warning CHEVROLET CAVALIER 1995 3.G Owner's Guide

Downloaded from www.Manualslib.com manuals search engine Appearance Care
Remember, cleaning products can be hazardous. Some
are toxic. Others can burst into flame
if you strike a
match or get them
on a hot part of the vehicle. Some are
dangerous
if you breathe their fumes in a closed space.
When
you use anything from a container to clean your
Chevrolet, be sure
to follow the manufacturer’s
warnings and instructions. And always open
your doors
or windows when you’re cleaning the inside.
Never use these to clean your vehicle:
Gasoline
Benzene
Naphtha
0 Carbon Tetrachloride
Acetone
0 Paint Thinner
Turpentine
0 Lacquer Thinner
0 Nail Polish Remover
They can all be hazardous -- some more than
others
-- and they can all damage your vehicle, too.
Don’t use any of these unless this manual says you can.
In many uses, these will damage your vehicle:
Alcohol
Laundry Soap
Bleach
Reducing Agents
Cleaning the Inside of Your Chevrolet
Use a vacuum cleaner often to get rid of dust and loose
dirt. Wipe vinyl or leather with a clean, damp cloth.
Your Chevrolet dealer has two
GM cleaners, a
solvent-type spot lifter and a foam-type powdered
cleaner. They will clean normal spots
and stains very
well.
Do not use them on vinyl or leather.
Here are some cleaning tips:
0 Always read the instructions on the cleaner label.
Clean up stains as soon as you can -- before they set.
Use a clean cloth or sponge, and change to a clean area
Use solvent-type cleaners in a well-ventilated area
often.
A soft brush may be used if stains are stubborn.
only. If you use
them, don‘t saturate the stained area.
If a ring forms after spot cleaning, clean the entire
area immediately or
it will set.
6-42

Downloaded from www.Manualslib.com manuals search engine Fuse Usage
S ALARM PCM/IGN IGN
Fuse
AIR BG 1
AIR BG 2
ALARM
CIG
CLSPCM
CLUSTER
CRUISE DRL
Inside Vehicle Fuse Block
Circuitry
Air Bag-DERM (Diagnostic Energy Reserve
Module) Power
Air Bag-DERM Crank Signal
Alarm Module: Illuminated Entry, Warning
Chimes
Cigar Lighter, Horn, Diagnostic Connector
Instrument Cluster, Powertrain Control Module
Instrument Cluster, Anti-Lock Brake System Cruise Control
Daytime Running Lamps IGN
INST
LPS
INT LAMP
Fuse
ERLS
EXT LAMP
F/P-INJ
FLSH-PAS
HEADLAMP
HVAC
Circuitry
Automatic Transaxle, Brake-Transaxle Shift
Interlock, A/C Compressor, Cruise Control,
Exhaust Gas Recirculation (2.2L Engine),
Cannister Purge Valve, A/C High Pressure
Switch (2.3L Engine)
Park Lamps, Side Marker Lamps, Instrument
Panel Lamps
Fuel Pump, Fuel Injectors
Flash To Pass Lamps
Headlamps
Heater/A/C Control, Rear Window Defogger,
Anti-lock Brake System, Engine Cooling Fan
(2.2L Engine), Engine Vent Heater
(2.3L Engine)
Engine Ignition
Instrument PaneiLamps
Alarm Module: 11,luminated Entry, Warning
Chimes, Overhead Lamps, MapReading Lamps,
Glove Box Lamp, Thnk Lamp, Radio, Power
Mirrors
Auto)
02 HTR Rear 02 HTR Sensor keater (2.3L Engine, Cal.
PCM/IGN Powertrain Control Module
PWR ACC Power
Door Locks
PWR WINDOW Power Windows, Power Sunroof
RADIO Radio
RR DFOG Rear Window Defogger
STOP-HAZ Stop Lamps, Hazard Lamps
TURN-B/U Turn
Signal Lamps, Backup Lamps
WIPER Windshield
Wipers, Windshield Washers
6-53

Downloaded from www.Manualslib.com manuals search engine 0 Section 9 Index
Adding Automatic Transaxle Fluid
................ 6- 18. 6- 19
BrakeFluid ................................. 6-27
Electrical Equipment
.......... 2-1 1 , 2- 12, 3- 12, 6-5 1
Engine Coolant ......................... 5- 16, 6-22
Engineoil
.................................. 6-11
Hydraulic Clutch Fluid ........................ 6-20
Manual Transaxle Fluid
....................... 6- 19
Power Steering Fluid ......................... 6-24
SoundEquipment
............................ 3-12
Windshield Washer Fluid
................. 2-32, 6-25
AirBag
....................................... 1-18
How Does
it Restrain ......................... 1-22
Howitworks
............................... 1-20
Location
................................... 1-20
Servicing
................................... 1-24
What Makes
it Inflate ......................... 1-22
What Will You See After it inflates .............. 1-22
When Should
it Inflate ........................ 1-2 1
Air Bag Readiness Light .................... 1-20, 2-61
Aircleaner
.................................... 6-15
Air Conditioning ................................ 3-2
Air Conditioning Compressor Button
................ 3-2
Alignment and Balance, Tires
..................... 6-39
Aluminum Wheels, Cleaning ...................... 6-48
Antenna. Fixed Mast ............................ 3-14
Anti-Lock Brake System Warning Light
......... 2.63. 4.6
Anti-Lock Brakes
............................... 4-6
Anti-Theft Feature.
CD Player .................... 3-10
Antifreeze ..................................... 6-21
Adding
............................... 5.16. 6.22
Checking
................................... 6-23
Appearance Care
............................... 6-42
Appearance Care and Materials
.................... 6-50
Ashtray and Lighter ............................. 2-44
Audiosystems
.................................. 3-5
Auto Down Feature
............................. 2-27
Automatic Transaxle.
Four Speed
Automatic Overdrive
......................... 2-17
First(1)
.................................... 2-18
Neutral
(N) ................................. 2-15
Park(P) .................................... 2-14
Reverse(R)
................................. 2-15
Second(2)
.................................. 2-16
Shifting
.................................... 2-14
Third (3)
................................... 2-17
Drive(D)
................................... 2-16
First(1)
.................................... 2-16
Neutral (N)
................................. 2-15
Automatic Transaxle. Three Speed
9-1

Downloaded from www.Manualslib.com manuals search engine Park(P) .................................... 2-14
Reverse(R)
................................. 2-15
Second(2)
.................................. 2-16
Shifting
.................................... 2-14
Automatic Transaxle Fluid ................... 6- 16. 6- 19
Adding
............................... 6- 18. 6- 19
Checking .............................. 6.16. 6.19
Battery.
LOW Maintenance ....................... 6-29
Battery Rundown Protection
...................... 2-4 1
Battery Warnings ............................ 5.2. 5.4
BBB Auto Line
................................. 8-3
Brake Adjustment
.............................. 6-28
Brake Fluid. Adding
............................. 6-27
Brake Master Cylinder
........................... 6-26
BrakePedalTravel
.............................. 6-28
Brake System Parts. Replacing
.................... 6-28
Brake System Warning Light
...................... 2-62
Brake-Transaxle Shift Interlock
............... 2-24. 7-40
BrakeWear
.................................... 6-27
Brake. Parking
................................. 2-21
Brakes. Anti-Lock
............................... 4-6
Brakes. Trailer
................................. 4-33
Braking
........................................ 4-5
Braking
in Emergencies ........................... 4-8
BTSI (Brake-Transaxle Shift Interlock)
......... 2-24. 7-40
Bulbs, Replacement
............................. 6-56
Headlamps
................................. 6-29
Taillamps
................................... 6-31 Canadian
Roadside Assistance
.................... 8-8
Capacities and Specifications ...................... 6-55
Carbon Monoxide .................... 2.25.4.25. 4.33
Cassette Tape Player Care
........................ 3-13
CDErrors
...................................... 3-9
CD Player Anti-Theft Feature
..................... 3- IO
Center Console Compartment ..................... 2-46
Center Passenger Position
........................ 1-31
Certification/TIre Label
.......................... 4-28
Chains. Safety
................................. 4-33
Chains. Tire
................................... 6-41
Changing a Flat Tire
............................. 5-20
Charging System Light
.......................... 2-66
Check Engine Light
............................. 2-68
Check Gages Light
.............................. 2-64
CheckOilLight
................................ 2-66
Checking Automatic Transaxle Fluid
................ 6- 16. 6- 19
BrakeFluid ................................. 6-26
Enginecoolant
.............................. 6-23
Engineoil
.................................. 6-10
Hydraulic Clutch Fluid
........................ 6-20
Manual Transaxle Fluid
....................... 6-19
Power Steering Fluid
......................... 6-24
Things Under the Hood
........................ 6-6
Checking Your Restraint Systems
.................. 1-45
Chemical Paint Spotting
.......................... 6-49
Child Restraints
................................ 1-34
Securing
in a Rear Outside Seat Position .......... 1-36
Securing
in the Center Rear Seat Position ......... 1-38
Securing
in the Right Front Seat Position .......... 1-40
9-2

Downloaded from www.Manualslib.com manuals search engine Driver Position ................................. 1 - 10
Driver’s Seat Manual Lumbar Support ............... 1-2
Driving
AtNight
................................... 4-13
City ....................................... 4-17
Defensive
................................... 4-1
Drunken
.................................... 4-2
Freeway
................................... 4- I8
In a Blizzard
................................ 4-24
In Foreign Countries ........................... 6-4
In the Rain ................................. 4- 14
OnCurves
................................... 4-8
OnGrades
.................................. 4-35
On Hill and Mountain Roads
................... 4-20
On Snow and Ice
............................. 4-23
Through Deep Standing Water
.................. 2- I2
Winter
..................................... 4-22
With
a Trailer ............................... 4-34
DrunkenDriving
................................ 4-2
Easy Entry Seat
................................ 1-4
Electrical Equipment. Adding ................ 3- 12. 6-5 1
Engine .................................... 6-8. 6-9
Enginecoolant ................................. 6-21
Adding
............................... 5-16. 6-22
Checking
................................... 6-23
Engine Coolant Heater
...................... 2- 12. 6. 14
Engine Coolant Temperature Gage
................. 2-64
Engine Identification
............................ 6-5 1
Engineoil .................................... 6-10
Adding
.................................... 6-11
Additives ................................... 6-14
EngineExhaust
................................ 2-25 Checking
................................... 6-10
What Kind
to Use ............................ 6-12
What
to do With Used Oil ..................... 6-14
Whentochange
............................. 6-14
Engine Overheating ............................. 5-12
Engine, Running It While Your Parked .............. 2-26
Engine, Specifications
........................... 6-57
Engine, Starting Your
............................ 2-10
Ethanol (In Fuel) ................................ 6-3
Exhaust. Engine
................................ 2-25
Fabric Cleaning
............................... 6-43
Fifth Gear. Manual Transaxle
..................... 2-19
FillingYourTank
................................ 6-4
Filter. Air Cleaner .............................. 6-15
Filter, Engine Oil
............................... 6-14
Finish Care .................................... 6-46
Finish Damage
................................. 6-48
First ( 1 ), 3 Speed Automatic Transaxle .............. 2-16
First (1 ), 4 Speed Automatic Transaxle .............. 2-18
First Gear, Manual Transaxle
...................... 2-19
Flash-to-Pass Feature ........................... 2-30
Flashers. Hazard Warning
......................... 5-1
Flat Tire, Changing ............................. 5-20
Fluids and Lubricants
....................... 6-55, 7-43
FogLamps
.................................... 2-40
Fold-Down Rear Seat
............................ 1-5
Foreign Countries. Fuel ........................... 6-4
Fourth Gear. Manual Transaxle
.................... 2-19
French Language Manual
11
Front Reading Lamps ............................ 2-40
Front Seatback Latches
........................... 1-4
.. ...........................
FrontTowing ................................... 5-9
9-4

Downloaded from www.Manualslib.com manuals search engine Fuel .................
Fuel Gage .............
Fuel. Filling Your Tank . .
Fuel. In Foreign Countries
Fuse Block. Inside Vehicle
Fuse Block. Under Hood
.
Fuses and Circuit Breakers
......................... 6-4
......................... 6-4
........................ 6-53
........................ 6-54
....................... 6-52
Gages
Y Engine Coolant Temperature ................... 2-64
Fuel
....................................... 2-67
Gasolines for Cleaner
Air ......................... 6-3
GAWR (Gross Axle Weight Rating)
................ 4-29
GearPositions
................................. 2-14
Glass, Cleaning
................................ 6-45
GVWR (Gross Vehicle Weight Rating)
.............. 4-29
Halogen Bulbs
................................ 6-29
Hazard Warning Flashers
.......................... 5- 1
Head Restraints ................................. 1-4
Headlamp High-Low Beam Changer ............... 2-30
Headlamp. Wiring
.............................. 6-54
Headlamps
.................................... 2-37
Headlamps. Bulb Replacement
.................... 6-29
Hearing or Speech Impaired. Customer Assistance
...... 8-2
Heating
........................................ 3-3
Heritage Pages
................................... 111
High Beam Lamps. How to Change ................ 2-30
Highway Hypnosis
.............................. 4-20
...
Hill and Mountain Roads ......................... 4-20
Hitches. Trailer
................................. 4-33
HoodProp
..................................... 6-7
Hood Release ................................... 6-6
Horn
......................................... 2-28
Hydraulic Clutch
............................... 6-20
Adding Fluid
................................ 6-20
Checking Fluid
.............................. 6-20
Hydroplaning
.................................. 4-16
If You’re Stuck: In Sand. Mud. Ice or Snow ......... 5-28
Ignition Key Positions
............................ 2-8
Ignition Switch
.................................. 2-8
Illuminated Entry
............................... 2-41
Inside Daymight Rearview Mirror
................. 2-42
Inside Vehicle Fuse Block
........................ 6-53
Inspections Brakesystem
............................... 7-42
Manual Transaxle
............................ 7-42
Restraint Systems
............................ 7-42
Steering. Suspension and Frt-Whl-Drive Axle Boot and
Seal
...................................... 7-42
InstrumentPanel
............................... 2-56
Instrument Panel Clusters
........................ 2-58
Gagecluster ................................ 2-59
Standard Cluster
............................. 2-58
Instrument Panel Intensity Control
................. 2-38
Instrument
Panel. Cleaning ....................... 6-45
Exhaust
Systems
............................. 7-42
Throttle Linkage
............................. 7-42
9-5

Downloaded from www.Manualslib.com manuals search engine Jack. Tire .................................... 5-20
Jump Starting ................................... 5-2
Key Lock Cylinders ............................ 7-39
Key Release Button .............................. 2-9
Keys .......................................... 2-1
Lamps ...................................... 2-37
Lamps On Reminder ............................ 2-37
Lane Change Indicator ........................... 2-29
Latches. Front Seatback ........................... 1-4
Leaving Your Vehicle ............................. 2-4
Light. Air Bag Readiness .................... 1-20. 2-61
Light. Safety Belt Reminder .................. 1-6. 2-61
Lighter and Ashtray ............................. 2-44
Air Bag Readiness ...................... 1-20. 2-61
Anti-Lock Brake System Warning
........... 2-63. 4-6
Brake System Warning ........................ 2-62
Charging System ............................. 2-66
CheckEngine ............................... 2-68
Check Gages ................................ 2-64
CheckOil .................................. 2-66
Low Coolant Warning ......................... 2-64
Manual Transaxle Shift ................... 2-20. 2-68
Oilwarning ................................. 2- 65
Passlock Warning ............................ 2-70
Safety Belt Reminder
..................... 1-6. 2-6 1
Loading Your Vehicle ........................... 4-28
Lock. Steering Column .......................... 7-40
Leaving Your Vehicle With the Engine Running ....... 2-23
Lights
Locks
......................................... 2-3
Door ....................................... 2-3
PowerDoor .................................. 2-4
Rear Door Security ............................ 2-4
Window .................................... 2-27
Long Trip. Before Leaving on a .................... 4-19
Low Coolant Warning Light ...................... 2-64
Low Maintenance Battery ........................ 6-29
Lubricants and Fluids ....................... 6-55, 7-43
Lubrication. Body .............................. 7-39
Maintenance Record ........................... 7-45
Maintenance Schedule ............................ 7-1
Maintenance Schedule. Recommended Fluids and
Lubricants
................................. 7-43
Owner Checks and Services .................... 7-38
Periodic Maintenance Inspections
............... 7-42
Schedule I Definition .......................... 7-4
Schedule I1 Definition .......................... 7-5
Scheduled Maintenance Services ................. 7-3
Maintenance Schedule I ........................... 7-6
Maintenance Schedule I1 ......................... 7-27
Maintenance When Trailer Towing ................. 4-36
Maintenance, Normal Replacement Parts ............ 6-57
Maintenance, Underbody ......................... 6-49
Malfunction Indicator Lamp (Check Engine Light) .... 2-68
ManualFrontSeat ............................... 1-1
Manual Transaxle
Fifth Gear
.................................. 2-19
Neutral
(N) Position .......................... 2-19
Parking Your Vehicle
......................... 2-24
Reverse (R) Position .......................... 2-19
FirstGear .................................. 2-19
FourthGear ................................. 2-19

Downloaded from www.Manualslib.com manuals search engine SecondGear ................................ 2-19
Shift Light
............................. 2.20. 2.68
Shiftspeeds
................................ 2-20
Shifting
.................................... 2-18
Third Gear
.................................. 2- 19
Manual Transaxle Fluid
.......................... 6- 19
Adding .................................... 6-19
Checking ................................... 6-19
Mirrors
....................................... 2-42
Convex Outside
............................ 2-43
Inside Day/Night Rearview
.................... 2-42
Power Remote Control
........................ 2-43
Remote Control
.............................. 2-42
Methanol
(In Fuel) ............................... 6-3
MTBE
(In Fuel) ................................. 6-3
Net. Convenience
.............................. 2-44
Neutral (N) Position. Manual Transaxle
............. 2-19
New Vehicle “Break-In”
.......................... 2-7
Nightvision
................................... 4-13
Neutral
(N) Position. Automatic Transaxle
........... 2- 15
OBD I1 ...................................... 2-69
Odometer. Tamper Resistant
...................... 2-59
Odometer. Trip
................................. 2-60
Off-Road Recovery
............................. 4- IO
Oil Warning Light .............................. 2-65
Oil. Engine .................................... 6-10
Ordering
Owner Publications
............................ 8-8
Service and Owner Publications .................. 8-8
Service Bulletins .............................. 8-8
Service Manuals
.............................. 8-8
Overdrive (D). 4 Speed Automatic Transaxle
........ 2-17
Overheated Engine
.............................. 5-12
Owner Checks and Services ....................... 7-38
Owner Publications. Ordering
...................... 8-8
Paint Spotting. Chemical
........................ 6-49
Park (P) Position. Automatic Transaxle
.............. 2-14
Park (P). Shifting Into
........................... 2-22
Park (P). Shifting Out
of ......................... 2-24
ParkingBrake
.................................. 2-21
Parking Lamps
................................. 2-37
Parking on Hills While Towing
a Trailer ............. 4-35
Parking Your Vehicle. Manual Transaxle
............. 2-24
Parking. AtNight
................................ 2-6
Passlock Theft-Deterrent System
................... 2-7
Periodic Maintenance Inspections
.................. 7-42
Power Door Locks
............................... 2-4
Power Remote Control
Mirror ..................... 2-43
Power Steering
.................................. 4-8
Power Steering Fluid Adding
.................................... 6-24
Checking ................................... 6-24
Power Windows
................................ 2-27
Pregnancy. Use of Safety Belts
.................... 1-24
Problems on
the Road ............................ 5-1
Publications. Service and Owner .................... 8-8
ParkingLots .................................... 2-6
Parking Over Things That Burn
.................... 2-25
Passing
....................................... 4-10
Passlock Warning Light
.......................... 2-70
9-7

Downloaded from www.Manualslib.com manuals search engine SafetyChains .................................. 4-33
Safety Defects Reporting to General Motors
.................... 8-5
Reporting to the Canadian Government
............ 8-5
Reporting to the United States Government ........ 8-4
Safety Warnings and Symbols
....................... vi
Scheduled Maintenance Services .................... 7-3
Seats .......................................... 1-1
Driver’s Seat Manual Lumbar Support ............. 1-2
Easy Entry
................................... 1-4
Fold-Down Rear
.............................. 1-5
ManualFrontSeat ............................. 1-1
Securing a Child Restraint ..................... 1-32
Seats and Restraint Systems
........................ 1 - I
Seats and Seat Controls ........................... 1 - 1
Second (2). 3 Speed
Automatic Transaxle
........................... 2- 16
Second (2), 4 Speed
Automatic Transaxle
........................... 2- 17
Second Gear. Manual Transaxle ................... 2- 19
Service
........................................ 6-1
Service and Appearance Care
...................... 6- 1
Service and Owner Publications .................... 8-8
Service Bulletins, Ordering
........................ 8-8
Service Manuals, Ordering ........................ 8-8
Service Parts Identification Label
.................. 6-5 1
Service Publications .............................. 8-8
Service Work, Doing Your Own .................... 6-1
Servicing Your Air Bag-Equipped Chevrolet
......... 1-24
Sheet Metal Damage
............................ 6-48
Shift Light. Manual Transaxle
................ 2-20. 2-68 Shift Speeds. Manual Transaxle
.................... 2-20
Shifting Into Park (P)
............................ 2-22
Shifting. Automatic Transaxle
.....................
Skidding ...................................... 4-12
Sound Equipment. Adding
........................ 3-12
Spare Tire. Compact
............................. 5-27
Specifications Chart
............................. 6-57
Speedometer ................................... 2-59
Starter Switch
.................................. 7-39
Starting Your Engine
............................ 2-10
2.2 Liter
.................................... 2-10
2.3Liter
.................................... 2-11
Steam.
If Coming From Your Engine ............... 5-12
Steering
....................................... 4-8
In Emergencies
............................... 4-9
Power
...................................... 4-8
Tips
........................................ 4-8
Steering Column Lock
........................... 7-40
Steering Wheel. Tilt
............................. 2-28
Storage. Of Your Vehicle ......................... 6-29
Stuck. If You Are ............................... 5-28
Sunvisors .................................... 2-44
Sunroof
....................................... 2-46
Supplemental Restraint System
(SRS) ............... 1-18
Surge Tank Pressure Cap ......................... 6-23
Symbols. Vehicle
................................ vm
Shifting Out of Park (P) .......................... 2-24
Shoulder Belt Height Adjuster
..................... 1 . 13
Stains. Cleaning ................................ 6-44
...
9-9

Downloaded from www.Manualslib.com manuals search engine Under Hood Fuse Block ........................ 6-54
Underbody Maintenance
......................... 6-49
Variable Controlled-Cycle Windshield Wiper
........ 2-3 1
Vehicle Damage Warnings vu
Vehicle Identification Number ..................... 6-5 1
Vehicle Loading ................................ 4-28
Vehicle Storage
................................ 6-29
Vehicle Symbols
................................. vlll
Vehicle. Control of a ............................. 4-5
Ventilation
..................................... 3-3
Ventilation System. Flow-Through
.................. 3-4
Ventilation Tips
................................. 3-5
Visors. Sun
.................................... 2-44
.. ..........................
...
warning Devices ............................... 5-2
Warning Flashers. Hazard
......................... 5-1
Warning Lights. Gages and Indicators
............... 2-60
Washing Your Vehicle
........................... 6-46
Weatherstrips
.................................. 6-46
Wheel
Nut Torque ......................... 5-25. 6-55
Wheel Replacement
............................. 6-40
Wheel Replacement. Used
........................ 6-41
WindowLock
.................................. 2-27
Windows
..................................... 2-26
Auto Down
................................. 2-27
Power
..................................... 2-27
Windshield Washer
............................. 2-32
Windshield Washer Fluid
.................... 2-32. 6-25
Windshield Wiper
.............................. 2-30
Windshield Wiper. Blade Replacement
.............. 6-32
Windshield Wiper. Circuit Breaker ................. 6-54
Winter. Driving In
.............................. 4-22
Wiring. Headlamp
.............................. 6-54
WreckerTowing
................................. 5-7
9-11