light CHEVROLET CAMARO 1995 4.G Repair Manual

Downloaded from www.Manualslib.com manuals search engine 5. Now adjust the vertical aim. Check the vertical aim
for each headlamp and adjust it as necessary.
6. Turn the vertical aiming screw until the bubble in the
7. If the gage readings are not centered, repeat steps 2
Try not to touch threaded parts other than the vertical
and horizontal aiming screws.
level
is centered at 0 (zero).
and
3.
To Replace a Headlamp
Before replacing a headlamp that does not light, check
to make sure that the wiring connector is securely
fastened to it.
See “Replacement Bulbs”
in the Index to check the size
and type of headlamp you need to
use before you begin
to replace the headlamp.
You must replace a headlamp
with one that
is exactly the same.
Be careful
not to move the aiming screws when you
replace the headlamp. If the headlamp being replaced
was properly aimed, the
new one will be also if it is
properly installed.
6-41

Downloaded from www.Manualslib.com manuals search engine Using Foam-Type Cleaner on Fabric
0
0
0
0
0
0
0
0
0
0
Vacuum and brush the area to remove any loose dirt.
Always clean a whole trim panel or section. Mask
surrounding trim along stitch or welt lines.
Mix Multi-Purpose Powdered Cleaner following the
directions on the container label.
Use suds only and apply with a clean sponge.
Don’t saturate the material.
Don’t rub it roughly.
As soon as you’ve cleaned the section, use a sponge
to remove the suds.
Rinse the section with a clean, wet sponge.
Wipe
off what’s left with a slightly damp paper towel
or cloth.
Then dry it immediately with a blow dryer or a heat
lamp.
~~~
NOTICE:
Be careful. A blow dryer may scorch the fabric.
Wipe with a clean cloth.
Using Solvent-Qpe Cleaner on Fabric
First, see if you have to use solvent-type cleaner at all.
Some spots and stains will clean off better with just
water and mild soap.
If you need to use a solvent:
Gently scrape excess soil from the trim material with
a clean, dull knife or scraper. Use very little cleaner,
light pressure and clean cloths (preferably
cheesecloth). Cleaning should start at the outside of
the stain, “feathering” toward the center. Keep
changing to
a clean section of the cloth.
0 When you clean a stain from fabric, immediately dry
the area with a blow dryer to help prevent a cleaning
ring. (See the previous NOTICE.)
Fabric Protection
Your Chevrolet has upholstery and carpet that has been
treated with Scotchgard” Fabric Protector,
a 3M
product. Scotchgard
TM protects fabrics by repelling oil
and water, which are the carriers of most stains. Even
with this protection, you still need to clean your
upholstery and carpet often to keep it looking new.
Further information on cleaning is available by calling
1-800-433-3296 (in Minnesota, 1-800-642-6167).
6-59

Downloaded from www.Manualslib.com manuals search engine Special Cleaning Problems
Greasy or Oily Stains
Stains caused by grease, oil, butter, margarine, shoe
polish, coffee with cream, chewing gum, cosmetic
creams, vegetable oils, wax crayon, tar and asphalt can
be removed as follows:
Carefully scrape off excess stain.
Follow the solvent-type instructions described
earlier.
Shoe polish, wax crayon, tar and asphalt will stain if
left on a vehicle seat fabric. They should be removed
as soon as possible. Be careful, because
the cleaner
will dissolve them and may cause them to spread.
Non-Greasy Stains
Stains caused by catsup, coffee (black), egg, fruit, fruit
juice, milk, soft drinks,
wine, vomit, urine and blood can
be removed as follows:
Carefully scrape off excess stain, then sponge the
soiled area with cool water.
If a stain remains, follow the foam-type instructions
described earlier.
If an odor lingers after cleaning vomit or urine,
treat the area with a waterhaking soda solution:
1 teaspoon (5 ml) of baking soda to 1 cup (250 ml)
of lukewarm water.
If needed, clean lightly with solvent-type cleaner.
Combination Stains
Stains caused by candy, ice cream, mayonnaise, chili
sauce and unknown stains can be removed as follows:
0 Carefully scrape off excess stain, then clean with
cool water and allow to dry.
If a stain remains, clean it with solvent-type cleaner.
Cleaning Vinyl
Use warm water and a clean cloth.
Rub with a clean, damp cloth to remove dirt. You
may have to do it more than once.
0 Things like tar, asphalt and shoe polish will stain if
you don’t get them off quickly. Use a clean cloth and
a GM VinylLeather Cleaner or equivalent product.
6-60

Downloaded from www.Manualslib.com manuals search engine Cleaning Your Convertible Top
Your convertible top should be cleaned often. If you use
an automatic car wash, use one with water jets and
hanging cloths.
When
you hand wash the top, do it in partial shade.
Vacuum away any dust and other material. Use a mild
soap, lukewarm water and a soft sponge.
A chamois or
cloth may leave
lint on the top, and a brush can chafe
the threads in the top fabric. Don’t use detergents, harsh
cleaners, solvents or bleaching agents.
When you clean the top, put
one hand under it to
support it. Wet the entire vehicle and wash the top
evenly to avoid spots or rings. Let
the soap remain on
the fabric for a few minutes. When the top is really dirty,
use a mild foam-type cleaner. Thoroughly rinse the
entire vehicle,
then let the top dry in direct sunlight.
To protect the convertible top:
After you wash the vehicle, make sure the top is
Don’t get any cleaner on the vehicle’s painted finish;
completely dry
before
you lower it.
it could leave streaks.
If you decide to go through an automatic car wash,
ask
the manager if the equipment could damage your
top.
Aluminum Wheels (If So Equipped)
Your aluminum wheels have a protective coating similar
to the painted surface
of your car. Don’t use strong
soaps, chemicals, chrome polish, abrasive cleaners or
abrasive cleaning brushes
on them because you could
damage this coating. After rinsing thoroughly,
a wax
may be applied.
I
I NOTICE:
If you have aluminum wheels, don’t use an
automatic car wash that has hard silicon carbide
cleaning brushes. These brushes can take the
protective coating
off your aluminum wheels.
Tires
To clean your tires, use a stiff brush with a tire cleaner.
When applying a tire dressing always take care
to wipe
off any overspray or splash from painted surfaces.
Petroleum-based products may damage
the paint finish.
6-64

Downloaded from www.Manualslib.com manuals search engine Headlamps
The headlamp wiring is protected by a circuit breaker.
An electrical overload will cause the lamps to go on
and
off, or in some cases to remain off. If this happens, have
your headlamp wiring checked right
away.
Windshield Wipers
The windshield wiper motor is protected by a circuit
breaker and a fuse. If the motor overheats due to heavy
snow, etc., the wiper
will stop until the motor cools. If
the overload is caused by some electrical problem and
not snow, etc., be sure to get it fixed.
The other is in the engine compartment. Open
the cover
on either of the boxes to expose the fuses.
Look at the silver-colored band inside the fuse. If the
band
is broken or melted, replace the fuse. Be sure you
replace a bad fuse with a new one of the correct size.
If you ever have a problem on the road and don’t have a
spare fuse, you can borrow one of the correct value. Just
pick some feature
of your vehicle that you can get along
without
- like the radio or cigarette lighter - and use
its fuse,
if it is the size you need. Replace it as soon as
you can.
Power Windows and Other Power Options
Circuit breakers protect the power windows and other
power accessories. When the current load is too heavy,
the circuit breaker opens and closes, protecting the
circuit until the problem
is fixed or goes away.

Downloaded from www.Manualslib.com manuals search engine Main Fuse Block
FUSE USAGECHART I I
I ”- RADIO
€I 160 ACCY CRANK
WINDOWS BATT WIPER/WASH IP DIMMER IGN
12[--1 11- gn
80 70 60 50
DEFOG/SEATS CIGAR/HORN TAIL LTS GAGES
COURTESY PWR
ACCY STOPIHAZARD PCM ION
RADIO ACCY TURN B- U AIR BAG
SEE OWNER’S MANUAL FOR MORE INFORMATION
PRINTED IN U.S.A 10264034
1. AIR BAG: SIR Components
2. TURN B-U: Backup Lamp; Daytime Running
Lamps Module (Canada); Turn Flasher
3. HVAC: Heater Control Selector Switch (Heater/Air
Conditioner); Rear Defogger
4. RADIO ASSY: BOSE’ Relay
5. PCM IGN: Powertrain Control Module; PASS-Key
II@Decoder Module; Fuel Pump Relay
6.
7.
8.
9.
STOPEIAZARD: Brake Lamp/Cruise Release
Switch; Hazard Flasher
PWR ACCY Power Door Locks; Power Mirrors;
Hatch Release
COURTESY: Audio Alarm Module; Courtesy
Lamps: Console Compartment, Glove
Box, Dome,
Trunk, Rear Courtesy, Rearview Mirror and Radio
GAGES: Audio Alarm Module; Daytime Running
lamps Module (Canada); Diagnostic Energy Reserve
Module; Instrument Cluster; Remote Lock Control
Module
10. TAIL LTS: Exterior Lighting
11. CIGAWORN: Cigarette Lighter; Horn Relay
12. DEFOG/SEATS: Power Seats; Rear Defogger
13. IP DIMMER: Brightness Control
14. WIPEIUWASH: Windshield WiperNasher
15. WINDOWS: Power Windows, Convertible Top
(Circuit Breaker)
Switch (Circuit Breaker)
16. CRANK: Diagnostic Energy Reserve Module
17. RADIO: Radio Amplifier

Downloaded from www.Manualslib.com manuals search engine Replacement Bulbs
Ashtray* ................................. 194
Automatic Transmission Indicator
.............. 73
Backup
................................... 1141
Center High-Mounted Stoplamp ............... 921
Cluster
................................... 161
Console .................................. 194
Dome .................................... 906
Fog ...................................... 885
Front Parking and Turn Signal
............... 2397
GloveBox ................................ 194
Headlamp
(Low Beam) ................... H-4351
Headlamp (High Beam)
................... H-4352
Door Courtesy
.............................. 74
*Manual transmission
only .
Heater and A/C Control ....................... 37
High Beam Indicator ........................ 161
Indicator Lights
............................ 161
Interior Door Handle
......................... 74
License .................................. 194
Reading
................................. 212-2
Rear Courtesy
............................. 562
Sidemarker
............................... 194
TailOnly
................................. 194
Tail/Stop/Turn
............................ 2057
Trunk
.................................... 562
Turn Signal Indicators
....................... 161
6-73

Downloaded from www.Manualslib.com manuals search engine 0 Vehicle color
0 Vehicle location
Telephone number where you can be reached
0 Vehicle mileage
0 Description of problem
Courtesy Transportation
Chevrolet/Geo offers Courtesy Transportation for
customers needing warranty service. Courtesy
Transportation will be offered
in conjunction with the
coverage provided by the BUMPER TO BUMPER New
Vehicle Limited Warranty to retail purchasers
of 1995
Chevrolet/Geo passenger cars and light duty trucks
(please see
your selling dealer for details).
Courtesy Transportation includes:
0 One way shuttle ride for any warranty repair
completed during the same day.
0 Up to $30 maximum daily vehicle rental allowance
for any overnight warranty repair up to 5 days, OR
0 Up to $30 maximum daily cab, bus, or other
transportation allowance in
lieu of rental for any
overnight warranty repair up to
5 days, OR
0 Up to $10 daily fuel allowance for rides provided by
another person (i.e., friend, neighbor, etc.)
in lieu of
rental for any overnight warranty repair up
to 5 days.
Note: All Courtesy Transportation arrangements will
be administered by your Chevrolet/Geo dealership
service management. Claim amounts should reflect
all actual costs.
0 Chevrolet/Geo Courtesy Transportation is not part of
the BUMPER TO BUMPER New Vehicle Limited
Warranty. Chevrolet/Geo reserves
the right to make
any changes or discontinue Courtesy Transportation
at any
time without notification.
0 For additional program details contact your
Chevrolet/Geo dealer.
In Canada, please consult your GM dealer for
information on courtesy transportation.
8-7

Downloaded from www.Manualslib.com manuals search engine 0 Section 9 INDEX
Acceleration slip Regulation (ASR) System
WarningLight
................................. 4-9
Acceleration Slip Regulation System Warning Light
... 2-71
Accessory plug
................................. 2-59
Adding. Automatic Transmission Fluid
.............. 6-25
Adding. Brake Fluid
............................. 6-36
Adding. Electrical Equipment
..................... 6-68
Adding. Engine Coolant .......................... 6-29
Adding. Engine Oil
............................. 6- 14
Adding. Manual Transmission Fluid
................ 6-26
Adding. Sound Equipment
........................ 3- 17
Adding. Windshield Washer Fluid
............. 2-41. 6-33
Aiming. Headlamp
.............................. 6-38
AirBag
....................................... 1-20
Air Bag Readiness Light .................... 1-20. 2-69
Air Bag. How Does
it Restrain .................... 1-22
Air Bag. How it Works
........................... 1-20
Air Bag Location
............................... 1-2 1
Air Bag. Servicing .............................. 1-24
Air Bag. What Makes
it Inflate .................... 1-22
Air Bag. What Will
You See After it inflates .......... 1-22
Air Bag. When Should it Inflate
................... 1-21
Aircleaner
.................................... 6-18
Adding.
Hydraulic Clutch Fluid
.................... 6-26
Adding. Power Steering Fluid
..................... 6-33
Air Bag System
................................ 1-20 Air Conditioning
................................ 3-3
Alignment and Balance. Tires
..................... 6-55
Aluminum Wheels. Cleaning ...................... 6-64
Antenna. Fixed Mast
............................ 3-18
Antenna. Power Mast Care
....................... 3-17
Anti-Lock
..................................... 4-6
Anti-Lock Brake System Warning Light
......... 2-70. 4-6
Anti-Lock Brakes
............................... 4-6
Anti-Theft. Theft-Deterrent Feature
................ 3-13
Antifreeze
..................................... 6-28
Antifreeze Adding
.............................. 6-29
Antifreeze Checking
............................ 6-29
Anti-Theft Feature. Theftlock
..................... 3-12
Appearance Care
............................... 6-58
Appearance Care and Materials
.................... 6-66
Ashtray and Lighter
............................. 2-62
Ashtray. Front
................................. 2-62
ASR (Acceleration Slip Regulation) System
Warning Light
................................. 4-9
Audio System. Tips About Your
................... 3-16
Audio Systems
.................................. 3-5
Automatic Transmission
......................... 2-21
Fluid
...................................... 6-21
Fluid. Adding ............................... 6-25
Fluid. Checking
.............................. 6-21
ShiftLever
................................. 2-21
9-1

Downloaded from www.Manualslib.com manuals search engine Automatic Overdrive Position .................. 2-23
First Gear
(1) Position ........................ 2-24
Neutral
(N) Position .......................... 2-23
Park (P) Position
............................. 2-23
Reverse
(R) Position .......................... 2-22
Second Gear (2) Position
...................... 2-24
Third Gear (3) Position
........................ 2-24
Axle. Rear
.................................... 6-27
Shifting
.................................... 2-21
Battery
...................................... 6-38
Replacement. Remote Lock Control
............... 2-8
Warnings
................................ 5.2. 5.4
Low Maintenance ............................ 6-38
BBB Auto Line
................................. 8-3
Blizzard
...................................... 4-27
Boot Cover. Installing
........................... 2-82
Brakes
....................................... 6-34
Adjustment
................................. 6-37
Fluid. Adding
............................... 6-36
Master Cylinder
............................. 6-34
Parking
.................................... 2-29
PedalTravel
................................ 6-37
System Parts. Replacing
....................... 6-37
System Warning Light
........................ 2-69
Trailer
..................................... 4-34
System Warning Light
........................ 2-69
Wear
...................................... 6-36
Brakes. Anti-Lock
............................... 4-6
Brakes. Trailer
................................. 4-34
Braking
........................................ 4-5
Braking. In Emergencies ......................... 4- 10
Break.ln. New Vehicle .......................... 2-14
Bulb Replacement
.............................. 6-38
Center High Mounted Stop Lamp
................ 6-44
Front Turn Signal Lamps
...................... 6-45
Headlamps
................................. 6-38
RearLamps
................................. 6-45
Rear Sidemarker Lamps
....................... 6-46
Canadian Roadside Assistance
.................... 8-7
Capacities and Specifications ...................... 6-74
Carbon Monoxide
.................... 2.34.4.28. 4.34
Cassette Storage
................................ 2-59
Cassette Tape Player Care
........................ 3-17
Center High Mounted Stop Lamp Bulb Replacement
... 6-44
CertificatiordTire Label
.......................... 4-29
Chains. Safety
................................. 4-34
Chains. Tire
................................... 6-57
Changing a Flat Tire
............................. 5-26
Check Gauges Light
............................. 2-78
Checking Things Under The Hood .................. 6-8
Checking Your Restraint Systems
.................. 1-41
Checking Automatic Transmission Fluid
.................. 6-21
Brake Fluid
................................. 6-35
Engine Coolant
.............................. 6-29
Engineoil
.................................. 6-13
Hydraulic Clutch Fluid
........................ 6-26
Manual Transmission Fluid
.................... 6-25
Power Steering Fluid ......................... 6-32
Restraint Systems
............................ 1-41
Chemical Paint Spotting .......................... 6-65
9-2