service CHEVROLET CAMARO 1993 Manual PDF

The services shown in this schedule up to 48,000 miles (80 000 km) should be
rformed after 48,000 miles at the same intervals.
ProCarManuals.com

Maintenance Schedule
Section A: Scheduled Maintenance Services (Cont.)
Schedule I1
Follow Schedule II ONLY if none of
the driving conditions specified in
Schedule I apply.
*An Emission Control Service.
r?r ne U. S. Environmental Protection Agency
has determined that the failure
to per$orm
this maintenance item will not nullify the
emission warranty or limit recall liability
prior
to the completion of vehicle usejid
life. General Motors, however, urges that
all recommended maintenance services be
per$omd at the indicated intervals and
the maintenance be recorded in “Section E:
Maintenance Record. ’’
292
ITEM
NO.
2
4
6
a
10
WHAT TO SERVICE
See “Explanation of Scheduled Maintenance
Services” following Schedules
I and II.
WHEN TO PERFORM
Miles (kilometers) or Months (whichever occurs first).
Transmission Service
I
See “Explanation of Scheduled Maintenance
Services” following Schedules
I and II.
ProCarManuals.com

The services shown in this schedule up to 45,000 miles (75 O00 km) should be
performed after
45,000 miles at the same intervals.
MILES (000)
7.5 I 15 I 22.5 I 30 I 37.5 1 45
KILOMETERS f000)
I I 1 I I e
293 9
ProCarManuals.com

Maintenance Schedule
Section A: Scheduled Maintenance Services (Cont.)
Eirplanation of Scheduled Maintenance Semices
Below are explanations of the services listed in Schedule I
and Schedule 11.
The proper fluids and lubricants
to use are listed in Section
D. Make sure whoever services your vehicle uses these. All
ITEM
NO. SERVICE
1 Engine Oil and Filter Change* - Always use SG
Energy Conserving I1 oils of proper viscosity. The
SG designation may be shown alone or in
combination with others, such as
SGKC, SG/CD,
or SF, SG, CC, etc. To determine the preferred
viscosity for your vehicle’s engine (e.g., SAE
5W-30 or 10W-30), see “Engine Oil” in the Index.
2 Chassis Lubrication - If your vehicle is equipped
with grease fittings, lubricate the suspension and
steering linkage. Lubricate the transmission shift
linkage. parts should be replaced and all necessary repairs done
before
you or anyone else drives the vehicle.
NOTE: To determine your engine’s displacement and code, see ‘‘Engine Identification” in the Index.
ITEM
NO. SERVICE
3 Tire and Wheel Rotation and Inspection - For
proper wear and maximum tire life, rotate your tires
following the instructions in this manual. See “Tires, Inspection and Rotation’’
in the Index.
Check the tires for uneven wear or damage. If
you
see irregular or premature wear, check the wheel
alignment. Check for damaged wheels also.
Inspect the belt for cracks, fraying, wear and proper
tension. Replace
as needed.
4 Engine Accessory Drive Belt Inspection* -
I
*An Emission Control Service.
9 294
ProCarManuals.com

ITEM
NO. SERVICE
5 Cooling System Service* - Drain, flush and refill
the system with new or approved recycled coolant
conforming to
GM Specification 1825M. Keep
coolant at the proper mixture as specified. See
“Coolant”
in the Index. This provides proper freeze
protection, corrosion inhibitor level and engine
operating temperature.
*An Emission Control Service.
ITEM
NO. SERVICE
Inspect hoses and replace if they are cracked,
swollen or deteriorated. Tighten screw-type hose
clamps. Clean the outside of the radiator and air
conditioning condenser. Wash the pressure cap and
neck.
To help ensure proper operation, we recommend a
pressure test
of both the cooling system and the
pressure cap.
295
ProCarManuals.com

Maintenance Schedule
aection A: Scheduled Maintenance Services (Cont.)
ITEM
NO. SERVICE
6 Transmission Service - For manual transmissions,
fluid doesn’t require changing.
For automatic transmissions, change both the fluid
and filter every
15,000 miles (25 OOO km) if the
vehicle is mainly driven under one
or more of these
conditions:
ITEM
NO. SERVICE
If you do not use your vehicle under any of these
conditions, change both the fluid and filter every
100,OOO miles (160 O00 km).
7 Spark Plug Replacement* - Replace spark plugs
with the proper type. See “Replacement Parts” in
the Index.
burns, cracks or other damage. Check
the boot fit at
the distributor and at
the spark plugs. Replace wires
as needed.
8 Spark Plug Wire Inspection** - Inspect for In heavy city traffic where the outside
temperature regularly reaches
90°F (32°C) or
higher.
In hilly or mountainous terrain.
When doing frequent trailer towing.
Uses such as found in taxi, police car or delivery
service.
*An Emission Control Service.
The
U. 5’. Environmental Protection Agency has determined that the failure to perform this maintenance item will not nullify the emission
warranty or limit recall liability prior to the completion
of vehicle useful life. General Motors, however, urges that all recommended
maintenance services be performed at the indicated intervals and the maintenance be recorded in “Section
E: Maintenance Record. ”
= 296
ProCarManuals.com

ITEM
NO. SERVICE
9 Air Cleaner Filter and Crankcase Ventilation
Filter Replacement*
- Replace every 30,000 miles
(50 OOO km) or more often under dusty conditions.
Ask your dealer for the proper replacement intervals
for your driving conditions.
ITEM
NO. SERVICE
10 Fuel Tank, Cap and Lines Inspections** -
Inspect fuel tank, cap and lines (including fuel rails
and injection assembly,
if equipped) for damage or
leaks. Inspect fuel cap gasket for an even filler neck
imprint or any damage. Replace parts as needed.
Periodic replacement of
the fuel filter is not
required.
*An Emission Control Service.
fr The U.S. Environmental Protection Agency has determined that the failure to per$orm this maintenance item will not nullify the emission
warranty
or limit recall liability prior to the completion of vehicle useful life. General Motors, however, urges that all recommended
maintenance services be per$ormed
at the indicated intervals and the maintenance be recorded in “Section E: Maintenance Record. ’’
ProCarManuals.com

Maintenance Schedule
Section B: Owner Checks and Services
Listed below are owner checks and services which should be
performed at the intervals specified to help ensure the
safety, dependability and emission control performance
of
your vehicle. Be
sure any necessary repairs are completed at once.
Whenever any fluids or lubricants are added to your vehicle,
make sure they are the proper ones, as shown in Section
D.
At Each Fuel Fill (/t is important for you or a service station 8ttend8nt to perform these underhood checks a\
t each fuel fili.)
CHECK
OR SERVICE WHAT TO DO
J
Engine Oil Level
necessary. See “Windshield Washer Fluid”
in the Index for further details.
Fluid Level Check the
windshield washer fluid level
in the windshield washer tank and add the proper fluid if Windshield Washer necessary. See “Coolant”
in the Index
for further details.
Level Check
the engine coolant
level in the coolant recovery tank and add the proper coolant mix if
Engine Coolant Check the engine
oil level and add the proper oil if necessary. See “Engine Oil”
in the Index for
further details.
ProCarManuals.com

At least Once a Month
CHECK
OR SERVICE I WHAT TO DO
Tire Inflation Check tire inflation. Make sure they are inflated to the pressures specified on the Tire-Loading
Information label located on the rear edge
of the driver’s door. See “Tires” in the Index for
further details.
At least Twice a Year
CHECK
I OR SERVICE I WHAT TO DO
Hydraulic Clutch Check the fluid level in the clutch reservoir. See “Hydraulic Clutch Fluid” in the Index. A fluid
System Inspection loss in this system could indicate a problem. Have the system inspected and repaired at once.
ProCarManuals.com

Maintenance Schedule
Section B: Owner Checks and Services (Cont.)
At lead Once a Year
CHECK
OR SERVICE WHAT TO DO
Lubricate the key lock cylinders with the lubricant specified in Section D.
Lubricate all body door hinges, including the hatchback lid. Al\
so lubricate all hinges and latches,
including those for the hood, rear compartment, console doors a\
nd
any folding seat hardware.
Section
D tells you what to use.
’.
1. Before you start, be sure you have enough room around tne vehicle.
2. Firmly apply both the parking brake (see “Parking Brake” \
in the Index if necessary) and
NOTE: Do not use the accelerator pedal, and be ready to turn off the engin\
e immediately if it
starts.
3. On automatic transmission vehicles, try to start the engine in each gear. The starter should
the regular brake.
work
only in P (Park) or N (Neutral). If the starter works in any other position, your
vehicle needs service.
On manual transmission vehicles, put the shift lever
in Neutral, push the clutch down
halfway and try to start
the engine. The starter should work only when the clutch is pushed
down all
the way to the floor. If the starter works when the clutch isn’t pushed all the way
down. your vehicle needs service.
... 300
ProCarManuals.com