ECU CHEVROLET CORVETTE 2005 6.G Service Manual

And, if you do have a heavy load, you should spread it
out. Do not carry more than 100 lbs (45 kg) in the
rear area of your vehicle.
{CAUTION:
Do not load your vehicle any heavier than the
Gross Vehicle Weight Rating (GVWR), or either
the maximum front or rear Gross Axle Weight
Rating (GAWR). If you do, parts on your
vehicle can break, and it can change the way
your vehicle handles. These could cause you
to lose control and crash. Also, overloading
can shorten the life of your vehicle.
Notice:Overloading your vehicle may cause
damage. Repairs would not be covered by your
warranty. Do not overload your vehicle.If you put things inside your vehicle — like suitcases,
tools, packages or anything else — they will go as fast
as the vehicle goes. If you have to stop or turn
quickly, or if there is a crash, they will keep going.
{CAUTION:
Things you put inside your vehicle can strike
and injure people in a sudden stop or turn, or
in a crash.
Put things in the rear area of your vehicle.
Try to spread the weight evenly.
Never stack heavier things, like suitcases,
inside the vehicle so that some of them
are above the tops of the seats.
Do not leave an unsecured child restraint
in your vehicle.
When you carry something inside the
vehicle, secure it whenever you can.
4-35

Coolant Surge Tank Pressure Cap
Notice:If the pressure cap is not tightly installed,
coolant loss and possible engine damage may
occur. Be sure the cap is properly and tightly
secured.
The coolant surge tank pressure cap must be fully
installed on the coolant surge tank. SeeEngine
Compartment Overview on page 5-12for more
information on location.
Engine Overheating
You will nd an engine coolant temperature gage on the
instrument panel cluster and a COOLANT OVER
TEMPERATURE message on the Driver Information
Center (DIC). SeeEngine Coolant Temperature
Gage on page 3-41andDIC Warnings and Messages
on page 3-54for more information.
If Steam Is Coming From Your Engine
{CAUTION:
Steam from an overheated engine can burn
you badly, even if you just open the hood. Stay
away from the engine if you see or hear steam
coming from it. Just turn it off and get
everyone away from the vehicle until it cools
down. Wait until there is no sign of steam or
coolant before you open the hood.
If you keep driving when your engine is
overheated, the liquids in it can catch re. You
or others could be badly burned. Stop your
engine if it overheats, and get out of the
vehicle until the engine is cool.
SeeOverheated Engine Protection Operating
Mode on page 5-26for information on driving
to a safe place in an emergency.
5-24

Emergency Tow:Tow to the nearest dealership
for warranty service or in the event of a
vehicle-disabling accident. Assistance provided
when the vehicle is mired in sand, mud, or snow.
Flat Tire Change:Installation of a spare tire will be
covered at no charge. The customer is responsible
for the repair or replacement of the tire if not
covered by a warrantable failure.
Jump Start:No-start occurrences which require a
battery jump start will be covered at no charge.
Dealer Locator Service
In many instances, mechanical failures are covered
under Chevrolet’s Bumper-to-Bumper warranty.
However, when other services are utilized, our Roadside
Assistance Representatives will explain any payment
obligations you might incur.
For prompt and efficient assistance when calling, please
provide the following to the Roadside Assistance
Representative:
Your name, home address, and home
telephone number.
Telephone number of your location.
Location of the vehicle.
Model, year, color, and license plate number.
Mileage, Vehicle Identication Number (VIN), and
delivery date of the vehicle.
Description of the problem.
While we hope you never have the occasion to use our
service, it is added security while traveling for you
and your family. Remember, we are only a phone
call away. Chevrolet Roadside Assistance:
1-800-CHEV-USA (1-800-243-8872), text
telephone (TTY) users, call 1-888-889-2438.
Chevrolet reserves the right to limit services or
reimbursement to an owner or driver when, in
Chevrolet’s judgement, the claims become excessive in
frequency or type of occurrence.
Roadside Assistance is not part of or included in the
coverage provided by the New Vehicle Limited Warranty.
Chevrolet reserves the right to make any changes or
discontinue the Roadside Assistance program at
any time without notication.
Canadian Roadside Assistance
Vehicles purchased in Canada have an extensive
roadside assistance program accessible from anywhere
in Canada or the United States. Please refer to the
Warranty and Owner Assistance Information book.
7-6

C
California Fuel.................................................. 5-5
Canadian Owners................................................ ii
Capacities and Specications............................5-92
Carbon Monoxide...................2-14, 2-33, 4-26, 4-36
Care of
Safety Belts................................................5-78
Your CD Player...........................................3-99
Your CDs ...................................................3-99
Cargo Cover..................................................2-50
Center Console Storage Area...........................2-47
Chains, Tire...................................................5-68
Check
Engine Light...............................................3-42
Checking Things Under the Hood......................5-10
Chemical Paint Spotting...................................5-82
Child Restraints
Child Restraint Systems...............................1-27
Infants and Young Children...........................1-24
Lower Anchorages and Top Tethers for
Children (LATCH System)..........................1-31
Older Children.............................................1-21
Securing a Child Restraint Designed for the
LATCH System........................................1-33
Securing a Child Restraint in the Passenger
Seat Position...........................................1-35
Top Strap...................................................1-31
Cigarette Lighter.............................................3-25Cleaning
Aluminum Wheels........................................5-81
Cargo Cover and Convenience Net................5-77
Coated Moldings.........................................5-77
Convertible Top...........................................5-80
Exterior Lamps/Lenses.................................5-79
Fabric/Carpet..............................................5-76
Fiberglass Springs.......................................5-82
Finish Care.................................................5-79
Inside of Your Vehicle..................................5-74
Instrument Panel, Vinyl, and Other Plastic
Surfaces.................................................5-77
Leather......................................................5-77
Removable Roof Panel.................................5-80
Tires..........................................................5-81
Underbody Maintenance...............................5-82
Washing Your Vehicle...................................5-78
Weatherstrips..............................................5-78
Windshield and Wiper Blades........................5-79
Climate Control System
Air Filter, Passenger Compartment.................3-31
Dual Automatic............................................3-25
Outlet Adjustment........................................3-31
Clutch, Hydraulic.............................................5-20
Control of a Vehicle.......................................... 4-5
Convenience Net............................................2-50
3

Hood
Checking Things Under................................5-10
Release.....................................................5-10
Horn............................................................... 3-6
How to Use This Manual...................................... ii
How to Wear Safety Belts Properly...................1-12
Hydraulic Clutch.............................................5-20
I
Ignition Positions.............................................2-21
Infants and Young Children, Restraints...............1-24
Ination -- Tire Pressure..................................5-58
Installing the Roof Panel..................................2-55
Instrument Panel
Overview..................................................... 3-4
Instrument Panel (I/P)
Brightness..................................................3-19
Cluster.......................................................3-33
J
Jump Starting.................................................5-38
K
Keyless Access System..................................... 2-4
Keyless Access System, Operation...................... 2-5
Keys............................................................... 2-3
L
Labelling, Tire Sidewall....................................5-52
Lamps
Battery Run-Down Protection.........................3-20
Courtesy....................................................3-19
Exterior......................................................3-15
Exterior Lighting Battery Saver......................3-19
Fog ...........................................................3-17
Reading.....................................................3-19
Twilight Sentinel
®........................................3-18
LATCH System
Child Restraints...........................................1-31
Securing a Child Restraint Designed for the
LATCH System........................................1-33
Latches, Seatback............................................ 1-6
Lifting Your Vehicle, Tires.................................5-69
Light
Active Handling System................................3-40
Airbag Off..................................................3-36
Airbag Readiness........................................3-35
7

Light (cont.)
Anti-Lock Brake System Warning...................3-39
Brake System Warning.................................3-38
Fog Lamp..................................................3-47
Highbeam On.............................................3-47
Lights On Reminder.....................................3-47
Malfunction Indicator....................................3-42
One-to-Four Shift.........................................3-38
Safety Belt Reminder...................................3-34
Security.....................................................3-47
TCS Warning Light......................................3-40
Tire Pressure..............................................3-42
Traction Control System (TCS) Warning..........3-40
Lighting
Entry/Exit...................................................3-19
Limited-Slip Rear Axle.....................................4-11
Loading Your Vehicle.......................................4-31
Lockout Protection..........................................2-13
Locks
Automatic Door Locks..................................2-13
Door..........................................................2-10
Lockout Protection.......................................2-13
Power Door................................................2-12
Programmable Automatic Door Unlock............2-13
Loss of Control...............................................4-16
Lumbar
Power and Side Bolsters................................ 1-3M
Maintenance Schedule
Additional Required Services........................... 6-6
At Each Fuel Fill........................................... 6-9
At Least Once a Month.................................. 6-9
At Least Once a Year.................................... 6-9
Introduction.................................................. 6-2
Maintenance Footnotes.................................. 6-7
Maintenance Record....................................6-16
Maintenance Requirements............................. 6-2
Normal Maintenance Replacement Parts.........6-14
Owner Checks and Services........................... 6-8
Recommended Fluids and Lubricants.............6-12
Scheduled Maintenance................................. 6-4
Using.......................................................... 6-2
Your Vehicle and the Environment................... 6-2
Malfunction Indicator Light................................3-42
Manual Seats................................................... 1-2
Manual Transmission
Fluid..........................................................5-20
Operation...................................................2-27
Memory.........................................................2-68
Message
DIC Warnings and Messages........................3-54
8

Roof Panel....................................................2-52
Installing the Roof Panel...............................2-55
Removing the Roof Panel.............................2-52
Storing the Roof Panel.................................2-54
Routing, Engine Drive Belt...............................6-15
Running the Engine While Parked.....................2-34
S
Safety Belt
Pretensioners..............................................1-20
Reminder Light............................................3-34
Safety Belts
Care of......................................................5-78
Driver Position............................................1-13
How to Wear Safety Belts Properly................1-12
Passenger Position......................................1-20
Questions and Answers About Safety Belts.....1-11
Safety Belt Extender....................................1-20
Safety Belt Use During Pregnancy.................1-19
Safety Belts Are for Everyone......................... 1-7
Safety Warnings and Symbols.............................. iii
Scheduled Maintenance..................................... 6-4
Seatback Latches............................................. 1-6Seats
Heated Seats............................................... 1-4
Manual........................................................ 1-2
Power Lumbar and Side Bolsters.................... 1-3
Reclining Seatbacks...................................... 1-4
Seatback Latches.......................................... 1-6
Six-Way Power Seats.................................... 1-2
Securing a Child Restraint
Designed for the LATCH System...................1-33
Passenger Seat Position...............................1-35
Security Light.................................................3-47
Selective Ride Control.....................................4-12
Service........................................................... 5-3
Adding Equipment to the Outside of Your
Vehicle..................................................... 5-5
Doing Your Own Work................................... 5-4
Engine Soon Light.......................................3-42
Publications Ordering Information...................7-11
Servicing Your Airbag-Equipped Vehicle..............1-51
Setting the Time.............................................3-78
Shifting Into Park (P).......................................2-30
Shifting Out of Park (P)...................................2-32
Signals, Turn and Lane-Change.......................... 3-8
Specications, Capacities.................................5-92
Speedometer..................................................3-34
11