battery CHEVROLET CORVETTE 1995 4.G Owner's Manual

Downloaded from www.Manualslib.com manuals search engine I- +
I B'
12. Remove the cables in reverse order to prevent
electrical shorting. Take care that they don't touch
each other or any other metal.
A. Heavy Metal Engine Part
B . Good Battery
C. Dead Battery
rowing Your Vehicle
Try to have a GM dealer or a professional towing
service tow your Corvette. The usual towing equipment
is a sling-type
(A) or a wheel-lift (B) or car carrier (C)
tow truck.

Downloaded from www.Manualslib.com manuals search engine You’ll see the following when you open the hood with
the
LTl engine:
1.
2.
3.
4.
5.
6.
7.
8.
9.
10.
11.
12.
Hydraulic Clutch Fluid Reservoir (if equipped)
Brake Fluid Reservoir
Battery
Electric Engine Fan
Air Cleaner
Coolant Recovery Tank Power Steering Fluid Reservoir
Engine Oil Fill Cap
Engine Oil Dipstick Windshield Washer Fluid Reservoir
Coolant High
Fill Reservoir
Automatic Transmission Dipstick (if equipped)
6-9

Downloaded from www.Manualslib.com manuals search engine Before closing the hood, be sure all the filler caps are
on.
You’ll see the following when you open the hood with
the
LT5 engine:
1. Hydraulic Clutch Fluid Reservoir
2. Brake Fluid Reservoir
3. Battery
4. Electric Engine Fan
6-10

Downloaded from www.Manualslib.com manuals search engine How To Check and Add Fluid
(LT1 Engine Only)
You must loosen and remove the two screws before the
PCM unit will lift out.
The clutch master cylinder is under the Powertrain Fluid should be added if the fluid
level is at or below the
Control Module (PCM) in the left rear area of the engine
ADD mark on the reservoir. There are additional
instructions on the reservoir cap.
compartment.
To check the fluid, look at the area between the PCM
and the battery.
To add fluid, remove the PCM unit. When returning
the PCM to its proper position, make
sure the unit is fully rearward
in the bracket prior to
installing the two screws.
How to Check and Add Fluid
(LT5 Engine Only)
The clutch master cylinder is under the Engine Control
Module (ECM) in the left rear area of the engine
compartment.
To check the fluid, look at the area
and the battery.
To add fluid, remove the ECM unit between
the ECM
6-25

Downloaded from www.Manualslib.com manuals search engine NOTICE:
Replacing Brake System Parts
The braking system on a modem vehicle is complex. Its
I
Continuing to drive with worn-out brake pads
could result in costly brake repair.
I
Some driving conditions or climates may cause a brake
squeal when the brakes are first applied or lightly
applied. This does not mean something is wrong with
your brakes.
Brake linings should always be replaced as complete
axle sets.
Brake Pedal Travel
See your dealer if the brake pedal does not return to
normal height, or if there is a rapid increase in pedal
travel. This could be
a sign of brake trouble.
Brake Adjustment
As you make brake stops, your disc brakes
automatically adjust for wear. many
parts have to be
of top quality and work well
together if the vehicle is to have really good braking.
Vehicles we design and test have top-quality
GM brake
parts in them, as your Corvette does when
it is new.
When you replace parts of your braking system
-- for
example, when your brake linings wear down and you
have to have new ones put in
-- be sure you get new
genuine
GM replacement parts. If you don’t, your
brakes may no longer work properly. For example, if
someone puts in brake linings that are wrong for your
vehicle, the balance between your front and rear brakes
can change
-- for the worse. The braking performance
you’ve come to expect can change
in many other ways if
someone puts
in the wrong replacement brake parts.
Battery
Every new Corvette has a Delco Freedom@ battery. You
never have to add water to one of these. When it’s time
for a new battery, we recommend a Delco Freedom@
battery. Get one that has the replacement number shown
on the original battery’s label. For battery replacement,
see your dealer or the Corvette Service Manual.
To
purchase a service manual, see “Service Publications” in
the Index.
6-35

Downloaded from www.Manualslib.com manuals search engine Vehicle Storage
If you’re not going to drive your vehicle for 25 days
or more, take off the black, negative (-) cable from
the battery. This
will help keep your battery from
running down.
Bulb Replacement
For the proper type of replacement bulb, see
“Replacement Bulbs” in the Index.
Halogen Bulbs
Contact your dealer to learn how to prepare your vehicle
for longer storage periods.
6-36

Downloaded from www.Manualslib.com manuals search engine Instrument Panel Fuse Block
IC 7 21 7 3c 7 4c 7 5c 7 AK: MDL WIPER RDO IGN HTD MIR
6c 7 TAIL 7c 7 HORN 8C 7 STOP/HAZ 9c 7 CRANK AIR BAG
1oc 7 CRANK
CLUTCH P/N
111 7 =c 7 131 7 141 7 15c 7
161 7 17c 7 18C 7 19c 7 2oc 7
RH ILLUM
LH ILLUM CNSLILLUM F.P. 1 F.P. 2
CCM3 VALET A/C CLUTCH UTILITY OXYGEN SEN
21c 722C 7 4 7 24c 7251 7
26C 7 27c 7 2ac 7 29c 7 301 7
311 7 3zc 7 =c 7 34c 7351 7
361 7 371 7 38C 7 391 7401 7
411 742c 7 431 7441 7~C 7
ENG2 lNJl INJ 2 TURN COIL
P.K.E. CLUSTER BACKUP
FAN ENG 1
PWR MIRROR CRUISE E.C.M. AIR BAG CCM 1
RHCTSY LHCTSY L.C.D. CCMP RDOBAlT
SPORTSEAT PWR LOCK A/C PROG CIGAR HATCH
CIRCUIT
BREAKERS
Two maxi -fuse blocks are located under hood
near battery.
- POWER SEAT
POWER WINDOW
P
6-69

Downloaded from www.Manualslib.com manuals search engine 28. Back-up Lamps Switch; Transmission Position
Switch; One to Four Shift Solenoid
29. Cooling Fan Relay Coil
#I, #2, #3
30. Camshaft Sensor (LT5); Canister Purge Solenoid;
Throttle Position Sensor Buffer Module (LT5);
EGR Circuit (LT1); Secondary Air Inlet Solenoid
(LT5); Ignition Control Module (LT5); HVAC
Solenoid Assembly; Mass Airflow Sensor (LT 1);
One
to Four Shift Relay
3 1. Power Mirror Adjuster Control; Lighted Rearview
Mirror; Visor Vanity Mirrors
32. Cruise Control Engage Switch; Daytime Running
Lamps Module; Low Tire Pressure Warning
Module; Cruise Control Cut-Off Relay
33. Engine Control Module
34. Air Bag System
35. Central Control Module
36. Footwell Courtesy Lamps; Door Courtesy Lamps;
Glove Compartment Lamps; Lighted Rearview
Mirror
37, Bose@ Amplifier Relay; Power Antenna Relay;
Cargo Compartment Lamps
38. Instrument Cluster; Tone Generator; Dome Lamp
Relay
39. Central Control Module
40, Radio Receiver (Battery); Radio Control Head;
Passive Keyless Entry Module
41. Sport Seats
42. Power Door Lock Switches; Driver Information
Center; Passive Keyless Entry Module
43. Heater and A/C Programmer
44. Cigarette Lighter; Accessory Plug
45. Hatch or Deck Lid Release Relay
K. Power Seats
L. Blank
M. Power Windows
N. Blank
P. Blank
6-71

Downloaded from www.Manualslib.com manuals search engine Leaving your hood open and your underhood lamps on
can drain your battery
. If you need to keep the hood
open for an extended period
of time. remove the
underhood lamps fuse
.
Replacement Bulbs
Air Conditioningmeater Control ................ 37
Automatic Transmission Indicator
........... 194NA
Back-up
................................. 1156
Center High-Mounted Stoplamp (except ZR-
1) ... 1156
Center High-Mounted Stoplamp (ZR-
1) ........ 89 1
Console
.................................. 564
Cornering
................................. 1156
Door Courtesy
........................... .21 2-2
DoorFlood
................................ 73
* These bulbs are not owner.serviceab1e . See your dealer.
Driver Information Center * ......................
Floor Courtesy ............................. 562
Fog
...................................... 896
Front Parkingmurn Signal
................. 2057NA
Headlamp ............................. HP6054
Instrument Cluster
License
................................... 24
MirrorFlood
............................... 74
* ............................
Mirror Reading ............................ 168
Rear Courtesy (Convertible)
.................. 562
Rear Courtesy (except Convertible)
............ 906
Sidemarker
................................ 24
Tail/Stop/Turn
............................ 2057
Visor Vanity Mirror
.......................... 74
Radio
* ......................................
Underhood ................................. 2-2
6-74

Downloaded from www.Manualslib.com manuals search engine Replacement Parts
Air Cleaner Filter ......................................
Battery
VIN Engine Code J ....................................
............................... A1097C
GM
Part No. 25096933 or equivalent
................................752-72
..................................................................... VIN Engine Code P 75B-72
Coolant High Fill Reservoir Cap ............................ RC36/GM Part No. 6410785 or equivalent
Crankcase Ventilation Valve
VIN Engine Code J ........................................................ CV746CB and CV9 13C
GM
Part No. 25042723 and GM Part No. 25098197or equivalent
VIN Engine Code
P CV895C
GM
Part No. 25095452 or equivalent
VIN Engine Code
J PF97OC (black)
GM
Part No. 25014155 or equivalent
VIN Engine Code
P ........ ............................................................
GM Part No. 25010908 or equivalent
....................................................................
Engine Oil Filter
..............................................................
PCV Valve (LT1) .............................. ......................... AC Type CV895C
PCV Valve (LT5) ........................... ................. ~.. AC Type CV746CB
AC Type CV913C
6-76