automatic transmission CHEVROLET BLAZER 2003 2.G Workshop Manual
[x] Cancel search | Manufacturer: CHEVROLET, Model Year: 2003, Model line: BLAZER, Model: CHEVROLET BLAZER 2003 2.GPages: 420, PDF Size: 2.94 MB
Page 381 of 420

100,000 Miles (166 000 km)
qInspect spark plug wires.An Emission Control
Service.
qReplace spark plugs.An Emission Control Service.
qIf you haven't used your vehicle under severe service
conditions listed previously and, therefore, haven't
changed your automatic transmission ¯uid, change
both the ¯uid and ®lter. Manual transmission
¯uid doesn't require change.
qAutomatic Transfer Case Only: Change transfer case
¯uid.
qInspect Positive Crankcase Ventilation (PCV) valve.
An Emission Control Service.
150,000 Miles (240 000 km)
qDrain, ¯ush and re®ll cooling system (or every
60 months since last service, whichever occurs ®rst).
See
Engine Coolant on page 5-22for what to use.
Inspect hoses. Clean radiator, condenser, pressure
cap and neck. Pressure test the cooling system
and pressure cap.
An Emission Control Service.
qInspect engine accessory drive belt.An Emission
Control Service.
6-25
Page 384 of 420

Manual Transmission Check
Check the transmission ¯uid level; add if needed. SeeManual Transmission Fluid on page 5-20. Check
for leaks. A ¯uid leak is the only reason for ¯uid loss.
Have the system inspected and repaired if needed.
Automatic Transmission Check
Check the transmission ¯uid level; add if needed. SeeAutomatic Transmission Fluid on page 5-17. A ¯uid loss
may indicate a problem. Check the system and repair
if needed.
Hydraulic Clutch System Check
Check the ¯uid level in the clutch reservoir. SeeHydraulic Clutch on page 5-21.
A ¯uid loss in this system could indicate a problem.
Have the system inspected and repaired at once.
At Least Once a Year
Key Lock Cylinders Service
Lubricate the key lock cylinders with the lubricant
speci®ed in Part D.
Body Lubrication Service
Lubricate all hood hinges, hood latch assembly,
secondary latch, pivots, spring anchor, release pawl,
door hinges, fuel door hinge, endgate hinges, outer
tailgate handle pivot points, tailgate hinges, tailgate
mounted spare tire (if equipped), glove box and console
doors, moving seat hardware and folding seat
hardware. Part D tells you what to use. More frequent
lubrication may be required when exposed to a corrosive
environment.
Starter Switch Check
{CAUTION:
When you are doing this check, the vehicle
could move suddenly. If it does, you or others
could be injured. Follow the steps below.
1. Before you start, be sure you have enough room
around the vehicle.
2. Firmly apply both the parking brake and the regular
brake. See
Parking Brake on page 2-34if
necessary.
Do not use the accelerator pedal, and be ready to
turn off the engine immediately if it starts.
6-28
Page 385 of 420

3. On automatic transmission vehicles, try to start the
engine in each gear. The starter should work only
in PARK (P) or NEUTRAL (N). If the starter works in
any other position, your vehicle needs service.
On manual transmission vehicles, put the shift lever
in NEUTRAL (N), push the clutch down halfway
and try to start the engine. The starter should work
only when the clutch is pushed down all the way
to the ¯oor. If the starter works when the clutch isn't
pushed all the way down, your vehicle needs
service.
Automatic Transmission Shift Lock
Control System Check
{CAUTION:
When you are doing this check, the vehicle
could move suddenly. If it does, you or others
could be injured. Follow the steps below.
1. Before you start, be sure you have enough room
around the vehicle. It should be parked on a level
surface.2. Firmly apply the parking brake, See
Parking Brake
on page 2-34if necessary.
Be ready to apply the regular brake immediately if
the vehicle begins to move.
3. With the engine off, turn the key to the RUN
position, but don't start the engine. Without applying
the regular brake, try to move the shift lever out
of PARK (P) with normal effort. If the shift lever
moves out of PARK (P), your vehicle needs service.
Ignition Transmission Lock Check
While parked, and with the parking brake set, try to turn
the ignition key to LOCK in each shift lever position.
·With an automatic transmission, the key should turn
to LOCK only when the shift lever is in PARK (P).
·With a manual transmission, the key should turn to
LOCK only when you press the key release button.
On all vehicles, the key should come out only in LOCK.
6-29
Page 386 of 420

Parking Brake and Automatic
Transmission Park (P) Mechanism
Check
{CAUTION:
When you are doing this check, your vehicle
could begin to move. You or others could be
injured and property could be damaged. Make
sure there is room in front of your vehicle in
case it begins to roll. Be ready to apply the
regular brake at once should the vehicle begin
to move.Park on a fairly steep hill, with the vehicle facing
downhill. Keeping your foot on the regular brake, set the
parking brake.
·To check the parking brake's holding ability: With
the engine running and transmission in NEUTRAL
(N), slowly remove foot pressure form the regular
brake pedal. Do this until the vehicle is held by the
parking brake only.
·To check the PARK (P) mechanism's holding
ability: With the engine running, shift to PARK (P).
Then release the parking brake followed by the
regular brake.
Underbody Flushing Service
At least every spring, use plain water to ¯ush any
corrosive materials from the underbody. Take care to
clean thoroughly any areas where mud and other debris
can collect.
6-30
Page 389 of 420

Part D: Recommended Fluids and
Lubricants
Fluids and lubricants identi®ed below by name, part
number or speci®cation may be obtained from your
dealer.
Usage Fluid/Lubricant
Engine OilEngine oil with the American
Petroleum Institute Certi®ed for
Gasoline Engines starburst symbol
of the proper viscosity. To determine
the preferred viscosity for your
vehicle's engine, see
Engine Oil on
page 5-11.
Engine Coolant50/50 mixture of clean, drinkable
water and use only
DEX-COOL
žCoolant. SeeEngine
Coolant on page 5-22.
Hydraulic Brake
SystemDelco Supreme 11 Brake Fluid or
equivalent DOT-3 brake ¯uid.
Windshield
Washer SolventGM Optikleen
žWasher Solvent or
equivalent.
Hydraulic
Clutch SystemHydraulic Clutch Fluid (GM Part No.
U.S. 12345347, in Canada
10953517, or equivalent DOT-3
brake ¯uid).
Usage Fluid/Lubricant
Parking Brake
Cable GuidesChassis Lubricant (GM Part No.
U.S. 12377985, in Canada
88901242, or equivalent) or lubricant
meeting requirements of NLGI #2,
Category LB or GC-LB.
Power Steering
SystemGM Power Steering Fluid (GM Part
No. U.S. 1052884, in Canada
993294, or equivalent).
Manual
TransmissionSynchromesh Transmission Fluid
(GM Part No. U.S. 12345349, in
Canada 10953465, or equivalent).
Automatic
TransmissionDEXRON
ž-III Automatic
Transmission Fluid.
Key Lock
CylindersMulit-Purpose Lubricant, Superlube
(GM Part No. U.S. 12346241, in
Canada 10953474, or equivalent).
Chassis
LubricationChassis Lubricant (GM Part No.
U.S. 12377985, in Canada
88901242, or equivalent) or lubricant
meeting requirements of NLGI #2,
Category LB or GC-LB.
Front and Rear
Axle (Standard
Differential)SAE 80W-90 Axle Lubricant (GM
Part No. U.S. 1052271, in Canada
10950849, or equivalent).
Rear Axle
(Locking
Differential)Axle Lubricant; use only GM Part
No. U.S. 1052271, in Canada
10950849.
Do not add friction
modi®er.
6-33
Page 390 of 420

Usage Fluid/Lubricant
Electronic
Transfer CaseDEXRONž-III Automatic
Transmission Fluid.
Automatic
Transfer CaseAUTO-TRAK II Fluid (GM Part No.
U.S. 12378508, in Canada
10953626).
Rear Driveline
Center Spline
and Universal
JointsChassis Lubricant (GM Part No.
U.S. 12377985, in Canada
88901242, or equivalent) or lubricant
meeting requirements of NLGI #2,
Category LB or GC-LB.
Constant
Velocity
Universal JointChassis Lubricant (GM Part No.
U.S. 12377985, in Canada
88901242, or equivalent) or lubricant
meeting requirements of NLGI #2,
Category LB or GC-LB.
Clutch Pushrod
to Clutch Fork
JointChassis Lubricant (GM Part No.
U.S. 12377985, in Canada
88901242, or equivalent) or lubricant
meeting requirements of NLGI #2,
Category LB or GC-LB.
Hood Latch
Assembly,
Secondary
Latch, Pivots,
Spring Anchor
and Release
PawlLubriplate Lubricant Aerosol (GM
Part No. U.S. 12346293, in Canada
992723, or equivalent) or lubricant
meeting requirements of NLGI #2,
Category LB or GC-LB.
Usage Fluid/Lubricant
Hood and Door
HingesMulti-Purpose Lubricant, Superlube
(GM Part No. U.S. 12346241, in
Canada 10953474, or equivalent).
Tailgate
Mounted Spare
Tire Carrier (if
equipped),
Outer Tailgate
Handle Pivot
Points and
HingesMulti-Purpose Lubricant, Superlube
(GM Part No. U.S. 12346241, in
Canada 10953474, or equivalent).
Weatherstrip
ConditioningDielectric Silicone Grease (GM Part
No. U.S. 12345579, in Canada
10953014, or equivalent).
Weatherstrip
SqueaksSynthetic Grease with Te¯on,
Superlube (GM Part No. U.S.
12371287, in Canada 10953437, or
equivalent).
6-34
Page 406 of 420

Audio System(s) (cont.)
Automatic Headlamp System............................3-11
Automatic Transfer Case..................................2-31
Automatic Transmission Check..........................6-28
Automatic Transmission Shift Lock Control
System Check.............................................6-29
Automatic Transmission...................................2-21
Fluid..........................................................5-17
Operation...................................................2-23
B
Backing Up....................................................4-61
Battery Replacement......................................... 2-6
Battery Run-Down Protection............................3-15
Battery..........................................................5-40
Before Leaving on a Long Trip.........................4-35
Before You Go Off-Roading..............................4-16
Body Lubrication Service..................................6-28
Brake Adjustment............................................5-39
Brake Fluid....................................................5-37
Brake Pedal Travel.........................................5-39
Brake Wear...................................................5-39
Brake............................................................2-34
Parking......................................................2-34
System Inspection.......................................6-32
System Warning Light..................................3-28
Brakes..........................................................5-37
Braking in Emergencies...................................4-10Braking........................................................... 4-8
Break-In, New Vehicle.....................................2-19
Bulb Replacement...........................................5-47
Halogen Bulbs............................................5-47
Headlamps.................................................5-48
One-Piece Front Turn Signal Lamps...............5-50
Replacement Bulbs......................................5-52
Taillamps....................................................5-51
Two-Piece Front Turn Signal Lamps...............5-50
Buying New Tires...........................................5-58C
California Fuel.................................................. 5-5
Canada ± Customer Assistance.......................... 7-5
Canadian Owners................................................ ii
Canadian Roadside Assistance........................... 7-8
Capacities and Speci®cations............................5-91
Capacities......................................................5-91
Carbon Monoxide...........................4-38, 4-54, 2-39
Care of.........................................................5-78
Safety Belts................................................5-78
Your Cassette Tape Player............................3-69
Your CD Player...........................................3-70
Your CDs ...................................................3-70
Cargo Cover..................................................2-58
Cargo Tie-Downs............................................2-58
Cassette Tape Messages.................................3-55
Cassette Tape Player Service...........................6-27
2
Page 410 of 420

F
Filter.............................................................5-15
Engine Air Cleaner......................................5-15
Finding a PTY Station.....................3-44, 3-51, 3-61
Finding a Station....................3-39, 3-41, 3-49, 3-58
Finish Care....................................................5-79
Finish Damage...............................................5-81
Five-Speed....................................................2-27
Fixed Mast Antenna........................................3-70
Flash-to-Pass Feature....................................... 3-6
Flat Tire, Changing.........................................5-63
Flat Tire........................................................5-62
Fluid.............................................................5-17
Automatic Transmission................................5-17
Manual Transmission....................................5-20
Power Steering...........................................5-35
Windshield Washer......................................5-36
FM ...............................................................3-69
Fog Lamps....................................................3-13
Following Distance..........................................4-61
Four Door Models...........................1-27, 1-29, 1-51
Four-Wheel Drive....................................2-28, 5-45
Front Axle......................................................5-46
Front Map Lamps...........................................3-14
Front Reading Lamps......................................3-14
Front Storage Area.........................................2-55
Fuel............................................................... 5-4
Additives...................................................... 5-5
California Fuel.............................................. 5-5Fuel (cont.)
Filling a Portable Fuel Container..................... 5-8
Filling Your Tank........................................... 5-6
Fuels in Foreign Countries.............................. 5-6
Gage.........................................................3-35
Gasoline Octane........................................... 5-4
Gasoline Speci®cations.................................. 5-5
Low Warning Light.......................................3-36
System Inspection.......................................6-31
Fuses...........................................................5-85
Fuses and Circuit Breakers...........................5-85
Windshield Wiper.........................................5-85
G
Gage............................................................3-35
Check Gages Warning Light..........................3-35
Engine Coolant Temperature.........................3-29
Fuel..........................................................3-35
Oil Pressure...............................................3-33
Speedometer..............................................3-24
Tachometer.................................................3-24
Voltmeter Gage...........................................3-27
Garage Door Opener.......................................2-44
Garment Hooks..............................................2-56
Gasoline......................................................... 5-4
Octane........................................................ 5-4
Speci®cations............................................... 5-5
Gate Ajar Light...............................................3-35
6
Page 414 of 420

Maintenance Schedule (cont.)
Using Your................................................... 6-4
Your Vehicle and the Environment................... 6-2
Maintenance When Trailer Towing.....................4-64
Making Turns.................................................4-61
Malfunction Indicator Light................................3-30
Manual Lumbar Controls.................................... 1-4
Manual Seats................................................... 1-2
Manual Transmission Check.............................6-28
Manual Transmission.......................................2-21
Fluid..........................................................5-20
Operation...................................................2-27
Matching Transmitter(s) to Your Vehicle............... 2-6
Memory Seat.................................................2-61
Mexico, Central America and Caribbean Islands/
Countries (Except Puerto Rico and U.S. Virgin
Islands) ± Customer Assistance....................... 7-5
Mirrors..........................................................2-41
Automatic Dimming Rearview........................2-41
Manual Rearview Mirror................................2-41
Outside Automatic Dimming Mirror.................2-43
Outside Convex Mirror.................................2-43
Outside Heated Mirrors................................2-43
Outside Manual Mirror..................................2-42
Outside Power Mirrors..................................2-42
Model Reference................................................ vi
MyGMLink.com................................................ 7-4N
New Vehicle Break-In......................................2-19
Normal Maintenance Replacement Parts............5-92
O
Odometer, Trip...............................................3-24
Odometer......................................................3-24
Off-Road Recovery..........................................4-12
Oil ................................................................5-11
Engine.......................................................5-11
Pressure Gage............................................3-33
Older Children, Restraints................................1-32
Online Owner Center........................................ 7-4
Operating Your All-Wheel-Drive Vehicle Off
Paved Roads..............................................4-15
Other Warning Devices...................................... 3-4
Outlet Adjustment............................................3-20
Outside.........................................................2-43
Automatic Dimming Mirror.............................2-43
Convex Mirror.............................................2-43
Heated Mirrors............................................2-43
Manual Mirror.............................................2-42
Power Mirrors.............................................2-42
Overhead Console..........................................2-48
Overseas ± Customer Assistance........................ 7-5
Owners, Canadian............................................... ii
Owner's Information........................................7-12
10
Page 415 of 420

P
Park (P)........................................................2-35
Shifting Into................................................2-35
Shifting Out of............................................2-37
Parking Brake and Automatic Transmission
Park (P) Mechanism Check...........................6-30
Parking on Hills..............................................4-63
Parking Your Vehicle.......................................2-38
Parking.........................................................2-34
Brake........................................................2-34
Over Things That Burn.................................2-38
Part A - Scheduled Maintenance Services............ 6-4
Part B - Owner Checks and Services................6-26
Part C - Periodic MaintenanceInspections..........6-31
Part D - Recommended Fluids and Lubricants....6-33
Part E - Maintenance Record...........................6-35
Passing.................................................4-13, 4-61
Passlock
ž......................................................2-18
Payload.........................................................4-54
Plan Ahead When Possible................................ 7-8
Playing a Cassette Tape..................................3-53
Playing a Compact Disc..................3-46, 3-55, 3-63
Playing a Speci®c Loaded
Compact Disc.............................................3-64
Playing the Radio...................3-38, 3-41, 3-48, 3-58
Power Steering...............................................4-10
Power...........................................................3-15
Accessory Outlets........................................3-15
Door Locks.................................................. 2-8Power (cont.)
Electrical System.........................................5-85
Lumbar Controls........................................... 1-4
Seat............................................................ 1-3
Steering Fluid.............................................5-35
Windows....................................................2-12
Programmable Automatic Door Locks.................. 2-8
Programming the HomeLink Transmitter.............2-45
Q
Questions and Answers About Safety Belts.........1-13
R
Radiator Pressure Cap....................................5-25
Radio Messages.............................3-40, 3-45, 3-53
Radios..........................................................3-37
AM-FM Radio.............................................3-38
Care of Your Cassette Tape Player................3-69
Care of Your CD Player...............................3-70
Care of Your CDs........................................3-70
Radio with Cassette and CD.........................3-48
Radio with CD............................................3-41
Radio with Six-Disc CD................................3-58
Setting the Time for Radios with Radio Data
Systems (RDS)........................................3-38
Setting the Time for Radios without Radio
Data Systems (RDS)................................3-37
11