engine coolant CHEVROLET CAVALIER 2003 3.G Owner's Manual

4. With the coolant surge
tank pressure cap off,
start the engine
and let it run until you
can feel the upper
radiator hose getting
hot. Watch out for
the engine cooling fan.
By this time, the coolant level inside the coolant
surge tank may be lower. If the level is lower than
the FULL COLD mark, add more of the proper
mixture to the coolant surge tank until the
level reaches the FULL COLD mark.5. Then replace the
pressure cap. Be sure
the pressure cap is
hand-tight and
fully seated. See your
dealer, if necessary.
5-32

Windshield Washer Fluid
What to Use
When you need windshield washer ¯uid, be sure to read
the manufacturer's instructions before use. If you will
be operating your vehicle in an area where the
temperature may fall below freezing, use a ¯uid that has
sufficient protection against freezing. See
Engine
Compartment Overview on page 5-12for reservoir
location.
Adding Washer Fluid
Open the cap with the
washer symbol on it. Add
washer ¯uid until the
tank is full.
Notice:
·When using concentrated washer ¯uid, follow
the manufacturer's instructions for adding
water.
·Don't mix water with ready-to-use washer ¯uid.
Water can cause the solution to freeze and
damage your washer ¯uid tank and other parts
of the washer system. Also, water doesn't
clean as well as washer ¯uid.
·Fill your washer ¯uid tank only three-quarters
full when it's very cold. This allows for
expansion if freezing occurs, which could
damage the tank if it is completely full.
·Don't use engine coolant (antifreeze) in your
windshield washer. It can damage your
washer system and paint.
5-34

100,000 Miles (166 000 km)
qReplace spark plugs.An Emission Control Service.
qChange automatic transaxle ¯uid and ®lter if the
vehicle is mainly driven under one or more of
these conditions:
þ In heavy city traffic where the outside
temperature regularly reaches 90ÉF (32ÉC) or
higher.
þ In hilly or mountainous terrain.
þ When doing frequent trailer towing.
þ Uses such as found in taxi, police or delivery
service.
If you do not use your vehicle under any of these
conditions, the ¯uid and ®lter do not require changing.
Manual transaxle ¯uid doesn't require changing.
150,000 Miles (240 000 km)
qDrain, ¯ush and re®ll cooling system (or every
60 months since last service, whichever occurs ®rst).
See
Engine Coolant on page 5-22for what to use.
Inspect hoses. Clean radiator, condenser, pressure
cap and neck. Pressure test the cooling system
and pressure cap.
An Emission Control Service.
qInspect engine accessory drive belt.An Emission
Control Service.
6-13

100,000 Miles (166 000 km)
qReplace spark plugs.An Emission Control Service.
qChange automatic transaxle ¯uid and ®lter if the
vehicle is mainly driven under one or more of
these conditions:
þ In heavy city traffic where the outside
temperature regularly reaches 90ÉF (32ÉC) or
higher.
þ In hilly or mountainous terrain.
þ When doing frequent trailer towing.
þ Uses such as found in taxi, police or delivery
service.
If you do not use your vehicle under any of these
conditions, the ¯uid and ®lter do not require changing.
Manual transaxle ¯uid doesn't require change.
150,000 Miles (240 000 km)
qDrain, ¯ush and re®ll cooling system (or every
60 months since last service, whichever occurs ®rst).
See
Engine Coolant on page 5-22for what to use.
Inspect hoses. Clean radiator, condenser, pressure
cap and neck. Pressure test the cooling system
and pressure cap.
An Emission Control Service.
qInspect engine accessory drive belt.An Emission
Control Service.
6-18

Part B: Owner Checks and Services
Listed in this part are owner checks and services
which should be performed at the intervals speci®ed to
help ensure the safety, dependability and emission
control performance of your vehicle.
Be sure any necessary repairs are completed at once.
Whenever any ¯uids or lubricants are added to your
vehicle, make sure they are the proper ones, as shown
in Part D.
At Each Fuel Fill
It is important for you or a service station attendant to
perform these underhood checks at each fuel ®ll.
Engine Oil Level Check
Check the engine oil level and add the proper oil if
necessary. SeeEngine Oil on page 5-14for further
details.
Engine Coolant Level Check
Check the engine coolant level and add DEX-COOLž
coolant mixture if necessary. SeeEngine Coolant
on page 5-22for further details.
Windshield Washer Fluid Level Check
Check the windshield washer ¯uid level in the windshield
washer tank and add the proper ¯uid if necessary. See
Windshield Washer Fluid on page 5-34for further details.
At Least Once a Month
Tire In¯ation Check
Make sure tires are in¯ated to the correct pressures.
Don't forget to check your spare tire. SeeTires on
page 5-51for further details.
Cassette Tape Player Service
Clean cassette tape player. Cleaning should be done
every 50 hours of tape play. SeeAudio System(s)
on page 3-36for further details.
At Least Twice a Year
Restraint System Check
Make sure the safety belt reminder light and all your
belts, buckles, latch plates, retractors and anchorages
are working properly. Look for any other loose or
damaged safety belt system parts. If you see anything
that might keep a safety belt system from doing its
job, have it repaired. Have any torn or frayed safety belts
replaced.
Also look for any opened or broken air bag coverings,
and have them repaired or replaced. (The air bag
system does not need regular maintenance.)
6-19

Part D: Recommended Fluids and
Lubricants
Fluids and lubricants identi®ed below by name, part
number or speci®cation may be obtained from your
dealer.
Usage Fluid/Lubricant
Engine OilEngine oil with the American
Petroleum Institute Certi®ed for
Gasoline Engines starburst symbol
of the proper viscosity. To determine
the preferred viscosity for your
vehicle's engine, see
Engine Oil on
page 5-14.
Engine Coolant50/50 mixture of clean, drinkable
water and use only
DEX-COOL
žCoolant. SeeEngine
Coolant on page 5-22.
Hydraulic Brake
SystemDelco Supreme 11 Brake Fluid or
equivalent DOT-3 brake ¯uid.
Windshield
Washer SolventGM Optikleen
žWasher Solvent or
equivalent.
Usage Fluid/Lubricant
Hydraulic
Clutch SystemHydraulic Clutch Fluid (GM Part No.
U.S. 12345347, in Canada
10953517, or equivalent DOT-3
brake ¯uid).
Power Steering
SystemGM Power Steering Fluid (GM Part
No. U.S. 1052884, in Canada
993294, or equivalent).
Manual
TransaxleDEXRON
ž-III Automatic
Transmission Fluid.
Automatic
TransaxleDEXRON
ž-III Automatic
Transmission Fluid.
Key Lock
CylindersMulit-Purpose Lubricant, Superlube
(GM Part No. U.S. 12346241, in
Canada 10953474, or equivalent).
Manual
Transaxle Shift
LinkageChassis Lubricant (GM Part No.
U.S. 12377985, in Canada
88901242, or equivalent) or lubricant
meeting requirements of NLGI #2,
Category LB or GC-LB.
Clutch Linkage
Pivot PointsEngine oil.
6-25

Checking Coolant............................................5-23
Checking Engine Oil........................................5-14
Checking Things Under the Hood......................5-10
Checking Your Restraint Systems......................1-58
Check...........................................................3-30
Engine Light...............................................3-30
Gages Warning Light...................................3-34
Chemical Paint Spotting...................................5-77
Child Restraints..............................................1-35
Child Restraint Systems...............................1-35
Infants and Young Children...........................1-32
Lower Anchorages and Top Tethers for
Children (LATCH System)..........................1-41
Older Children.............................................1-29
Securing a Child Restraint Designed for
the LATCH System...................................1-43
Securing a Child Restraint in a Rear
Seat Position...........................................1-43
Securing a Child Restraint in the Right
Front Seat Position...................................1-46
Top Strap Anchor Location............................1-40
Top Strap...................................................1-39
Where to Put the Restraint...........................1-38
Chime Level Adjustment..................................3-79
Cigarette Lighter.............................................3-16
Cleaning Aluminum or Chrome-Plated Wheels.....5-76
Cleaning Exterior Lamps/Lenses.......................5-75
Cleaning Fabric/Carpet....................................5-71
Cleaning Glass Surfaces..................................5-73Cleaning Interior Plastic Components.................5-73
Cleaning the Top of the
Instrument Panel.........................................5-73
Cleaning Tires................................................5-77
Cleaning Vinyl................................................5-73
Cleaning Windshield and Wiper Blades..............5-76
Cleaning........................................................5-71
Inside of Your Vehicle..................................5-71
Outside of Your Vehicle................................5-74
Underbody Maintenance...............................5-77
Weatherstrips..............................................5-74
Climate Control System...................................3-17
Outlet Adjustment........................................3-20
Clutch, Hydraulic.............................................5-21
Compact Disc Messages.................3-48, 3-63, 3-75
Compact Spare Tire........................................5-70
Content Theft-Deferrent....................................2-15
Control of a Vehicle.......................................... 4-5
Convenience Net............................................2-36
Coolant.........................................................3-29
Engine Temperature Gage............................3-29
Heater, Engine............................................2-21
Low Warning Light.......................................3-30
Surge Tank Pressure Cap.............................5-24
Cooling System..............................................5-27
Cruise Control.................................................. 3-8
Cupholder(s)..................................................2-35
Current and Past Model Order Forms................7-11
3

Emissions Inspection and Maintenance
Programs...................................................3-32
Engine Compartment Fuse Block......................5-84
Engine Coolant Level Check.............................6-19
Engine Cooling When Trailer Towing..................4-40
Engine Oil Additives........................................5-17
Engine Oil Level Check...................................6-19
Engine..........................................................5-18
Air Cleaner/Filter.........................................5-18
Battery.......................................................5-39
Check and Service Engine Soon Light............3-30
Compartment Overview................................5-12
Coolant Heater............................................2-21
Coolant Temperature Gage...........................3-29
Coolant......................................................5-22
Cooling System Inspection............................6-23
Exhaust.....................................................2-30
Oil .............................................................5-14
Overheating................................................5-25
Starting......................................................2-19
Enhanced Traction System (ETS)........................ 4-8
Active Light................................................3-29
Warning Light.............................................3-28
Entry Lighting.................................................3-15
Express-Down Window....................................2-14
Extender, Safety Belt.......................................1-28
Exterior Lamps...............................................3-12F
Filter.............................................................5-18
Engine Air Cleaner......................................5-18
Finding a PTY Station
(RDS and XMŸ).........................3-43, 3-53, 3-67
Finding a Station....................3-37, 3-41, 3-51, 3-65
Finish Care....................................................5-75
Finish Damage...............................................5-77
Five-Speed....................................................2-25
Fixed Mast Antenna........................................3-78
Flash-to-Pass................................................... 3-6
Flat Tire, Changing.........................................5-61
Flat Tire........................................................5-60
Fluid.............................................................5-20
Automatic Transaxle.....................................5-20
Manual Transaxle........................................5-20
Power Steering...........................................5-33
Windshield Washer......................................5-34
FM Stereo.....................................................3-76
Fog Lamps....................................................3-14
Folding the Seatback........................................ 1-8
Following Distance..........................................4-38
Forward Gears...............................................2-24
Front Reading Lamps......................................3-15
Fuel............................................................... 5-4
Additives...................................................... 5-5
California Fuel.............................................. 5-5
Filling a Portable Fuel Container..................... 5-9
Filling Your Tank........................................... 5-7
5

Fuel (cont.)
Fuels in Foreign Countries.............................. 5-6
Gage.........................................................3-35
Gasoline Octane........................................... 5-4
Gasoline Speci®cations.................................. 5-5
System Inspection.......................................6-23
Fuses...........................................................5-81
Fuses and Circuit Breakers...........................5-81
Windshield Wiper.........................................5-81
G
Gage............................................................3-34
Check Gages Warning Light..........................3-34
Engine Coolant Temperature.........................3-29
Fuel..........................................................3-35
Speedometer..............................................3-23
Tachometer.................................................3-23
Gasoline......................................................... 5-4
Octane........................................................ 5-4
Speci®cations............................................... 5-5
GM Mobility Program for Persons with
Disabilities.................................................... 7-5
H
Hazard Warning Flashers................................... 3-3
Head Restraints............................................... 1-5Headlamp High/Low-Beam Changer.................... 3-6
Headlamp Wiring............................................5-81
Headlamps....................................................5-45
Bulb Replacement.......................................5-45
Front Turn Signal and Parking Lamps.............5-47
Halogen Bulbs............................................5-45
Highway Hypnosis...........................................4-22
Hill and Mountain Roads..................................4-22
Hitches..........................................................4-37
Hood............................................................5-10
Checking Things Under................................5-10
Release.....................................................5-10
Horn............................................................... 3-4
How the System Alarm is Activated...................2-15
How to Add Coolant to the Coolant Surge Tank . . 5-29
How to Check and Add Fluid............................5-21
How to Check Power Steering Fluid..................5-33
How to Check................................................5-52
How to Detect a Tamper Condition....................2-16
How to Inspect the Engine Air Cleaner/Filter.......5-19
How to Turn Off the System Alarm....................2-16
How to Use This Manual...................................... ii
How to Wear Safety Belts Properly...................1-14
Hydraulic Clutch System Check........................6-20
Hydraulic Clutch.............................................5-21
Hydroplaning..................................................4-18
6

Light.............................................................3-24
Air Bag Readiness.......................................3-24
Anti-Lock Brake System Warning...................3-27
Brake System Warning.................................3-26
Charging System.........................................3-25
Check Gages Warning.................................3-34
Enhanced Traction System (ETS)
Active Light.............................................3-29
Enhanced Traction System (ETS)
Warning Light..........................................3-28
Low Coolant Warning...................................3-30
Malfunction Indicator....................................3-30
Oil Pressure...............................................3-33
Passlock
žWarning.......................................3-34
Safety Belt Reminder...................................3-24
Service Vehicle Soon...................................3-35
Up-Shift.....................................................3-26
Loading Your Vehicle.......................................4-32
Lockout Protection..........................................2-10
Locks............................................................. 2-7
Door........................................................... 2-7
Leaving Your Vehicle....................................2-10
Lockout Protection.......................................2-10
Power Door.................................................. 2-8
Rear Door Security Locks............................... 2-9
Long Trip/Highway De®nition.............................. 6-6Long Trip/Highway Intervals............................... 6-6
Long Trip/Highway Scheduled Maintenance........6-14
Loss of Control...............................................4-14
Low Coolant Warning Light..............................3-30
M
Maintenance, Normal Replacement Parts............5-86
Maintenance Schedule.....................................6-19
At Each Fuel Fill.........................................6-19
At Least Once a Month................................6-19
At Least Once a Year..................................6-20
At Least Twice a Year..................................6-19
Brake System Inspection..............................6-24
Caliper/Knuckle MaintenanceInspection..........6-24
Engine Cooling System Inspection.................6-23
Exhaust System Inspection...........................6-23
Fuel System Inspection................................6-23
How This Section is Organized....................... 6-3
Introduction.................................................. 6-2
Long Trip/Highway Scheduled Maintenance.....6-14
Maintenance Requirements............................. 6-2
Part A - Scheduled Maintenance Services......... 6-4
Part B - Owner Checks and Services.............6-19
Part C - Periodic MaintenanceInspections......6-23
Part D - Recommended Fluids
and Lubricants.........................................6-25
8