lock CHEVROLET BLAZER 1997 2.G Owners Manual

Downloaded from www.Manualslib.com manuals search engine FuseKircuit Breaker Usage
5
6
7
8
9
10
11
12
13
14
15
Oxygen Sensor Heater, Exhaust Gas
Recirculation, Cam Sensor,
CANN.
Purge, Canister Vent Solenoid, Mass
Airflow Sensor, Cam Shaft Sensor
Blower Motor, Temperature
Door
Motor, HI Blower Relay Coil
Power Auxiliary Outlets, Assembly
Line Diagnostic Link
Rear Window Defogger
PCMNCM Battery,
Fuel Pump
PCM/VCM Ignition, Injectors, Crank
Sensor, Coil Driver Module
Radio, Inside Rearview Mirror Map
Lamp, Overhead Console Reading
Lamps, Rear Wiper, Rear Washer,
Overhead Console Display
Anti-Lock Braking System, VCM
Clock, Radio Battery, CD Player
A/C Compressor Battery Feed
Daytime Running Lamps;
Fog
Lamps, Fog Lamp Relay
IGN-3
FuseKircuit
Breaker
Usage
16
17
18
19
20
21
22
23
24
Turn Signals and Back-up Lamps,
Brake-Transmission Shift Interlock
Solenoid
Windshield Washer, Windshield
Wiper Motor
Not Used
Electric Shift Transfer Case
Crank Relay, Air Bag Module
Not Used
Air Bag Module
Cluster Illumination, Radio
Illumination, Heater Lamp,
4WD
Illumination, Chime Module, Fog
Lamp Illumination, Rear Wiper
Switch Illumination, Rear Defogger
Switch Illumination, Liftglass
Release Switch Illumination,
Overhead Console Illumination
PRNDL Power, 4L6OE Automatic
Transmission
6-61

Downloaded from www.Manualslib.com manuals search engine Short TripKity Maintenance Schedule
The services shown in this schedule up to 100,000 miles
( 166 000 km) should be performed after 100,000 miles
(166 000 km) at the same intervals. The services shown
at
150,000 miles (240 000 km) should be performed at
the same interval after 150,000 miles
(240 000 km).
See “Owner Checks and Services” and “Periodic
Maintenance inspections” following.
Footnotes
? The U.S. Environmental Protection Agency or the
California Air Resources Board has determined that
the
failure to perform this maintenance item will not nullify
the emission warranty or limit recall liability prior
to the
completion of the vehicle’s
useful life. We, however,
urge that all recommended maintenance services
be
performed at the indicated intervals and the maintenance
be recorded.
# Lubricate the front suspension, ball joints, steering
linkage and transfer case shift linkage, parking brake
cable guides, propshaft splines, universal joints and
brake pedal springs.
+ A good time to check your brakes is during tire
rotation. See “Brake System Inspection” under “Periodic Maintenance Inspection” in Part
C of this schedule.
** Drive axle service (see “Recommended Fluids and
Lubricants’’ in
the Index for proper lubricant to use):
0
a
0
Locking Differential -- Drain fluid and refill at first
engine oil change. At subsequent oil changes, check
fluid level and add fluid as needed. If driving in
dusty areas or towing a trailer, drain fluid and refill
every
15,000 miles (25 000 km).
Standard Differential -- Check fluid level and add
fluid
as needed at every oil change. If driving in
dusty areas
or towing a trailer, drain fluid and refill
every
15,000 miles (25 000 km).
More frequent lubrication may be required for
heavy-duty
or off-road use.

Downloaded from www.Manualslib.com manuals search engine The services shown in this schedule up to 100.000 miles
( 166 000 km) should be performed after 100,000 miles
( 166 000 km) at the same intervals. The services shown
at
150.OOO miles (240 000 km) should be performed at
the same interval after 150.0OO miles
(240 000 km ).
See "Owner Checks and Services" and "Periodic
Maintenance Inspections" following.
Footnotes
-f- The U.S. Environmental Protection Agency or the
California Air Resources Board has determined that the
failure to perform this maintenance item.
will not nullify
the emission warranty or limit recall liability prior to the
completion of the vehicle's useful life. We. however.
urge that all recommended maintenance services be
performed at the indicated intervals and the maintenance
be recorded.
# Lubricate the front suspension, ball joints, steering
linkage and transfer case shift linkage. parking brake
cable guides. propshaft splines. universal joints and
brake pedal springs.
+ A good time to check your brakes is during tire
rotation. See "Brake System Inspection" under "Periodic
Maintenance Inspections" in
Part C of this schedule.
** Drive axle service (see "Recommended Fluids and
Lubricants"
in the Index for proper lubricant to use):
Locking Differential -- Drain fluid and refill at first
engine oil change. At subsequent oil changes, check
fluid level and add fluid as needed.
Standard Differential -- Check fluid level and add
fluid as needed
at every engine oil change.
More frequent lubrication may be required for
heavy-duty or off-road use.
7-30

Downloaded from www.Manualslib.com manuals search engine At Least Twice a Year
Restraint System Check
Make sure the safety belt reminder light and all your
belts, buckles, latch plates, retractors and anchorages are
working properly. Look for any other loose or damaged
safety belt system parts. If you see anything that might
keep a safety belt system from doing its job, have it
repaired. Have any torn or frayed safety belts replaced.
Also look for any opened or broken air bag covers, and
have them repaired or replaced. (The air bag system
does not need regular maintenance.)
Wiper Blade Check
Inspect wiper blades for wear or cracking. Replace blade
inserts that appear worn or damaged or that streak
or
miss areas of the windshield. Also see “Wiper Blades,
Cleaning” in the Index.
Manual Transmission Check
Check the transmission fluid level; add if needed. See
“Manual Transmission’’
in the Index. Check for leaks.
A fluid loss may indicate a problem. Have the system
inspected and repaired
if needed.
Automatic Transmission Check
Check the transmission fluid level; add if needed. See
“Automatic Transmission” in the Index. A fluid loss
may indicate a problem. Check the system and repair
if needed.
Hydraulic Clutch System Check
Check the fluid level in the clutch reservoir. See
“Hydraulic Clutch Fluid” in the Index.
A fluid loss in
this system could indicate a problem. Have the system
inspected and repaired at once.
At Least Once a Year
Key Lock Cylinders Service
Lubricate the key lock cylinders with the lubricant
specified
in Part D.
Body Lubrication Service
Lubricate all body door and fuel door hinges, rear
compartment hinges, latches and locks including
the
glove box, console doors and the body hood and any
moving seat hardware. Lubricate
the hood safety lever
pivot and prop rod pivot. Part
D tells you what to use.
More frequent lubrication may be required when
exposed
to a corrosive environment.
7-47

Downloaded from www.Manualslib.com manuals search engine Starter Switch Check
A CAUTION:
When you are doing this check, the vehicle could
move suddenly.
If it does, you or others could be
injured.
Follow the steps below.
1. Before you start, be sure you have enough room
around the vehicle.
2. Firmly apply both the parking brake (see ”Parking
Brake”
in the Index if necessary) and the regular brake
NOTE: Do not use the accelerator pedal. and be
ready to turn
off the engine imnlediately if it starts.
3. On automatic transmission vehicles.
try to start the
engine in each gear. The
starter should work only in
PARK (P) or NEUTRAL (N). If the starter works in
any other position. your vehicle needs service.
On manual transmission vehicles.
put the shift lever
in NEUTRAL (N), push the clutch down halfway
and try
to start the engine. The starter’ shoLlld work
only when the clutch is pushed down all the way to
the floor. If the starter works when the clutch isn’t
pushed all the way down. your vehicle needs service.
Brake-”kansmission Shift Interlock (BTSI) Check
(Automatic Transmission)
I A CAUTION:
When you are doing this check, the vehicle could
move suddenly.
If it does, you or others could be
injured.
Follow the steps below.
’ . Before you start, be sure you have enough room
around the vehicle.
It should be parked on a
level surface.
2. Firmly apply the parking brake (see ”Parking Brake’‘
in the Index if necessary).
NOTE: Be ready to apply the regular brake
immediately
if the vehicle begins to move.
3. With the engine off. turn the key to the RUN
position, but don‘t start the engine. Without applying
the regular brake. try
to move the shift lever out of
PARK (P) with normal effort. If the shift lever
moves out
of PARK (P), your vehicle’s BTSI
needs service.
7-48

Downloaded from www.Manualslib.com manuals search engine Ignition Transmission Lock Check
While parked, and with the parking brake set, try to turn
the ignition key to
LOCK in each shift lever position.
0 With an automatic transmission, the key should turn
to LOCK only when the shift lever is in PARK (P).
LOCK only when the shift lever is in REVERSE (R).
0 With a manual transmission, the key should turn to
On vehicles with a key release button, try
to turn the key
to LOCK without pressing the button. The key should
turn to
LOCK only when you press the key button.
On all vehicles, the key should come out only in LOCK.
Parking Brake and Automatic Transmission
PARK (P) Mechanism Check
I A CAUTION:
~~~~ ~~~~~~~~~~~~~~~~~~~~ ~~
When you are doing this check, your vehicle
could begin to move.
You or others could be
injured and property could be damaged. Make
sure there
is room in front of your vehicle in case
it begins to roll. Be ready to apply the regular
brake at once should the vehicle begin to move.
~ ~~~~____~~~~ ~ ~~ ~
Park on a fairly steep hill, with the vehicle facing
downhill. Keeping your
foot on the regular brake, set the
parking brake.
To check the parking brake’s holding ability:
With
the engine running and transmission in
NEUTRAL (N), slowly remove foot pressure from
the regular brake pedal.
Do this until the vehicle is
held by
the parking brake only.
To check the PARK (P) mechanism’s holding ability:
With
the engine running, shift to PARK (P). Then
release all brakes.
7-49

Downloaded from www.Manualslib.com manuals search engine USAGE
Manual
Transmission Automatic
Transmission
Key Lock
Cylinders
Chassis
Lubrication
Front Wheel Bearings
Differential,
Front and Rear
Axle
FLUIDLUBRICANT
Synchromesh Transmission
Fluid (GM Part No. 12345349
or equivalent).
DEXRON@-I11 Automatic
Transmission Fluid.
Multi-Pu ose lubricant,
Superlube
% (GM Part
No. 12346241 or equivalent).
Chassis lubricant (GM Part
No. 12377985 or equivalent) or
lubricant meeting requirements
of NLGI
# 2, Category LB
or GC-LB.
Wheel bearing lubricant meeting
requirements of NLGI
# 2,
Category GC or GC-LB (GM Part
No. 105 1344
or equivalent).
Axle Lubricant (GM Part
No. 1052271) or
SAE 8OW-90
GL-5 Gear Lubricant.
USAGE
Transfer Case
Windshield
Washer Solvent
Transfer Case Shift Lever,
Propeller Shaft
Slip Splines and
Universal Joints
~ ~~~
Clutch Pushrod
to Clutch Fork
Joint
Constant
Velocity
Universal Joint
FLUIDLUBRICANT
DEXRON@-I11 Automatic
Transmission Fluid.
GM Optikleen@ Washer
Solvent (GM Part No. 10515 15)
or equivalent.
Chassis lubricant
(GM Part
No. 12377985 or,equivalent) or
lubricant meeting requirements
of NLGI ## 2, Category LB
or GC-LB.
Chassis lubricant (GM
Part
No. 12377985 or equivalent) or
lubricant meeting requirements
of NLGI
# 2, Category LB
or GC-LB.
Chassis lubricant (GM Part
No. 12377985 or equivalent) or
lubricant meeting requirements
of NLGI # 2, Category LB
or GC-LB.
7-53

Downloaded from www.Manualslib.com manuals search engine Chevrolet/Geo Roadside
Assistance Program
To enhance Chevrolet’s strong commitment to customer
satisfaction, Chevrolet is excited to announce the
establishment of
the Chevrolet/Geo Roadside Assistance
Center.
As the owner of a 1997 Chevrolet/Geo,
membership
in Roadside Assistance is free. Roadside Assistance
is available 24 hours
a day,
365 days a year, by calling 1-800-CHEV-USA
(1-800-243-8872). This toll-free number will provide
you over-the-phone roadside assistance
with minor
mechanical problems.
If your problem cannot be
resolved over
the phone, our advisors have access to a
nationwide network of dealer recommended service
providers. Roadside membership is free, however some
services may incur costs.
Roadside offers two levels
of service to the customer,
Basic Care and Courtesy” Care:
a
a
a
a
Toll-free number, 1-800-CHEV-USA
Free towing for warranty repairs
Basic over-the-phone technical advice
Available dealer services at reasonable costs (ie.,
wrecker services, locksmith/key service, glass
repair, etc.)

Downloaded from www.Manualslib.com manuals search engine ROADSIDE Courtesy Care PROVIDES:
0 Roadside Basic Care services (as outlined above)
Plus:
FREE Non-Warranty Towing (to the closest dealer
from a legal roadway)
0 FREE LocksrnithKey Service (when keys are lost
on
the road or locked inside)
0 FREE Flat Tire Service (spare installed on the road)
0 FREE Jump Start (at home or on the road)
0 FREE Fuel Delivery ($5 of fuel delivered on
the road) Chevrolet/Geo offers Courtesy Transportation
for
customers needing warranty
service. Courtesy
Transportation
will be offered in conjunction with
the coverage provided by the Bumper
to Bumper
New Vehicle Limited Warranty to eligible purchasers
of 1997 Chevrolet/Geo passenger car and light duty
trucks. (Please see
your selling dealer for details.)
Note:
Colmesy Care is available to Retail and Retail Lease
Customers operating
1997 and newer ChevroletlGeo
vehicles for
a period of 3 years/36,000 miles (60 000 km),
whichever occurs first. All
Corlrtes! Curr services must
be pre-arranged by Chevrolet Roadside or dealer
Service Management.
Basic Cure and Corwtesy Care are not part of or
included
in the coverage provided by the New Vehicle
Limited Warranty. Chevrolet reserves the right
to
modify or discontinue Basic Care and Cmrtesy Ccm
at any time.
8-6

Downloaded from www.Manualslib.com manuals search engine Section 9 Index
Accessory Power Outlets ........................ 2-63
Adding Equipment to the Outside
of Your Vehicle ...... 6-3
Adding Sound Equipment
........................ 3-20
Add-on Equipment ............................. 4-44
AirBag
....................................... 1-20
Adding Equipment ............................ 1-25
How Does it Restrain .......................... 1-23
How it Works
................................ 1-22
Location
.................................... 1-22
Readiness Light
....................... . 1-21. 2-73
Servicing
................................... 1-25
What Makes it Intlate
.......................... 1-23
What
You See After it Inflates ................... 1-24
When Should
it Inflate ......................... 1-23
Aircleaner
.................................... 6-13
Air Conditioning
................................ 3-3
Refrigerants
................................. 6-64
Alignment and Balance, Tire ...................... 6-46
All-Wheel Drive
.......................... 2-23, 6-21
Aluminum Wheels. Cleaning
...................... 6-55
Antenna. Fixed
................................. 3-21
Appearancecare
............................... 6-49
Anti-Lock Brake
System Warning Light
......... 2-76, 4-7
Materials
.................................... 6-57 Arbitration Program
.............................. 8-9
Ashtrays ...................................... 2-61
Audio Systems
.................................. 3-6
Automatic Overdrive
............................ 2-20
Automatic Transmission Check
...................................... 7-47
Fluid
....................................... 6-14
Operation
................................... 2-18
Park Mechanism Check
........................ 7-49
Shifting
..................................... 2-18
Starting Your Engine
.......................... 2-15
Armrest. Storage
............................... 2-56
Axle Front
....................................... 6-22
Rear
....................................... 6-20
Backglass Wipers.
Blade Replacement ............. 6-40
Battery ....................................... 6-32
ChargeLight
................................ 2-73
Jump Starting
................................. 5-3
Replacement. Keyless Entry
..................... 2-7
Warnings
................................ 5-3. 5-5
BBB Auto Line
................................. 8-9
Better Business Bureau Mediation
................... 8-9
9-1