Fluids CHEVROLET CORVETTE 1994 4.G User Guide

Downloaded from www.Manualslib.com manuals search engine Maintenance Schedule
C L Section A: Scheduled Maintenance Services (Cont.)
Explanation of Scheduled
Maintenance Services
Following are explanations of the services
listed in Schedule I and Schedule
11.
The proper fluids and lubricants to use are
listed in Section D. Make sure whoever
services your vehicle uses these. All parts
should be replaced and all necessary
repairs done before you or anyone else
drives the vehicle.
NOTE: To determine your engine’s
displacement and code, see
“Engine Identification” in the
Index.
ITEM
NO. SERVICE
1 Engine Oil and Filter Change* -
Always use SH or SG Energy
Conserving I1 oils of proper
viscosity. The engine requires a
special oil meeting GM Standard
GM4718M. Oils meeting this
Standard may be identified as
synthetic, and should also be
identified as API Service
SH or
SG. However, not all Synthetic
API Service
SH oils will meet
ITEM
NO. SERVICE
this GM Standard. You should
look for and use only an oil that
meets GM Standard GM4718M.
To determine the preferred
viscosity for your vehicle’s
engine (e.g.,
SAE 5W-30 or SAE
10W-30), see “Engine Oil” in
the Index.
Your vehicle has an Engine Oil
Life Monitor. This monitor will
show you when to change the oil
- usually between 3,000 miles
(5 000 km) and 7,500 miles
( 12 500 km) since your last oil
change. Under severe conditions
the indicator may come on before
3,000 miles
(5 000 km). Never
drive your vehicle more than
7,500 miles (12
500 km) or 12
months without an oil change.
The system won’t detect dust in
the oil..
So if you drive in a dusty
area be sure
to change your oil
every 3,000 miles
(5 000 km) or
sooner if the “Change Oil” light
comes on.
ITEM
NO.
2
3
4
SERVICE
Remember to reset the Oil Life
Monitor when the oil has been
changed. For more information, see “Engine Oil Life Monitor”
in the Index.
Chassis Lubrication
- Lubricate
suspension and steering linkage.
Lubricate the transmission shift
linkage, and parking brake cable guides, underbody contact points
and linkage.
Engine Accessory Drive Belt(s) Inspection
- Inspect the belt(s)
for cracks, fraying, wear and
proper tension. Replace as needed. (Belts can have many
small cracks in individual ribs
without affecting performance.)
Cooling System Service*
-
Drain, flush and refill the system with
new or approved recycled
coolant conforming to GM
Specification 1825M. Keep
coolant at the proper mixture as
specified. See “Coolant” in the
* An Emission Control Service.
. . .236

Downloaded from www.Manualslib.com manuals search engine Maintenance Schedule
Section B: Owner Checks and Services
isted below are owner checks and services which should be performed at the intervals specified to help ensure the safety,
ependability and emission control performance of your vehicle. Be sure any necessary repairs are completed at once.
Vhenever any fluids or lubricants are added
to your vehicle, make sure they are the proper ones, as shown in Section D.
If Each Fuel Fill (/t is important for you or a service station attendant to perform these underhood checks at each fuel fill.)
i CHECK
OR SERVICE I WHAT TO DO
Engine Oil Level
Check the windshield washer fluid level in the windshield washer
tank and add the proper fluid if
Windshield Washer Check
the engine coolant level and add the proper coolant mix if necessary. See “Coolant” in
Engine Coolant Level Check the
engine oil level and add the proper oil if necessary. See “Engine Oil” in the Index for
Fluid Level necessary.
See “Windshield Washer Fluid” in the Index for further details.
further details.
the
Index for further details.
It Least Once a Month
CHECK
OR SERVICE
Tire Inflation
Cassette Deck
WHAT TO DO
Check tire inflation. Make sure they are inflated to the pressures specified on the Tire-Loading
Information label located on the rear edge
of the driver’s door. See “Tires” in the Index for
further details.
Clean cassette deck. Cleaning should be done every
15 hours of tape play. See “Audio Systems”
in the Index for further details.
. .238

Downloaded from www.Manualslib.com manuals search engine Maintenance Schedule
Section D: Recommended Fluids & Lubricants
NOTE: Fluids and lubricants identified below by name, part number or specification may be obtained from your GM Dealer.
USAGE FLUID/LUBRICANT
Engine Oil
API service SH or SG Energy Conserving I1 oils of the proper viscosity. To determine the
preferred viscosity for your vehicle’s engine, see “Engine Oil” in the Index. The engine requires
a special oil meeting GM Standard GM4718M. Oils meeting this stan\
dard may be identified as
synthetic, and should also be identified as API Service SH. However, not all Synthetic API
Service SH oils will meet this GM Standard.
You should look for and use only an oil that meets
GM Standard GM4718M.
Engine Coolant
50/50 mixture of water (preferably distilled) and good quality ethylene glycol base antifreeze
(GM Part No. 1052753 or equivalent) conforming to GM Specification 1825M or approved
recycled coolant conforming to GM Specification 1825M.
Hydraulic Brake Delco-Supreme
ll@ Brake Fluid (GM Part No. 1052535 or equivalent DOT-3 brake fluid).
System
Hydraulic Clutch System Hydraulic Clutch Fluid
(GM Part No. 12345347 or equivalent).
Parking Brake
Chassis lubricant (GM Part No. 1052497 or equivalent) or lubricant meeting requirements of
Guides NLGI Grade 2, Category LB or GC-LB.
Power Steering
GM Synthetic Power Steering Fluid (GM Part
No. 12345866 or 12345867 or equivalent).
System
Manual Transmission
Transmission DEXRON@-I11 or
DEXRON@-IIE Automatic Transmission Fluid.
Automatic Manual Transmission Fluid
SAE 5W-30 (GM Part
No. 1052931 or equivalent).
. . .244

Downloaded from www.Manualslib.com manuals search engine Maintenance Schedule
Section D: Recommended Fluids & Lubricants (Cont.)
USAGE FLUID/LUBRICANT
Hood Latch Assembly
a. Pivots and Spring
b. Chassis lubricant (GM Part No. 1052497 or equivalent)
or lubricant meeting requirements of b. Release Pawl a.
Engine oil.
Anchor
NLGI Grade 2, Category LB
or GC-LB.
Hood and Door
Hinges, Fuel Door
Hinge, Rear
Compartment Lid
Hinges, Concealed
Headlight Hinges,
Hatch Hinges, Folding
Front Seats
Weatherstrips Engine oil
or Lubriplate Lubricant (GM Part No. 1050109).
Dielectric Silicone Grease (GM Part No. 12345579 or equivalent).
See “Replacement Parts” in the Index for recommended replacement filters, valves and spark plugs.
. . .246

Downloaded from www.Manualslib.com manuals search engine Index
New Vehicle “Break-In” ........ 46
Night. Driving at
............... 131
Night Vision
................... 131
Noise Reduction
................ 113
Numeric Gauge Readings
......... 83
Odometer. Speedometer and
...... 80
Odometer. Trip .................. 81
Off-Road Recovery
............. 129
Off-Road Track Use
.............. 49
Oil Pressure Gauge. Engine
........ 91
Oil Temperature Gauge. Engine
..... 93
Oil. Engine
.................... 178
Operation of Lights
.............. 66
Overheating. Engine
............ 150
Owner Checks and Services
....... 238
P (Park). Shifting into ........... 57
P (Park). Shifting out of ........... 58
Paint
Chemical Spotting
............ 2 16
Finish Care
.................. 2 14
Finish Damage
............... 2 15
Foreign Material
.............. 2 1 5
One to Four Light ................ 55
Parking
AtNight
..................... 43
Brake
....................... 56
Brake Indicator Light
........... 85
Lots ........................ 43
I . . 266
Parking
Over Things That Bum
......... 59
Your Vehicle
.................. 58
PASS-Key ..................... 45
Passenger Position (Safety Belts)
... 27
Passenger Seat. Securing a Child Restraint in the
........... 30
Passing
....................... 129
Passive Keyless Entry Light
....... 95
Passive Keyless Entry System
...... 38
Pedal Travel. Brake
............. 194
Periodic Maintenance Inspections
. . 242
Plug. Accessory
................. 76
PKE .......................... 38
Power Antenna Mast Care
............ 118
Door Locks
................... 38
Remote Control Mirrors
......... 69
Seat
......................... 12
Steering
.................... 127
Steering Fluid
................ 19 1
Switch. Engine ................ 49
Windows
.................... 60
Pregnancy. Safety Belt Use during
....................... 27
Problems on the Road
........... 141
Publications. Service
............ 256
Questions Many People Ask about
Safety Belts
- and the Answers.
Here are
................... 18 Radio
Reception.
Radio. To Play the
Understanding
............... 117
AM/FM Stereo with Cassette AM/FM Stereo with Cassette Tape Player
................ 113
Tape and Compact Disc Player
................ 115
Rain. Driving
in the ............. 132
Rainy Weather Tips. Some
Other
...................... 133
Rear Axle
..................... 188
Rear Axle. Limited-Slip
........... 56
Rear Storage Compartment
........ 73
Rear Towing Hook-Ups
.......... 149
Rear Window Defogger
.......... 111
Rearview Mirror. Inside Daymight
.............. 69
Reclining Seatbacks. Manual
....... 13
Recommended Fluids and Lubricants
............... 244
Recovery. Off-Road
............. 129
Release Button. Key
.............. 47
Release. Hood
................. 175
Release. Remote Hatch
........... 41
Reminder Light. Safety Belt
....... 19
Reminder. Lights On
............. 67
Remote Control Mirrors. Power ..... 69
Remote Hatch Release
............ 41