change wheel CHEVROLET EXPRESS CARGO 2021 User Guide

Chevrolet Express Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
14583525) - 2021 - CRC - 12/9/20
222 Vehicle Care
“Removing the Flat Tire and Installing
the Spare Tire”underTire Changing
0 229 and “Wheel Nut Torque” under
Capacities and Specifications 0261 and
“Removing the Flat Tire and Installing
the Spare Tire” underTire Changing
0 229.
The outer tire on a dual wheel setup
generally wears faster than the inner
tire. Tires last longer and wear more
evenly if they are rotated. See Tire
Inspection 0221 and
Tire Rotation 0221. Also see
Maintenance Schedule 0251.
If the full-size spare tire is part of the
tire rotation, make sure the tire rotated
into the spare position is stored
securely. Push, pull, and then try to
rotate or turn the tire. If it moves, use
the wheel wrench/hoist shaft to tighten
the cable. See Tire Changing0229.
Use this rotation pattern when rotating
the tires if the vehicle has dual rear
wheels.
When installing dual wheels, check that
the vent holes in the inner and outer
wheels on each side are lined up.
Adjust the front and rear tires to the
recommended inflation pressure on the
Tire and Loading Information label after
the tires have been rotated. See Tire
Pressure 0217 and
Vehicle Load Limits 0132.
Reset the Tire Pressure Monitor System.
See Tire Pressure Monitor Operation
0 218. Check that all wheel nuts are properly
tightened. See
“Wheel Nut Torque”
under Capacities and Specifications
0 261, and “Removing the Flat Tire and
Installing the Spare Tire” underTire
Changing 0229.
{Warning
Rust or dirt on a wheel, or on the
parts to which it is fastened, can
cause wheel nuts to become loose
over time. The wheel could come off
and cause a crash. When changing a
wheel, remove any rust or dirt from
places where the wheel attaches to
the vehicle. In an emergency, a cloth
or paper towel can be used; however,
use a scraper or wire brush later to
remove all rust or dirt.
Lightly coat the inner diameter of the
wheel hub opening with wheel bearing
grease after a wheel change or tire
rotation to prevent corrosion or rust
build-up.

Chevrolet Express Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
14583525) - 2021 - CRC - 12/9/20
228 Vehicle Care
slowly. But if there is ever a blowout, here
are a few tips about what to expect and
what to do:
If a front tire fails, the flat tire creates a
drag that pulls the vehicle toward that side.
Take your foot off the accelerator pedal and
grip the steering wheel firmly. Steer to
maintain lane position, and then gently
brake to a stop, well off the road,
if possible.
A rear blowout, particularly on a curve, acts
much like a skid and may require the same
correction as used in a skid. Stop pressing
the accelerator pedal and steer to straighten
the vehicle. It may be very bumpy and
noisy. Gently brake to a stop, well off the
road, if possible.
{Warning
Driving on a flat tire will cause
permanent damage to the tire.
Re-inflating a tire after it has been driven
on while severely underinflated or flat
may cause a blowout and a serious crash.
Never attempt to re-inflate a tire that has
been driven on while severely(Continued)
Warning (Continued)
underinflated or flat. Have your dealer or
an authorized tire service center repair or
replace the flat tire as soon as possible.
{Warning
Lifting a vehicle and getting under it to
do maintenance or repairs is dangerous
without the appropriate safety equipment
and training. If a jack is provided with
the vehicle, it is designed only for
changing a flat tire. If it is used for
anything else, you or others could be
badly injured or killed if the vehicle slips
off the jack. If a jack is provided with the
vehicle, only use it for changing a
flat tire.
If a tire goes flat, avoid further tire and
wheel damage by driving slowly to a level
place, well off the road, if possible. Turn on
the hazard warning flashers. See Hazard
Warning Flashers 092.
{Warning
Changing a tire can be dangerous. The
vehicle can slip off the jack and roll over
or fall causing injury or death. Find a
level place to change the tire. To help
prevent the vehicle from moving:
1. Set the parking brake firmly.
2. Put an automatic transmission in P (Park) or a manual transmission in
1 (First) or R (Reverse).
3. Turn off the engine and do not restart while the vehicle is raised.
4. Do not allow passengers to remain in the vehicle.
5. Place wheel blocks, if equipped, on both sides of the tire at the opposite
corner of the tire being changed.
When the vehicle has a flat tire (2), use the
following example as a guide to assist in the
placement of the wheel blocks (1),
if equipped.

Chevrolet Express Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
14583525) - 2021 - CRC - 12/9/20
Vehicle Care 229
1. Wheel Block (If Equipped)
2. Flat Tire
The following information explains how to
repair or change a tire.
Tire Changing
Removing the Spare Tire and Tools
Equipment needed for a cargo van or a
passenger van is in the passenger side rear
corner of the vehicle.
Remove the retaining wing bolt and lift it
off of the mounting bracket.
Equipment needed for a 15-passenger seating
arrangement is secured on the rear floor on
the passenger side of the vehicle.Remove the retaining wing bolt and lift it
out of the mounting bracket to access the
equipment.
The tools you will be using include:

Chevrolet Express Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
14583525) - 2021 - CRC - 12/9/20
Service and Maintenance 255
(6)Or every 12 months, whichever comes
first. See Wiper Blade Replacement 0201.
(7) Replace air conditioning desiccant every
seven years.
Special Application Services
.Vehicles with Dual Wheels: Check dual
wheel nut torque at 160, 1 600, and
10 000 km (100, 1,000, and 6,000 mi) of
driving. Repeat this service whenever a
tire/wheel is serviced or removed.
.Severe Commercial Use Vehicles Only:
Lubricate chassis components every oil
change.
.Have underbody flushing service
performed. See “Underbody Maintenance”
in Exterior Care 0242.
Additional Maintenance
and Care
Your vehicle is an important investment and
caring for it properly may help to avoid
future costly repairs. To maintain vehicle
performance, additional maintenance
services may be required. It is recommended that your dealer perform
these services
—their trained dealer
technicians know your vehicle best. Your
dealer can also perform a thorough
assessment with a multi-point inspection to
recommend when your vehicle may need
attention.
The following list is intended to explain the
services and conditions to look for that may
indicate services are required.
Battery
The 12-volt battery supplies power to start
the engine and operate any additional
electrical accessories.
.To avoid break-down or failure to start
the vehicle, maintain a battery with full
cranking power.
.Trained dealer technicians have the
diagnostic equipment to test the battery
and ensure that the connections and
cables are corrosion-free.
Belts
.Belts may need replacing if they squeak
or show signs of cracking or splitting.
.Trained dealer technicians have access to
tools and equipment to inspect the belts
and recommend adjustment or
replacement when necessary. Brakes
Brakes stop the vehicle and are crucial to
safe driving.
.Signs of brake wear may include chirping,
grinding, or squealing noises, or difficulty
stopping.
.Trained dealer technicians have access to
tools and equipment to inspect the brakes
and recommend quality parts engineered
for the vehicle.
Fluids
Proper fluid levels and approved fluids
protect the vehicle’s systems and
components. See Recommended Fluids and
Lubricants 0257 for GM approved fluids.
.Engine oil and windshield washer fluid
levels should be checked at every fuel fill.
.Instrument cluster lights may come on to
indicate that fluids may be low and need
to be filled.
Hoses
Hoses transport fluids and should be
regularly inspected to ensure that there are
no cracks or leaks. With a multi-point
inspection, your dealer can inspect the hoses
and advise if replacement is needed.

Chevrolet Express Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
14583525) - 2021 - CRC - 12/9/20
Index 293
Signals, Turn and Lane-Change . . . . . . . . . . . . 93
Sliding Door . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .14
Special Application Services . . . . . . . . . . . . . . 255
Specifications and Capacities . . . . . . . . . . . . . 261
Speedometer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 71
StabiliTrakOFF Light . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 79
Start Assist, Hill . . . . . . . . . . . . . . . . . . . . . . . . . . .147
Start Vehicle, Remote . . . . . . . . . . . . . . . . . . . . . 10
Starter Switch Check . . . . . . . . . . . . . . . . . . . . . 200
Starting the Engine . . . . . . . . . . . . . . . . . . . . . . . 137
Steering . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 127 Fluid, Power . . . . . . . . . . . . . . . . . . . . . . . . . . . 196
Wheel Adjustment . . . . . . . . . . . . . . . . . . . . . . 65
Wheel Controls . . . . . . . . . . . . . . . . . . . . . . . . . 66
Storage Areas
Front . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 63
Storage Compartments . . . . . . . . . . . . . . . . . . . 63
Stuck Vehicle . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 131
Sun Visors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21
Swing-out Windows . . . . . . . . . . . . . . . . . . . . . . 20
Switches Airbag On-Off . . . . . . . . . . . . . . . . . . . . . . . . . . . 42
Symbols . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2
System Forward Collision Alert (FCA) . . . . . . . . . . . 154
Infotainment . . . . . . . . . . . . . . . . . . . . . . . 96, 276
Noise Control . . . . . . . . . . . . . . . . . . . . . . . . . . 199 Systems
Driver Assistance . . . . . . . . . . . . . . . . . . . . . . 150
T
Taillamps . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 203
Text Telephone (TTY) Users . . . . . . . . . . . . . . 267
Theft-Deterrent Systems . . . . . . . . . . . . . . . . . . . 17
Immobilizer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16
Time . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 69
Tires . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 212 All-Season . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 212
Buying New Tires . . . . . . . . . . . . . . . . . . . . . . 223
Chains . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 227
Changing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 229
Designations . . . . . . . . . . . . . . . . . . . . . . . . . . . 214
Different Size . . . . . . . . . . . . . . . . . . . . . . . . . . 225
Full-Size Spare . . . . . . . . . . . . . . . . . . . . . . . . . 236
If a Tire Goes Flat . . . . . . . . . . . . . . . . . . . . . 227
Inspection . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 221
Pressure . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 217
Pressure Light . . . . . . . . . . . . . . . . . . . . . . . . . . 80
Pressure Monitor Operation . . . . . . . . . . . 218
Pressure Monitor System . . . . . . . . . . . . . . 218
Rotation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 221
Sidewall Labeling . . . . . . . . . . . . . . . . . . . . . . 213
Terminology and Definitions . . . . . . . . . . . 215
Uniform Tire Quality Grading . . . . . . . . . . 225
Wheel Alignment and Tire Balance . . . . 226 Tires (cont'd)
Wheel Replacement . . . . . . . . . . . . . . . . . . . . 226
When It Is Time for New Tires . . . . . . . . . 223
Winter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 213
Top Tier Fuel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 157
Tow/Haul Mode . . . . . . . . . . . . . . . . . . . . . . . . . .145
Tow/Haul Mode Light . . . . . . . . . . . . . . . . . . . . 78
Towing Driving Characteristics . . . . . . . . . . . . . . . . . 160
Equipment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 172
General Information . . . . . . . . . . . . . . . . . . . 160
Recreational Vehicle . . . . . . . . . . . . . . . . . . . 240
Trailer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 164
Trailer Sway Control (TSC) . . . . . . . . . . . . . . 175
Vehicle . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 240
Traction
Control System (TCS)/StabiliTrakLight . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 79
Traction Control/Electronic Stability Control . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .147
Trademarks and License Agreements . . . . . . 117
Trailer
Sway Control (TSC) . . . . . . . . . . . . . . . . . . . . . 175
Tow Mirrors . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18
Towing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 164

Chevrolet Express Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
14583525) - 2021 - CRC - 12/9/20
294 Index
TransmissionAutomatic . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 142
Fluid, Automatic . . . . . . . . . . . . . . . . . . 186, 189
Transportation Program, Courtesy . . . . . . . 270
Trip Odometer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 71
Turn and Lane-Change Signals . . . . . . . . . . . . 93
U
Uniform Tire Quality Grading . . . . . . . . . . . . 225
Using This Manual . . . . . . . . . . . . . . . . . . . . . . . . . .2
V
Vehicle Alarm System . . . . . . . . . . . . . . . . . . . . . . . . . . 16
Canadian Owners . . . . . . . . . . . . . . . . . . . . . . . . 2
Control . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 127
Identification Number (VIN) . . . . . . . . . . . . 260
Load Limits . . . . . . . . . . . . . . . . . . . . . . . . . . . . 132
Messages . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 85
Personalization . . . . . . . . . . . . . . . . . . . . . . . . . 86
Remote Start . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
Security . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15
Speed Messages . . . . . . . . . . . . . . . . . . . . . . . . 86
Towing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 240
Vehicle Ahead Indicator . . . . . . . . . . . . . . . . . . . 79
Vehicle Care Tire Pressure . . . . . . . . . . . . . . . . . . . . . . . . . . . . 217 Vehicle Data Recording and Privacy . . . . . . 274
Ventilation, Air . . . . . . . . . . . . . . . . . . . . . . . . . . .124
Visors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21
Voltmeter Gauge . . . . . . . . . . . . . . . . . . . . . . . . . .73
W
Warning
Brake System Light . . . . . . . . . . . . . . . . . . . . . 77
Caution and Danger . . . . . . . . . . . . . . . . . . . . . 2
Lane Departure (LDW) . . . . . . . . . . . . . . . . . . 157
Warning Lights, Gauges, and Indicators . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 70
Warnings Hazard Flashers . . . . . . . . . . . . . . . . . . . . . . . . . 92
Washer Fluid . . . . . . . . . . . . . . . . . . . . . . . . . . . . 196
Wheels Alignment and Tire Balance . . . . . . . . . . . . 226
Different Size . . . . . . . . . . . . . . . . . . . . . . . . . . 225
Replacement . . . . . . . . . . . . . . . . . . . . . . . . . . . 226
When It Is Time for New Tires . . . . . . . . . . . 223
Where to Put the Restraint . . . . . . . . . . . . . . . . 51
Windows . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .19 Enhanced Technology Glass . . . . . . . . . . . . . . 21
Manual . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19
Power . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20
Rear . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21
Swing-out Windows . . . . . . . . . . . . . . . . . . . . 20 Windshield
Replacement . . . . . . . . . . . . . . . . . . . . . . . . . . . 202
Wiper/Washer . . . . . . . . . . . . . . . . . . . . . . . . . . 67
Winter Driving . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 130
Winter Tires . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 213
Wiper Blade Replacement . . . . . . . . . . . . . . . . 201