heater CHEVROLET CRUZE 2019 Track Prep Guide

Chevrolet Cruze Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
12146336) - 2019 - crc - 10/22/18
218 Driving and Operating
enhance vehicle operation in cold
weather at temperatures below 0 °C
(32 °F). Use of No. 1-D diesel fuel
may lower the fuel economy. For
additional information for better cold
weather operation, seeEngine
Heater 0177.
Water in Fuel (Diesel)
Improper fuel tank inspection or
cleaning, or contaminated fuel from
suppliers, can cause water to be
pumped into the fuel tank along
with the diesel fuel. If a WATER IN
FUEL - CONTACT SERVICE
message displays, the water must
be drained immediately.
{Warning
Diesel fuel containing water is still
combustible. You or others could
be burned. If the fuel needs to be
drained, keep sparks, flames, and
smoking materials away from the
mixture. As an added precaution, drain the
diesel fuel filter of residual water at
every engine oil change. If the
WATER IN FUEL - CONTACT
SERVICE message comes on
frequently, even after draining water
from the fuel filter, see your dealer.
Water in Fuel Troubleshooting
If the WATER IN FUEL - CONTACT
SERVICE message comes on:
Problem Recommended
Action
Message
displays but
goes off during
the ignition
cycle. The fuel filter is
partially filled
with water. Drain
the water as
soon as
possible. See
"Removing
Water from the
Fuel Filter"
following. Problem
Recommended
Action
Message
displays and
stays on. Drain the fuel
filter
immediately.
If no water can
be drained, and
the temperature
is below
freezing, then
water may be
frozen in the
filter. Move the
vehicle to a
warm location to
thaw the water,
then drain the
fuel. If water still
does not drain,
see your dealer.

Chevrolet Cruze Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
12146336) - 2019 - crc - 10/22/18
Vehicle Care 243
1.6L L4 Diesel Engine (LH7)
1. Engine Cooling Fan (Outof View)
2. Engine Coolant Surge Tank and Pressure Cap
{Warning
An underhood electric fan can
start up even when the engine is
not running and can cause injury.
Keep hands, clothing, and tools
away from any underhood
electric fan.
{Warning
Do not touch heater or radiator
hoses, or other engine parts.
They can be very hot and can
burn you. Do not run the engine if
there is a leak; all coolant could
leak out. That could cause an
engine fire and can burn you. Fix
any leak before driving the
vehicle.
Engine Coolant
The cooling system in the vehicle is
filled with DEX-COOL engine
coolant. This coolant is designed to
remain in the vehicle for 5 years or
240 000 km (150,000 mi), whichever
occurs first.
The following explains the cooling
system and how to check and add
coolant when it is low. If there is a
problem with engine overheating,
see Engine Overheating 0246.
What to Use
{Warning
Plain water, or other liquids such
as alcohol, can boil before the
proper coolant mixture will. With
plain water or the wrong mixture,
the engine could get too hot but
there would not be an overheat
warning. The engine could catch
fire and you or others could be
burned.
Use a 50/50 mixture of clean,
drinkable water and DEX-COOL
coolant. If using this mixture,
nothing else needs to be added.
This mixture:
. Gives freezing protection down
to−37 °C (−34 °F), outside
temperature.
. Gives boiling protection up to
129 °C (265 °F), engine
temperature.
. Protects against rust and
corrosion.

Chevrolet Cruze Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
12146336) - 2019 - crc - 10/22/18
Vehicle Care 247
too serious. Sometimes the engine
can get a little too hot when the
vehicle:
.Climbs a long hill on a hot day.
. Stops after high-speed driving.
. Idles for long periods in traffic.
If the overheat warning is displayed
with no sign of steam: 1. Turn the air conditioning off.
2. Turn the heater on to the highest temperature and to the
highest fan speed. Open the
windows as necessary.
3. When it is safe to do so, pull off the road, shift to P (Park) or
N (Neutral), and let the
engine idle.
If the engine coolant temperature
gauge is no longer in the overheat
zone, the vehicle can be driven.
Continue to drive the vehicle slowly
for about 10 minutes. Keep a safe
distance from the vehicle in front.
If the warning does not come back
on, continue to drive normally and
have the cooling system checked
for proper fill and function. If the warning continues, pull over,
stop, and park the vehicle
right away.
If there is no sign of steam, idle the
engine for three minutes while
parked. If the warning is still
displayed, turn off the engine until it
cools down.
Washer Fluid
What to Use
When windshield washer fluid is
needed, be sure to read the
manufacturer's instructions before
use. If operating the vehicle in an
area where the temperature may fall
below freezing, use a fluid that has
sufficient protection against
freezing.
Adding Washer Fluid
Open the cap with the washer
symbol on it. Add washer fluid until
the tank is full. See
Engine
Compartment Overview 0233 for
reservoir location.
Caution
. Do not use washer fluid that
contains any type of water
repellent coating. This can
cause the wiper blades to
chatter or skip.
. Do not use engine coolant
(antifreeze) in the
windshield washer. It can
damage the windshield
washer system and paint.
. Do not mix water with
ready-to-use washer fluid.
Water can cause the
solution to freeze and
damage the washer fluid
tank and other parts of the
washer system.
(Continued)

Chevrolet Cruze Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
12146336) - 2019 - crc - 10/22/18
Vehicle Care 265
The vehicle may not be equipped
with all of the fuses, relays, and
features shown.Fuses Usage
F01 Starter
F02 Starter
F03 O2 sensor
F04 Engine control module
F05 Aero shutter/ Fuel flex
F06 Transmission control module
F07 –
F08 Engine control module
F09 A/C
F10 Canister vent
F11 Heated seats
F12 EOCM/CGM
F13 –
F14 Diesel NOx/CVT8 transmission Fuses Usage
F15 O2 sensor
F16 Fuel injection
F17 Fuel injection
F18 SCR module
F19 Diesel NOx/Coolant motor
F20 –
F21 DC/AC converter
F22 ABS system
F23 Windshield washer/ Rear windows
F24 –
F25 Diesel fuel heating
F26 Transmission
F27 –
F28 –
F29 Heated rear window
F30 Mirror defogger
F31 – Fuses Usage
F32 Display LED/DC DC converter/FPPM/
Electrical heater/A/C
module
F33 Anti-theft warning horn
F34 Horn
F35 Trunk power outlet
F36 Right high-beam headlamp
F37 Left high-beam headlamp
F38 –
F39 Front fog lamps
F40 AIR solenoid
F41 Switchable water pump/Water in fuel
sensor
F42 Manual headlamp leveling
F43 Fuel pump

Chevrolet Cruze Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
12146336) - 2019 - crc - 10/22/18
370 Index
Driving (cont'd)Loss of Control . . . . . . . . . . . . . . . 162
Off-Road Recovery . . . . . . . . . . . 161
Vehicle Load Limits . . . . . . . . . . . 165
Wet Roads . . . . . . . . . . . . . . . . . . . 162
Winter . . . . . . . . . . . . . . . . . . . . . . . . 164
E
Electrical Equipment,
Add-On . . . . . . . . . . . . . . . . . . . . . . . 226
Electrical System Engine Compartment FuseBlock . . . . . . . . . . . . . . . . . . . . . . . . 263
Fuses and Circuit Breakers . . . 262
Instrument Panel Fuse
Block . . . . . . . . . . . . . . . . . . . . . . . . 267
Overload . . . . . . . . . . . . . . . . . . . . . 262
Emergency OnStar . . . . . . . . . . . . . . . . . . . . . . . 356
Engine Air Cleaner/Filter . . . . . . . . . . . . . 241
Check Light (MalfunctionIndicator) . . . . . . . . . . . . . . . . . . . . 124
Compartment Overview . . . . . . . 233
Coolant Temperature
Gauge . . . . . . . . . . . . . . . . . . . . . . 121
Cooling System . . . . . . . . . . . . . . . 242
Drive Belt Routing . . . . . . . . . . . . 340 Engine (cont'd)
Exhaust . . . . . . . . . . . . . . . . . . . . . . 181
Heater . . . . . . . . . . . . . . . . . . . . . . . . 177
Oil Life System . . . . . . . . . . . . . . . 239
Oil Pressure Light . . . . . . . . . . . . 129
Overheating . . . . . . . . . . . . . . . . . . 246
Power Messages . . . . . . . . . . . . . 138
Running While Parked . . . . . . . . 181
Starting . . . . . . . . . . . . . . . . . . . . . . . 173
Engines Diesel Fuel . . . . . . . . . . . . . . . . . . . 215
Entry Lighting . . . . . . . . . . . . . . . . . . . 149
Event Data Recorders . . . . . . . . . . 353
Exhaust Fluid Diesel . . . . . . . . . . . . . . . . . . . . . . . . 183
Exit Lighting . . . . . . . . . . . . . . . . . . . . 149
Extended Parking . . . . . . . . . . . . . . . 180
Extender, Seat Belt . . . . . . . . . . . . . . 72
Exterior Lamp Controls . . . . . . . . . 143
Exterior Lighting Battery Saver . . . . . . . . . . . . . . . . . . . . . . . . . 149
F
Filter . . . . . . . . . . . . . . . . . . . . . . . . . . . . 182Fuel . . . . . . . . . . . . . . . . . . . . . . . . . . 251
Replacement (Fuel) . . . . . . . . . . . 221 Filter,
Engine Air Cleaner . . . . . . . . . . . 241
Flash-to-Pass . . . . . . . . . . . . . . . . . . . 145
Flashers, Hazard Warning . . . . . . 146
Flat Tire . . . . . . . . . . . . . . . . . . . . . . . . 291 Changing . . . . . . . . . . . . . . . . . . . . . 299
Floor Mats . . . . . . . . . . . . . . . . . . . . . . 320
Fluid
Automatic Transmission . . . . . . 240
Brakes . . . . . . . . . . . . . . . . . . . . . . . . 249
Washer . . . . . . . . . . . . . . . . . . . . . . . 247
Fog Lamps . . . . . . . . . . . . . . . . . . . . . 147 Bulb Replacement . . . . . . . . . . . . 257
Folding Mirrors . . . . . . . . . . . . . . . . . . 52
Forward Automatic Braking . . . . . 205
Forward Collision Alert (FCA) System . . . . . . . . . . . . . . . . . 203
Frequency Statement Radio . . . . . . . . . . . . . . . . . . . . . . . . . 351
Front Fog Lamp Light . . . . . . . . . . . . . . . . . . . . . . . . . . 131
Front Pedestrian Braking (FPB) System . . . . . . . . . . . . . . . . . 207
Front Seats Adjustment . . . . . . . . . . . . . . . . . . . . . 59
Heated . . . . . . . . . . . . . . . . . . . . . . . . . 62
Fuel Additives . . . . . . . . . . . . . . . . . . . . . 215

Chevrolet Cruze Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
12146336) - 2019 - crc - 10/22/18
Index 371
Fuel (cont'd)Biodiesel . . . . . . . . . . . . . . . . . . . . . 216
Cold Weather Operation . . . . . . 217
Diesel Engines . . . . . . . . . . . . . . . 215
Economy Driving . . . . . . . . . . . . . . . 27
Filling a Portable Fuel
Container . . . . . . . . . . . . . . . . . . . 225
Filling the Tank . . . . . . . . . . 221, 223
Filter . . . . . . . . . . . . . . . . . . . . . . . . . . 251
Filter Replacement . . . . . . . . . . . 221
Foreign Countries . . . . . . . . . . . . 215
Gauge . . . . . . . . . . . . . . . . . . . . . . . . 120
Low Fuel Warning Light . . . . . . . 130
Prohibited Fuels . . . . . . . . . . . . . . 214
Recommended . . . . . . . . . . . . . . . 214
Running out of Fuel . . . . . . . . . . . 220
Top Tier . . . . . . . . . . . . . . . . . 213, 214
Water in Fuel . . . . . . . . . . . . . . . . . 218
Fuel for Diesel Engines . . . . . . . . . 215
Fuses Engine Compartment FuseBlock . . . . . . . . . . . . . . . . . . . . . . . . 263
Fuses and Circuit Breakers . . . 262
Instrument Panel Fuse
Block . . . . . . . . . . . . . . . . . . . . . . . . 267
G
Gas Strut(s) . . . . . . . . . . . . . . . . . . . . 254 Gauges
Engine Coolant
Temperature . . . . . . . . . . . . . . . . 121
Fuel . . . . . . . . . . . . . . . . . . . . . . . . . . 120
Odometer . . . . . . . . . . . . . . . . . . . . . .119
Speedometer . . . . . . . . . . . . . . . . . .119
Tachometer . . . . . . . . . . . . . . . . . . . .119
Trip Odometer . . . . . . . . . . . . . . . . .119
Warning Lights and Indicators . . . . . . . . . . . . . . . . . . . .114
General Information
Service and Maintenance . . . . . 322
Towing . . . . . . . . . . . . . . . . . . . . . . . . 226
Vehicle Care . . . . . . . . . . . . . . . . . . 229
Glove Box . . . . . . . . . . . . . . . . . . . . . . 106
GM Mobility Reimbursement Program . . . . . . . . . . . . . . . . . . . . . . . 345
H
Halogen Bulbs . . . . . . . . . . . . . . . . . . 255
Hazard Warning Flashers . . . . . . . 146
Head Restraints . . . . . . . . . . . . . . . . . 58
HeadlampsAiming . . . . . . . . . . . . . . . . . . . . . . . . 255
Automatic . . . . . . . . . . . . . . . . . . . . . 145
Bulb Replacement . . . . . . . . . . . . 255
Daytime RunningLamps (DRL) . . . . . . . . . . . . . . . . 145 Headlamps (cont'd)
Flash-to-Pass . . . . . . . . . . . . . . . . . 145
High-Beam On Light . . . . . . . . . . 131
High/Low Beam Changer . . . . . 145
Lamps On Reminder . . . . . . . . . 131
Heated Steering Wheel . . . . . . . . . . . . . . . .110
Heated Front Seats . . . . . . . . . . . . . . 62
Heated Mirrors . . . . . . . . . . . . . . . . . . . 52
Heater Engine . . . . . . . . . . . . . . . . . . . . . . . . 177
Heating . . . . . . . . . . . . . . . . . . . . 151, 153
High-Beam On Light . . . . . . . . . . . . 131
High-Speed Operation . . . . . . . . . . 278
Hill and Mountain Roads . . . . . . . . 163
Hill Start Assist (HSA) . . . . . . . . . . 195
Hood . . . . . . . . . . . . . . . . . . . . . . . . . . . 231
Horn . . . . . . . . . . . . . . . . . . . . . . . . . . . . 110
How to Wear Seat Belts Properly . . . . . . . . . . . . . . . . . . . . . . . . 67
HVAC . . . . . . . . . . . . . . . . . . . . . . 151, 153
I
Ignition Positions . . . . . . . . . . 169, 171
Ignition Transmission Lock Check . . . . . . . . . . . . . . . . . . . . . . . . . 252
Immobilizer . . . . . . . . . . . . . . . . . . . . . . 50