load capacity CHEVROLET ASTRO PASSENGER 1993 1.G Owners Manual

Downloaded from www.Manualslib.com manuals search engine PO480
If you have the optional luggage carrier, you can load things on \
top of your
vehicle. The luggage carrier has slats attached to the roof, s\
ide rails, and
tiedowns.
Loading cargo that weighs more than
200 pounds (91 kg) on the luggage
carrier may damage your vehicle. When you carry large things, never le\
t
them hang over the rear
or the sides of your vehicle. Load your cargo so
that it rests on the slats and does not scratch or damage the vehi
Put the cargo against the side rails and fasten
it securely to the 1
carrier. Put the main weight as far forward as you can.
Don’t exceed the maximum vehicle capacity when loading your \
vehicle. For
more information on vehicle capacity and loading, see “Loadin\
g Your Vehicle’’
in the Index.
To prevent damage or
loss of cargo as you’re driving, check now and then to
make sure the luggage carrier and cargo are still securely fas\
tened.
249

Downloaded from www.Manualslib.com manuals search engine Fuel Gage
Sfandard Cluster Digifal Cluster
FU
PO651
The fuel gage tells you how much fuel you have remaining, whe\
n the ignition is on. When the gage first indicates empty you still have a \
little fuel left, but
you should get more fuel as soon as possible.
A box around the fuel gage symbol on the digital cluster will begin to flash
when your tank is
1/8 full or less.
Here are four things some owners ask about. None of these indicate a
problem with your fuel gage:
At the gas station, the gas pump shuts off before the gage reads full.
The fuel tank will take either a little more or a little les\
s fuel to fill up
The gage moves a little when you turn a corner or speed up. \
The gage doesn’t go back to empty when you turn off the ignition.
than the gage shows.
For your fuel tank capacity, see the Index under “Fluid Cap\
acities.”
2-63

Downloaded from www.Manualslib.com manuals search engine Weight of the Trailer Tongue
The tongue load (A) of any trailer is an important weight to measure because it
affects the total or gross weight of your vehicle. The gross vehicle weight (GVW)
includes the curb weight of the vehicle, any cargo you may carry in it, and the
people who will be riding in the vehicle. And
if you will tow a trailer, you must
add the tongue load
to the GVW because your vehicle will be carrying that
weight too. See “Loading Your Vehicle in the Index for more information about
your vehicle’s maximum load capacity.
---
A B
--1
I
1
AN490002
If you’re using a “dead-weight” hitch, the trailer tongue \
(A) should weigh 10% of
the total loaded trailer weight (B). If you have a “weight-distributing” hitch, the
trailer tongue (A) should weigh
12% of the total loaded trailer weight (B).
After you’ve loaded your trailer, weigh the trailer and then\
the tongue,
separately,
to see if the weights are proper. If they aren’t, you may be able to
get them right simply by moving some items around in the trai\
ler.
Total Weight on Your Vehicle’s Tires
Be sure your vehicle’s tires are inflated to the limit for cold tires. You’ll find
these numbers on the Certification label
at the rear edge of the driver’s door (or
see the “Tire Loading” in the Index.) Then be sure you
don’t go over the GVW
limit for your vehicle.
4-45

Downloaded from www.Manualslib.com manuals search engine Service dk Appearance Care
K3608
Turn off the engine and give the oil a few minutes to drain back down into
the oil pan.
If you don’t, the oil dipstick might not show the actual level\
.
To Check Engine Oil: Pull out the dipstick and clean it with a paper towel
or cloth, then push it back in all the way. Remove it again, keeping the tip
lower.
K3609
When to Add Oil: If the oil is at or below the ADD line, then you’ll need to
add some oil. But you must use the right kind. This section \
explains what
kind
of oil to use. For crankcase capacity see ‘Capacities and Speci\
fications’’
in the Index.
6-1 0

Downloaded from www.Manualslib.com manuals search engine Service & Appearance Care
Loading Your Vehicle
K3651
The Certificationrrire label is found on the rear edge of the driver’s door. The
label shows the size of your original tires and the inflation pressures needed
to obtain the gross vehicle weight capacity of your vehicle. This is called the
GVWR (Gross Vehicle Weight Rating). The GVWR includes the weight of the
vehicle, all occupants, fuel and cargo.
The Certificationflire label also tells you the maximum weights for the front
and rear axles, called Gross Axle Weight Rating (GAWR).
To find out the
actual loads on your front and rear axles, you need
to go to a weigh station
and weigh your vehicle. Your dealer can help you with this. Be sure
to
spread out your load equally on both sides of the centerline.
Never exceed the GVWR for your vehicle, or the Gross Axle Wei\
ght Rating
(GAWR) for either the front or rear axle.
And,
if you do have a heavy load, you should spread it out.
Do not load your vehicle any heavier than the GVWR or the
- maximum front and rear GAWRs. If you do, parts on your vehicle
can break, or
it can change the way your vehicle handles. These
could cause you
to lose control. Also, overloading can shorten the
life
of your vehicle. I
6-42

Downloaded from www.Manualslib.com manuals search engine Using heavier suspension components to get added durability might not
change your weight ratings. Ask your dealer to help you load your vehicle the
right way.
i NOTICE
I Your warrantv does not cover Darts or components that fail because of
If you put things inside your vehicle-like suitcases, tools, packages, or
anything else-they will go as fast
as the vehicle goes. If you have to stop
or turn quickly, or
if there is a crash, they’ll keep going.
A
Things you put inside your vehicle can strike and injure peopl\
e in a
sudden stop or turn, or in a crash.
Put things in the cargo area of your vehicle. Try to spread the
weight evenly.
Never stack heavier things, like suitcases, inside the vehicle \
so
that some
of them are above the tops of the seats.
When you carry something inside the vehicle, secure it
whenever you can.
Don’t leave a seat folded down unless you need to.
Pay/oad
The Payload Capacity is shown on the CertificationRire label. This is the
maximum load capacity that your vehicle can carry. Be sure to \
include the
weight of the people inside as part of your load.
If you added any
accessories or equipment after your vehicle left the factory, r\
emember to
subtract the weight of these things from the payload. Your dealer can help
you with this.
6-43

Downloaded from www.Manualslib.com manuals search engine failure. The grade C corresponds to a level of performance which all
passenger car tires must meet under the Federal Motor Vehicle \
Safety
Standard
No. 109. Grades B and A represent higher levels of performance on
the laboratory test wheel than the minimum required by law.
Warning: The temperature grade for this tire is established for\
a tire that is
properly inflated and not overloaded. Excessive speed, underinfla\
tion,
or
excessive loading, either separately or in combination, can cause heat buildup
and possible tire failure.
These grades are molded on the sidewalls of passenger car tire\
s.
While the tires available as standard
or optional equipment on General Motors
vehicles may vary with respect to these grades, all such tires meet General
Motors performance standards and have been approved for use on \
General
Motors vehicles.
All passenger type (P Metric) tires must conform to Federal
safety requirements in addition to these grades.
Wheel Alignment and lire Balance
The wheels on your vehicle were aligned and balanced carefully \
at the
factory to give you the longest tire life and best overall pe\
rformance.
In most cases, you will not need
to have your wheels aligned again.
However,
if you notice unusual tire wear or your vehicle pulling one way or
the other, the alignment may need to be reset. If you notice your vehicle
vibrating when driving on a smooth road, your wheels may need \
to be
rebalanced.
Wheel Replacement
Replace any wheel that is bent, cracked or badly rusted. If wheel nuts keep
coming loose the wheel, wheel
bolts, and wheel nuts should be replaced. If
the wheel leaks air out, replace it (except some aluminum whe\
els, which can
sometimes be repaired). See your GM dealer if any of these c\
onditions exist.
Your dealer will know the kind of wheel you need.
Each new wheel should have the same load carrying capacity dia\
meter, width,
offset, and be mounted the same way as the one
it replaces.
If you need to replace any of your wheels, wheel bolts, or wheel nuts,
replace them only with new GM original equipment parts. This way, you will
be sure you have the right wheel, wheel bolts, and wheel nuts\

for your
vehicle.
6-50

Downloaded from www.Manualslib.com manuals search engine Air Conditioning Refrigerants
Not all air conditioning refrigerants are the same. If the air conditioning
system in your vehicle needs refrigerant, be sure the proper refrigerant
is
used. If you’re not sure, ask your GM dealer.
Air Conditioning Refrigerant Capacity
TYPE SYSTEM QUANTITY
R-12 C-60 3.00
Ibs. (1.4 kg)
R-12 C-69 3.75 Ibs. (1.7 kg)
Crankcase
QUANTITY
ENGINE Without Filter
I With Filter
VIN CODE
4.3L
4.5 Quarts
(4.3 Liters) 4 Quarts (3.8 Liters) W 4.3L
4.5 Quarts (4.3 Liters) 4 Quarts (3.8 Liters) Z
All quantities are approximate.
After refill, the level
MUST be checked.
TO1 8E
Fuel Tank
TYPE QUANTITY
Standard 27 Gallons (102 Liters)
I
Quantity is approximate.
TO1 87 I
6-65

Downloaded from www.Manualslib.com manuals search engine INDEX
A
Air Cleaner .................................... 6-1 9
Air Conditioning
.............................. 3-6
Fan Lever
.................................... 3-6
Function Lever
............................ 3-6
Maintenance
.............................. 6-39
Rear
............................................. 3-8
Refrigerant Capacity
................. 6-65
Temperature Lever
...................... 3-6
All-Wheel Drive
............................. 6-23
Antenna, Fixed Mast
.................... 3-29
Antilock Brakes (See “Brakes”) Appearance Care
......................... 6-52
Materials
.................................... 6-59
Ashtrays
........................................ 2-50
Assist Handles
.............................. 2-68
Audio Systems
................................ 3-9
AM Radio
.................................. 3-11
AM-FM Stereo Audio Cassette
AM-FM Stereo Audio
AM-FM Stereo Audio
AM-FM Stereo Audio System
.. 3-1 3
Anti-Theft Feature
..................... 3-26
Compact Disc Care
.................. 3-28
Automatic Transmission
............... 2-1 7
Fluid ........................................... 6-20
Arbitration Program
........................ 8-3
System with Equalizer
.......... 3-1 8
Cassette System
................... 3-1 5
Compact Disc (CD) System .... 3-23
Cassette Tape Player
..... 3-21, 3-22
.
. I
Axle
Front.
.......................................... 6-24
Rear
........................................... 6-23
B
Battery ........................................... 6-34
Belts (See “Safety Belts”) Better Business Bureau Mediation
..................................... 8-3
Blizzard
.......................................... 4-42
Brakes Adjustment
................................. 4-17
Antilock
...................................... 4-14
Fluid
...........................................
Hydro-Boost System (Hydraulic Pump)
................... 6-34
Master Cylinder
......................... 6-32
Parking
....................................... 2-20
Pedal Travel
.............................. 4-17
Rear Drum
................................. 4-17
Replacing Parts
......................... 6-33
Trailer
......................................... 4-46
Wear Indicators ......................... 4-17
In Emergencies
......................... 4-18
Break-In, New Vehicle
.................. 2-13
Bulb Replacement
........................ 6-35
Halogen.
..................................... 6-35
Replacement Chart
................... 6-66
6-32
System Warning Light
.... 2-58, 4-16
Braking
.......................................... 4-12
9-1

Downloaded from www.Manualslib.com manuals search engine ..
.
E
Engine Block Heater
..................... 2.16. 3-9
Coolant
............................ 5.11. 6-26
Coolant Temperature Gage
...... 2-60
Cover
......................................... 6-1 5
Exhaust ............................ 2.24. 6-41
Fan Noise
.................................. 5-1 6
Identification
..................... 6.60. 6-64
Oil (See “Oil”) Overheating
................................. 5-8
Running While Parked
... 2.22. 2-25
Equipment. Add-on
...................... 6-44
Exhaust System
............................ 6-41
F
Finish Care
........................................... 6-56
Damage
..................................... 6-57
Automatic Transmission
............ 6-20
Brake
......................................... 6-32
Capacities
.................................. 6-64
Coolant
............................ 5.11. 6-26
Leak Check
............................... 6-34
Power Steering
......................... 6-30
Transfer Case
........................... 6-23
Windshield Washer
................... 6-31
Fog Lamps
.................................... 2-42
Four-wheel Antilock
..................... 4-1 5
Front Seats ..................................... 1-2
Fuel
................................................. 6-4
Gage
.......................................... 2-63
In Foreign Countries
................... 6-6
Regulator
................................... 2-1 5
Tank Capacity ........................... 6-65
Fuse Block
.................................... 6-63
Fuses and Circuit Breakers
......... 6-68
Fluid
Filling Your Tank
......................... 6-6
G
Gages
Fuel ............................................ 2-63 ....
Voltmeter .................................... 2-64
Gasolines for Cleaner Air
.............. 6-5
H
Hatch Release Switch .................. 2-27
Hazard Warning Flashers
.............. 5-2
Head Restraints
............................ 1-11
Headlights
...................................... 6-35
High Beams
..................... 2.66. 4-24
High-Low Beam
......................... 2-31
Reminder Light
.......................... 2-44
Heating System
.............................. 3-5
Fan Lever
.................................... 3-5
Rear
............................................. 3-7
Temperature Lever
...................... 3-5
Highway Hypnosis
........................ 4-34
Hitches Hood Block Heater.,
............................ 2-16
Function Lever
............................ 3-5
4-46
...........................................
Latches and Hinge ................... 6-40
Release
........................................ 6-8
Horn
............................................... 2-28
Hydroplaning
................................. 4-27
I
If You’re Stuck in Sand. Mud.
Ice or Snow
.............................. 5-32
Ignition Switch
............................... 2-13
Inflation-Tire Pressure
................... 6-45
Instrument Cluster
........................ 2-52
Standard
.................................... 2-55
Digital
......................................... 2-52
J
Jack Storage ................................. 5-18
Jump Starting
.................................. 5-3
9-3