transmission oil CHEVROLET ASTRO PASSENGER 1994 1.G Owners Manual
[x] Cancel search | Manufacturer: CHEVROLET, Model Year: 1994, Model line: ASTRO PASSENGER, Model: CHEVROLET ASTRO PASSENGER 1994 1.GPages: 340, PDF Size: 16.86 MB
Page 77 of 340
Downloaded from www.Manualslib.com manuals search engine How long should you keep the coolant heater plugged in? The answer
depends on the weather, the kind
of oil you have, and some other things.
Instead of trying to list everything here, we ask that you contact a
GM
dealer in the area where you’ll be parking your vehicle. The dealer can give
you the best advice for
that particular area.
Automatic Transmission
There are several
different positions for
your shift lever.
P (Park) - This locks your rear wheels. It’s the best position to use
when you start your engine because your vehicle can’t move easily.
2- 17
Page 183 of 340
Downloaded from www.Manualslib.com manuals search engine Parking on Hills
You really should not park your vehicle, with a trailer attached, on a hill. If
something goes wrong, your rig could start to move. People can be injured.
and both your vehicle and the trailer can be damaged.
But if you ever have to park your rig on a hill, here’s how to do it:
1. Apply your regular brakes, but don’t shift into “P” (Park) yet.
2. Have someone place chocks under the trailer wheels.
3. When the wheel chocks are in place, release the regular brakes until the
chocks absorb the load.
4. Reapply the regular brakes. Then apply your parking brake, and shift to
5. Release the regular brakes.
“P” (Park).
When You Are Ready to Leave After Parking on a Hill
1. Apply your regular brakes and hold the pedal down while you:
Start your engine;
Shift into a gear; and
Release the parking brake.
2. Let up on the brake pedal.
3. Drive slowly until the trailer is clear of the chocks.
4. Stop and have someone pick up and store the chocks.
Maintenance When Trailer Towing
Your vehicle will need service more often when you’re pulling a trailer. See
the Maintenance Schedule for more on this. Thin.gs that are especially
important in trailer operation are automatic transmission fluid (don’t
overfill), engine oil, axle lubricant, belt, cooling system, and brake
adjustment. Each of these
is covered in this manual, and the Index will help
you find them quickly. If you’re trailering, it’s a good idea to review these
sections before you start your trip.
Check periodically
to see that all hitch nuts and bolts are tight.
Trailer Light Wiring
See “Trailer Wiring Harness” in the Index.
4-29
Page 219 of 340
Downloaded from www.Manualslib.com manuals search engine Service & Appearance Care
...
Section
Here you will find information about the care of your vehicle . This part
begins with service and fuel information. and then it shows how to check
important fluid and lubricant levels
. There is also technical information
about your vehicle. and a section devoted to its appearance care
.
Service ................................................... 6-2
Fuel
..................................................... 6-3
Checking Things Under the Hood
.............................. 6-7
Hood Release
........................................... 6-7
Engineoil
.............................................. 6-9
Enginecover
.......................................... 6-15
Air Cleaner
............................................ 6-19
Automatic Transmission Fluid ............................. 6-20
RearAxle
............................................. 6-24
All-WheelDrive
........................................ 6-24
Transfercase
.......................................... 6-24
FrontAxle
............................................. 6-25
Engine Coolant
....................................... 6-26
Windshield Washer Fluid
................................. 6-31
Brake Master Cylinder
................................... 6-32
Replacing Brake System Parts
.................... ........ 6-35
Battery
.................................................. 6-35
Vehiclestorage
......................................... 6-35
FluidLeakCheck
.......................................... 6-36
Bulb Replacement
......................................... 6-36
Other Maintenance Items
.................................... 6-41
Tires
.................................................... 6-47
Appearancecare
.......................................... 6-54
Vehicle Identification Number
................................ 6-63
Service Parts Identification Label
..................... .... 6-65
Capacities and Specification Charts
................ . . 6-68
Fuses and Circuit Breakers ........... 6-72
Power Steering Fluid .................................. 6-30
Loading Your Vehicle
.... .............................. 6-44
6-1
Page 238 of 340
Downloaded from www.Manualslib.com manuals search engine If you have the 4.3L engine (VIN Code W) with the square air cleaner, you
can change the air cleaner filter without removing the engine cover. Just lift
the hood, unsnap both clips and remove
the top. After changing the filter,
snap both clips to secure
the air cleaner. Be sure air cleaner lid is correctly
positioned to seal out dust and contaminants that are harmful
to your engine.
Refer to the Maintenance Schedule to determine when to replace the air
filter.
See “Scheduled Maintenance Services”
in the Index.
NOTICE:
If the air cleaner is off, a backfire can cause a damaging engine
fire. And, dirt can easily get into your engine, which
will damage
it. Always have the air cleaner in place when you’re drivin\
g.
Automatic Transmission Fluid
When to Check and Change
A good time to check your automatic transmission fluid level is when the
engine oil is changed. Refer to the Maintenance Schedule to determine
when to change your fluid. See “Scheduled Maintenance Services” in the
Index.
How to Check
Because this operation can be a little difficult, you may choose to have this
done at a GM dealership Service Department.
If you do it yourself, be sure to follow all the instructions here,
or you could
get a false reading on the dipstick.
6-20
Page 300 of 340
Downloaded from www.Manualslib.com manuals search engine MAlNTENANCE SCHEDULE I/
Item Miles (000) 7.5 15 22.5 30
No. Kilometers (000) 12.5 25 37.5 50
Service
Oil Filter Change*- 12 Months, or
1 12 Months, or I 1 1 I
2 Chassis Lubrication-Every
3 Cooling System Service*
-Every
24 Months or
4 I Air Cleaner Filter Replacement* I I I I 0
5 Front Wheel Bearing Repack
(2WD Only) 0
6 Transmission Service **
7 Fuel Filter Replacement*$ 0
8 Spark Plug Replacement* 0
9 Spark Plug Wire Inspection*
10 Engine Timing Check*$
11 Fuel Tank, Cap and Lines
12 Engine Accessory Drive Belt
13 Tire and Wheel Rotation
0 0
14 Drive Axle Service 0.00
15 Brake Systems Inspection** Inspection*$
Inspection”
* An Emission Control Service
** See “Explanation of Scheduled Maintenance Services” in the Index
$ The California Air Resources Board has determined that the fail\
ure to perform this
maintenance item will not nullify the emission warranty or limi\
t recall liability prior
to the
completion
of vehicle useful life. General Motors, however, urges that all recommended
maintenance services be performed at the indicated intervals and\
the maintenance be
recorded.
THE SERVICES SHOWN
ON THIS CHART UP TO 60,000 MILES (100 000 km) ARE TO BE
DONE AFTER
60,000 MILES AT THE SAME INTERVALS.
TI 003
7-6
Page 307 of 340
Downloaded from www.Manualslib.com manuals search engine Recommended Fluids & Lubricants
NOTE: Fluids and lubricants identified below by name, part number or
specification may be obtained from your GM Dealer.
USAGE
Engine Oil
Engine Coolant Hydraulic Brake Systems
Parking Brake Cable
Power Steering System
Manual Steering Gear
Automatic Transmission
Differential: a. Standard
- Front and
Rear Axle
b. Locking
Transfer Case Column Shift
FLUIDLUBRICANT
API service SH or SG Energy
Conserving I1 oils
of the proper
viscosity. The “SH” or
“SG’
designation may be shown alone or in
combination with others, such as
“SWCD”, or
“SH, SG, CD,” or
“SGKD”, etc. To determine the
preferred viscosity oil for your
vehicle’s engine (e.g. SAE 5W-30).
See “Engine Oil”
in the Index.
Mixture of water and a good quality
ethylene glycol base antifreeze or an
approved recycled coolant conforming
to GM Specification GM-6038-M
(GM Part No. 1052103).
Delco Supreme I1 brake fluid
(GM
Part No. 1052535 or DOT-3).
Chassis lubricant meeting
requirements of NLGI Grade 2,
Category LB or GC-LB or (GM Part
No. 1052497).
GM Hydraulic Power Steering Fluid
(GM Part No. 1052884) or equivalent.
GM Lubricant (GM Part
No. 10521 82) or equivalent.
DEXRON @-I11
is preferred, if
unavailable use DEXRON @-IIE .
a. SAE-80W-90 GL-5 gear lubricant
(GM Part
No. 105227 1).
b. SAE-80W-90 gear lubricant (GM
Part
No. 1052271).
DEXRON@-IIE Automatic
Transmission Fluid.
Chassis lubricant meeting
requirements of NLGI Grade 2,
Catagory LB or GC-LB
(GM Part
No. 1052497).
7- 13
Page 308 of 340
Downloaded from www.Manualslib.com manuals search engine USAGE
Hood Latch Assembly:
a. Pivots and spring anchor
b. Release Pawl
Front Wheel Bearings Automatic Transmission Shift
Linkage, Floor Shift Linkage, Hood and Door Hinges, Body Door Hinge Pins, Folding Seat,
Fuel Door Hinge
Key Lock Cylinders
Chassis Lubrication Windshield Washer Solvent
Weatherstrips Gas Line
FLUIDLUBRICANT
a. Engine oil (GM Part
No. 1050 109).
b. Chassis lubricant meeting
requirements
of NLGI Grade 2,
Catagory LB or (GM Part
No. 1052497 or equivalent)
or
GC-LB .
Wheel bearing lubricant meeting
requirements
of NLGI Grade 2,
Catagory GC or GC-LB (GM Part
No. 105 1344).
Engine Oil (GM Part
No. 1050109).
GM Multi-Purpose lubricant
(GM Part
No. 12345 120) or a
synthetic light weight engine oil
Chassis lubricant meeting
requirements
of NLGI Grade 2,
Category LB or GC-LB (GM Part
No. 1052497).
GM Optikleen@ washer solvent
(GM
Part No. 105 15 15) or equivalent.
Dielectric Silicone grease (GM Part No. 12345579) or equivalent.
Gas Line De-Icer (GM Part
No. 1051516).
(SAE 5W-30).
7- 14
Page 311 of 340
Downloaded from www.Manualslib.com manuals search engine needs no water. I
See Page 6-35.
Brake Fluid
Reservoir
See Page 6-32. 1
Automatic A
Transmission
Fluid
See Page 6-20.
Fuel
Capacity
27 US. Gal.
(102 L.). Use
unleaded
gas
only. 87 octane
or higher.
See Page 6-3.
!
Hood Release
Lever
See Page 6-7.
Engine Oil
See Page 6-9.
Battery
The Delco
Freedom battery
-
-
-
11 't- i
--I!
fil I
I! I '" 1, 1. .
Cooling
System
Check and add
coolant only at
the coolant recovery tank.
See Page 6-26.
' Windshield
Washer
Fluid
See Page 6-31.
3
bower
Steering Reservoir
See Page 6-30.
4 Spare Tire
' Pressure
Compact Spare
See Page 6-48.
Cold Tire
Pressure
See Tire Loading
label on the
driver's
door.
See Page 6-44.
7- 17
Page 328 of 340
Downloaded from www.Manualslib.com manuals search engine Exhaust System ................................................. 6-43
F
FanNoise ...................................................... 5-18
Filter Replacement Chart
.......................................... 6-74
Finish
Care
........................................................ 6-59
Damage
..................................................... 6-61
Automatic Transmission
........................................ 6-20
Brake
....................................................... 6-32
Capacities
................................................... 6-69
CoolantRecovery
............................................. 5-14
FrontAxle
................................................... 6-25
Leak Check
.................................................. 6-36
Powersteering
............................................... 6-30
Radiator
..................................................... 5-15
Rear Axle
................................................... 6-24
RecommendedFluids
.......................................... 7-13
Transfercase
................................................ 6-24
Windshield Washer
............................................ 6-31
FogLamps
..................................................... 2-42
Four-wheel Anti-lock
............................................. 4-7
Frontseats
...................................................... 1-2
Fuel
........................................................... 6-3
FillingYourTank
.............................................. 6-5
Foreign Countries
.............................................. 6-5
Gage
....................................................... 2-61
Gasolines for Cleaner Air
........................................ 6-4
Tankcapacity ................................................ 6-69
Fuses and Circuit Breakers
........................................ 6-72
FuseBlock
.................................................. 6-67
Headlights
................................................... 6-66
Power Windows and Other Power Options
......................... 6-66
Trailer Wiring Harness
......................................... 6-66
Windshield Wipers
....................... .............. 6-66
Fluid
G
Gages ......................................................... 2-61
Coolant Temperature Gage
...................................... 2-63
FuelGage
................................................... 2-61
Odometer
................................................... 2-53
Oil Pressure Gage
............................................. 2-62
Speedometer
................................................. 2-53
Trip Odometer
................................................ 2-53
Voltmeter
.................................................... 2-64
Gasolines for Cleaner Air
.......................................... 6-4
Hatch Release Switch ............................................. 2-28
HalogenBulbs
........................................ ....... 6-36