coolant CHEVROLET BLAZER 1994 2.G Owner's Manual

Downloaded from www.Manualslib.com manuals search engine Explanation Of Scheduled Maintenance Services
Below are explanations of the services listed in the maintenance charts.
The proper fluids and lubricants to use are listed in this section. Make sure
whoever services your vehicle
uses these. All parts should be replaced and
all necessary repairs done before you or anyone else drives the vehicle.
1.
2.
3.
4.
5.
ENGINE OIL AND OIL FILTER CHANGE* - ALWAYS USE
API SERVICE SH OR SG ENERGY CONSERVING I1 OILS OF THE
PROPER VISCOSITY. The “SH” or “SG” designation may be shown
alone or in combination with others, such as “SHKD”, or
“SH, SG,
CD,” or “SG/CD”, etc.
To determine the preferred viscosity oil for your
vehicle’s engine (e.g. SAE
5W-30), see “Engine Oil” in the Index.
CHASSIS LUBRICATION - Lubricate the front suspension, ball
joint, steering linkage, and transfer case shift linkage, parking brake
cable guides, propshaft splines, universal joints, brake pedal springs,
and clutch pedal springs at the intervals specified on the proper
maintenance schedule, or at every engine oil change, whichever comes
first.
Ball joints should
not be lubricated unless their temperature is 10°F
(-12°C) or higher. When the weather is cold, let them warm up before
lubricating them
or they could be damaged.
Also, be sure to check all the vehicle fluid levels at this time.
COOLING SYSTEM SERVICE* - Drain, flush and refill the
system with new or approved recycled coolant conforming to “GM
Specification
603%”’. See “Engine Coolant” in the Index for the
proper coolant and mixture to use in your vehicle.
Also inspect
the hoses and replace them if they are cracked, swollen, or
deteriorated. Clean the outside of the radiator and air conditioning
condenser. Wash the radiator neck. To ensure proper operation,
pressure test the radiator and cap.
AIR CLEANER FILTER REPLACEMENT” - Replace at
specified intervals. Ask your dealer for the proper replacement
intervals for your driving conditions.
FRONT WHEEL BEARING REPACK (2-WHEEL DRIVE
ONLY) - Clean and repack the front wheel bearings at each brake
relining,
or at the specified interval, whichever comes first.
*An Emission Control Service
7-7

Downloaded from www.Manualslib.com manuals search engine Recommended Fluids & Lubricants
NOTE: Fluids and lubricants identified below by name, part number or
specification may be obtained from your GM Dealer.
USAGE
Engine Oil
Engine Coolant
Hydraulic Clutch System
Hydraulic Brake Systems
Parking Brake Cable Power Steering System
Manual Steering Gear
Automatic Transmission
5-Speed Manual Transmission
(RPO MY2)
FLUIDLUBRICANT
API service SH or SG Energy
Conserving
I1 oils of the proper
viscosity. The “SH” or
“SG’
designation may be shown alone or
in combination with others, such as
“SH/CD”, or “SH, SG, CD,”
or
“SG/CD”, etc. To determine the
preferred viscosity oil for your
vehicle’s engine (e.g.
SAE 5W-30),
see “Engine Oil”
in the Index.
Mixture of water and
a good quality
ethylene glycol base antifreeze or
an approved recycled coolant
conforming to GM Spectification
GM-6038-M (GM Part
No. 1052 103).
Hydraulic Clutch Fluid (GM Part
No. 12345347 or equivalent).
Delco Supreme
1 1 @ brake fluid
(GM Part No. 1052535 or DOT-3).
Chassis lubricant meeting
requirements
of NLGI Grade 2,
Catagory
LiIl or GC-LB or
(GM Part No. 1052497).
GM Power Steering Fluid (GM Part
No. 1052884) or equivalent.
GM Lubricant (GM Part
No. 1052182) or equivalent.
DEXRON
@-I11 (preferred) or
DEXRON @-IIE Automatic
Transmission Fluid.
Synchromesh Transmission Fluid
(GM Part
No. 12345349).
7- 13

Downloaded from www.Manualslib.com manuals search engine Service Station Checks
It is important for you or a service station attendant to perform these
under-hood checks at each fuel fill.
Check the engine oil level and add if necessary.
Check the engine coolant level and add if necessary.
Check the windshield washer fluid level and add if necessary.
See the Index under these items
for information on how to check them.
7-17

Downloaded from www.Manualslib.com manuals search engine Hood Release
Lever
See Page 6-6.
Remote
Oil Filter
See Page 6-13.
Power Steering
Reservoir
See Page 6-26.
Windshield -
Washer Fluid
See Page 6-28.
/ Brake Fluid
reservoir
See Page 6-29.
/
Clutch Fluid -
Reservoir
See Page 6-20.
Spare Tire
Pressure
Located on left
rear wall, endgat
3r floor.
See Page 6-42.
Battery
The Delco
Freedom battery
needs no water.
See Page 6-31.
,Cooling System
Check and add
coolant
only at
the coolant recovery tank.
See Page 6-23.
Engine Oil
See Page 6-8.
Transmission
Fluid
Automatic:
See Page 6-15.
Manual:
See Page 6-18.
/ Zacity 20 U.S.
Gal. (76.0L. Use
only, 87 Octane
or higher.
See Page 6-3.
Cold Tire
Pressure
See tire-loading
sticker
on the
inside
of the
rear edge
of
the driver's door
lock pillar.
See Page 6-39.
7-18

Downloaded from www.Manualslib.com manuals search engine C
Capacities and Specification Charts .................................. 6-62
Carbon Monoxide
.................................. 2.8.2.29.2.30. 4-4
Catalytic Converter
.............................................. 6-38
Certificatioflire Label
........................................... 6-39
Changing a Flat Tire
.............................................. 5-19
Chemical Paint Spotting
........................................... 6-56
Cassette
Tape Player (see “Audio Systems”
)
Child Restraints (See “Safety Belts”)
Cigarette LightedAshtrays
......................................... 2-57
Circuit Breakers (See “Fuses”)
Cleaning Finishcare
.................................................. 6-54
Glass
....................................................... 6-53
InsideofVehicle
.............................................. 6-50
OutsideofVehicle
............................................. 6-54
VinylorLeather
.............................................. 6-52
Wheels and Tires
.............................................. 6-55
Windshield
.................................................. 6-54
AMRadio
.................................................... 3-9
Instrument
Panel, Top
.......................................... 6-53
Special Problems
.............................................. 6-52
Clock AM-FM Stereo Audio Compact Disc (CD) System
................... 3-20
AM-FM Stereo Audio System
................................... 3-11
AM-FM Stereo Audio System
with Cassette Deck ................... 3-14
AM-FM Stereo Audio System with Cassette Deck and Equalizer ........ 3-17
Comfort Controls
................................................. 3-2
ConvenienceNet
................................................ 2-63
Coolant (See “Engine”)
Cooling System Capacity
.......................................... 6-63
Crankcase Capacity
.............................................. 6-63
Cruise Control
.................................................. 2-44
Increasespeed
............................................... 2-46
OnHills
..................................................... 2-48
Passing
..................................................... 2-47
Reducespeed
................................................ 247
Resume
..................................................... 246
Set
......................................................... 2-45
ToGetOutOf
................................................ 2-48
Customer Assistance for the Hearing or Speech Impaired
................. 8-3
Customer Satisfaction Procedure
..................................... 8-2
Daytime Running Lights (Canada Only)
.............................. 2-51
Indicator Light
.......................................... 2-5 1. 2-74
DomeLights
.................................................... 2-52
Doors
.......................................................... 2-5
Locks ........................................................ 2-6
2

Downloaded from www.Manualslib.com manuals search engine Driving Across an Incline
............................................. 4-21
After Off-Road Driving
........................................ 4-24
AtNight
.................................................... 4-24
BackingUp
.................................................. 4-41
Defensive
.................................................... 4-2
Downhill
.................................................... 4-19
Freeway
..................................................... 4-28
Guidelines
................................................... 4-12
Highway Hypnosis
............................................ 4-30
Hydroplaning
................................................ 4-26
InBlizzard
................................................... 4-34
InCity
...................................................... 4-27
In Mud. Sand. Snow. Or Ice
................................ 4-22. 5-32
InRain
...................................................... 4-25
InWater
..................................................... 4-23
LossofControl
............................................... 4-11
Nightvision
................................................. 4-25
Off-Roading
................................................. 4-13
On Hill and Mountain Roads
.................................... 4-30
On Off-Road Hills
............................................ 4-16
OnSnoworIce
............................................... 4-32
Passing
..................................................... 4-10
Skidding
.................................................... 4-12
Stuck
in Deep Snow ...................................... 4-32. 5-32
Throughwater
.......................................... 2-19. 4-23
Uphill
...................................................... 4-17
Winter
...................................................... 4-32
With
a Trailer ................................................ 4-37
DrunkenDriving
................................................. 4-2
Electrical System Accessory Power Outlet
........................................ 2-56
Add-on Equipment
........................................... 6-60
Endgate ........................................................ 2-8
Electric Glass Release ........................................... 2-9
Mounted Spare Tire Carrier
..................................... 2-10
Adding Coolant
.......................................... 5-1 3. 6-24
Aircleaner
.................................................. 6-14
Coolant (Block) Heater
................................. 2-19 3.5, 6-13
Coolant
................................................ 6-23. 6-63
Coolant Temperature Gage
...................................... 2-70
Exhaust ..................................................... 2-29
FanNoise
................................................... 5-18
Identification
................................................. 6-62
Oil (See “Oil”)
Overheating
.................................................. 5-11
RunningWhileParked
......................................... 2-30
Starting
..................................................... 2-17
Equipment, Add-on ............................................. 6-41
Exhaustsystem ................................................. 6-38
Engine
3

Downloaded from www.Manualslib.com manuals search engine FanNoise ...................................................... 5-18
Finish
Filter
Replacement Chart
.......................................... 6-68
Care
........................................................ 6-54
Damage ..................................................... 6-55
Automatic Transmission
........................................ 6-15
Brake
....................................................... 6-29
Capacities
................................................... 6-62
CoolantRecovery
............................................. 5-13
FrontAxle
................................................... 6-22
Leakcheck
.................................................. 6-31
ManualTransmission
.......................................... 6-18
Powersteering
............................................... 6-26
Radiator
..................................................... 5-15
RearAxle
................................................... 6-20
Recommended Fluids
.......................................... 7-13
Transfercase
................................................ 6-21
Windshield Washer ............................................ 6-28
FogLamps
..................................................... 2-50
Four-WheelDrive
.......................................... 2-31, 6-21
Transfer Case
...................................... 2-3 1,2-33, 6-21
FrontAxle
................................................... 6-22
Fuel
........................................................... 6-3
FillingYourTank
.............................................. 6-5
Fluid
Hydraulicclutch
.............................................. 6-20
Foreign Countries
.............................................. 6-4
Gage
....................................................... 2-76
Gasolines for Cleaner Air
........................................ 6-4
Tankcapacity
................................................ 6-63
Fuses and Circuit Breakers
................................... 6-60, 6-66
FuseBlock
.................................................. 6-61
Headlights
.............................................. 6-61, 6-63
Power Windows and Other Power Options
......................... 6-61
Trailer Wiring Harness
......................................... 6-61
Windshield Wipers
............................................ 6-61
Gages
......................................................... 2-76
FuelGage
................................................... 2-76
Odometer ................................................... 2-65
OilPressureGage
............................................. 2-72
Speedometer
................................................. 2-65
Tachometer
.................................................. 2-67
Trip Odometer
................................................ 2-66
Voltmeter
.................................................... 2-77
Coolant Temperature Gage ...................................... 2-70
4