maintenance schedule CHEVROLET CAMARO 1993 Owner's Manual

Maintenance Schedule
aection A: Scheduled Maintenance Services (Cont.)
ITEM
NO. SERVICE
6 Transmission Service - For manual transmissions,
fluid doesn’t require changing.
For automatic transmissions, change both the fluid
and filter every
15,000 miles (25 OOO km) if the
vehicle is mainly driven under one
or more of these
conditions:
ITEM
NO. SERVICE
If you do not use your vehicle under any of these
conditions, change both the fluid and filter every
100,OOO miles (160 O00 km).
7 Spark Plug Replacement* - Replace spark plugs
with the proper type. See “Replacement Parts” in
the Index.
burns, cracks or other damage. Check
the boot fit at
the distributor and at
the spark plugs. Replace wires
as needed.
8 Spark Plug Wire Inspection** - Inspect for In heavy city traffic where the outside
temperature regularly reaches
90°F (32°C) or
higher.
In hilly or mountainous terrain.
When doing frequent trailer towing.
Uses such as found in taxi, police car or delivery
service.
*An Emission Control Service.
The
U. 5’. Environmental Protection Agency has determined that the failure to perform this maintenance item will not nullify the emission
warranty or limit recall liability prior to the completion
of vehicle useful life. General Motors, however, urges that all recommended
maintenance services be performed at the indicated intervals and the maintenance be recorded in “Section
E: Maintenance Record. ”
= 296
ProCarManuals.com

Maintenance Schedule
Section B: Owner Checks and Services
Listed below are owner checks and services which should be
performed at the intervals specified to help ensure the
safety, dependability and emission control performance
of
your vehicle. Be
sure any necessary repairs are completed at once.
Whenever any fluids or lubricants are added to your vehicle,
make sure they are the proper ones, as shown in Section
D.
At Each Fuel Fill (/t is important for you or a service station 8ttend8nt to perform these underhood checks a\
t each fuel fili.)
CHECK
OR SERVICE WHAT TO DO
J
Engine Oil Level
necessary. See “Windshield Washer Fluid”
in the Index for further details.
Fluid Level Check the
windshield washer fluid level
in the windshield washer tank and add the proper fluid if Windshield Washer necessary. See “Coolant”
in the Index
for further details.
Level Check
the engine coolant
level in the coolant recovery tank and add the proper coolant mix if
Engine Coolant Check the engine
oil level and add the proper oil if necessary. See “Engine Oil”
in the Index for
further details.
ProCarManuals.com

Maintenance Schedule
Section B: Owner Checks and Services (Cont.)
At lead Once a Year
CHECK
OR SERVICE WHAT TO DO
Lubricate the key lock cylinders with the lubricant specified in Section D.
Lubricate all body door hinges, including the hatchback lid. Al\
so lubricate all hinges and latches,
including those for the hood, rear compartment, console doors a\
nd
any folding seat hardware.
Section
D tells you what to use.
’.
1. Before you start, be sure you have enough room around tne vehicle.
2. Firmly apply both the parking brake (see “Parking Brake” \
in the Index if necessary) and
NOTE: Do not use the accelerator pedal, and be ready to turn off the engin\
e immediately if it
starts.
3. On automatic transmission vehicles, try to start the engine in each gear. The starter should
the regular brake.
work
only in P (Park) or N (Neutral). If the starter works in any other position, your
vehicle needs service.
On manual transmission vehicles, put the shift lever
in Neutral, push the clutch down
halfway and try to start
the engine. The starter should work only when the clutch is pushed
down all
the way to the floor. If the starter works when the clutch isn’t pushed all the way
down. your vehicle needs service.
... 300
ProCarManuals.com

Maintenance Schedule
Section C: Periodic Maintenance Inspections
Listed below are inspections and services which should be
performed at least twice a year (for instance, each spring
and fall). You should let your
GM dealer’s service department
or other qualified service center do these jobs.
Make sure any necessary repairs are completed at once.
INSPECTION
OR SERVICE I WHAT SHOULD BE DONE
Steering and Suspension Inspect the front and rear suspension and steering system for damaged, loose or missing parts,
Inspection signs
of wear, or lack of lubrication. Inspect the power steering lines and hoses for proper
hookup, binding, leaks, cracks, chafing, etc.
Exhaust System
Inspection Inspect the complete exhaust
system. Inspect the body near the exhaust system.
Look for broken,
damaged, missing or out-of-position parts as well as open seams, holes, loose connections, or
other conditions which could cause a heat build-up in the floor pan or could ].et exhaust fumes
into the vehicle. See “Engine Exhaust’’
in the Index.
Throttle Linkage Inspect the throttle linkage for interference or binding, and for damaged or missing parts.
Inspection Replace parts as needed.
I 303
ProCarManuals.com

Maintenance Schedule
Section C: Periodic Maintenance Inspections (Cont.)
INSPECTION
OR SERVICE
Rear Axle Service
Brake System Inspection
WHAT SHOULD BE DONE
Check the gear lubricant level in the rear axle and add if needed. See “Rear Axle” in the Index. A
fluid
loss in this system may indicate a problem. Check the system and repair it if needed. If your
vehicle
is used to pull a trailer, change the gear lubricant every 7,500 miles (12 500 km).
Inspect the complete system. Inspect brake lines and hoses for proper hookup, binding, leaks, cracks,
chafing, etc. Inspect disc brake pads for wear and rotors for surface condition. Also inspect drum
brake linings for wear and cracks. Inspect other brake parts, including drums, wheel cylinders,
calipers, parking brake, etc. The parking brake is self-adjusting and no manual adjustment is
required. You may need to have your brakes inspected more often if your driving habits or conditions
result in frequent braking.
NOTE: A low brake fluid level can indicate worn disc brake pads which may need to be serviced.
Also, if the brake system warning light stays on
or comes on, something may be wrong with the
brake system. See “Brake System Warning Light” in
the Index. If your anti-lock brake system
warning light stays on, comes on or flashes, something may be wrong with the anti-lock brake
system. See “Anti-Lock Brake System Warning Light” in
the Index.
~~
. * 304
ProCarManuals.com

Maintenance Schedule
Section D: Recommended Fluids & Lubricants
NOTE: Fluids and lubricants identified below by name, part number or specification may be obtained from your GM dealer.
USAGE FLUIWLUBRICANT
Engine Oil
proper viscosity. The
SG designation may be shown alone or in combination with others, such as
GM
Goodwrench Motor Oil or equivalent for API service SG Energy Conserving I1 oils
of the
SGKC, SGKD, or SF, SG, CC, etc. To determine the preferred viscosity for your vehicle’s
engine, see “Engine Oil”
in the Index.
(GM Part
No. 1052753) conforming to GM Specification 1825M or approved recycled coolant
conforming to GM Specification
1825M.
Engine Coolant 50/50 mixture of water (preferably distilled) and good quality ethylene glycol base antifreeze
Hydraulic Brake System Delco-Supreme
11 Brake Fluid (GM Part No. 1052535) or equivalent DOT-3 Brake Fluid.
Hydraulic Clutch Fluid (GM Part
No. 12345347) or equivalent.
Hydraulic Clutch
System
Power Steering System GM
Hydraulic Power Steering Fluid (GM Part No.
1052884) or equivalent.
Manual Transmission DEXRONm-IIE Automatic Transmission Fluid
(GM Part No. 12345881).
Automatic Transmission DEXRONB-IIE Automatic Transmission Fluid
(GM Part No. 1234588 1).
ProCarManuals.com

Maintenance Schedule
Section D: Recommended Fluids & Lubricants (Cont.)
~- ~
USAGE
Key Lock Cylinders
Automatic Transmission
Shift Linkage
Clutch Linkage Pivot
Points
Floor Shift Linkage
Chassis Lubrication
Windshield Washer
Solvent
Windshield
& Wiper
Blades
I
FLUID/LUBRICANT
Lubricate with Multi-Purpose Lubricant (GM Part No. 12345120) or synthetic SAE 5W-30 engine
oil or silicone lubricant
(GM Part No. 1052276 or 1052277).
Engine Oil.
Engine Oil.
Engine Oil.
Chassis lubricant meeting requirements
of NLGI Grade 2, Category LI~ or OC-LB (GM Part No.
1052497) or equivalent.
GM Optikleen@ Washer Solvent (GM Part
No. 1051515) or equivalent.
Clean with Bon-Ami Powder@
(GM Part No. 105001 1).
ProCarManuals.com

Maintenance Schedule
Section E: Maintenance Record
After the scheduled services are performed, record the date, or Schedule I1 maintenance charts which correspond to the
odometer reading and who performed the service in the
maintenance performed. Also,
you should retain all
columns indicated. When completing the Maintenance maintenance receipts.
Your owner information portfolio is a
Performed column, insert the numbers from the Schedule
I convenient place to store them.
... 308
DATE ODOMETER
READING SERVICED BY MAINTENANCE PERFORMED
ProCarManuals.com

Maintenance Schedule
Section E: Maintenance Record (Cant.)
DATE ODOMETER
READING SERVICED BY MAINTENANCE PERFORMED
'310
ProCarManuals.com

Maintenance Schedule
Section E: Maintenance Record (Cont.)
I DATE I ODOMETER I READING SERVICED BY I MAINTENANCE PERFORMED
... 31 2
ProCarManuals.com