power steering fluid CHEVROLET CORVETTE 1998 5.G Owners Manual

Downloaded from www.Manualslib.com manuals search engine Section 6 Service and Appearance Care
Here you will find information about the care of your vehicle. This section begins with service and fuel information,
and then it shows how to check important fluid and lubricant levels. There is also technical information about your
vehicle, and a part devoted to its appearance care.
6-2
6-3
6-8
6- 12
6- 16
6-18
6- 19
6-20
6-2
1
6-22
6-26
6-26
6-27
6-29
6-32
6-33
6-37
6-40
Service
Fuel
Filling a Portable Fuel Container
Engine Oil
Air Cleaner
Automatic Transmission Fluid
Manual Transmission Fluid
Hydraulic Clutch
Rear Axle
Engine Coolant Surge Tank Pressure Cap
Power Steering Fluid
Windshield Washer Fluid
Brakes
Battery
Bulb Replacement
Windshield Wiper Blade Replacement
Tires 6-52
6-52
6-54
6-54
6-55
6-55
6-56
6-57
6-58
6-58
6-59
6-59
6-61
6-62
6-62
6-62
6-69
6-70 Appearance Care Cleaning the Inside of Your Vehicle
Care of Safety Belts
Cleaning Glass Surfaces
Weatherstrips Cleaning a Removable Roof Panel
Cleaning the Outside of Your Vehicle
Cleaning Your Convertible Top
Cleaning Aluminum Wheels
Cleaning Tires
Finish Damage
Underbody Maintenance
Appearance Care Materials Chart
Vehicle Identification Number (VIN)
Service Parts Identification Label
Electrical System
Replacement Bulbs
Capacities and Specifications
6-1

Downloaded from www.Manualslib.com manuals search engine A. Coolant Surge Tank and Pressure Cap
B. Battery
C. Engine Oil Dipstick
D. Engine Oil Fill Cap
E. Air Cleaner
E Power Steering Fluid Reservoir
G. Brake Fluid Reservoir
H. Hydraulic Clutch Fluid Reservoir (If Equipped)
I. Windshield Washer Fluid Reservoir
Before closing the hood, be sure all the filler caps
are on properly. Then, just pull the hood down and
close it firmly.
!
: ,:: '3 :
6-11

Downloaded from www.Manualslib.com manuals search engine Surge Tank Pressure Cap
NOTICE:
The surge tank pressure cap is a 15 psi (105 kPa)
pressure-type cap and must be tightly installed to prevent coolant
loss and possible engine damage
from overheating.
When you replace the surge tank pressure cap, a GM cap
is recommended.
Thermostat
Engine coolant temperature is controlled by a thermostat
in the engine coolant system. The thermostat stops the
flow of coolant through the radiator until the coolant
reaches a pre-set temperature.
When you replace the thermostat, a GM thermostat
is recommended.
Power Steering Fluid
When to Check Power Steering Fluid
It is not necessary to regularly check power steering fluid
unless you suspect there is a leak
in the system or you hear
an unusual noise. A fluid loss in this system could indicate
a problem. Have the system inspected
and repaired.

Downloaded from www.Manualslib.com manuals search engine How To Check Power Steering Fluid
When the engine compartment is cool, wipe the cap and
the top of the reservoir clean, then unscrew the cap and
wipe the dipstick with a clean rag. Replace the cap and
completely tighten it. Then remove the cap again and
look at the fluid level on the dipstick.
The level should be at the FULL COLD mark. If
necessary, add only enough fluid to bring the level up
to the mark.
0 When the engine
compartment is hot, the
level should be at the
HOT mark.
When the engine compartment is cool, the
level should be at the
FULL COLD mark.
What to Use
To determine what kind of fluid to use, see
“Recommended Fluids and Lubricants” in the Index.
Always use the proper fluid. Failure to use the proper
fluid can cause leaks and damage hoses and seals.
Windshield Washer Fluid
What to Use
When you need windshield washer fluid, be sure to read
the manufacturer’s instructions before use. If you will be
operating your vehicle in
an area where the temperature
may fall below freezing, use a fluid that has sufficient
protection against freezing.
6-27

Downloaded from www.Manualslib.com manuals search engine Part C: Periodic Maintenance
Inspections
Listed below are inspections and services which should
be performed at least twice a year (for instance, each spring and fall).
You should let your dealer’s service
department or other qualified service center do these jobs.
Make sure any necessary repairs are completed at once.
Proper procedures to perform these services may be
found in a service manual. See “Service and Owner
Publications” in the Index.
Steering and Suspension Inspection
Inspect the front and rear suspension and steering
system for damaged, loose or missing parts, signs of
wear or lack of lubrication. Inspect the power steering
lines and hoses for proper hook-up, binding, leaks,
cracks, chafing, etc.
Tire and Wheel Inspection
Inspect the tires for uneven wear or damage. If there is
irregular or premature wear, check the wheel alignment.
Inspect for damaged wheels.
Exhaust System Inspection
Inspect the complete exhaust system. Inspect the body
near the exhaust system. Look for broken, damaged, missing
or out-of-position parts as well as open seams,
holes, loose connections or other conditions which could
cause a heat build-up in the floor pan or could let
exhaust fumes into the vehicle. See “Engine Exhaust”
in the Index.
Radiator and Heater Hose Inspection
Inspect the hoses and have them replaced if they are
cracked, swollen or deteriorated. Inspect all pipes, fittings
and clamps; replace as needed. Clean the outside of the
radiator and air conditioning condenser.
To help ensure
proper operation, a pressure test of the cooling system
and pressure cap is recommended at least once a year.
Rear Axle Service
Check the gear lubricant level in the rear axle and add if
needed. See “Rear Axle” in the Index.
A fluid loss may
indicate a problem. Check the axle and repair it
if needed.
Brake System Inspection
Inspect the complete system. Inspect brake lines and
hoses for proper hook-up, binding, leaks, cracks,
chafing, etc. Inspect disc brake pads for wear and
rotors for surface condition. Inspect other brake parts,
including calipers, parlung brake, etc. You may need to
have your brakes inspected more often if your driving
habits or conditions result in frequent braking.
7-15

Downloaded from www.Manualslib.com manuals search engine Part D: Recommended Fluids and
Lubricants
NOTE: Fluids and lubricants identified below by name,
part number
or specification may be obtained from
your dealer.
USAGE
Engine Oil
FLUIDLUBRICANT
The engine requires a special
Engine Oil meeting GM Standard
GM4718M. Oils meeting this
Standard may be identified as
synthetic, and should
also be
identified with the American
Petroleum Institute Certified For Gasoline Engines “Starburst” symbol. However, not all
Synthetic API oils with the
Starburst symbol will meet this
GM Standard. You should look for
and use only an oil that meets GM
Standard GM47 18M. For the
proper viscosity, see “Engine Oil”
in the Index.
USAGE ~~
Engine Coolant
Hydraulic Brake
System
Hydraulic Clutch System
~
Power Steering System
Manual Transmission
Automatic Transmission
FLUIDLUBRICANT
50/50 mixture of clean water
(preferably distilled) and use only
GM Goodwrench@ DEX-COOL@
or Havoline@ DEX-COOL@
Coolant. See “Engine Coolant” in
the Index.
Delco Supreme
11 @ Brake Fluid
(GM Part No. 12377967
or
equivalent DOT-3 Brake Fluid).
Hydraulic Clutch Fluid (GM Part
No. 12345347 or equivalent
DOT-3 Brake Fluid).
GM Synthetic Power Steering
Fluid
(GM Part No. 12345866 or
12345867 or equivalent).
DEXRON@-I11 Automatic
Transmission Fluid. DEXRON@
-111 Automatic
Transmission Fluid.

Downloaded from www.Manualslib.com manuals search engine Neutral Automatic Transmission
....................... 2-27
Manual Transmission
.......................... 2-29
Neutral. Manual Transmission
..................... 2-29
New Vehicle Break-In
........................... 2-20
Nightvision
................................... 4-15
Off-Road Recovery
............................ 4- 12
Oil. Engine
.................................... 6-12
One to Four Light
............................... 2-30
Outlet. Accessory
............................... 2-59
Overdrive. Automatic Transmission
................ 2-28
Overheated Engine Protection Operating Mode
....... 5- 13
Overheating Engine
............................. 5 - 13
Owner Checks and Services
....................... 7-11
Owner Publications. Ordering
..................... 8- 12
InCanada
................................... 8-11
Paint Spotting. Chemical
........................ 6-60
Park Automatic Transmission
....................... 2-26
Shifting Into
................................. 2-34
Shifting Out of
............................... 2-36 .
Parking AtNight
.................................... 2-17
Brake
...................................... 2-32 ... Lots ....................................... 2-1'1
Your Vehicle. Manual Transmission .............. 2-36
Parking Brake Mechanism Check
.................. 7- 14
Over Things That Burn
........................ 2-37
Passenger Position
.............................. 1 - 18
Passing
....................................... 4- 12 Pass-Key@
.................................... 2-18
Periodic Maintenance Inspections
.................. 7-15
Portable Fuel Container. Filling a
................... 6-8
Door Locks
................................... 2-5
Remote Control Mirrors
........................ 2-54
Seat
......................................... 1-2
Steering
.................................... 4-10
Steering Fluid
................................ 6-26
Windows
................................... 2-40
Plug
....................................... 6-63
Powerseat
..................................... 1-2
Pregnancy, Use
of Safety Belts .................... 1-17
Problems on the Road
............................ 5-1
Publications, Service and Owner
................... 8-12
InCanada
................................... 8-11
Power
Racing or Other Competitive Driving
.............. 2-24
Radio Reception
................................ 3-27
Radios
....................................... 3-12
Rain. Driving
In ................................ 4-17
Reading Lamps
................................ 2-53
Axle
....................................... 6-21
Axle Service
................................. 7-15
Storage
..................................... 2-56
Towing
..................................... 5-11
Window Defogger
............................ 3-11
Reclining Seatbacks
.............................. 1-3
Rear
Turn Signal and Taillamp Bulb Replacement
....... 6-35
Rearview Mirror, Inside Daymight
................. 2-53
Recommended Fluids
and Lubricants ............... 7-16
9-7