heating CHEVROLET CAVALIER 1998 3.G User Guide

Downloaded from www.Manualslib.com manuals search engine If there seems to be no leak, with the engine on, check to
see
if the electric engine cooling fan is running. If the
engine is overheating, the fan should be running. If
it
isn’t, your vehicle needs service.
How to Add Coolant to the Coolant
Surge Tank
If you haven’t found a problem yet, but the coolant level
isn’t at the
FULL COLD mark, add a 50/50 mixture of
clean water (preferably distilled) and DEX-COOL@
coolant at the coolant surge tank, but be sure the cooling system, including the coolant surge tank pressure cap, is
cool before you do it. (See “Engine Coolant” in the
Index for more information.)
Steam and scalding liquids from a hot cooling
system can blow out and burn you badly. They
are under pressure, and
if you turn the coolant
surge tank pressure cap
-- even a little -- they
can
come out at high speed. Never turn the cap
when the cooling system, including the coolant
surge tank pressure cap,
is hot. Wait for the
cooling system and coolant surge tank pressure
cap to cool
if you ever have to turn the
pressure cap.
5-18

Downloaded from www.Manualslib.com manuals search engine How to Check
You do not need to check the fluid level unless you
suspect a clutch problem.
To check the fluid level, take
the cap
off. If the fluid reaches the step inside the
reservoir, the fluid level is correct.
Engine Coolant
The cooling s stem in your vehicle is filled with
DEX-COOL
8 engine coolant. This coolant is designed
to remain in your vehicle for
5 years or 150,000 miles
(240 000 km) whichever occurs first, if you add only
DEX-COOL’ extended life coolant.
The following explains your cooling system and how
to add coolant when it is low. If you have a problem
with engine overheating, see “Engine Overheating” in
the Index.
A 50/50 mixture of water and DEX-COOL@
coolant will:
Give freezing protection down to -34°F (-37°C).
Give boiling protection up to 265 “F (129°C).
Protect against rust and corrosion.
Help keep the proper engine temperature.
Let the warning lights and gages work as
they should.
NOTICE:
When adding coolant, it is important that you
use only
DEX-COOL@ (silicate-free) coolant.
If coolant other than DEX-COOL is added to
the system, premature engine, heater core or
radiator corrosion may result. In addition, the
engine coolant will require change sooner
-- at
30,000 miles (50 000 km) or 24 months,
whichever occurs first. Damage caused by the
use of coolant other than DEX-COOL@ is not
covered by your new vehicle warranty.
6-25

Downloaded from www.Manualslib.com manuals search engine Adding Coolant
If you need more coolant, add the proper DEX-COOL@
coolant mixture at the surge tank, but only when the
engine is cool.
I’
You can be burned if you spill coolant on hot
engine parts. Coolant contains ethylene glycol,
and
it will burn if the engine parts are hot
enough. Don’t spill coolant on a hot engine.
When replacing the pressure cap, make sure it is tight.
Surge Tank Pressure Cap
NOTICE:
Your surge tank cap is a 15 psi (105 kPa)
pressure-type cap and must be tightly installed to
prevent coolant
loss and possible engine damage
from overheating.
When you replace your surge tank pressure cap, a GM
cap is recommended.
Thermostat
Engine coolant temperature is controlled by a thermostat
in the engine coolant system. The thermostat stops the
flow of coolant through the radiator until the coolant
reaches
a preset temperature.
When
you replace your thermostat, an ACDelco
thermostat is recommended.

Downloaded from www.Manualslib.com manuals search engine Windshield Wiper Blade Replacement Tires
Your new vehicle comes with high-quality tires made by
a leading tire manufacturer. If you ever have questions
about your tire warranty and where to obtain service, see
your Chevrolet Warranty booklet for details.
Replacement blades come in different types and are
removed in different ways. For the proper type and
length, see “Capacities and Specifications” in the Index.
Here’s how to remove the Shepherd’s
Hook type:
1. Pull the windshield wiper arm away from
2. Push the release lever and slide the wiper assembly
the
windshield.
toward the driver’s side
of the vehicle.
3. Install a new blade by reversing Steps 1 and 2.
Poorly maintained and improperly used tires
are dangerous.
0 Overloading your tires can cause
overheating as a result
of too much friction.
You could have an air-out and a serious
accident. See (‘Loading Your Vehicle” in
the Index.
Underinflated tires pose the same danger as
overloaded tires. The resulting accident
could cause serious injury. Check all tires
frequently to maintain the recommended
pressure. Tire pressure should be checked
when your tires are cold.
CAUTION: (Continued)
6-40

Downloaded from www.Manualslib.com manuals search engine Door Locks ..................................... 2-4
Drive. Automatic Transaxle
....................... 2-22
Driver Position
................................. 1 - 14
Driving City
........................................ 4-19
Defensive
.................................... 4-2
Drunken
..................................... 4-3
Freeway
.................................... 4-20
In a Blizzard
................................. 4-26
In Foreign Countries
........................... 6-5
In
the Rain .................................. 4-16
Night
...................................... 4-15
On Curves
.................................. 4-10
On Grades While Towing a Trailer
............... 4-38
On Hill and Mountain Roads
.................... 4-22
On Snow and Ice
............................. 4-25
Through Water
............................... 4- 18
WetRoads
.................................. 4-16
Winter
...................................... 4-24
With a Trailer
................................ 4-36
Drunken Driving
................................ 4-3
Easy Entry Seat
................................ 1-6
Electrical Equipment. Adding
........... 2.16.3.22. 6.58
Electrical System
............................... 6-58
Engine
.................................. 6.10. 6.11
Coolant
..................................... 6-25
Coolant Heater
............................... 2- 18
Coolant Level Check .......................... 7-30
Coolant Temperature Gage
..................... 2-70 Exhaust
................. 2.10.2.30.2.31.4.27. 4.36
Fuse Block
.................................. 6-62
Identification
................................ 6-57
OilLevelCheck
.............................. 7-30
Overheating
................................. 5-14
Running While Parked
......................... 2-31
Specifications
................................ 6-65
Starting Your
...................... 2.15.2.16. 2.17
Engineoil
.................................... 6-12
Adding
..................................... 6-13
Additives
................................... 6-16
Checking
................................... 6-13
Used
....................................... 6-16
What To Use
................................. 6-14
Whentochange
.............................. 6-16
Enhanced Traction System
......................... 4-8
Active Light
............................. 2.70. 4.9
Operation
.................................... 4-8
Ethanol
........................................ 6-4
ETS
.......................................... 4-8
Active Light
............................. 2.70. 4.9
Warning Light
........................... 2.69. 4.9
Exhaust. Engine
................. 2.10.2.30.4.27. 4.36
Exterior Lamps
................................. 2-40
Exterior LampsLenses. Cleaning
.................. 6-52
Warning Light
........................... 2.69. 4.9
Fabric Cleaning
............................... 6-49
Fabric Protection
............................... 6-50
Fifth Gear. Manual Transaxle ..................... 2-25
9-4

Downloaded from www.Manualslib.com manuals search engine Filling a Portable Fuel Container .................... 6-7
Filling Your Tank
................................ 6-5
Filter. Air
................................ 6-17. 6-64
Finishcare
.................................... 6-52
Finish Damage ................................. 6-55
First Gear. Automatic Transaxle
.............. 2.22. 2.24
First Gear. Manual Transaxle
...................... 2-25
Flashers. Hazard Warning
......................... 5-2
Flash-To-Pass
................................. 2-34
Flat Tire. Changing
............................. 5-23
Fluids and Lubricants
............................ 7-37
FogLamps
.................................... 2-42
Foreign Countries. Fuel
........................... 6-5
Fourth Gear. Manual Transaxle
.................... 2-25
French Language Manual
11
Front Reading Lamps ............................ 2-44
FrontTowing
.................................. 5-10
Fuel
.......................................... 6-3
Filling a Portable Container
...................... 6-7
Filling Your Tank
.............................. 6-5
Gage
....................................... 2-76
In Foreign Countries ........................... 6-5
Fuses and Circuit Breakers ....................... 6-59
.. ...........................
Gages Engine Coolant Temperature
.................... 2-70
Fuel
....................................... 2-76
Speedometer
................................. 2-64
Tachometer
.................................. 2-65
GAWR
....................................... 4-31 Gear Positions. Automatic Transaxle
................ 2-20
Gear Positions. Manual Transaxle
.................. 2-24
Gross Axle Weight Rating
........................ 4-31
Guide en Franqais
11
GVWR ....................................... 4-31
Gross Vehicle Weight Rating
...................... 4-31 .. .................................
Halogen
Bulbs ................................ 6-35
Hazard Warning Flashers 5-2
Head Restraints
................................. 1-5
Bulb Replacement
............................ 6-36
High/Low Beam Changer
...................... 2-34
OnReminder
................................ 2-40
Hearing Impaired. Customer Assistance
.............. 8-4
Heating ........................................ 3-5
High-Beam Headlamps
.......................... 2-34
Highway Hypnosis
.............................. 4-22
Hill and Mountain Roads
......................... 4-22
Hitches. Trailer
................................. 4-36
Hood
Checking Things Under ......................... 6-8
Prop
........................................ 6-9
Release
...................................... 6-8
Horn
......................................... 2-32
Hydraulic Clutch
............................... 6-24
Fluid
....................................... 6-24
Hydroplaning
.................................. 4-18
.
..........................
Headlamps .................................... 2-40
Wiring
..................................... 6-58
Systemcheck
................................ 7-31
9-5

Downloaded from www.Manualslib.com manuals search engine Oil. Engine .................................... 6-12
Oil Pressure Light
.............................. 2-73
Overdrive, Automatic Transaxle
................... 2-23
Overheating Engine
............................. 5- 14
Owner Checks and Services ....................... 7-30
Owner Publications. Ordering
................ 8-1 1, 8-12
Paint Spotting. Chemical
........................ 6-55
Park
Automatic Transaxle
.......................... 2-20
Shifting Into
................................. 2-27
Shifting Out of
............................... 2-29
Parking AtNight
.................................... 2-11
Brake
...................................... 2-26
Brake Mechanism Check
....................... 7-34
Lots
....................................... 2- 12
Over Things That Burn
........................ 2-30
With a Trailer
................................ 4-39
Your Vehicle, Manual Transaxle
................. 2-29
Passenger Position
.................... 1-23, 1-30. 1-36
With
a Trailer ................................ 4-37
Passlock@
..................................... 2-12
Warning Light
............................... 2-75
Periodic Maintenance Inspections
.................. 7-35
Power
DoorLocks
................................... 2-5
Option Fuses ................................ 6-58
Remote Control Mirror ........................ 2-46
Passing
....................................... 4-12 Steering
............................... 4- 10. 6.29
Steering Fluid
................................ 6-29
Windows
................................... 2-32
Pregnancy, Use of Safety Belts
.................... 1-22
Problems on the Road
............................ 5-1
Publications, Service and Owner
.............. 8- 11, 8- 12
Radio Reception .............................. 3-22
Radios
.......................... 3.7.3.9.3.11. 3.16
Rain. Driving In ................................ 4-16
Raising the Convertible Top Manually
.............. 2-57
Raising Your Convertible Top
..................... 2-56
Rear Door Security Locks
........................... 2-5
Outside Seat Position
.......................... 1-30
Safety Belt Comfort Guides
..................... 1-33
Seatpassengers .............................. 1-30
Towing
..................................... 5-12
Window Defogger
............................. 3-6
RearTowing
................................... 5-12
Rear Turn Signal Bulb Replacement
................ 6-37
Rearview Mirror ................................ 2-45
Reclining Front Seatbacks
......................... 1-4
Recommended Fluids and Lubricants
............... 7-37
Recreational Vehicle Towing
...................... 4-28
Refrigerants. Air Conditioning
.................... 6-64
Remote Trunk Release
........................... 2-11
Removing the Boot
............................. 2-54
Rearview Mirror,
Inside Daymight
................. 2-45
9-8