

Wiper Blade Check
Inspect wiper blades for wear or cracking. Replace
blade inserts that appear worn or damaged or that
streak or miss areas of the windshield. Also see
Cleaning the Outside of Your Vehicle on page 5-86.
Spare Tire Check
At least twice a year, after the monthly inflation check
of the spare tire determines that the spare is inflated to
the correct tire inflation pressure, make sure that the
spare tire is stored securely. Push, pull, and then
try
to rotate or turn the tire. If it moves, use the wheel
wrench
to tighten the cable. See Changing a
Flat Tire on page 5-71.
Weatherstrip Lubrication
Silicone grease on weatherstrips will make them last
longer, seal better, and not stick or squeak. Apply
silicone grease with a clean cloth. During very cold,
damp weather more frequent application may be
required. See
Part D: Recommended Fluids and
Lubricants on page
6-32.
Automatic Transmission Check
Check the transmission fluid level; add if needed.
See
Automatic Transmission Fluid on page 5-25.
A fluid loss may indicate a problem. Check the
system and repair
if needed.
At Least Once a Year
Key Lock Cylinders Service
Lubricate the key lock cylinders with the lubricant
specified in Part D.
Body Lubrication Service
Lubricate all body door hinges, the body hood, fuel door
and rear compartment hinges, latches and locks
including interior glove box and console doors, hood
latch assembly, secondary latch, pivots, spring anchor,
release pawl and any moving seat hardware. Lubricate
the hood safety lever pivot and prop rod pivot. Part D
tells you what to use. More frequent lubrication may be
required when exposed
to a corrosive environment.
6-27

Automatic Headlamp System ..................
Automatic Transmission
Fluid
................................................
Automatic Transmission Check ................
Automatic Transmission Shift Lock Control
System Check
...................................
Operation .........................................
......... 3-13
......... 5-25
......... 2-23
......... 6-27
......... 6-28
Backing Up
.................................................... 4-38
Battery
.......................................................... 5-46
Battery Replacement
......................................... 2-6
Battery Run-Down Protection
............................ 3-1 6
Before Leaving on a Long Trip
......................... 4-21
Bench Seat
............................................ 1-1 1, 1-57
Body Lubrication Service
.................................. 6-27
Brake Parking
...................................................... 2-26
System Inspection
....................................... 6-31
System Warning Light
.................................. 3-28
Brake Adjustment
............................................ 5-45
Brake Fluid
.................................................... 5-42
Brake Pedal Travel
......................................... 5-45
Brake Wear
................................................... 5-45
Brakes
.......................................................... 5-42
Braking in Emergencies
..................................... 4-9
Break-In, New Vehicle
..................................... 2-19
Braking
........................................................... 4-6
Bucket Seats, Rear
......................................... 1-12 Bulb
Replacement
........................................... 5-55
Halogen Bulbs ............................................ 5-55
Headlamps
............................ ......... 5-55
Replacement Bulbs
.............................. 5-61
Taillamps
.................................................... 5-60
Front
Turn Signal Lamps
.............................. 5-59
Buying New Tires
................................... 5-66
C
California Fuel .................................................. 5-6
Canada
........................................................... 7-5
Canadian Owners
................................................ ii
Canadian Roadside Assistance ............ ....... 7-7
Cancelling the Sliding Door
Security Lock
.......................................... 2-12
Capacities and Specifications
........................ 5-99
Carbon Monoxide
............... ..... 4-24, 4-31, 2-30
Care of
Safety Belts
.... ~ ~ ~ ~ ..................... 5-86
Care of Your
CD Player
.......... ...., ............ ..... 3-50
CDS
.......................................................... 3-50
Cargo Vans
........................................... 1-41, 1-48
Center Passenger Position, Safety Belts
............. 1-27
Chains, Tires
..................................... ..... 5-70
Charging System Light
....................... ..... 3-27
Engine Light
.............................. , ..... 3-30
Check
Gages Warning Light
................................... 3-36
2

Checking Brake Fluid .................................. 5-43
Checking Coolant ............................................ 5-29
Checking Engine Oil ........................................ 5-15
Checking Things Under the Hood ...................... 5-1 1
Checking Your Restraint Systems ...................... 1-71
Chemical Paint Spotting ................................... 5-89
Child Restraints
Child Restraint Systems
............................... 1-44
Infants and Young Children ........................... 1-38
Lower Anchorages and Top Tethers for
Children (LATCH System)
.......................... 1-52
Older Children ............................................. 1-35
Securing a Child Restraint Designed for
the LATCH System
................................ 1-54
Securing a Child Restraint in a Center
Seat Position
....................................... 1-57
Securing a Child Restraint in a Rear
Outside Seat Position
............................... 1-54
Securing a Child Restraint in the Right
Front Seat Position
................................... 1-59
Top Strap ................................................... 1-48
Top Strap Anchor Location ............................ 1-50
Where to Put the Restraint ........................... 1-47
Cigarette Lighter ............................................. 3-1 7
Cleaning
Inside of Your Vehicle
.................................. 5-83
Outside of Your Vehicle ................................ 5-86
Underbody Maintenance ............................... 5-89
Weatherstrips .............................................. 5-86
Cleaning Exterior Lamps/Lenses ....................... 5-86
Climate Control System ................................... 3-18
Rear .......................................................... 3-21
Rear Heating System ................................... 3-19
Compact Disc Messages .................................. 3-45
Compact Spare Tire ........................................ 5-82
Composite Headlamps ..................................... 5-56
Control of a Vehicle .......................................... 4-6
Convenience Net ............................................ 2-45
Coolant
Engine Temperature Gage
............................ 3-30
Heater, Engine ............................................ 2-22
Cooling System .............................................. 5-33
Cruise Control ................................................ 3-10
Current and Past Model Order Forms ................ 7-12
Customer Assistance Information
Customer Assistance for Text
Customer Assistance
Off ices ........................... 7-4
Customer Satisfaction Procedure ..................... 7-2
GM Mobility Program for Persons with
Disabilities
................................................ 7-5
Reporting Safety Defects to General Motors ....... 7-11
Reporting Safety Defects to the
Canadian Government
.............................. 7-11
Reporting Safety Defects to the United States Government
......................... 7-10
Roadside Assistance Program ......................... 7-6
Service Publications Ordering Information ........ 7-11
Rear Air Conditioning System ........................ 3-20
Courtesy Transportation ......... ...... 7-8
Telephone (TTY) Users ............................... 7-4
3

Inspection (cont.) Exhaust System
........................ ....... 6-30
Fuel System
............................................... 6-30
Part C
- Periodic Maintenance ....................... 6-30
Steering, Suspension and Front Drive Axle
Boot and Seal
......................................... 6-30
Throttle System
........................................... 6-31
Installing a Garage Door Opener
....................... 2-40
Instrument Panel Cluster
....................................................... 3-24
Overview
.................................................. 3-2
Instrument Panel Brightness Control
.............. 3-1 5
Instrument Panel Fuse Block ............................ 5-93
Interior Lamps
................................................ 3-15
Interior Plastic Components
.............................. 5-85
Introduction Transfer Case (All-Wheel Drive) Inspection
........ 6-31
Jump Starting
....................................... ... 5-47
Key Lock Cylinders Service
.............................. 6-27
Keys
............................................................... 2-2
Keyless Entry System
....................................... 2-4
L
Lamps
Exterior
...................................................... 3-12
Interior
....................................................... 3-15
Lap Belt
........................................................ 1-27
Lap-Shoulder Belt
................................... 1-18, 1-29
LATCH System
Child Restraints
........................................... 1-52
Securing a Child Restraint Designed for
the LATCH System
........................... . 1-54
Latches, Seatback
............................................ 1-6
Leather
......................................................... 5-85
Leaving Your Vehicle
....................................... 2-10
Leaving Your Vehicle With the
Engine Running
.......................................... 2-28
Light
Air Bag Readiness
....................................... 3-26
Brake System Warning
................................. 3-28
Charging System
......................................... 3-27
Check Gages Warning
................................. 3-36
Low Fuel Warning
....................................... 3-37
Malfunction Indicator
.................................... 3-30
Safety Belt Reminder
................................... 3-26
Security
.............................................. 3-35
Service All-Wheel-Drive
......................... 3-35
Tow/Haul Mode
........................................... 3-36
Lamps On Reminder
....................................... 3-14
Anti-Lock Brake System Warning
................... 3-29
7

Restraint System Check ..................... ... 6-26
Checking Your Restraint Systems
..... ... 1-71
Replacing Restraint System Parts
After a Crash
....................................... 1-71
Checking
.................................................... 1-71
Restraints, Head
............................................... 1-5
Retained Accessory Power (RAP)
...................... 2-20
Right Front Passenger Position, Safety Belts
......... 1-27
Roadside Assistance Program
....................................... 7-6
Rocking Your Vehicle To Get It Out
................... 4-28
Running Your Engine While You Are Parked
....... 2-31
Restraint Systems
Replacing Parts
........................................... 1-71
Safety Belt
Safety Belts
Reminder Light
... .................................. 3-26
Care
of ...................................................... 5-86
Center Passenger Position
............................ 1-27
Driver Position
............................................ 1-1 8
How to Wear Safety Belts Properly ................ 1-18
Questions and Answers About Safety Belts
........ 1-1 7
Rear Safety Belt Comfort Guides for
Children and Small Adults
......................... 1-32
Rear Seat Passengers
................................. 1-29
Right Front Passenger Position
...................... 1-27 Safety Belts
(cont.)
Safety Belt Extender
.................................... 1-34
Safety Belts Are for Everyone
....................... 1-13
Safety Belt
Use During Pregnancy
................. 1-26
Safety Chains
................................................. 4-36
Safety Warnings and Symbols
.............................. III
Sealed Beam Headlamp .................................. 5-55
Seatback Latches ............................................. 1-6
Seats Bench Seat
.......... ..........., ........ 1-11
Bucket Seats, Rear
................... ........ 1-12
Head Restraints
............................................ 1-5
Manual
........................................................ 1-2
Manual Lumbar
............................................. 1-3
Power Seat
.................................................. 1-3
Rear Seat Operation
...................................... 1-7
Reclining Seatbacks
...................................... 1-4
Seatback Latches
.......................................... 1-6
Center Seat Position
.................................... 1-57
Designed for the LATCH System
................... 1-54
Rear Outside Seat Position ........................... 1-54
Right Front Seat Position
.............................. 1-59
Security Light
................................................. 3-35
Selecting the Right Schedule, Maintenance
.......... 6-5
Selecting the Fan Speed
.................................. 3-20
Service
........................................................... 5-3
Adding Equipment to the Outside of
Your Vehicle
.............................................. 5-4
All-Wheel-Drive Light
.................................... 3-35
...
Securing a Child Restraint
11

Service (cont.)
Doing Your Own Work
................................... 5-3
Engine Soon Light
....................................... 3-30
Publications Ordering Information
................... 7-1 1
Sewice Bulletins ............................................. 7-1 2
Service Engine Soon Light in the United States
or Check Engine Light
in Canada
.................................................. 3-30
Service Manuals
............................................. 7-1 1
Servicing Your Air Bag-Equipped Vehicle ............ 1-69
Setting Preset Stations
............................ 3-39, 3-42
Setting the Temperature
................................... 3-20
Setting the Time
Radios with HR and MN Buttons
................... 3-38
Radios with the Set Button
........................... 3-38
Setting the Tone (Bassnreble)
.................. 3-40, 3-43
Shifting Into Park (P)
....................................... 2-27
Sheet
Metal Damage
....................................... 5-88
Shifting Out of Park (P)
................................... 2-29
Short Trip/City Definition
.................................... 6-5
Short TripKity Intervals
..................................... 6-5
Short Trip/City Scheduled Maintenance
...... ... 6-7
Shoulder Belt Height Adjuster
............... ..... 1-20
Skidding
........................................ ......... 4-13
Sliding Door Security Lock
............................... 2-1 1
Sliding Side Door
............................................ 2-10
Some Other Rainy Weather Tips
....................... 4-18
Spare Tire Check
............................................ 6-27 Special Fabric Cleaning
Problems
..................... 5-84
Specifications, Capacities
................................. 5-99
Speedometer
.................................................. 3-25
Steering
.......................................................... 4-9
Starter Switch
Check
....................................... 6-28
Starting Your Engine
....................................... 2-21
Steering in Emergencies
.................................. 4-10
Steering, Suspension and Front Drive Axle
Boot and Seal Inspection .............................. 6-30
Steering Tips
................................................... 4-9
Storage Areas
................................................ 2-38
Convenience Net
......................................... 2-45
Luggage Carrier
.......................................... 2-44
Overhead Console
....................................... 2-39
Storing a Flat or Spare Tire and
Tools ............... 5-81
Stuck in Sand, Mud, Ice or Snow
...................... 4-28
Sun Visors
..................................................... 2-17
Sunglasses Storage Compartment
..................... 2-44
Taillamps
....................................................... 5-60
Theft.Deterrent. Radio
..................................... 3-47
Theft-Deterrent Systems
................................... 2-18
Passlock@
............................................... 2-18
Throttle System Inspection
........................... 6-31
Tilt Wheel
........................................................ 3-5
Tire Inflation Check
......................................... 6-26
12