cooling CHEVROLET EXPRESS 1997 1.G Owner's Manual

Downloaded from www.Manualslib.com manuals search engine Engine Identification -- Gasoline Engines
Type V6 V8 Engine
“VORTEC”4300 “VORTEC”5000
VIN Code W M
Fuel System CSFI~ CSFI 1
Central Sequential Fuel
Injection
2Sequential Fuel Injection
Wheel Nut Torque
MODEL
All
TORQUE
140 ft-lb (1 90 N-m)
Cooling System Capacity
ENGINE VIN
“VORTEC”4300 W
“VORTEC”5000 M
“VORTEC”5700 R
“VORTEC”7400 J
“VORTEC”5700
V8
R
CSFI 1
“VORTEC”7400
V8
J
SFI*
QTY Without Rear Heater*
1 1 Quarts (10.4 L)
17 Quarts ( 16 L)
17 Quarts ( 16 L)
23 Quarts (21.8 L)
QTY With Rear Heater*
14 Quarts (13.2 L)
20 Quarts (18.9 L)
20 Quarts (18.9 L)
26 Quarts (24.6 L)
After refill, the level MUST be checked as outlined under “Engine Cooling System” in Section 5.
*All quantities are approximate.

Downloaded from www.Manualslib.com manuals search engine Maintenance Schedule
I Short TripKity Intervals -- Gasom
Every 100,000 Miles (166 000 km): Spark Plug Wire
Inspection. Spark Plug Replacement. Positive
Crankcase Ventilation (PCV) Valve Inspection.
Every 150,000 Miles (240 000 km): Cooling System
These intervals only summarize maintenance services.
Be sure to-follow the complete maintenance schedule on
the following pages.
Service (or every 60 months, whichever occurs first).
I
Follow this maintenance schedule only if none of the
conditions from
the Short Trip/City Maintenance
Schedule is true.
Do not use this schedule if the vehicle
is used
for trailer towing, driven in a dusty area or used
off paved roads. Use the Short Trip/City schedule for
these conditions.
Driving a vehicle with ~l$dly warmed engine under
highway conditions causes engine
oil to break
down slower:

Downloaded from www.Manualslib.com manuals search engine Maintenance Schedule
Every 7,500 Miles (12 500 km): Engine Oil and Filter
Change (or every
12 months, whichever occurs first).
Chassis Lubrication (or every
12 months, whichever
occurs first). Drive Axle Service. Tire Rotation.
Every 15,000 Miles (25 000 km): Shields and
Underhood Insulation Inspection (GVWR above
8,500 lbs. only).
Every 30,000 Miles (50 000 km): Fuel Filter
Replacement. Air Cleaner Filter Replacement. Front
Wheel Bearing Repack (or at each brake relining,
whichever occurs first).
Every 50,000 Miles (83 000 km): Automatic
Transmission Service (vehicles over
8600 GVWR or
driven under severe conditions only).
Every 60,000 Miles (100 000 km): Engine Accessory
Drive Belt Inspection. Fuel Tank, Cap and Lines
Inspection. Exhaust Gas Recirculation System
Inspection. Evaporative Control System Inspection.
I Long Tripmighway Intervals -- Gasoline Engines 1
Every 100,000 Miles (166 000 km): Spark Plug Wire
Inspection. Spark Plug Replacement. Positive
Crankcase Ventilation (PCV) Valve Inspection.
Every 150,000 Miles (240 000 km): Cooling System
Service (or every
60 months, whichever occurs first).
These intervals only summarize maintenance services.
Be sure to follow the complete maintenance schedule
on the following pages.
7-7

Downloaded from www.Manualslib.com manuals search engine I Short ’IYipKity Maintenance Schedule =- Gasoline Engines I
- In hilly or mountainous terrain.
- When doing frequent trailer towing.
- Uses such as found in taxi, police or
delivery service.
IJ’yo~1 do not use your vehicle under any of these
conditions, the.fluid
and.filter do not require changing.
0 Inspect Positive Crankcase Ventilation
(Pcv) valve.
An Emission Control Service.
I I I 1
DATE
SERVICED BY ACTUAL MILEAGE
150,000 Miles (240 000 km)
0 Drain, flush and refill cooling system
(or every
60 months since last service,
whichever occurs first). See “Engine
Coolant” in the Index for
what to use.
Inspect hoses. Clean radiator, condenser,
pressure cap and neck. Pressure test cooling
system and pressure cap.
An Emission Control Service.
DATE SERVICED BY ACTUAL MILEAGE

Downloaded from www.Manualslib.com manuals search engine Long TripMighway Maintenance Schedule -- Gasoline Engines 1
100,000 Miles (166 000 km) (Continued)
- In hilly or mountainous terrain.
- When doing frequent trailer towing.
- Uses such as found in taxi, police or
delivery service.
If you do not use your vehicle under any of these
conditions, thefluid andfilter do not require changing.
0 Inspect Positive Crankcase Ventilation
(Pcv) valve. An Emission Control Service.
150,000 Miles (240 000 km)
0 Drain, flush and refill cooling system
(or every
60 months since last service,
whichever occurs first). See “Engine
Coolant”
in the Index for what to use.
Inspect hoses. Clean radiator, condenser,
pressure cap and neck. Pressure test the
cooling system and pressure cap.
Arz Emission Control Service.
DATE SERVICED BY ACTUAL MILEAGE
7-44

Downloaded from www.Manualslib.com manuals search engine Climate Control. Standard ......................... 3-2
Climate Control System
........................... 3-2
Clock. Setting the
................................ 3-8
Comfort Controls
................................ 3-2
Compact Disc Care
............................. 3-27
Compact Disc Player
....................... 3-18. 3-22
Console Storage
................................ 2-44
Control
of a Vehicle .............................. 4-6
Convex Outside Mirror
.......................... 2-44
Coolant
....................................... 6-22
RecoveryTank
............................... 5-16
Cooling System
................................ 5- 14
Courtesy Transportation ........................... 8-8
Cruise Control ................................. 2-36
Cupholders
.................................... 2-44
Customer Assistance for Text Telephone Users
......... 8-4
Customer Assistance Information
................... 8- 1
Customer Satisfaction Procedure .................... 8-2
Damage. Finish ............................... 6-56
Damage. Sheet Metal
............................ 6-55
Daytime Running Lamps Indicator Light
............ 2-54
Daytime
Running Lamps
......................... 2-40
Dead Battery
................................... 5-3
Defects. Reporting Safety
........................ 8- 10
Defensive Driving
............................... 4-2
Defogging
................................. 3-2. 3-4
Defrosting
................................. 3.2. 3.4
Dome
Lamps .................................. 2-40
Door
Locks ....................................... 2-4
Sliding
..................................... 2-11
Storage
..................................... 2-45
Storagepocket
............................... 2-45
Swing-Out Side
............................... 2-9
Drive Position. Automatic Transmission
............. 2-22
Driver Position
................................. 1-15
Driving
City
........................................ 4-19
Defensive
.................................... 4-2
Drunken
..................................... 4-3
Freeway
.................................... 4-20
InaBlizzard
................................. 4-25
In Foreign Countries ........................... 6-5
In the Rain .................................. 4-16
Night
...................................... 4-14
OnCurves
................................... 4-9
On Grades While Towing
a Trailer ............... 4-36
On Hill and Mountain Roads .................... 4-22
OnSnowandIce
............................. 4-24
Throughwater ............................... 4-18
WetRoads
.................................. 4-16
Winter
...................................... 4-24
With a Trailer
................................ 4-34
Drunken Driving
................................ 4-3
Dual Tire Operation
............................. 6-45

Downloaded from www.Manualslib.com manuals search engine Electrical Equipment. Adding
Electrical System
............
Electronic Road Speed Governor
Engine
....................
Coolant ..................
Coolant Level Check .......
Coolant Temperature Gage . .
Exhaust ..................
Fuse Block ...............
Identification .............
Oil Level Check ...........
Overheating ..............
Running While Parked ......
Starting Your .............
Engine Oil .................
Adding ..................
Additives ................
Checking ................
Pressure Gage .............
Used ....................
Cooling System ...........
................... 6-59
................... 6-59
(Gasoline Engines)
... 2-60
.................... 6-9
................... 6-22
................... 7-45
................... 2-59
................... 6-65
................... 2-28
................... 6-63
.............. 6.58. 6..65
................... 7-45
................... 5-12
................... 2-28
................... 2-17
................... 6-12
................... 6-12
................... 6-16
................... 6-13
................... 2-57
................... 6-16
Whentochange
.............................. 6-16
Exhaust. Engine
................................ 2-28
Fabric Cleaning
............................... 6-50
Fan Control. Climate Control System
................ 3-2
Filling Your Tank
................................ 6-5
Filter. Air
..................................... 6-17
Finish Care
.................................... 6-54 Finish Damage
................................. 6-56
First Gear. Automatic Transmission
................ 2-22
Flashers. Hazard Warning
......................... 5-2
Flat Tire. Changing
............................. 5-23
Fluids and Lubricants
............................ 7-51
Foreign Countries. Fuel
........................... 6-5
French Language Manual
11
Front ParkingKurn Signal Lamp Bulb Replacement .... 6-35
Front Storage Area .............................. 2-44
FrontTowing
.................................. 5-10
Fuel .......................................... 6-3
Canada
...................................... 6-5
FillingYourTank
.............................. 6-5
Gage
....................................... 2-58
In Foreign Countries
........................... 6-5
Tankcapacity
............................... 6-66
Fuses
and Circuit Breakers ....................... 6-60
.. ...........................
Gages
Engine Coolant Temperature
.................... 2-59
Engine Oil Pressure
........................... 2-57
Fuel
....................................... 2-58
Speedometer
................................. 2-49
Voltmeter
................................... 2-60
Gear Positions. Automatic Transmission
............. 2-20
Gross Axle Weight Rating ........................ 4-28
Gross Vehicle Weight Rating
...................... 4-27
Guide en Frangais
11
GVWR ....................................... 4-27
GAWR
....................................... 4-28
.. .................................
9-4
.