length CHEVROLET CORVAIR 1965 2.G Owners Manual

Downloaded from www.Manualslib.com manuals search engine CHEVROLET
"ALL TRANSISTOR"
RADIOS
To operate the radios, the igni­
tion switch must
be in "ON" or
"ACC" position.
Antenna
For best FM operation the an­
tenna must be extended to a length
of 31 inches. For best AM opera­
tion
the antenna should be fully
extended.
••• AM Radios
The left hand control knob is the "on-off" switch and volume control. At
its base is the tone control wing knob. The right hand knob is the manual
station selector. With
the optional rear seat speaker, a wing knob at the base
of the station selector knob allows use of front, rear or both speakers.
Five push buttons allow station selection in the Push Button Radio. To
preset, pull the push button "out" as far as it will go, tune in the desired
station manually and then push the button fully "in." Repeat for each push
button.
• • • AMI FM Radio
This set receives clear static-free FM broadcasts as well as standard AM
programs. Move the slide bar to select AM or FM reception. Controls are the
same as in Manual and Push Button radios. FM broadcasts may be received
as far as 60 miles from the sending station, depending on the power of the
station and existing terrain. Push buttons may be set for AM, FM or both.
• • • Stereo Multiplex Adapter
The optional Stereo Multiplex Adapter permits FM Stereo reception with
the AM/FM
radio. Radio controls are used to turn the set on and off and for
station selection. Controls on
the adapter are Volume, Tone and Balance (to
-balance the front and rear speakers!. For a pleasing stereo effect the front
speaker reproduces one channel and the rear speaker reproduces the other
channel. The indicator light on the adapter will be lighted when the radio is
tuned to an FM stereo station. Most broadcasts on such stations will be in
stereo.
16

Downloaded from www.Manualslib.com manuals search engine TIRE CARE
Keep your tires inflated to the recommended pres­
sures.
Over-inflation can adversely affect riding comfort,
quietness and tire life while under-inflation affects vehicle
handling and tire life.
RECOMMENDED TIRE INFLATION PRESSURES (Based on Original Equipment Tires)
CORVAIR (6.50-134 PR Tires) Cold-Hot**
Average Owner Service up to 5-Front Rear Front Rear
passenger load (normal i nfla-tion) Air conditioned models and convertibles 15 28 18 33 All other models 15 26 18 31 Continuous Service with up to fu II load ca pacity or h ig h speeds (maximu m inflation) 19 30 22 35
NOTE: As shown in the above table, Corvair rear tire pressures should be maintained at least 11 psi higher than front tire pressures;
CORVAIR .95
7.00 x 14"4 ply S.P. 24 30 28 35 7.00 x 14-6 ply S.P. 24
34 28 39 7.00 x 14-6 ply I Light Truck 24
45 28 50
7 .00 x 14 -8 ply I Type 24 60 28 65
Spare Tire...,.lnflate to proper Rear (Cold) pressure. Deflate to correct pressure when using as front tire. -After car has been parked for 3 hours or more or driven less than one mile. --Pressures can riseas much as 7 pounds above cold figures depending on loads carried, length of driving, and car speed prior to check.
, Fron t tire loads increase appreciably with cargo
lci'ading; therefore the above is recommended for best
steering characteristics.
34
Full load capacity of the vehicle is 1 OOOlbs. total.
Consisting of 3 passengers in front seat, 3 passengers
in
rear seat and 100 Ibs . luggage.
Manufacturer's original equipment 4-plyrating tires
are designed and thoroughly tested to meet all normal
requirements of your vehicle as outlined above.
For continuous full load service or heavy duty oper­
ation, eight ply rated tire options are recommended at
the above recommended tire pressures.
Switching Tires
When rear tires are replaced, put new tires on front
and used on rear and reset to recommended tire
pressures. ,
FOR MAXIMUM TIRE LIFE
• Ke.ep tires properly inflated.
• Check regularly for cuts, bruises and puncturing ob­
jects. Nails etc. will often be carried in the tire with
no noticeable loss of air. Do not remove a puncturing
object until prepared to change or repair the tire.
• Avoid unnecessary sudden starts and stops; take curves
and corners slowly.
•
Avoid driving over curves, sharp objects or chuckholes.
•
Have wheel alignment checked periodically, especially
when tires show unusual wear.

Downloaded from www.Manualslib.com manuals search engine SPECIFICATIONS
SERIAL AND UNIT NUMBERS
Engine Number Stamped on the engine block behind and to left of the fu el pump.
Body Number Corvair-Stamped on a plate attached to top of rear rail to left of engine mount , within the engine compartment.
Corvair Greenbrier-Stamped on a plate attached to the front inner body panel, with in the drive compartment.
Serial Number Corvair-Stamped on veh icle identification plate attached to left rear side rail, within the engine compartment. Corvair Greenbrier-Stamped on vehicle identification plate attached to the left front door lock pillar.
DIMENSIONS
length: Corvair Greenbrier ................................. 179.7 in.
Co r
vair ........................................... 183 .3 in .
Width :
Corva ir
Greenbrier ............... .•... ... .......... 70.0 in.
Co rvair ........................................... 69.7 in.
Height :
Corvair
Greenbrier ............. ........ ........... " 68.5 in.
Corvair Sport Sedan ............. .. ................ " 51.2 in.
Corvai r Sport Coupe ................................. 51.3 in.
Corva ir Convertible ...........•............ ....... " 51.5 in.
Wheel. Bas e:
Corvair Greenbri.er ... ............................. '95.0 in.
Corvair ........................................ . . 108 .0 in.
Turning Diameter:
Corvair
Greenbrier ..... .................•.......... 42.6 ft .
Corvair ........................................... 36.0 ft . Greenbrier-load length .............................. 106 .2 in. Greenbrier-load Width . .....•........................ 59.4 in. Greenbrier-load Compartment Height .. , ............... 54.0 in.
44
S ide loading Doors-Width ................. '.' ... .4.90 x 53. 5 in.
Rear loading Doors .............................. 36.0 x 44.6 in .
CAPACITIES
Gasol ine Tank :
Corvair
Greenbrier ... .............................. 18.5 gal. Co rvair ......................•..........•........ 14.0 gal. Crankcase Refill .................. ........ .. ............ 4 qt. Add for filter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .. 1 pt .
Transmission :
3.Speed ..................•......................... . 2 pt. 4·Speed ..................... ........................ 3 pt.
D ifferent ial ... .. .............•....................... 4% pt . Cooling Sys tem ............ .. ................ Air Coo led Engine
ENGINE SPECIFICATIONS
Horsepower: 95 hp Turbo·Air 164 ... ................ ..... 95 @ 3600 rpm 110 hp Turbo·Air 164 .............. : ......... 110@ 4400 rpm 140 hp Turbo·Air 164 ..... :oO .............. 140 @ 5200 rpm 180 hp Turbocharged 164 .................... 180 @ 4000 rpm
Compression Ratio:
95 hp Turbo·Air 164 ................................. 8.25 :1 110 and 140 hp Turbo -Air 164 ........................ 9 .25:1 180 hp Turbocharged 164 ........ ... ........ _ ........ 8.25 :1
Displacement .................................... . .. 164 cu. in.
Bore and Stroke (all engines) ................. ....... 3K 6"x2 .94" Firing Order ............... ....................... 1.4·5 -2 ·3-6
Spark Plugs: 95 hp Turba·Air 164 (Gap .. 035) ............. ....... AC·46·FF 11 0 and 140 hp Turba·Air 164 and 180 hp Turbocharged 164 (Gap .030) ...........•.......... AC·44-FF

Downloaded from www.Manualslib.com manuals search engine Corvair passenger cars are designed primarily for
passenger conveyance. However, it is well known that
many owners do use the Corvair to pull trailers, and
when available trailer hauling options have been used,
the owners
have experienced very satisfactory service.
When a trailer is attached to a car, the car becomes
not only a load-carrying vehicle, but a load-pulling
vehicle. The demands of this type of operation are very
different from those for which the automobile is pri­
marily designed and may present problems, such as
spring
and tire loading, braking, cooling, lighting, and
steering. However, careful driving practices and the use
of factory-recommended options will better satisfy the
requirements
of trailer hauling.
If in the opinion of the manufacturer a part or com­
ponent of a motor vehicle has been adversely affected
46
by misuse of the vehicle with trailer loads, such part or
component will not be covered by the manufacturer's
warranty.
The size of and equipment for trailers, including
such items as hitches and safety chains, brakes, lights,
power-weight ratios and over-all length, are generally
subject to safety regulations in all states, and it is the
responsibility of the user to make certain that he is in
full
compliance with the regulations of the states in
which he plans to operate with a trailer of the Interstate
Commerce Commission,
if applicable, before doing so.
Further, when
operating a car with a trailer attached,
the driver must realize that the performance, steering
characteristics,
and braking distance of his car have
been altered, and that he must exercise greater caution
to safely handle his car and trailer.